7B04铝合金和30CrMnSiA钢短期腐蚀的电化学行为研究

目的研究7B04铝合金和30CrMnSiA合金钢试样的电化学性能。方法采用电化学实验、扫描电子显微镜(SEM)、腐蚀坑深度测试分别对7B04铝合金和30CrMnSiA合金钢试样在是否经过天然海水浸泡的情况下进行测试分析,得到微观腐蚀形貌和腐蚀坑深度以及试样表面不带锈和带锈时的电化学性能。结果随着Na Cl浓度增大,7B04铝合金和30CrMnSiA钢的自腐蚀电流变大,两者之间存在明显的电位差,接触后会发生电偶腐蚀。电偶电流与阴阳极面积比和Na Cl浓度有关,阴阳极面积比增大或Na Cl浓度升高均会导致电偶效应增强。经过海水短期浸泡后,7B04铝合金表面的锈层不仅没有起到抑制腐蚀的作用,反而使自腐蚀加重,但电偶效应确实有所减弱。结论沿海设备在使用过程中应竭力避免铝合金在锈层下工作。     

Gas/particle partitioning of atmospheric PCDD/Fs in a satellite town in Eastern China

Gas/particle partitioning of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) in ambient air was investigated in a satellite town in Eastern China from April 2007 to January 2008 comprehending large temperature variations (from 3 to 34 °C, daily average). Molecular weight, molecular structure and ambient temperatures are the three major factors that govern the gas/particle partitioning of atmospheric PCDD/Fs throughout the year. Generally, good agreements were obtained (except for winter) between measured particulate fractions and theoretical estimates of both the Junge–Pankow adsorption model and Harner Bidleman absorption model using different sets of subcooled liquid vapor pressure and octanol–air partition coefficient (K_oa), respectively. Models utilizing estimates, derived from gas chromatographic retention indices (GC-RIs), are more accurate than that of entropy-based. Moreover, during winter, the K_oa-based model using the GC-RIs approach performs better on lower chlorinated PCDD/Fs than that of -based. Furthermore, possible sources of mismatch between measured and predicted values in winter (3–7 °C) were discussed. Gas adsorption artifact was demonstrated to be of minor importance for the phenomena observed. On the other hand, large deviations of slopes (m_r) and intercepts (b_r) in logK_p vs. plots from theoretical values are observed in the literature data and these are found to be linearly correlated with ambient temperatures (P<0.001) in this study. This indicates that the non-equilibrium partitioning of PCDD/Fs in winter may be significantly influenced by the colder temperatures that may have slowed down the exchange between gaseous and particulate fractions.     

联苯代谢对微生物的生长胁迫及分裂抑制

以联苯/多氯联苯降解菌株R04（Rhodococcus sp.R04）和几种模式微生物为研究对象，利用高效液相色谱、荧光显微镜、扫描电子显微镜等分析微生物在联苯及其代谢物培养条件下细胞分裂和形态的变化.结果表明联苯及其代谢产物对红球菌R04和几种模式微生物细胞的分裂有抑制作用，并对部分微生物形态有影响.与前体-联苯及其代谢产物2-羟基-6-酮基-6-苯基-2，4-己二烯酸相比，2，3-二羟基联苯对G⁺、G^-细菌，或是酵母细胞分裂都有较强的抑制和形态的改变.2，3-二羟基联苯导致R.R04和缺陷型R.R04细胞形成不完整隔膜的比例增加；造成96.4%的大肠杆菌BL21细胞表面凹陷，胞质内容物流失，菌体体积缩小；导致枯草芽孢杆菌89.6%的细胞体积明显缩小；导致金黄色葡萄球菌基本没有细胞能形成完整的分裂隔膜；导致红酵母细胞能进行出芽生殖的比例从64.2%降低到19.3%，但对其细胞形态无明显改变.联苯代谢物2，3-二羟基联苯对红球菌R04及其它微生物细胞分裂和增殖的抑制作用比其前体-联苯强，建议在研究环境化合物与微生物互作时，应考虑环境化合物代谢的毒性效应.     

微量元素对牛粪低温厌氧发酵的影响

为考察较低温度(<17℃)条件下添加微量金属元素对厌氧发酵产气量的影响,在发酵底物TS(含固率)为10%下采用10 L玻璃瓶作反应器,以牛粪为原料,向厌氧生物反应器中分别添加MnSO4、FeSO4·7H2O、电解锰渣,分析了厌氧消化系统运行过程中的产气量、COD(化学需氧量)和pH的变化。结果表明,锰元素能促进低温下牛粪的厌氧发酵,加速反应启动。当添加6 g MnSO4、100 g电解锰渣时,单位质量VS产气率分别为0.26 mL/g和0.64 mL/g,添加6 g FeSO4·7H2O与空白对照组均未见明显产气。     

高效降解微囊藻毒素食酸戴尔福特菌USTB-04的培养与活性研究

主要针对筛选的高效降解微囊藻毒素(microcystins,MCs)的食酸戴尔福特菌USTB-04(Delftia acidovorans,DA菌)的培养方法进行了研究.结果表明,以葡萄糖、甘油和乙醇作为惟一碳源时,与氯化铵和尿素相比,酵母粉是支持DA菌生长的较好氮源.在以酵母粉作为惟一氮源时,与甘油和乙醇相比,葡萄糖是提高DA菌生长速度的较好碳源.进一步研究显示,以葡萄糖和酵母粉作为碳源和氮源时,可以支持DA菌的快速稳定生长,但在以甘油和酵母粉作为碳源和氮源时.培养出的DA菌降解MCs的比活性最高.此研究在培养高细胞浓度DA菌作为生物催化剂用于饮用水源中的MCs去除方面具有重要意义.     

