Recycling polymeric waste from electronic and automotive sectors into value added products

The environmentally sustainable disposal and recycling of ever increasing volumes of electronic waste has become a global waste management issue. The addition of up to 25% polymeric waste PCBs (printed circuit boards) as fillers in polypropylene (PP) composites was partially successful: while the tensile modulus, flexural strength and flexural modulus of composites were enhanced, the tensile and impact strengths were found to decrease. As a lowering of impact strength can significantly limit the application of PP based composites, it is necessary to incorporate impact modifying polymers such as rubbery particles in the mix. We report on a novel investigation on the simultaneous utilization of electronic and automotive rubber waste as fillers in PP composites. These composites were prepared by using 25 wt.% polymeric PCB powder, up to 9% of ethylene propylene rubber (EPR), and PP: balance. The influence of EPR on the structural, thermal, mechanical and rheological properties of PP/PCB/ EPR composites was investigated. While the addition of EPR caused the nucleation of the β crystalline phase of PP, the onset temperature for thermal degradation was found to decrease by 8%. The tensile modulus and strength decreased by 16% and 19%, respectively; and the elongation at break increased by ~71%. The impact strength showed a maximum increase of ~18% at 7 wt.%–9 wt.% EPR content. Various rheological properties were found to be well within the range of processing limits. This novel eco-friendly approach could help utilize significant amounts of polymeric electronic and automotive waste for fabricating valuable polymer composites.

Open image in new window

     

AN EXAMINATION OF THE MECHANISMS CONTROLLING GROUNDWATER GRADIENTS IN HYPER-ARID REGIONAL SEDIMENTARY BASINS1

ABSTRACT: Although evidence of modern recharge in the North African and Arabian sedimentary basin aquifers exists, it is difficult to determine the volume of recharge. Also, from the evidence of regional groundwater gradients, the flow within the aquifers seems to be appreciably greater than one would intuitively expect. A hypotehtical model embodying the characteristics of the aquifers has been used to investigate the likely significance of various possible flow mechanisms. It is shown that while dewatering in the unconfined area can possibly contribute to flows for a considerable period of time, the maintenance of water levels in the unconfined zone must be the result of modern recharge. It is also shown that recharge depths of less than 10 mm per annum are sufficient given suitable aquifer parameters. Results for various combinations of aquifer parameters and configurations are given, including layered aquifers and the effects of restricted oufflows. Comparisons are made using a “bench mark” example. The work indicates that there is little point in carrying out conventional hydrological balance studies in hyper-arid areas and that, instead, more emphasis should be placed upon good groundwater hydrographic data and modeling.     

Effects of the mosquito larvicide GB-1111 on bird eggs

Golden Bear Oil (GB-1111; legal trade name for GB-1313) is a petroleum distillate used in the United States and other countries as a mosquito larvicide. As part of an evaluation of the potential effects of GB-1111 on birds, fertile eggs of mallards (Anas platyrhynchos) and bobwhite (Colinus virginianus) were incubated in the laboratory, and treated on day 4 of incubation with external applications equivalent to either 0, 1/3, 1, 3 or 10 times the maximum rate (X) of 47 l/ha (5 gal/A) of field application of GB-1111. Hatching success was significantly reduced in mallards treated at 3 and 10 times the maximum field application, with a calculated approximate LD50 of 1.9 times the maximum field application. Most mortality occurred within a week of treatment. Hepatic P450-associated monooxygenase activity (ethoxyresorufin-O-dealkylase; EROD) was negatively related to dose. In the 3X group there was a significant increase in the concentration of hepatic reduced glutathione (GSH) but a decrease in protein-bound thiols (PBSH). Hatching success of bobwhite was marginally reduced at the highest level of treatment (10X). Other effects at this level in bobwhite included a significant increase in incidence of abnormal embryos or hatchlings, lower body and liver weights, and a two-fold increase in hepatic microsomal EROD activity in hatchlings. The recommended maximum rate of field application of GB-1111 is unlikely to impair the survival or development of bobwhite embryos but is potentially toxic to mallard embryos under conditions of larvicide drift or spray overlap.     

