不同好氧预处理方式对餐厨垃圾产甲烷的影响

为了研究不同好氧预处理方式对餐厨垃圾厌氧消化产甲烷的影响,通过建立3个模拟厌氧生物反应器,研究了传统厌氧生物反应器C1、上层好氧预处理-厌氧生物反应器C2和底部好氧预处理-厌氧生物反应器C3 3种不同操作条件下的产甲烷过程.结果表明,挥发性有机酸的累积使C1始终处于产甲烷滞后阶段;而C2、C3的好氧预处理通过加快易水解酸化组分和过量挥发性有机酸的好氧降解,有效缓解了酸性抑制,产甲烷滞后时间明显缩短至10 d内.第32天C2停止上层曝气后,在27 d内甲烷浓度达到了50％以上,同时,产甲烷速率迅速上升,并在第81天可达到峰值773 mL/(kg·d).C3在第11天停止底部曝气后,虽然经过22 d的时间甲烷浓度即上升至50％,但之后产甲烷速率经历回落阶段后再次逐渐上升,在实验结束时仅达到517 mL/(kg·d).上层曝气的好氧预处理方式所需曝气时间相对较长,但其产甲烷启动快,与底部曝气相比,其后期的甲烷化过程更稳定并可达到较高的产甲烷速率.     

红霉素对产甲烷菌的抑制及其驯化

红霉素是一类具有一定生物毒性的抗生素类药品,为探明红霉素对产甲烷菌的抑制作用及其可驯化能力,依次在厌氧瓶中进行厌氧毒性试验、在升流式厌氧污泥床反应器(UASB)中进行连续实验,测定累计甲烷产量、相对产甲烷速率、COD去除率、甲烷含量.结果表明,红霉素为150 mg.L-1时产甲烷速率降为56.1%;250 mg.L-1时反应速率降低99%以上,活性受到完全抑制.保持红霉素投加量为20 mg.L-1连续运行60 d,COD去除率、甲烷含量可达到81.4%、64.2%.红霉素对甲烷菌有抑制作用,半抑制浓度为150 mg.L-1.甲烷菌对红霉素有一定的驯化能力,驯化60 d后COD去除率、甲烷含量较未驯化时可提高15.13%、22.05%.     

Effect of a high strength chemical industry wastewater on microbial community dynamics and mesophilic methane generation

A high strength chemical industry wastewater was assessed for its impact on anaerobic microbial com- munity dynamics and consequently mesophilic methane generation. Cumulative methane production was 251 mL/g total chemical oxygen demand removed at standard temperature and pressure at the end of 30 days experimental period with a highest recorded methane percentage of 80.6% of total biogas volume. Volatile fatty acids （VFAs） analysis revealed that acetic acid was the major intermediate VFAs produced with propionic acid accumulating over the experimental period. Quantitative analysis of microbial communities in the test and control groups with quantitative real time polymerase chain reaction highlighted that in the test group, Eubacteria （96.3%） was dominant in comparison with methanogens （3.7%）. The latter were dominated by Methanomicrobiales and Methanobacteriales while in test groups increased over the experimental period, reaching a maximum on day 30. Denaturing gradient gel electrophoresis profile was performed, targeting the 16S rRNA gene of Eubacteria and Archaea, with the DNA samples extracted at 3 different time points from the test groups. A phylogenetic tree was constructed for the sequences using the neighborhood joining method. The analysis revealed that the presence of organisms resembling Syntrophomonadaceae could have contributed to increased production of acetic and propionic acid intermediates while decrease of organisms resembling Pelotomaculum sp. could have most likely contributed to accumulation of propionic acid. This study suggested that the degradation of organic components within the high strength industrial wastewater is closely linked with the activity of certain niche microbial communities within eubacteria and methanogens.     

