| 电絮凝过程中倒极消除极板钝化 |
| |
| 引用本文： | 黄雪琪, 靖波, 陈文娟, 尹先清, 李赓. 电絮凝过程中倒极消除极板钝化[J]. 环境工程学报, 2019, 13(11): 2661-2667. doi: 10.12030/j.cjee.201901028 |
| |
| 作者姓名： | 黄雪琪 靖波 陈文娟 尹先清 李赓 |
| |
| 作者单位： | 1.长江大学，石油石化污染控制与处理国家重点实验室，荆州 434023; 2.长江大学化学与环境工程学院，荆州 434023; 3.海洋石油高效开发国家重点实验室，北京 100027; 4.中海油研究总院，北京 100027 |
| |
| 摘 要： | 针对电絮凝处理污水过程中极板易发生钝化影响电絮凝效果的问题，采用倒极方法消除了极板钝化，并通过SEM和EDS，定性、定量分析不同反应时间段极板的表面形态和元素含量的变化，研究了表面钝化层成分及含量随处理时间的变化趋势。结果表明：电絮凝处理压裂废水中Al阳极钝化层的主要成分是Al2O3，阴极钝化层的主要成分是CaCO3；倒极后的阴极板表面Al2O3含量在20 h内由48.94%下降到18.73%，阳极板Al2O3含量由11.87%降低到9.28%，这表明倒极能有效消除Al2O3氧化膜对极板钝化的影响；对于Ca2+含量较低的压裂废水，倒极使CaCO3的吸附量控制在0.01%~0.34%，可有效控制极板钝化现象的发生。
|
| 关 键 词： | 电絮凝净水 油田压裂废水处理 极板钝化 极板倒极 |
| 收稿时间： | 2019-01-04 |
Elimination of electrode passivation by reversing electrodes in the process of electroflocculation |
| |
| HUANG Xueqi, JING Bo, CHEN Wenjuan, YIN Xianqing, LI Geng. Elimination of electrode passivation by reversing electrodes in the process of electroflocculation[J]. Chinese Journal of Environmental Engineering, 2019, 13(11): 2661-2667. doi: 10.12030/j.cjee.201901028 |
| |
| Authors: | HUANG Xueqi JING Bo CHEN Wenjuan YIN Xianqing LI Geng |
| |
| Affiliation: | 1.State Key Laboratory of Petroleum Pollution Control, Yangtze University, Jingzhou 434023, China; 2.College of Chemical and Environmental Engineering,Yangtze University, Jingzhou 434023, China; 3.State Key Laboratory of Offshore Oil Exploitation, Beijing 100027, China; 4.China National Offshore Oil Corporation Research Institute, Beijing 100027, China |
| |
| Abstract: | To solve the problem that the electrode plate is frequently passivated which will affect the electroflocculation efficiency in the process of sewage treatment, reversing electrodes operation was used to eliminate electrode passivation. The variations of surface morphology and element contents of the electrodes at different reaction time intervals were qualitatively and quantitatively analyzed by SEM and EDS. The variation trends of composition and element content of surface passivation layer with processing time were investigated. The results show that, in the electroflocculation treatment of fracturing wastewater, the main components of passivation layers on the aluminum anode and cathode were Al2O3 and CaCO3, respectively. After 20 h reversing electrodes operation, the content of Al2O3 on the surface of the cathode electrode decreased from 48.94% to 18.73%, and it on the surface of anode electrode decreased from 11.87% to 9.28%. The results indicate that the reversing electrodes method can effectively eliminate the effect of the Al2O3 oxide film on electrode passivation. When electroflocculation method was used to treat fracturing wastewater with low content of Ca2+, the content of CaCO3 could be controlled within the range of 0.01%~0.34% on the surface of the electrode by reversing electrodes operation, which can effectively control the electrode passivation. |
| |
| Keywords: | water purification by electroflocculation oilfield fracturing wastewater treatment electrode passivation reversing electrodes |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
| 点击此处可从《环境工程学报》浏览原始摘要信息 |
|
点击此处可从《环境工程学报》下载全文 |
|
