Nitrogen fertilizer recommendations for corn grown on soils amended with oily food waste

Soil and plant indices of soil fertility status have traditionally been developed using conventional soil and crop management practices. Data on managing N fertilizer for corn (Zea mays L.) produced on soils amended with C-rich organic materials, such as oily food waste (OFW) is scarce. Identification of a reliable method for making N fertilizer recommendations under these conditions is imperative. The objective of this research was to evaluate soil NO(3)-N (0- to 30-cm depth) at preplant and presidedress (PSNT) times of sampling for predicting N requirements for corn grown on fields receiving OFW. Experiments were conducted at two locations in Ontario, Canada over 3 yr (1995-1997) where OFW was applied at different rates (0, 10, and 20 Mg ha(-1)), times (fall and spring), and slope positions (upper, mid, and lower) within the same field. Presidedress soil NO(3)-N contents were higher compared with preplant time of sampling under all OFW management conditions. Corn grain yields were significantly affected by OFW management and N fertilizer application rates. Maximum economic rate of N application (MERN) varied depending on OFW management conditions. Presidedress soil NO(3)-N contents had a higher inverse relationship with MERN (r = -0.88) compared with soil NO(3)-N at preplant (r = -0.74) time of sampling. A linear regression model (Y = 180.1 - 8.22 NO(3)-N at PSNT) is proposed for making N fertilizer recommendations to corn grown on soils amended with OFW in this geographical region.     

Recycling soil nitrate nitrogen by amending agricultural lands with oily food waste

With current agricultural practices the amounts of fertilizer N applied are frequently more than the amounts removed by the crop. Excessive N application may result in short-term accumulation of nitrate nitrogen (NO3-N) in soil, which can easily be leached from the root zone and into the ground water. A management practice suggested for conserving accumulated NO3-N is the application of oily food waste (FOG; fat + oil + greases) to agricultural soils. A two-year field study (1995-1996 and 1996-1997) was conducted at Elora Research Center (43 degrees 38' N, 80 degrees W; 346 m above mean sea level), University of Guelph, Ontario, Canada to determine the effect of FOG application in fall and spring on soil NO3-N contents and apparent N immobilization-mineralization of soil N in the 0- to 60-cm soil layer. The experiment was planned under a randomized complete block design with four replications. An unamended control and a reference treatment [winter wheat (Triticum aestivum L.) cover crop] were included in the experiment to compare the effects of fall and spring treatment of oily food waste on soil NO3-N contents and apparent N immobilization-mineralization. Oily food waste application at 10 Mg ha(-1) in the fall decreased soil NO3-N by immobilization and conserved 47 to 56 kg NO3-N ha(-1), which would otherwise be subject to leaching. Nitrogen immobilized due to FOG application in the fall was subsequently remineralized by the time of fertilizer N sidedress, whereas no net mineralization was observed in spring-amended plots at the same time.     

Phosphorus and nitrate nitrogen in runoff following fertilizer application to turfgrass

Intensively managed golf courses are perceived by the public as possibly adding nutrients to surface waters via surface transport. An experiment was designed to determine the transport of nitrate N and phosphate P from simulated golf course fairways of 'Tifway' bermudagrass [Cynodon dactylon (L.) Pers.]. Fertilizer treatments were 10-10-10 granular at three rates and rainfall events were simulated at four intervals after treatment (hours after treatment, HAT). Runoff volume was directly related to simulated rainfall amounts and soil moisture at the time of the event and varied from 24.3 to 43.5% of that added for the 50-mm events and 3.1 to 27.4% for the 25-mm events. The highest concentration and mass of phosphorus in runoff was during the first simulated rainfall event at 4 HAT with a dramatic decrease at 24 HAT and subsequent events. Nitrate N concentrations were low in the runoff water (approximately 0.5 mg L-1) for the first three runoff events and highest (approximately 1-1.5 mg L-1) at 168 HAT due to the time elapsed for conversion of ammonia to nitrate. Nitrate N mass was highest at the 4 and 24 HAT events and stepwise increases with rate were evident at 24 HAT. Total P transported for all events was 15.6 and 13.8% of that added for the two non-zero rates, respectively. Total nitrate N transported was 1.5 and 0.9% of that added for the two rates, respectively. Results indicate that turfgrass management should include applying minimum amounts of irrigation after fertilizer application and avoiding application before intense rain or when soil is very moist.     

