含氧柴油对柴油机排放及细颗粒物碳质组分的影响

乙缩醛(1,1-diethoxyethane)与柴油互溶性好, 可替代乙醇作为生物质来源的柴油含氧添加成分. 生物柴油掺混可以提高乙缩醛和柴油混合燃料的闪点及含氧量. 在柴油发动机台架上, 考察柴油和2种含氧柴油(10%乙缩醛+90%柴油和10%乙缩醛＋10%生物柴油＋80%柴油)在2个固定转速不同负荷的5个工况点的排放特性, 分析了NO_x、HC、CO和PM_2.5排放情况, 并用DRI的碳分析仪分析了PM_2.5中的碳质组分.结果表明, 与普通柴油排放相比, 含氧柴油对NO_x排放速率的影响不大, 在某些工况点HC排放速率有较显著的增加. 含氧柴油降低了柴油机PM_2.5排放速率, 最大降低幅度29%. 从碳质组成上看, 含氧燃料降低了PM_2.5中总碳 (total carbon,TC) 的排放速率, 最大降低幅度24%. 含氧柴油的元素碳(elemental carbon,EC)排放速率普遍低于普通柴油; 有机碳(organic carbon,OC)的排放速率在发动机高转速工况时明显低于普通柴油; PM_2.5的OC/EC值在大多数工况下高于普通柴油. 3种燃料排放PM_2.5的碳质组成百分比相似, OC和EC主要为OC1和EC1. 含氧柴油降低了柴油机PM_2.5的排放速率, 颗粒物中OC的比例有所增加, 但对颗粒物的碳质组分组成没有明显的影响.

Effects of Oxygenated Fuels on Emissions and Carbon Composition of Fine Particles from Diesel Engine

Acetal (1,1-diethoxyethane) is considered as an alternative to ethanol as bio-derived additive for diesel fuel, which is miscible in diesel fuel. Biodiesel can improve the oxygen content and flash point of the fuel blend of acetal and diesel fuel. Two oxygenated fuels were prepared: a blend of 10% acetal+90% diesel fuel and 10%acetal+10% biodiesel+80% diesel fuel. The emissions of NO_x, HC and PM_2.5 from oxygenated fuels were investigated on a diesel engine bench at five modes according to various loads at two steady speeds and compared with base diesel fuel. Additionally, the carbon compositions of PM_2.5 were analyzed by DRI thermal/optical carbon analyzer. Oxygenated fuels have unconspicuous effect on NO_x emission rate but HC emission rate is observed significantly increased at some modes. The emission rate of PM_2.5 is decreased by using oxygenated fuels and it decreases with the increase of fuel oxygen content. The emission rates of TC (total carbon) and EC (elemental carbon) in PM_2.5 are also decreased by oxygenated fuels. The emission rate of organic carbon (OC) is greatly decreased at modes of higher engine speed. The OC/EC ratios of PM_2.5 from oxygenated fuels are higher than that from base diesel fuel at most modes. The carbon compositions fractions of PM_2.5 from the three test fuels are similar, and OC1 and EC1 are contributed to the most fractions of OC and EC, respectively. Compared with base diesel fuel, oxygenated fuels decrease emission rate of PM_2.5, and have more OC contribution to PM_2.5 but have little effect on carbon composition fractions.