垃圾焚烧重金属迁移特性及其影响因素

综述了城市固体垃圾(MSW)焚烧过程中的Hg、Cd、Pb、Cu、Zn、As和Cr等几种主要重金属污染源在焚烧过程中的迁移特性及其主要影响因素。将重金属在焚烧过程中的迁变归结为:蒸发、气相和表面反应、冷凝成核团聚和飞灰吸附等4个主要过程;而垃圾中重金属的初始浓度、原始垃圾的基体盐分(如A l、S i和K、Na等的存在形式)、垃圾中的C l(PVC和NaC l)和S的含量、垃圾的含水量以及焚烧过程中的运行参数(温度、滞留时间、氧化-还原气氛)等都会对焚烧过程的迁移规律产生影响。     

气氛对垃圾焚烧中重金属迁移特性的影响

对城市生活垃圾焚烧过程中Ni、Cd、Cu、Pb、Cr和Zn 6种重金属在不同气氛中的挥发率进行了研究,同时比较了氧化性气氛和还原性气氛、中性气氛和酸性气氛以及在混合气氛中各重金属的挥发率。结果表明,氧化性和还原性气氛对Ni、Cu和Cr挥发影响较大,Cr、Cd、Pb和Zn在还原气氛下挥发率比在氧化气氛下高,而Ni和Cu则...     

广东某大型城市生活垃圾焚烧厂9种重金属的迁移特征

采集广东某大型城市生活垃圾焚烧厂一期(WI-A)和二期(WI-B)的进厂垃圾、渗滤液、飞灰、底渣和烟气样品,分析了各样品中砷、镉、钴、铬、铜、汞、镍、铅、锌共9种重金属含量,研究重金属的迁移特征。结果显示,9种重金属呈现4类不同的迁移特征,钴、铜、镍、铬主要迁移至底渣中,锌、砷、铅主要迁移至底渣和飞灰中,镉主要迁移至飞灰中,汞主要迁移至飞灰和烟气中。活性炭吸附和布袋除尘器的组合对除汞以外的重金属治理效果明显。WI-A和WI-B垃圾中的汞分别约有28%、37%随烟气排到环境中。     

医疗垃圾焚烧飞灰重金属形态分析

利用原子吸收光谱仪分别对医疗垃圾焚烧飞灰重金属含量和重金属形态及其随颗粒度分布特性进行了分析,结果表明,飞灰中Cd、Zn、Pb等的浸出浓度远超标与这些重金属的可交换态和碳酸盐态含量较高有关;飞灰颗粒度主要在96 μm以下,96～150 μm的颗粒中Cd、Pb含量最高,且Zn、Cd的形态以可交换态为主.     

城市垃圾焚烧飞灰重金属药剂配伍稳定化实验研究

以飞灰中富含的Pb和Zn为目标重金属,对飞灰中重金属药剂配伍稳定化效果了实验研究.选用EDTA、Na2S、NaH2PO4等稳定化药剂和pH值控制,首先将试剂单独投加飞灰中测定重金属浸出浓度,分析各试剂的稳定化效果;然后通过系列试验观察现象,确定试剂最优投加顺序;最后,按照试剂性质制定4个配伍方案,按照最优投加顺序投加试剂,测定分析各个配伍方案的稳定化效果.结果表明:pH值保持在弱碱性(10左右),重金属稳定化效果较好.EDTA二钠、NaH2PO4和Na2S重金属稳定化效果明显,而有机试剂EDTA二钠稳定化效果明显优于NaH2PO4和Na2S;稳定化药剂投加顺序以Na2S、EDTA二钠、NaH2PO4顺序投加处理效果为最佳;配伍方案4处理效果明显优于其他方案,可以实现稳定化药剂配伍相合,提高飞灰中重金属稳定化效果,同时减少有机螯合剂的使用量,从而降低处理成本.     

柠檬酸及柠檬酸铵电场强化水洗脱除垃圾焚烧飞灰中重金属

为进一步强化城市生活垃圾焚烧飞灰中重金属电场水洗脱除效果,详细研究柠檬酸和柠檬酸铵强化洗脱效果,分析了初始pH、辅助剂浓度和电流密度对飞灰中重金属去除率的影响,探讨了处理后飞灰的浸出毒性.结果表明,柠檬酸和柠檬酸铵辅助剂的电场强化水洗均能显著去除飞灰中重金属,且去除率随着初始pH的减少、辅助剂浓度的增加和电流密度的增加...     