Effect of nitrogen fertilizer application on growing season soil carbon dioxide emission in a corn-soybean rotation

Nitrogen application can have a significant effect on soil carbon (C) pools, plant biomass production, and microbial biomass C processing. The focus of this study was to investigate the short-term effect of N fertilization on soil CO(2) emission and microbial biomass C. The study was conducted from 2001 to 2003 at four field sites in Iowa representing major soil associations and with a corn (Zea mays L.)-soybean (Glycine max L. Merr.) rotation. The experimental design was a randomized complete block with four replications of four N rates (0, 90, 180, and 225 kg ha(-1)). In the corn year, season-long cumulative soil CO(2) emission was greatest with the zero N application. There was no effect of N applied in the prior year on CO(2) emission in the soybean year, except at one of three sites, where greater applied N decreased CO(2) emission. Soil microbial biomass C (MBC) and net mineralization in soil collected during the corn year was not significantly increased with increase in N rate in two out of three sites. At all sites, soil CO(2) emission from aerobically incubated soil showed a more consistent declining trend with increase in N rate than found in the field. Nitrogen fertilization of corn reduced the soil CO(2) emission rate and seasonal cumulative loss in two out of three sites, and increased MBC at only one site with the highest N rate. Nitrogen application resulted in a reduction of both emission rate and season-long cumulative emission of CO(2)-C from soil.     

Damage costs of nitrogen fertilizer in Europe and their internalization

This paper estimates the environmental impacts and damage costs (‘external costs’) of synthetic nitrogen fertilizer and discusses options for reducing these impacts, including their consequences for farmers and for producers of fertilizer. The damage costs of the fertilizer life cycle that could be estimated are large, about 0.3 [euro]/kg_N (compared to the current market price of about 0.5 [euro]/kg_N); much of that is due to global warming by N₂O and CO₂ emissions during fertilizer production and N₂O emissions from fertilized fields. Policy options for internalizing these costs are discussed, and the consequences of reduced fertilizer input on crop yield are explored. If the damage costs were internalized by a pollution tax or tradable permits that are auctioned by the government, the economic consequences would be heavy, with a large revenue loss for farmers. However, if it is internalized by tradable permits that are given out free, the revenue loss for farmers is small. The loss for fertilizer producers increases linearly with the amount of external cost that is internalized, by contrast to the loss for farmers which increases quadratically but is very small for a damage cost of 0.3 [euro]/kg_N. Expressed as a change in the fertilizer-dependent part of the farmers' revenue (crop yield × crop price – fertilizer used× fertilizer price), the decrease is less than 0.5% for most crops; the losses are larger only for crops with low [euro]/ha revenue. Averaged over wheat, barley, potatoes, sugar beet and rapeseed, the loss to farmers is about 0.1% in the UK and 0.4% in Sweden. The revenue loss for fertilizer producers is larger, about 8% in the UK and 14% in Sweden.     

Soil nitrous oxide emissions following band-incorporation of fertilizer nitrogen and swine manure

