| 闪锌矿常压酸浸含硫气体排放量控制研究 |
| |
| 引用本文： | 刘俊峰,易平贵.闪锌矿常压酸浸含硫气体排放量控制研究[J].环境工程,1996,14(6):23-27. |
| |
| 作者姓名： | 刘俊峰 易平贵 |
| |
| 作者单位： | 湘潭矿业学院化工系 湖南411201
(刘俊峰，易平贵)，湘潭矿业学院化工系 湖南411201(唐冬秀) |
| |
| 摘 要： | 采用铁闪锌矿常压直接酸浸制取硫酸锌、研究了浸取条件对气体硫化物排放量的影响。试验结果表明:浸取时硫酸浓度为20％～40％(m),温度为120～140℃,液固比为(4:1)～(8:1)(m),通氧速度为35～50cm~3·(min.dm~3)~(-1),含硫气体排放量最低,常压酸浸2h,锌的一次浸取率达90％以上,闪锌矿中的硫绝大部分转化为单质硫。
|
| 关 键 词： | 铁闪锌矿 常压酸浸 含硫气体 控制 |
THE CONTROL TO THE EXHAUST OF THE GAS CONTAINING SULFIDES IN THE LEACHING PROCESS OF ZINC SULPHIDE CONCENTRATE BY SULPHURIC ACID ON THE NORMAL PRESSURE |
| |
| Liu Junfeng Yi Pinggui Tang Dongxiu.THE CONTROL TO THE EXHAUST OF THE GAS CONTAINING SULFIDES IN THE LEACHING PROCESS OF ZINC SULPHIDE CONCENTRATE BY SULPHURIC ACID ON THE NORMAL PRESSURE[J].Environmental Engineering,1996,14(6):23-27. |
| |
| Authors: | Liu Junfeng Yi Pinggui Tang Dongxiu |
| |
| Abstract: | The effect of the condition on the exhuast of the gas containing sulfides in the leaching processes of zinc sulphide concentrate to produce zinc sulphate by sulphuric acid on the normal pressure was discussed, which show as follow: the content of sulfuric acid is 20-40% , the leaching temperature is 120-140℃ , the ratio of solid to liquid is 1:6-1:8(mass ratio), the velocity of the aeration of oxygen is 35-50cm3/min.dm3(the volume of the leaching liquid) and the amount of the exhausting gas containing sulfides is very low. The leaching yield of zinc exceeds 90% after two hour's leaching processes, and the sulfides in iron and zinc sulphide concentrate has almost become into sulphur if it follows the leaching conditions shown as before. |
| |
| Keywords: | Iron and zinc sulphide concentrate leaching processes on the normal pressure the gas containing sulfides and control |
| 本文献已被 CNKI 维普 等数据库收录！ |