Cost‐Effective Sediment Dredge Disposal Options for Small Craft Harbors in Canada

Sediment dredge disposal options were reviewed to improve cost‐effectiveness and environmental safety for dredging of coastal sediments at the Department of Fisheries and Oceans Small Craft Harbours (DFO‐SCH) program in Canada. Historically, contaminated dredge sediments exceeding federal guidelines were disposed of in nearby landfills. Recent federal regulatory changes in sediment quality guidelines adopted by provincial regulators in Canada has resulted in updates to guidelines for disposal of contaminated solids in landfills. Updates now require specific and general disposal options for contaminated dredge material destined for land‐based disposal, resulting in more expensive disposal in containment cells (if contaminated sediments exceed federal guidelines). However, as part of this study, a leachate testing method was applied to contaminated sediments to simulate migration of potential contaminants in groundwater. Using this approach, leachate quality was compared to federal freshwater criteria and drinking water quality guidelines for compliance with new regulations. Leachate testing performed on the highest sediment contaminant concentrations triggered less than 2 percent potable water exceedances, meaning that most dredge spoils could be disposed of in privately owned or provincially operated landfill sites, providing less expensive disposal options compared to containment cell disposal. Current dredge disposal practices were reviewed at 35 harbor sites across Nova Scotia and their limitations identified in a gap analysis. Improved site management was developed following this review and consultation with interested marine stakeholders. New disposal options and chemical analyses were proposed, along with improvements to cost efficiencies for management of dredged marine sediments in Atlantic Canada. © 2013 Wiley Periodicals, Inc.     

Reproductive variability over a four-year period in the sea urchin Evechinus chloroticus (Echinoidea: Echinodermata) from differing habitats in New Zealand

 The endemic New Zealand echinoid, Evechinus chloroticus (Valenciennes), was sampled approximately monthly from September 1990 to October 1994 at three sites in Tory Channel, Marlborough Sounds, New Zealand. These channel sites (outer, mid and inner) were up to 20 km from the open ocean and differed in their shore type, exposure to wave action and macrophyte abundance. E. chloroticus showed an annual reproductive cycle at each site, with gametogenesis commencing in the late austral winter and spawning in summer. Maximum gonad indices (reproductive potential) varied spatially, with the outer site generally having higher maximum gonad indices than the inner site, and temporally, with maximum gonad indices occurring earlier in 3 of the 4 seasons at the outer site than the inner site. The mid and inner sites showed much greater variation in maximum gonad indices (range 15.83 to 26.99% and 11.87 to 20.90%, respectively) than the outer site (range 19.31 to 22.95%). Reproductive output (weight of gametes released per gram echinoid) also varied, with the different sites showing significantly different outputs in the different years. A regression of maximum reproductive potential against reproductive output was significant ( p < 0.001), and had a positive slope with an r ² of 0.79. While, the initiation of gametogenesis was relatively synchronous between sites and years, and is possibly cued by increasing daylength, it progressed at different rates among populations. Spawning did show spatial and temporal variability, occurring near the time of highest sea-surface temperatures (∼15 °C). The observed variations in reproductive cycle may be related to small-scale variability in diet and environmental conditions. Furthermore, asynchronous spawning, variable spawning duration, and variable reproductive output are likely to strongly influence annual recruitment variability in E. chloroticus, with different larval subpopulations contributing unequally in different years. The ecological consequences of this, both for the ability of E. chloroticus to propagate itself in space and time and for the management of the developing E. chloroticus fishery in New Zealand, are discussed. Received: 9 December 1998 / Accepted: 13 June 2000     

Biogeochemical gradients as a framework for understanding waste‐site evolution

The migration of biogeochemical gradients is a useful framework for understanding the evolution of biogeochemical conditions in groundwater at waste sites contaminated with metals and radionuclides. This understanding is critical to selecting sustainable remedies and evaluating sites for monitored natural attenuation, because most attenuation mechanisms are sensitive to geochemical conditions, such as pH and redox potential. Knowledge of how gradients in these parameters evolve provides insights into the behavior of contaminants with time and guides characterization, remedy selection, and monitoring efforts. An example is a seepage basin site at the Savannah River Site in South Carolina where low‐level acidic waste has seeped into groundwater. The remediation of this site relies, in part, on restoring the natural pH of the aquifer by injecting alkaline solutions. The remediation will continue until the pH upflow of the treatment zone increases to an acceptable value. The time required to achieve this objective depends on the time it takes the trailing pH gradient, the gradient separating the plume from influxing natural groundwater, to reach the treatment zone. Predictions of this length of time will strongly influence long‐term remedial decisions. © 2008 Wiley Periodicals, Inc.     

