有机高分子絮凝剂AUF的研制及其除油效果测定

以尿素、甲醛为原料合成脲醛树脂，加入环氧氯丙烷对树脂进行改性，再加入三乙铵进行季胺化，得到改性脲醛树脂季铵盐絮凝剂AUF。在WEMCO浮选机上考察AUF的除油性能及最佳合成条件。结果表明：AUF投药量为10mg／L时，出水中油浓度达到国家排放标准；当甲醛、尿素、环氧氯丙烷三者的摩尔比为2：1：0.5，季铵化温度为80～110C，反应时间为4～5h时，得到的絮凝剂AUF除油效果最好。     

聚合物驱采出水处理工艺研究

聚合物驱油技术在大庆油田得到广泛应用,由于采出水粘度大、油珠粒径小,其处理难度大于油田常规水驱采出水。通过对聚合物驱采出水的特性分析,并在现场分别进行了以横向流除油器(串联DTH聚结器)和水力旋流器为主体的工艺试验。其工艺参数分别为:横向流除油器和DTH聚结除油器的处理量均为85 m3/h,有效停留时间为2.4 h。过滤器为石英砂、磁铁矿双层滤料,处理量为20 m3/h,过滤周期24 h,反冲洗时间为15 min,一次和二次过滤的滤速分别为12 m3/h和8 m3/h。试验结果表明:两种工艺均可代替现有的沉降过滤工艺处理聚合物驱采出水。     

一体式膜生物反应器(SMBR)处理抗生素废水研究

采用一体式膜生物反应器处理抗生素废水,用配水在水温30℃,体积负荷分别为0.5COD/m3*d,1.0COD/m3*d,1.5kgCOD/m3*d,出水COD、NH3-N均小于21.7mg/L、14.1mg/L,原水实验中在水温30℃时,体积负荷为0.957kgCOD/m3*d时,出水平均值分别为26.53mg/L,2.84mg/L、有较好的处理效果.     

中空纤维膜生物反应器处理炼厂浮选池出水试验研究

研究设计的膜生物反应器处理炼厂浮选池出水,在每天进水容积负荷1.0 kg COD/m3,进水COD浓度600 mg/L,MLSS为900～5500 mg/L的条件下,无论活性污泥表现正常还是膨胀,过滤出水中COD均稳定地小于90 mg/L,处理效果好于目前炼油厂的合建式曝气池(容积负荷为0.5 kg COD/m3左右,出水COD100 mg/L左右)。试验运行期间,膜通量最高可达到42 L/m2·h。该工艺的技术关键是采用特殊流态来降低膜堵塞的膜生物反应器和优良质量的膜。     

高矿化度稠油采出水处理实验

为解决稠油采出水合格、有序排放问题,针对稠油采出水高矿化度、可生物性差,完全采用好氧工艺处理污水难度较大的水质特点,通过对车510稠油采出水进行分析,提出了实现采出水达标排放的技术路线,并开展稠油采出水达标处理的现场实验。结果表明采用"混凝沉降+水解酸化—接触氧化"工艺处理该采出水,其出水水质中COD_(Cr)≤120mg/L、石油类≤10mg/L、挥发酚≤0.5mg/L,可达到GB 8978—1996《污水综合排放标准》中二级指标。     

焦化废水处理新工艺研究

对某钢铁厂焦化废水进行曝气吹脱10h,氨氮去除率达73.7%,然后用缺氧-SBR工艺处理焦化废水,进水浓度为COD1474mg/L、NH3-N826.8mg/L时,缺氧SRT10h,SBR曝气10h,沉降2h,出水COD186mg/L、NH3-N290.25mg/L,去除率分别达到87.83%、64.9%。     

生物填料塔处理餐厅污水的研究

分别以自行开发的组合型填料和焦炭作生物载体构成的生物填料等塔对餐厅污水处理进行了试验研究,试验考察了污水入塔COD值对塔中DO的影响,观察到的结果表明：长期在高入塔COD下运行对生物膜系统的持久、稳定不利;水力停留时间取3h－4h,COD的容积去除负荷为4kg/m^3.d时,出水既可达标,又可保持较高的处理能力;鼓风曝气时,气水比取8－12可使出水达标,而功耗较低;在相同的微生物系统和操作条件下,布水布气性好的组合填料处理效果高于布水气性差的焦炭。     

套管保护液对钻井废水处理效果的影响＊

通过研究高含硫气田钻井完井后套管保护液对钻井废水处理效果的影响,可知:采用混凝/二次絮凝/吸附工艺处理不含套管保护液的钻井废水时,出水COD<150 mg/L;当套管保护液加量>0.5 mL/L时,出水中COD随套管保护液用量增加而急剧升高,远大于150 mg/L;采用混凝/吸附/微电解组合工艺处理含套管保护液的完井钻井废水,出水COD<150 mg/L,满足GB 8978-1996《污水综合排放标准》二级标准的要求。     

