| 低浓度煤层气双塔真空变压吸附实验 |
| |
| 引用本文： | 竹涛,韩一伟,王若男,张星,刘海兵,刘锋.低浓度煤层气双塔真空变压吸附实验[J].环境工程,2020,38(10):156-161,46. |
| |
| 作者姓名： | 竹涛 韩一伟 王若男 张星 刘海兵 刘锋 |
| |
| 作者单位： | 1. 中国矿业大学(北京) 大气环境管理与污染控制研究所, 北京 100083; |
| |
| 基金项目： | 中央高校基本科研业务费专项;中央引导地方科技发展专项;山西省科技重大专项 |
| |
| 摘 要： | 我国低浓度煤层气资源丰富，但利用率低，且大部分直接排放到环境中，不仅造成了资源浪费，也加重了大气温室效应，因此，对低浓度煤层气进行变压吸附富集分离研究具有节能和环保的双重意义。采用双塔真空变压吸附装置进行低浓度煤层气变压吸附富集分离的研究，实验采用活性炭和碳分子筛混合吸附剂，考察了吸附压力、半周期、吸附塔高径比和混合吸附剂配比等参数对CH4分离效果的影响，并确定了最优工艺条件分别为180 kPa、90 s、7和2。该研究结果可为低浓度煤层气资源化利用提供参考。
|
| 关 键 词： | 低浓度 煤层气 活性炭 优化 工艺条件 |
| 收稿时间： | 2019-11-05 |
EXPERIMENTAL STUDY ON VACUUM PRESSURE SWING ADSORPTION OF LOW CONCENTRATION COAL-BED METHANE IN TWIN TOWERS |
| |
| ZHU Tao,HAN Yi-wei,WANG Ruo-nan,ZHANG Xing,LIU Hai-bing,LIU Feng.EXPERIMENTAL STUDY ON VACUUM PRESSURE SWING ADSORPTION OF LOW CONCENTRATION COAL-BED METHANE IN TWIN TOWERS[J].Environmental Engineering,2020,38(10):156-161,46. |
| |
| Authors: | ZHU Tao HAN Yi-wei WANG Ruo-nan ZHANG Xing LIU Hai-bing LIU Feng |
| |
| Institution: | 1. Institute of Atmospheric Environment Management and Pollution Control, China University of Mining & Technology(Beijing), Beijing 100083, China;2. Ministry of Environmental Protection Solid Waste and Chemicals Management Technology Center, Beijing 100029, China;3. Suzhou University of Science & Technology, Suzhou 215009, China |
| |
| Abstract: | Low concentration coal-bed gas resources are rich in China, but the utilization rate is low, and most of it is directly emitted into the environment, not only caused the waste of resources, also increased atmospheric greenhouse effect. Therefore, the study on enrichment and separation of low-concentration coal-bed gas by pressure-swing adsorption (PSA) technology has the dual function of energy saving and environmental protection. In this paper, the dual-tower vacuum PSA device was used, and the adsorbent in the experiment was activated carbon and carbon molecular sieve mixing adsorbent. The influence of adsorption pressure, half-period, adsorption tower height diameter ratio and mixed adsorbent ratio on the separation effect of CH4 were investigated, and the optimal process conditions were determined as follows:180 kPa, 90 s, 7 and 2, namely. The results could provide technical support for the resource utilization of low concentration coal-bed gas. |
| |
| Keywords: | |
| 本文献已被 万方数据 等数据库收录！ |
| 点击此处可从《环境工程》浏览原始摘要信息 |
| 点击此处可从《环境工程》下载免费的PDF全文 |
|