Carbofuran residues in organic soils in Southwestern Ontario, 1977

Organic soils from 22 farms with a history of carbofuran use for soil insect control were sampled in November, 1977. Analysis for carbofuran was by electron capture gas chromatography of the heptaflurobutyric derivative. Nineteen of the 22 soils contained detectable (sensitivity 0.02 ppm) carbofuran residues. However only 8 of the soils contained greater than 0.5 ppm total carbofuran. The highest total carbofuran residue was 1.5 ppm, of which 0.31 ppm was 3-ketocarbofuran. In other soil samples 3-ketocarbofuran comprised 7-50% of the total carbofuran residue. No 3-hydroxycarbofuran was detected. The order of persistence of granular application of 3 insecticides as seed-furrow treatments was ethion greater than fonofos greater than carbofuran.     

Assessment of hazards associated with pesticide container disposal and of rinsing procedures as a means of enabling disposal of pesticide containers in sanitary landfills

To study problems associated with pesticide container disposal, a small vegetable production area in southwestern Ontario, the Thedford Marsh, was selected as the site for a model study. A container collection system was organized during the 1981 growing season, with collections being made from the ca. 50 growers on the marsh twice each month. In addition to the regular collection program a cleanup service for empty pesticide containers stored on farms or discarded on public lands also was initiated. More than 3600 containers were collected and disposed of at an authorized landfill site. Ca. 2/3 were herbicide containers, ca. 1/4 were insecticide containers, and 3% were fungicide containers. Unrinsed containers contained as much as 5 1/2% of the original contents with an average of 1%. Containers rinsed by the triple rinse method or using rinsing devices (E-Z Rinse, JET Rinse) generally contained less than 0.1% of the original content. Some formulations presented rinsing problems due to settling and caking. The results indicated that, while unacceptable quantities of pesticide residues remain in unrinsed containers, most rinsed pesticide containers will be acceptable for disposal at municipal sanitary landfill sites.     

Sea ice microbial production supports Ross Sea benthic communities: influence of a small but stable subsidy

Diversity in guilds of primary producers enhances temporal stability in provision of organic matter to consumers. In the Antarctic ecosystem, where temporal variability in phytoplankton production is high, sea ice contains a diatom and microbial community (SIMCO) that represents a pool of organic matter that is seasonally more consistent, although of relatively small magnitude. The fate of organic material produced by SIMCO in Antarctica is largely unknown but may represent an important link between sea ice dynamics and secondary production in nearshore food webs. We used whole tissue and compound-specific stable isotope analysis of consumers to test whether the sea ice microbial community is an important source of organic matter supporting nearshore communities in the Ross Sea. We found distinct gradients in delta13C and delta15N of SIMCO corresponding to differences in inorganic carbon and nitrogen acquisition among sites with different sea ice extent and persistence. Mass balance analysis of a suite of consumers demonstrated large fluxes of SIMCO into the nearshore food web, ranging from 5% to 100% of organic matter supplied to benthic species, and 0-10% of organic matter to upper water column or pelagic inhabitants. A delta13C analysis of nine fatty acids including two key biomarkers for diatoms, eicosapentaenoic acid (EPA, 20:5omega3), and docosahexaenoic acid (DHA, 22:6omega3), confirmed these patterns. We observed clear patterns in delta13C of fatty acids that are enriched in 13C for species that acquire a large fraction of their nutrition from SIMCO. These data demonstrate the key role of SIMCO in ecosystem functioning in Antarctica and strong linkages between sea ice extent and nearshore secondary productivity. While SIMCO provides a stabilizing subsidy of organic matter, changes to sea ice coverage associated with climate change would directly affect secondary production and stability of benthic food webs in Antarctica.