Treatment of liquid swine manure (LSM) offers opportunities to improve manure nutrient management. However, N2O fluxes and cumulative emissions resulting from application of treated LSM are not well documented. Nitrous oxide emissions were monitored following band-incorporation of 100 kg N ha(-1) of either mineral fertilizer, raw LSM, or four pretreated LSMs (anaerobic digestion; anaerobic digestion + flocculation: filtration; decantation) at the four-leaf stage of corn (Zea mays L.). In a clay soil, a larger proportion of applied N was lost as N2O with the mineral fertilizer (average of 6.6%) than with LSMs (3.1-5.0%), whereas in a loam soil, the proportion of applied N lost as N2O was lower with the mineral fertilizer (average of 0.4%) than with LSMs (1.2-2.4%). Emissions were related to soil NO3 intensity in the clay soil, whereas they were related to water-extractable organic C in the loam soil. This suggests that N2O production was N limited in the clay soil and C limited in the loam soil, and would explain the interaction found between N sources and soil type. The large N2O emission coefficients measured in many treatments, and the contradicting responses among N sources depending on soil type, indicate that (i) the Intergovernmental Panel on Climate Change (IPCC) default value (1%) may seriously underestimate N2O emissions from fine-textured soils where fertilizer N and manure are band-incorporated, and (ii) site-specific factors, such as drainage conditions and soil properties (e.g., texture, organic matter content), have a differential influence on emissions depending on N source.     

Fertilizer residence time affects nitrogen uptake efficiency and growth of sweet corn

Understanding plant N uptake dynamics is critical for increasing fertilizer N uptake efficiency (FUE) and minimize the risk of N leaching. The objective of this research was to determine the effect of residence time of N fertilizer on N uptake and FUE of sweet corn. Plants were grown in 25 L columns during the fall and spring to mimic short-term N uptake dynamics. Nitrogen was applied either 1, 3, or 7 d before a weekly leaching event, using KNO3 solution (total of 393 kg N ha(-1)). Residence times (tR) were tR-1, tR-3, and tR-7 d before weekly removal of residual soil N. Plant N uptake was calculated by comparing weekly N recovery from planted with non-planted columns. During the fall, N uptake values at 70 d after emergence were 59, 73, and 126 kg N ha(-1). During the spring, corresponding values were 54, 108, and 159 kg N ha(-1). A linear response of plant growth and yield to the tR was observed under cooler conditions, whereas a quadratic response occurred under warmer conditions. There was correlation between root length density and yield. It is concluded that increasing N fertilizer residence time, which is indicative of better irrigation practices, enhanced overall sweet corn growth, yield, N uptake, and FUE, consequently reduced the risk of N being leached below the root zone before complete N uptake.     

Reduction of nitrate leaching with haying or grazing and omission of nitrogen fertilizer

In some high-fertility, high-stocking-density grazing systems, nitrate (NO(3)) leaching can be great, and ground water NO(3)-N concentrations can exceed maximum contaminant levels. To reduce high N leaching losses and concentrations, alternative management practices need to be used. At the North Appalachian Experimental Watershed near Coshocton, OH, two management practices were studied with regard to reducing NO(3)-N concentrations in ground water. This was following a fertilized, rotational grazing management practice from which ground water NO(3)-N concentrations exceeded maximum contaminant levels. Using four small watersheds (each approximately 1 ha), rotational grazing of a grass forage without N fertilizer being applied and unfertilized grass forage removed as hay were used as alternative management practices to the previous fertilized pastures. Ground water was sampled at spring developments, which drained the watershed areas, over a 7-yr period. Peak ground water NO(3)-N concentrations before the 7-yr study period ranged from 13 to 25.5 mg L(-1). Ground water NO(3)-N concentrations progressively decreased under each watershed and both management practices. Following five years of the alternative management practices, ground water NO(3)-N concentrations ranged from 2.1 to 3.9 mg L(-1). Both grazing and haying, without N fertilizer being applied to the forage, were similarly effective in reducing the NO(3)-N levels in ground water. This research shows two management practices that can be effective in reducing high NO(3)-N concentrations resulting from high-fertility, high-stocking-density grazing systems, including an option to continue grazing.     