降解纤维素产甲烷的四菌复合系

自然环境中通常是微生物群落协同完成纤维素的降解,构建可降解纤维素的混菌体系是认识微生物相互作用的关键.利用富集培养法,结合变性梯度凝胶电泳(DGGE)指纹检测技术以及厌氧滚管技术,建立了一种筛选简单降解纤维素产甲烷复合菌系的方法.利用此方法从青藏高原若尔盖高寒湿地分离到一个由4株菌构成的降解纤维素产甲烷的稳定菌系.结果表明,该复合菌系由纤维素水解菌Clostridium glycolicum、非纤维素水解菌Trichococcus flocculiformis和Parabacteroides merdae、产甲烷古菌Methanobacterium subterraneum等具有不同功能的4种菌株组成,且在这4株菌的共同作用下可将纤维素直接转化为CH4.该简单复合系的获得为今后纤维素转化甲烷复合菌系的代谢控制和遗传改造提供了一个平台.     

船舶载运煤炭甲烷释放特性研究

为了研究船舶载运煤炭甲烷释放规律,基于Fick扩散定律建立了货舱甲烷体积分数计算模型,分析了不同扩散系数条件下甲烷释放量与时间的关系,确定了空隙系数的取值范围,通过对某船舶煤炭运输过程中甲烷体积分数随船实测对模型进行了验证.结果表明,货舱甲烷体积分数随运输时间增加而增加,扩散系数为1.0×10-8 cm2/s时,甲烷释放量达到极大值;煤炭的空隙系数基本在0.53～ 0.57 m3/t之间.当煤炭极限甲烷解吸量为1.6 ～ 3.83 m3/t时,货舱甲烷最高体积分数在0.53％ ～ 1.22％,5个货舱中4个货舱的甲烷释放量与理论计算相吻合,1个货舱的最大甲烷释放量高出理论计算量6％,船运煤炭过程中的甲烷释放计算模型与实测结果较为吻合.对于甲烷体积分数超限的货舱,及时通风可使甲烷体积分数迅速降低,有效地解决船运煤炭过程中甲烷体积分数超限的问题.     

An Avoidable Tragedy at the Sea Cliff (Rincon) Oil Field

Three men were killed and four others were injured during a well drill operation on Hobson Well C-10A in the Sea Cliff Oil Field (also known as Rincon Oil Field), in Ventura County, California, United States, on August 10, 1994, as a result of errors made by the work supervisors at the site. The oil field was under management by Vintage Petroleum, Ltd., which was sued for negligence by the families of the deceased and injured. The coroner's autopsy examination concluded that the cause of the deaths was due to the inhalation of the toxic gas carbon monoxide (CO). This gas was assumed to have been released from the firing of high-energy guns (HEGs) using carbon-rich explosive pentaerythritol tetranitrate (PETN) in an oxygen-depleted environment, during a fracking operation by Schlumberger Corporation on Well C-10A. The author of this article was appointed as an expert witness by Schlumberger to evaluate if the coroner's conclusion was correct. A series of chemical analytical analyses were conducted on the vapor phase of samples, in addition to dissolved components in water from Well C-10A and two adjacent wells. Stable isotope analyses were also conducted on hydrogen (H₂), methane (CH₄), nitrogen (N₂), CO, and water (H₂O) 3 weeks after the accident, as well as on four additional occasions from September to December 1994. Control test analyses were performed on the products from HEG firings, using the same explosives as those used in the perforation of Well C-10A in control chambers at a Schlumberger facility in Houston, Texas. The conclusion reached was that the dominant products of PETN detonations are H₂, CH₄, CO, and N₂. However, the isotope ratios (D/H and ¹³C/¹²C) of methane in the control experiments were different in Well C-10A, following the detonation on August 10, 1994, than those resulting from controlled PETN explosions. The conclusion reached in this study was that the fracking of the well at a depth of around 2,150 ft had increased the permeability of the sediment layers in the Padres Zone at that depth to allow the rapid release of a large quantity of natural gas, primarily CH₄, which supersaturated the water in the well. This event caused the formation of a large bubble, which ballooned out of the well to the surface, displacing air in the location where the men were working, and thus causing asphyxiation, which resulted in the death of the three men. The judge accepted this interpretation.     

