热镀锌板表面钝化时的磷化工艺

热镀锌板表面钝化（铬酸盐钝化），主要是为了防止在使用过程中其表面被氧化。由于表面的钝化膜的存在。使得磷化工艺无法进行，从而影响涂装后涂层的附着力（铬酸盐钝化膜不如磷化膜附着性好）和耐蚀性能（铬离子不耐氯离子的腐蚀）。为了提高热镀锌板表面钝化后其表面的涂装性能，开发出一种适合上述条件的磷化工艺。     

Enhancement of UV and chromate mutagenesis by nickel ions in the Chinese hamster HGPRT Assay †

1. The HGPRT (Hypoxanthine‐Guanine‐Phospho‐Ribosyl‐Transferase) assay with Chinese Hamster V79 cells was used to measure the mutagenic effects of UV irradiation, potassium dichromate and nickel chloride. The agents were tested separately and in the combinations of UV plus nickel and dichromate plus nickel.

2. UV, Cr(VI) and Ni(II) were confirmed to be mutagenic in the V79 cell assay. The combination of UV(5J/m²) and Ni(II) (0.5 mM) caused a mutation rate 11.2 times above that corresponding to the sum of the individual mutation rates of these agents. The combined action of Cr(VI) (0.1 mM) and Ni(II) (0.5 mM) produced a mutation rate 2.8 fold above that corresponding to the sum of the individual rates of the separate agents.

3. The enhancing effect of nickel chloride on the mutagenicity of UV or Cr(VI) is interpreted by an interference of Ni(II) with the repair of DNA lesions.     

密封消解法测定高氯离子含盐废水COD_(Cr)的探讨

针对国标重铬酸钾法测定高氯离子含盐废水CODCr时的不足,提出用密封消解法来测定高盐废水CODCr的观点,通过丁酮氧化率、氯离子干扰、混配水样和实际水样测定结果的比较,对国标法和密封消解法进行了验证。试验结果表明:在测定高氯离子含盐废水CODCr值时,密封消解法优于重铬酸钾法,能够真实准确地反映废水的CODCr。     

Preparation, characterization and application of CuCrO2/ZnO photocatalysts for the reduction of Cr(VI)

The delafossite CuCrO₂ elaborated by sol-gel from 40 nm diameter colloid is optically active in the visible region. It is characterized physically and photoelectrochemically. The microstructure is fairly homogenous with a mean crystallite size of ca. 2 μm. The optical gap (1.30 eV), determined from the diffuse reflectance, is well suited to the sunlight spectrum. The Mott Schottky plot is characteristic of P-type conductivity with a flat band potential of -0.26 V_SCE. As application, the photoreduction of chromate is successfully achieved in air-equilibrated suspension CuCrO₂/ZnO (1/1). CuCrO₂ is photoactivated by visible light and the electrons in the conduction band (-1.34 V_SCE) are injected to ZnO. In the presence of salicylic acid, a conversion of Cr(VI) to Cr(III) of 57% is obtained under optimal conditions (pH 3 at 25℃, 5×10^-4 mol/L) because of the HCrO₄^- dark adsorption onto ZnO (4HCrO₄^- + 3C₇H₆O₃ + 18O₂ + 16H⁺ → 4Cr³⁺ + 21CO₂ + 19H₂O, ΔG⁰ = -557 kcal/mol). Prolonged illumination is accompanied by a deceleration in the photoactivity owing to the competitive water reduction, an issue of energetic concern. The hetero-system exhibits self sensitization for hydrogen production with an evolution rate of 149 μmol/(hr·g).     

Resourcefulization approaches to pollution control of chromate residues in China

Over 2 million tons of chromate residues as hazardous wastes have been accumulated from chromate production processes during the past more than 30 years in China. Some serious pollution problems have been caused due to no appropriate technology and management. Approaches are reviewed to pollution control of chromate residues by utilizing them as secondary resources in this paper. In addition to legislation for pollution control, chromate residues can be used as raw materials to produce a great diversity of useful industrial products. Strategies are also recommanded for the resourcefulization of chromate residues.     

铁铜内电解-膨润土组合工艺处理含铬废水

研究利用铁铜内电解工艺和膨润土吸附的联合作用,对含铬废水进行处理。含铬模拟废水首先经过铁铜内电解法装置,该出水再经膨润土吸附,以达到去除效果。并考察此组合工艺的各种影响因素。结果表明:(1)铁铜内电解预处理确定最佳反应参数为:铁铜用量之比为8:1,反应时间为100 min,pH值为3.0;(2)膨润土最佳吸附条件为:膨润土用量为2 g/l,反应时间为20 min;(3)在最佳反应条件下,对初始浓度分别为30 mg/l和60 mg/l的实际制革废水中的铬进行了处理,都取得较好的去除效果,其Cr(VI)去除率分别为99.54%和99.32%。     

Model reactions of chromium compounds with mammalian and bacterial cells†

Chromate uptake, reduction, cytotoxicity and mutagenicity were studied with human red blood cells, Chinese hamster ovary (CHO) cells and/or Salmonella typhimurium mutant cells. All cell types rapidly took up chromates whereas chromium(III) salts were excluded under the experimental conditions. Red blood cells reduced and accumulated chromium from chromate. At concentrations above 0.1 mM, chromate inactivated the red cell chromate carrier. Chromate above 0.01 mM inhibited CHO cell proliferation irrespective of the cations present. Chromate and two chromium(III) complexes were mutagenic with Salmonella mutants in the Ames’ assay. A model for chromate metabolism and genotoxicity is proposed.     

Arsenic and chromate removal from water by iron chips-Effects of anions

The purpose of this study is to estimate the removal efficiency of As and Cr (VI) by one kind of industrial waste — iron chips, as well as to estimate the effects of typical inorganic anions (sulfate, phosphate, and nitrate), and typical organic anions (citrate, oxalate, and humate) on As or Cr (VI) removal. The results showed that 98% of As (V) and 92% of As (III) could be removed from aqueous phase by the iron chips within 60 min. Compared with As species, Cr (VI) was removed much more rapidly and efficiently with 97% of Cr (VI) being removed within 25 min. The removal efficiency for arsenic was in the order: As (III) (sulfate), As (III) (nitrate) or As (III), As (III) (humate), As (III) (oxalate), As (III) (citrate), As (III) (phosphate), and for chromate was in the order: Cr (VI) (sulfate), Cr (VI) (phosphate) or Cr (VI) (nitrate) or Cr (VI) (oxalate), Cr (VI), Cr (VI) (citrate), Cr (VI) (humate). In all the treatments, pH level increased with time except for As (III), the removal of which was either without anions or in the presence of humate or nitrate.     

铬酸钡光度法测定硫酸盐的改进研究

铬酸钡光度法是测定水中硫酸盐的常用方法之一，但是因为过滤法本身的粗糙使得检测结果重现性差、准确率低。为了提高该方法的准确度和精密度，现用离心机分离代替实验中过滤分离沉淀。实验表明离心机分离法线形范围0～200mg/L，回归方程：y=0．1129x-0．0030，γ=0．9992，检出限为7．10ng/L，回收率约96％～104％，相对标准偏差（RSD）为0．45％．2．37％，结果无显著性差异（t=0．24，P〉0．01）。该方法可应用于水中硫酸盐含量测定以提高准确度，方法快速简便，并与标准方法（重量法）比较，结果满意。