Leaching and crop uptake of nitrogen and phosphorus from pig slurry as affected by different application rates

The influence of increasing pig slurry applications on leaching and crop uptake of N and P by cereals was evaluated in a 3-yr study of lysimeters filled with a sandy soil. The slurry was applied at N rates of 50 (S50), 100 (S100), 150 (S150), and 200 (S200) kg ha(-1) during 2 of the 3 yr. The P rates applied with slurry were: 40 (S50), 80 (S100), 120 (S150), and 160 (S200) kg ha(-1) yr(-1). Simultaneously, NH4NO3 and Ca(H2PO4)2 were applied at rates of 100 kg N ha(-1) and 50 kg P ha(-1), respectively, to additional lysimeters (F100), while others were left unfertilized (F0). During the 3-yr period, the leaching load of total N tended to increase with increasing slurry application to, on average, 139 kg ha(-1) at the highest application rate (S200). The corresponding N leaching loads (kg ha(-1)) in the other treatments were: 75 (F0), 103 (F100), 93 (S50), 120 (S100), and 128 (S150). The loads of slurry-derived N in the S100, S150, and S200 treatments were significantly larger (P < 0.05) than those of fertilizer-derived N. In contrast, P leaching tended to decrease with increasing input of slurry, and it was lower in all treatments that received P at or above 50 kg P ha(-1) yr(-1) with slurry or fertilizer than in the unfertilized treatment. The crop use efficiency of added N and P was clearly higher when NH4NO3 and Ca(H2PO4)2 were used rather than slurry (60 vs. 35% for N, 38 vs. 6-9% for P), irrespective of slurry application rate. Therefore, from both a production and water quality point of view, inorganic fertilizers seem to have environmental benefits over pig slurry when used on sandy soils.     

Effect of selected and non-selected urban waste compost on the initial growth of corn

Brazil produces approximately 242,000 t of waste per day, 76% of it being dumped outdoors and only 0.9% recycled, including composting, which is an alternative still little known in Brazil. In search of a better destination for residues produced by domestic activities, composting stands as a feasible alternative. Organic compost from waste may be used for various purposes, among which are soil recovery, commercial production, pastures, lawns and reforestry and agriculture. However, the quality of the compost determines the growth and the development of plants. The effect of compost made from urban waste on corn plant (Zea mays L.) growth was investigated. Two types of compost were used: the selected compost (SC), produced from organic waste selectively collected; and the non-selected compost (NSC), taken from a 15-year-old cell from the Canabrava land-fill, located in Salvador, Bahia, Brazil (altitude 51 m, 12°22′–13°08′S, 38°08′–38°47′W). Corn was seeded in polyethylene pots, with soil-compost mixing substrate in the proportion of 0, 15, 30, 45 and 60 t ha⁻¹ equivalent doses. Chemical analyses of the compost and growth properties of the plant like chlorophyll content; height and stem diameter; aerial and radicular dry biomasses, were used to evaluate compost quality. Plants cultivated with SC presented a superior gain, being of 52.5% in stem diameter, 71.1 and 81.2% in root and stem biomasses, respectively. Chlorophyl content alterations were observed in plants from treatments using 30 t compost ha⁻¹ dose onwards. Conventional and multivariate statistical methods were used to evaluate these results. The beneficial action of organic compost in plant growth was confirmed with this research.     

Simulating long-term and residual effects of nitrogen fertilization on corn yields, soil carbon sequestration, and soil nitrogen dynamics

Soil carbon sequestration (SCS) has the potential to attenuate increasing atmospheric CO2 and mitigate greenhouse warming. Understanding of this potential can be assisted by the use of simulation models. We evaluated the ability of the EPIC model to simulate corn (Zea mays L.) yields and soil organic carbon (SOC) at Arlington, WI, during 1958-1991. Corn was grown continuously on a Typic Argiudoll with three N levels: LTN1 (control), LTN2 (medium), and LTN3 (high). The LTN2 N rate started at 56 kg ha(-1) (1958), increased to 92 kg ha(-1) (1963), and reached 140 kg ha(-1) (1973). The LTN3 N rate was maintained at twice the LTN2 level. In 1984, each plot was divided into four subplots receiving N at 0, 84, 168, and 252 kg ha(-1). Five treatments were used for model evaluation. Percent errors of mean yield predictions during 1958-1983 decreased as N rate increased (LTN1 = -5.0%, LTN2 = 3.5%, and LTN3 = 1.0%). Percent errors of mean yield predictions during 1985-1991 were larger than during the first period. Simulated and observed mean yields during 1958-1991 were highly correlated (R2 = 0.961, p < 0.01). Simulated SOC agreed well with observed values with percent errors from -5.8 to 0.5% in 1984 and from -5.1 to 0.7% in 1990. EPIC captured the dynamics of SOC, SCS, and microbial biomass. Simulated net N mineralization rates were lower than those from laboratory incubations. Improvements in EPIC's ability to predict annual variability of crop yields may lead to improved estimates of SCS.     