污泥预处理强化厌氧水解与产甲烷实验研究

污泥传统厌氧消化因水解瓶颈而导致有机物转化甲烷产率低下.选择适当工况对污泥实施预处理可同时实现对污泥中木质纤维素破稳和污泥微生物细胞破壁,从而释放出较多溶解性COD(SCOD),使有机物水解变得容易进行,最终导致甲烷产率大幅提高.本研究通过热水解(T=150℃,t=30 min)、超声波(P =500 W,t=2 h)、碱解(pH =13,t=2h)和酸解(pH =2,t=2 h)等4种预处理方式对原污泥实施最优工况预处理,分别获得了50.9％、39.1％、31.0％和22.4％的COD溶出率.对预处理后污泥进行传统条件下(SRT =20 d)厌氧消化,分别获得了53.6％、40％、26.8％和24％的甲烷产率(mL/g VSS)增量.同时,预处理后污泥中木质纤维素类物质降解率亦大大增加.缩短SRT(10 d)会导致传统厌氧消化甲烷产率急剧减少,但是,污泥预处理却非常有利于甲烷产率的提高,因此可通过外在预处理方式来逾越内在厌氧水解的瓶颈.     

Coal facies characteristics and its control on methane content in South Yanchuan Block,Southeast Ordos Basin,China

The variability in depositional environments in ancient peat bog and coal facies characteristics was investigated with 29 coal samples from four coalbed methane wells in South Yanchuan Block, Southeast Ordos Basin, China. The control of methane content is described as coal facies parameters and the corresponding measurements of methane content. The results indicated that the depositional environment of ancient peat bog in South Yanchuan Block is primarily a lower delta plain, and a low tissue preservation index (TPI) and high gelification index (GI) are typical features of reservoir’s coal facies, reflecting a deep water depositional environment in ancient peat bog. Compared with the coal facies characteristics of the western area, the coal reservoir in the eastern area displays low GI and high ash content as a result of ancient peat bog’s proximity to sea and source area. Various lateral methane contents are influenced by burial depth, whereas the characteristics of coal facies have a strong control on methane content within the single well in vertical direction. The methane content increases with increase in GI and vitrinite to inertinite ratio (V:I), while there are indistinct relationships between TPI and transportation index with methane content. With high GI and longer distance to sea and source area, the methane content in the western area is higher than that of the eastern area. High desmocollinite content also has a negative influence on methane content.     

Carbon emission reduction and cost–benefit of methane digester systems on hog farms in China

Three different sizes of hog farms were selected to analyze the carbon emissions reduction and the cost–benefit of three methane digester systems. The sizes of the digesters are 2,200, 2,200 and 800 m³, respectively. The sales of slaughter hogs from them are 50,000, 35,000 and 10,000 head, respectively. The carbon emissions reductions were 5,237, 4,017, and 1,334 tons, respectively. The results show that while the methane digester systems have a significant effect on carbon emissions reduction, it is difficult to operate the systems sustainably. If the carbon emissions reduction can be traded at high enough prices in the carbon offset markets, then the systems will be profitable and sustainable. Newly established China's domestic carbon offset market could provide this possibility, but more government support is needed. In addition, this study shows that scale economies make the digester adoption relatively more profitable for larger farms than smaller ones.     

热处理对猪粪高固厌氧消化产甲烷能力的影响

畜禽粪便属于有机物含量高、卫生风险大的污染物.本研究探寻不同热处理时间下,猪粪(含固率27.6%)不稀释直接进行70℃热处理的情况及热处理对中温高固厌氧消化的影响.结果表明,热处理能够去除猪粪的部分有机物,并能明显提高高固厌氧消化的产甲烷能力和产甲烷速率.热处理时间为1、2、3和4 d时,热处理对猪粪的VS去除率分别为15.1%、15.5%、17.8%、20.0%,甲烷产率(以CH4/VSadd计)分别为284.4、296.3、309.2、264.4 m L·g-1,相比原粪的甲烷产率分别提高49.7%、55.9%、62.7%、39.2%.热处理时间为3 d时,猪粪的甲烷产率最高.热处理对猪粪产甲烷的促进效果显著,能耗适中,并能够起到巴氏消毒的作用,具有较好的工程价值.