城市生活垃圾焚烧处理过程中重金属迁移规律研究

通过采集厦门2个垃圾焚烧发电厂进厂垃圾、渗滤液、飞灰、炉渣和烟气样品,分析垃圾组成成分及各组分的重金属含量,结果表明,垃圾中以厨余、橡塑类和纸类为主,共占到垃圾干基的78．08％,重金属含量大小次序为Zn〉Cu〉Pb〉Cr〉Ni〉Cd〉Hg;垃圾渗滤液中除Zn外,其他金属的含量都较低,一厂渗滤液中重金属Ni、Zn迁移量较大,分别达到24．46％和8．52％。二厂渗滤液中重金属的迁移有相同的趋势,但含量相对较高。垃圾焚烧后其重金属主要分布在飞灰和废渣中,烟气中的含量非常少,不同金属的含量均有差别,这与金属的性质有很大关系;通过浸出毒性分析,飞灰中重金属酸溶态含量多,容易浸出,属于危险废物。同时,不同烟气处理工艺产生的飞灰的重金属浸出量有很大差别。     

超积累植物与煤在混烧过程中重金属的迁移特性

通过在管式炉中进行了煤与超积累植物——伴矿景天的混烧实验,主要研究了不同燃烧温度、不同氮氧比气氛以及煤与伴矿景天的不同混合质量比对混烧过程中重金属(Cd、Zn与Pb)迁移情况的影响,并应用XRD技术分析灰渣中重金属的存在形式。实验分析表明:升高温度能在不同程度上增强Cd、Zn与Pb的挥发,提高其在飞灰中的含量;与单独燃烧伴矿景天相比,煤与伴矿景天混烧更有利于Cd和Zn保留在底渣中,但不利于Pb保留在底渣中;对于不同氮氧比气氛而言,Zn和Cd在底渣中的含量随着气氛中氧气含量的提高而升高,而气氛对Pb的影响是随着氧气含量的增加,Pb在底渣的含量是先增加后减少;当煤在混烧中的比例较高时,Cd更多向飞灰迁移,Pb和Zn则更多地残留于底渣。     

城市生活垃圾焚烧飞灰的熔融分离处理

焚烧法处理城市生活垃圾已在世界先进发达国家广泛采用。垃圾焚烧飞灰含有大量的重金属,必须进行合理安全处置。在分析城市生活垃圾焚烧飞灰的物理化学性质基础上,研究了垃圾焚烧飞灰固化成型、熔融分离的无害化处理新工艺。实验结果表明：飞灰固化成球的适宜粘结剂为5%～7%消石灰,养护时间为10～12 d,固化球强度达0.24 kg/cm²以上,可以满足运输和熔化分离要求;固化后的飞灰在1 300℃左右熔融分离后,重金属的分离效果好,达到97%以上,可达到无害化处理标准;对1 300℃和1 400℃熔融分离后熔渣的重金属浸出毒性测试显示,重金属浸出毒性问题可以完全解除。研究结果表明,采用飞灰固化-熔融分离工艺处理城市生活垃圾焚烧飞灰是可行的。     

垃圾焚烧过程中影响重金属分布因素的研究

在转式垃圾焚烧炉和固定床加热炉中，研究了有机垃圾焚烧过程中温度、水分、无机氯及有机氯对几种重金属分布的影响。研究结果表明，焚烧垃圾过程中焚烧温度对重金属分布特性的影响特性不一，重金属锌和铅容易转移到气相中去，而重金属镍和铬大部分是以固态形式残留在底渣中；水能与重金属及其化合物发生反应，引起物质转变，影响重金属的分布；氯的存在也影响重金属的分布特性，氯的参与使重金属更易向飞灰或烟气中迁移。     

垃圾焚烧过程中影响重金属分布因素的研究

在转式垃圾焚烧炉和固定床加热炉中,研究了有机垃圾焚烧过程中温度、水分、无机氯及有机氯对几种重金属分布的影响。研究结果表明,焚烧垃圾过程中焚烧温度对重金属分布特性的影响特性不一,重金属锌和铅容易转移到气相中去,而重金属镍和铬大部分是以固态形式残留在底渣中;水能与重金属及其化合物发生反应,引起物质转变,影响重金属的分布;氯的存在也影响重金属的分布特性,氯的参与使重金属更易向飞灰或烟气中迁移。     