7B04铝合金海洋性大气腐蚀研究

通过在青岛和海南开展的7B04铝合金户外大气暴露试验,利用失重分析、形貌观察、断面分析和电化学交流阻抗谱等研究了7B04铝合金在海洋性大气环境中的腐蚀动力学规律和腐蚀特征。结果表明,在青岛和海南等海洋性大气环境中,7B04铝合金腐蚀初期以点蚀形式萌生,随后向均匀腐蚀发展;腐蚀过程均经历了腐蚀速率由高到低的过程,且腐蚀失重与时间的关系均可用幂函数显著回归;电化学阻抗谱分析表明当腐蚀产物足够厚时,7B04铝合金海洋性大气腐蚀的电化学过程由侵蚀性离子的扩散步骤来控制。     

Comparison of refrigerated warehouse energy demand with R-717 and R-507 using eQUEST model

Natural refrigerant ammonia R-717 and synthetic azeotropic refrigerant R-507 (a blend containing 50% R-143a and 5% R-125 by weight) are used in a wide range of refrigeration systems especially in low-temperature applications. R-717 and R-507 are ozone friendly refrigerants, which have no Ozone Depletion Potential (ODP). Global Warming Potential (GWP) of R-717 and R-507 is equal to zero and 3300, respectively. The high amount of R-507 GWP demonstrates its negative effect on the Earth’s climate change. In this study, a refrigerated warehouse located in Cincinnati, Ohio was modeled and the total energy demand and Coefficient of Performance (COP) was evaluated by eQUEST using two scenarios. The R-717 and R-507 were used as refrigerant in the first and second scenarios, respectively. The results showed that using R-717 in the refrigeration system leads to a 15% energy saving and a higher COP compared to R-507 in all working conditions. The only exception is that at an evaporating temperature below ?35°C which COP values of both refrigerants are approximately equal.     

Degradation of poly(β-hydroxyalkanoates) and polyolefin blends in a municipal wastewater treatment facility

Six types of plastics and plastic blends, the latter composed at least partially of biodegradable material, were exposed to aerobically treated wastewater (activated sludge) to ascertain their biodegradability. In one study, duplicate samples of 6% starch in polypropylene, 12% starch in linear low-density polyethylene, 30% polycaprolactone in linear low-density polyethylene, and poly(-hydroxybutyrate-co-hydroxyvalerate) (PHB/V), a microbially produced polyester, were exposed to activated sludge for 5 months, and changes in mass, molecular weight average, and tensile properties were measured. None of the blended material showed any sign of degradation. PHB/V, however, showed a considerable loss of mass and a significant loss of tensile strength. In a second study, PHB/V degraded rapidly, but another type of microbial polymer which forms a thermoplastic elastomer, poly(-hydroxyoctanoate), did not degrade. These results illustrate the potential for disposal and degradation of PHB/V in municipal wastewater.     

高强铝合金海洋大气环境剥层腐蚀研究

通过7B04铝合金海洋大气环境户外和棚下暴露试验,研究了7B04铝合金的宏观/微观腐蚀特征及其对力学性能的影响。结果表明,7B04铝合金在海洋大气环境中的腐蚀表现为点蚀—晶间腐蚀—剥层腐蚀的规律,棚下暴露比户外暴露严重,反面暴露比正面暴露严重。同时,从显微组织、晶间电偶腐蚀、腐蚀产物＂楔入作用＂等方面剖析了7B04铝合金剥层腐蚀的机理。     

Biodegradation of methyl parathion by Acinetobacter radioresistens USTB-04

Biodegradation of methyl parathion (MP),a widely used organophosphorus pesticide,was investigated using a newly isolated bacterium strain Acinetobacter radioresistens USTB-04.MP at an initial concentration of 1200 mg/L could be totally biodegraded by A.radioresistens USTB-04 as the sole carbon source less than 4 d in the presence of phosphate and urea as phosphorus and nitrogen sources,respectively.Biodegradation of MP was also achieved using cell-free extract of A.radioresistens USTB-04.MP at an initial concentration of 130 mg/L was completely biodegraded in 2 h in the presence of cell-free extract with a protein concentration of 148.0 mg/L,which was increased with the increase of pH from 5.0 to 8.0.Contrary to published reports,no intermediate or final degradation metabolites of MP could be observed.Thus we suggest that the cleavage of C--C bond on the benzene ring other than P-O bond may be the biodegradation pathway of MP by A.radioresistens USTB-04.