乌鲁木齐市餐厨垃圾资源化处理处置探讨

本文介绍了餐厨垃圾的概念及乌鲁木齐餐厨垃圾的主要来源,对目前国内外餐厨垃圾资源化处理技术进行了探讨,介绍了饲料化技术、肥料化处理技术、生物厌氧发酵处理技术以及生物柴油技术,分析了各种技术存在的优缺点,并对国内外处理处置现状进行综述,对乌鲁木齐市餐厨垃圾处理工作进行了展望和探讨.     

Plant growth and uptake of mineral elements at an oily sludge landfarming site in Kuwait

Oily sludge landfarmed in Kuwait soil contains higher concentrations of certain elements than that of the untreated of, soil, e.g. S, Cu, Cr, Zn, Pb, Ni, Mo and V. The growth and elemental content of three different plants grown on a sandy soil previously treated with different concentrations of oily sludge were studied. Tested plants differed in their response to landfarmed oily sludge; ryegrass was the least affected followed by oats, then barley. Uptake of elements differed both qualitatively and quantitatively between test plants. In barley, Zn increased in plants cultivated in soil treated with oily sludge, whereas other metal concentrations were reduced or not affected, namely, Cu, Pb, Ni, V. The uptake of P was greater in plants grown on treated soil compared with those on untreated soil, whereas Na, Ca, K, were either reduced or unaffected. In oats, Zn, Ni, Cu, Pb, V, were not significantly changed. Uptakes of K, Ca, P, and Na in plants from treated soil were higher than that of the control. In ryegrass, heavy metal concentrations were either reduced or remained the same as that of the control. In all cases, concentrations of essential heavy metals and other true elements under investigation were still lower than the levels considered to be sufficient for micronutrients. Thus, the oily sludge was a source of certain micro-nutrients which were deficient in the sandy soil. Further, it appears that uptake and distribution of elements in plant tissues were both highly variable according to the plant, species, and the soil characteristics.     

The effects on waste reduction and recycling rates when different components of the waste stream are counted

States differ in the components or solid waste management activities which they include when determining solid waste reduction and recycling rates. Thus, when attempting to draw comparisons among states, confusion arises in two ways: (1) use of two types of rates; and (2) use of different components or activities when calculating a given rate. This paper presents a mathematical basis for understanding the impacts on rate calculations when variations occur in the components and activities included in those calculations. Estimates of the incremental changes occurring in the rate calculations when incineration or selected components such as yard waste, construction and demolition wastes, and junked automobiles, are added to a base of municipal solid waste constituents are found using national data. Finally, the achieved rates reported by states counting different combinations are compared.     

Modeling carbon and nitrogen transformations for adjustment of compost application with nitrogen uptake by wheat