核桃果皮炭粉对3种重金属离子吸附的影响

采用均匀设计的实验方法,研究了2种核桃果皮炭粉（提取水溶性混合物和未提取水溶性混合物的核桃皮炭粉）对Cr、Cu和Cd等重金属离子的吸附最优条件以及对3种离子吸附的影响因素。结果表明,核桃皮炭粉对Cr（Ⅵ）、Cd2+和Cu2+的吸附最优条件为：pH=4,温度为60℃,浓度为150 μg/mL,吸附剂用量为2.4 g,时间为120 min;pH=4.5,温度为30℃,浓度为180 μg/mL,吸附剂用量为5.4 g,时间为60 min;pH=5,温度为80℃,浓度为210 μg/mL,吸附剂用量为0.4 g,时间为100 min;pH和Cr（Ⅵ）浓度增大,不利于2种吸附剂对Cr（Ⅵ）的吸附;pH和温度增大,不利于2种吸附剂对Cu2+的吸附;温度和吸附剂用量增加,有利于2种吸附剂对Cd2+的吸附。未提取水溶性混合物比提取水溶性混合物的核桃果皮炭粉对3种金属的吸附显著。2种吸附剂的吸附率均表现为Cr>Cd>Cu。     

Major factors influencing bacterial leaching of heavy metals (Cu and Zn) from anaerobic sludge

Anaerobically digested sewage sludges were treated for heavy metal removal through a biological solubilization process called bacterial leaching (bioleaching). The solubilization of copper and zinc from these sludges is described in this study: using continuously stirred tank reactors with and without sludge recycling at different mean hydraulic residence times (1, 2, 3 and 4 days). Significant linear equations were established for the solubilization of zinc and copper according to relevant parameters: oxygen reduction potential (ORP), pH and residence time (t). Zinc solubilization was related to the residence time with a r2 (explained variance) of 0.82. Considering only t=2 and 3 days explained variance of 0.31 and 0.24 were found between zinc solubilization as a function of ORP and pH indicating a minor importance of those two factors for this metal in the range of pH and ORP experimented. Cu solubilization was weakly correlated to mean hydraulic residence time (r2=0.48), while it was highly correlated to ORP (r2=0.80) and pH (r2=0.62) considering only t of 2 and 3 days in the case of pH and ORP. The ORP dependence of Cu solubilization has been clearly demonstrated in this study. In addition to this, the importance of the substrate concentration for Cu solubilization has been confirmed. The hypothesis of a biological solubilization of Cu by the indirect mechanism has been supported. The results permit, under optimum conditions, the drawing of linear equations which will allow prediction of metal solubilization efficiencies from the parameters pH (Cu), ORP (Cu) and residence time (Cu and Zn), during the treatment. The linear regressions will be a useful tool for routine operation of the process.     

底泥性质对重金属生物淋滤效果的影响

生物淋滤技术是一项可以将重金属从污染底泥或土壤中分离出来的环境修复技术,具有反应温和、耗酸少、运行成本较低、去除效率高,以及脱毒后底泥的脱水性能好等优点。然而,底泥成分复杂、流域特异性高,这使得相似的生物淋滤工艺对不同底泥的重金属去除效果不尽相同、淋滤技术的工艺参数标准化难度增加。综述了底泥性质对淋滤反应的3方面影响:底泥中的有机质与酸可挥发性硫化物(AVS)会改变重金属的形态;pH、可还原性硫、水溶性有机物(DOM)会对淋滤功能菌的活性产生影响;底泥粒度和耗酸能力(ACC)也会影响重金属的化学淋出效果。在此基础上提出今后该技术有待开展的研究内容,以期为该技术的进一步推广应用提供理论依据和技术支撑。     

再生水农灌过程中重金属迁移规律研究

再生水回用于农业灌溉,可以缓解农业水资源的需求压力,这对徐州缺水地区具有重要意义.通过土柱模拟实验,研究了不同灌溉方式及2种典型农作物——小麦、玉米的种植对As、Cd、Cu、Zn在徐州灌区土壤中迁移行为的影响.实验用添加重金属的再生水和地下水进行土柱滴灌.结果表明,再生水灌溉和再生水、地下水轮灌之后,重金属主要在土样表...     