AO-MBR一体化污水处理系统的中试研究

以生活杂用水为回用目标,研究了AO-MBR一体化污水处理系统对生活污水的处理情况。试验表明,HRT为8 h、SRT为50 d、回流比为120%时,冬季阶段,系统出水的COD浓度低于30 mg/L,BOD5浓度低于10 mg/L,氨氮浓度低于5.0 mg/L,色度低于30度,浊度低于0.3 NTU;夏季阶段,系统出水的COD在2.1～20.5 mg/L之间,BOD5在1.5～7.4 mg/L之间,氨氮在0.04～2.57 mg/L之间,色度在10～30度之间,浊度在0.12～0.27 NTU之间,出水水质达到生活杂用水水质标准。     

催化氧化复合生物技术处理油气田压裂返排液

针对油气田压裂返排液处理难度大的问题,以四川某气田井组压裂返排液为研究对象,通过对其水质特征和治理技术现状的分析,提出催化氧化复合生物处理工艺并进行了现场实验。实验结果表明:该技术对于压裂返排液COD去除效果明显,最终出水COD浓度均降至100mg/L以下,COD去除率达到98%以上;G-BAF生化系统进水盐度在0.5%~5%时,系统适应性非常好,有机物去除率达93%以上;当盐度提高到8%时,有机物去除率仍能保持在84%左右,G-BAF生化系统适合高盐度压裂返排液的处理;压裂返排液出水主要污染指标COD浓度、氨氮浓度、SS浓度、pH值均达到GB 8978—1996《污水综合排放标准》一级标准,出水可用于油田及污水处理站设备清洁、钻井岩屑清洗等,实现废水综合利用。     

EFFECTIVENESS OF WASTE MINIMIZATION PROJECTS IN REDUCING WATER DEMAND BY UK INDUSTRY1

ABSTRACT: There is growing interest in managing water demand in the UK. A series of waste minimization clubs have been set up within the country and this paper identifies the effectiveness of these clubs in reducing the demand for water within industry. Membership of these clubs is voluntary and the only incentive for industry to reduce water consumption, and consequently the production of effluent, is the almost immediate financial saving made by the company, often achieved by accounting for the water consumption and loss within site from the point of input from the water supplier to output in the form of effluent. On average, companies are able to reduce water consumption by up to 30 percent. If the entire industrial sector within the UK were to achieve this degree of savings, it is possible that approximately 1300Ml/d could be saved.     

油田采油废水的可生化性研究

通过实验,采用BOD动力学方程原理对胜利油田王岗、桩西联采油废水的可生化性进行了研究。结果表明 :采油废水的生化氧化速度常数k值较小 ,生化氧化速度m值也不高 ,说明用生化法处理采油废水时生化处理速度慢 ,反应时间长 ;BOD5/COD大于0.3 ,CODnb/COD小于0.5,说明采油废水的可生化性尚好 ,氧化深度较大。     

ACUTE RESIDUAL TOXICITY OF SEVERAL DISINFECTANTS IN DOMESTIC AND INDUSTRIAL WASTE WATER1

ABSTRACT: This study determined the acute toxicity of waste water disinfected with chlorine, bromine chloride, or ozone. The residual toxicity of effluent dechlorinated with sulfur dioxide was also tested. Toxicity tests were conducted with cyprinid, salmonid, and centrarchid fishes, as well as several species of fresh water macroinvertebrates. Residual chlorine exhibited the greatest toxicity of the disinfectants tested; dechlorination with sulfur dioxide effectively eliminated the toxicity of chlorinated effluent. Residual ozone produced mortality in test animals only under special conditions where subjects were exposed to effluent immediately after it was contacted with ozone, and chlorobrominated effluent was more toxic to salmonids than chlorinated effluent.     

CITY OF TUCSON WASTE WATER EFFLUENT DELIVERY FACILITY1

ABSTRACT: The Tucson area is totally dependent on ground water, which is in increasingly short supply due to excessive overdrafts. Tucson area waste water treatment plants discharge material quantities of secondary effluent downstream, which is lost to evapotranspiration and recharge of the ground water basin. The city and the four large mining companies who share the common Santa Cruz basin ground water, recognized the common water supply problem and agreed to fund a feasibility study for mining process use of the effluent to partly alleviate the overdraft of ground water. The study analyzed the projected waste water effluent resources, potential mining company demand for waste water effluent and possible interface of an effluent delivery facility with the proposed Central Arizona Project. The effluent resources were analyzed with respect to potential demand. An optimum alignment was selected. An optimum system was detailed through design schematics, amortized cost and finance requirements, and an implementation schedule. It was concluded that a waste water effluent delivery facility could be implemented which would utilize reclaimed effluent in quantities approximating 35 percent of basin overdraft and which would provide revenue for full cost recovery over a 20 year operation period. The mining companies are studying the internal economic impacts of the project.     