Road traffic emission factors for heavy metals

Quantifying the emissions and concentrations of heavy metals in urban air is a prerequisite for assessing their health effects. In this paper a combination of measurements and modelling is used to assess the contribution from road traffic emissions. Concentrations of particulate heavy metals in air were measured simultaneously during 1 year at a densely trafficked street and at an urban background site in Stockholm, Sweden. Annual mean concentrations of cadmium were 50 times lower than the EU directive and for nickel and arsenic concentrations were 10 and six times lower, respectively. More than a factor of two higher concentrations was in general observed at the street in comparison to roof levels indicating the strong influence from local road traffic emissions. The only compound with a significantly decreasing trend in the urban background was Pb with 9.1 ng m^?3 in 1995/96 compared to 3.4 ng m^?3 2003/04. This is likely due to decreased emissions from wear of brake linings and reduced emissions due to oil and coal combustion in central Europe.Total road traffic emission factors for heavy metals were estimated using parallel measurements of NOx concentrations and knowledge of NOx emission factors. In general, the emission factors for the street were higher than reported in road tunnel measurements. This could partly be due to different driving conditions, since especially for metals which are mainly emitted from brake wear, more stop and go driving in the street compared to in road tunnels is likely to increase emissions. Total emissions were compared with exhaust emissions, obtained from the COPERT model and brake wear emissions based on an earlier study in Stockholm. For Cu, Ni and Zn the sum of brake wear and exhaust emissions agreed very well with estimated total emission factors in this study. More than 90% of the road traffic emissions of Cu were due to brake wear. For Ni more than 80% is estimated to be due to exhaust emissions and for Zn around 40% of road traffic emissions are estimated to be due to exhaust emissions. Pb is also mainly due to exhaust emissions (90%); a fuel Pb content of only 0.5 mg L^?1 would give similar emission factor as that based on the concentration increment at the street. This is the first study using simultaneous measurements of heavy metals at street and roof enabling calculations of emission factors using a tracer technique.     

Migration of heavy metals in soil as influenced by compost amendments

Soils contaminated with heavy metals can pose a major risk to freshwaters and food chains. In this study, the success of organic and inorganic intervention strategies to alleviate toxicity in a highly acidic soil heavily contaminated with As, Cu, Pb, and Zn was evaluated over 112 d in a mesocosm trial. Amelioration of metal toxicity was assessed by measuring changes in soil solution chemistry, metal leaching, plant growth, and foliar metal accumulation. Either green waste- or MSW-derived composts increased plant yield and rooting depth, reduced plant metal uptake, and raised the pH and nutrient status of the soil. We conclude that composts are well suited for promoting the re-vegetation of contaminated sites; however, care must be taken to ensure that very short-term leaching pulses of heavy metals induced by compost amendment are not of sufficient magnitude to cause contamination of the wider environment.     

燃烧条件对灰渣中重金属元素形态的影响

根据改进了的BCR连续提取法,重金属元素形态分为酸可提取态、氧化物结合态、有机物结合态和残渣态,实验研究了不同燃烧温度、空气流量和燃烧气氛对燃煤重金属（Cr、Mn、Ni、Cu、Zn、As、Cd和Pb）的形态分布和挥发特性的影响规律。结果表明：在原煤和灰渣中,各重金属元素均主要以稳定的残渣态存在;8种重金属元素的挥发性难易程度顺序为Pb、Cd、Zn>As、Cr、Ni、Cu>Mn;燃烧温度从650℃升至1 050℃过程中,各重金属元素4种存在形态的逸出率逐渐升高,逸出率最低增大幅度为20%,最高达60%;随空气流量的增大,重金属元素的有机物结合态和残渣态加速分解和挥发,各重金属元素的逸出率不断增大;除元素Mn和Ni较易于在贫氧气氛中挥发外,元素Cr、Cu、Zn、As、Cd和Pb均在富氧气氛中比较易于挥发气化。     

市政污泥焚烧过程中重金属迁移转化行为研究进展

焚烧已成为市政污泥处置或资源化利用的重要手段.焚烧过程会改变市政污泥中重金属的化合态和价态,从而影响其迁移转化行为.目前,国内外已对市政污泥焚烧过程中重金属的迁移转化行为开展了大量研究.梳理和归纳了市政污泥特性以及焚烧炉炉型、焚烧温度、停留时间、反应气氛和添加物等工况对重金属迁移转化行为影响的研究进展,并提出了未来仍需...