四川某煤矿矿井废水处理优化设计应用与调试

本文以四川某煤矿矿井废水处理工程为例,介绍了该工程比较优化的方案应用,即依据该工程所处的地势,将废水处理站建在坡度比较大的地方,采用多座斜管沉淀池并联运行,提高了沉淀效率。矿井水全部自流进入各构筑物,大幅减少了投资及设备维护费用。在工艺调试阶段,先在实验室进行一系列矿井废水混凝试验。结果表明,采用PAC和PAM配合投加絮凝效果最好,最佳投药量PAC为25mg／L,PAM为4m/L。该工程构筑物简单,处理效果好,出水达到GB20426—2006排放标准。     

NPR工艺在城镇污水处理中的应用

介绍了将NPR工艺应用于某城镇污水处理厂的工程概况,工艺流程,各主要处理构筑物的设计参数以及运行情况,运行实践表明,该工艺对污染物浓度较低的城镇污水有很好的处理效果,各项指标均可达到现行的排放标准。     

Quality of Water from Hand Dug Wells in Onitsha Metropolitan Areas of Nigeria

Summary Wide Range of human and anthropogenic activities impinges on the urban environment in most cities in Nigeria, to degrade the quality of water resources. Some of these activities (daily discharge of solid and liquid waste, industrial effluent, and physo-chemical weathering processes) are discharged directly on sources of water supply to the populace of Onitsha. Based on this problem, this paper examines the quality of water from hand-dug wells in Onitsha. 15 wells water samples were collected during the month of January, July, and August with the aid of sterilized containers. And sent to the laboratory for analyses, results showed that wells that are located close to dumpsites are more polluted in terms of turbidity, TSS, CaCo₂ conductivity salinity acidity, Pb, Fe and bacteriological quality of the well water. Also most of the hand-dug well water qualities are unsafe for human consumption, because they are generally above the WHO maximum acceptable threshold. Since this source of water form one of the major source of water to the inhabitants, there is need for purification proper disposal of waste, public education of the health implication of waste/impure water and other management measures.     

RECLAIMED WASTE WATER FOR GROUNDWATER RECHARGE1

ABSTRACT. The Orange County Water District has conducted studies in waste water reclamation and groundwater recharge since 1965. The work has been done in three phases: (1) Study in both laboratory and pilot-scale units on the feasibility of reclaiming trickling filter effluent for injection through wells into confined aquifers; (2) long-term injection study to determine the fate of injected reclaimed water and to observe the performance of a multi-casing injection well; (3) testing alternative treatment methods in a 25,000 gpd pilot plant to solve the water quality problems which developed during the injection study. The reclaimed trickling filter effluent was found to be injectable and did not cause excessive well clogging. The multi-casing injection wells performed very satisfactorily. The reclaimed water would be acceptable for domestic use after travel through 500 feet of a confined aquifer in that bacteria, virus and toxic material were consistently absent. However, the odor and taste which persisted in the injected reclaimed water and the high concentration of dissolved inorganics are undesirable characteristics. Methods to eliminate the odor are being tested at the present time. A cooperative project with the Office of Saline Water is under way to develop a source of desalted seawater to blend with reclaimed waste water.     

双滤料曝气生物滤池污水深度处理的研究

采用陶粒、沸石为滤料的曝气生物滤池对生物处理系统二级出水进行深度处理回用,研究了水力停留时间、气水体积比对污染物COD和NH3-N处理效果的影响。结果表明：水力停留时间为8 h,气水体积比为3∶1的工况下,处理效果较好。稳定运行后,出水COD、BOD5、SS、NH3-N、TP和色度平均值分别为15.6 mg/L、3.2 mg/L、8.5 mg/L、1.24 mg/L、0.40mg/L和8度,达到《城市污水再生利用—城市杂用水水质》（GB/T 18920-2002）标准,出水可用于道路清扫、绿化等。     

组合工艺处理上虞市总干渠微污染原水的中试启动研究

根据上虞市总干渠微污染原水水质特点,采用混凝沉淀＋曝气生物沸石滤池（ZBAF）＋活性炭滤池（GAC）组合工艺进行中试研究,考察了运行初期ZBAF的挂膜启动情况和组合工艺整体对此类水体的处理效果。结果表明：ZBAF在水温25℃~29℃、气水比1∶2、滤速2.5m/h下运行20天即挂膜成功;挂膜成熟后,组合工艺在5m/h滤速下对浊度、氨氮、UV254、CODMn的去除率分别达99%、85%、70%和75%,出水水质良好,浊度、氨氮、CODMn分别稳定在0.5NTU、0.1mg/L、1.5 mg/L以下。