Environmentally sound management of the use of composts in agriculture relies on matching the rate of release of available N from compost-amended soils to the crop demand. To develop such management it is necessary to (i) characterize the properties of composts that control their rates of decomposition and release of N and (ii) determine the optimal amount of composts that should be applied annually to wheat (Triticum aestivum L.). Carbon and N mineralization were measured under controlled conditions to determine compost decomposition rate parameters, and the NCSOIL model was used to derive the organic wastes parameters that control the rates of N and C transformations in the soil. We also characterized the effect of a drying period to estimate the effects of the dry season on C and N dynamics in the soil. The optimized compost parameters were then used to predict mineral N concentration dynamics in a soil-wheat system after successive annual applications of compost. Sewage sludge compost (SSC) and cattle manure compost (CMC) mineralization characteristics showed similar partitioning into two components of differing ease of decomposition. The labile component accounted for 16 to 20% of total C and 11 to 14% of total N, and it decomposed at a rate of 2.4 x 10(-2) d(-1), whereas the resistant pool had a decomposition rate constant of 1.2 to 1.4 x 10(-4) d(-1). The main differences between the two composts resulted from their total C and N and inorganic N contents, which were determined analytically. The long-term effect of a drying period on C and N mineralization was negligible. Use of these optimization results in a simulation of compost mineralization under a wheat crop, with a modified plant-effect version of the NCSOIL model, enabled us to evaluate the effects of the following factors on the C and N dynamics in soil: (i) soil temperature, (ii) mineral N uptake by plants, and (iii) release of very labile organic C in root exudates. This labile organic C enhanced N immobilization following application, and so decreased the N available for uptake by plants.     

Impact of food industrial waste on anaerobic co-digestion of sewage sludge and pig manure

The performance of an anaerobic digestion process is much dependent on the type and the composition of the material to be digested. The effects on the degradation process of co-digesting different types of waste were examined in two laboratory-scale studies. In the first investigation, sewage sludge was co-digested with industrial waste from potato processing. The co-digestion resulted in a low buffered system and when the fraction of starch-rich waste was increased, the result was a more sensitive process, with process overload occurring at a lower organic loading rate (OLR). In the second investigation, pig manure, slaughterhouse waste, vegetable waste and various kinds of industrial waste were digested. This resulted in a highly buffered system as the manure contributed to high amounts of ammonia. However, it is important to note that ammonia might be toxic to the micro-organisms. Although the conversion of volatile fatty acids was incomplete the processes worked well with high gas yields, 0.8-1.0 m3 kg(-1) VS.     

Environmental and social implications of waste in U.S. agriculture and food sectors

Because the agriculture/food sectors appear to be driven by short-term economic and political forces, cheap energy, and agricultural-chemical technologies, waste and environmental/social problems in the agricultural/food sectors are estimated to cost the nation at least $150 billion per year. Most of the waste and environmental/social problems can be eliminated through better resource management policies and the adoption of sustainable agricultural practices.Based on a paper entitled Waste in U.S. Agricultural and Food Sectors—Environmental and Social Costs presented at the Gross National Waste Product Forum, Washington, D.C.     

Valorization of sodium sulfate waste to potassium sulfate fertilizer: experimental studies,process modeling,and optimization

ABSTRACT

Sodium sulfate is a common low-value industrial by-product but can be managed using the Glaserite process to convert it into high-value potassium sulfate. The aim of the study is to investigate the potential for implementing this process in an industrial application. Experimental studies were completed to determine the yield and purity of both glaserite and potassium sulfate. Process simulation using SysCAD was utilized to optimize a two-stage glaserite process to produce potassium sulfate. Comparison of experimental and simulated data was made to validate the simulator’s results, finding the AAD in solid and liquid phase for glaserite production to be 6.9% and 5.7%, respectively, and for potassium sulfate to be 5.7% and 2.3%, respectively. For a process treating seven MT/hr of Na₂SO₄, a KCl feed strategy of 3.0 MT/hr to the glaserite reactor and 4.5 MT/hr to the K₂SO₄ reactor was found to maximize yield and minimize water demand. It was also found that ambient temperatures were preferred for the K₂SO₄ reactor and that K₂SO₄ yield suffered significantly under certain conditions when the glaserite reactor operated at 50°C or above.     

Composting of vinasse and cotton gin waste by using two different systems

Two composts were obtained by co-composting of a concentrated depotassified beet vinasse and cotton gin waste using two different aeration systems: static aerated pile (forced aeration provided by a blower whom operated in the positive mode) and windrow (turned pile). The composting mixtures were cotton gin trash (55%) and vinasse (45%) (dry weight). In static pile, the total amount of vinasse was added at the beginning of the process whereas, in windrow two additions of vinasse were performed. Differences in temperature changes between both composting systems were found: a faster increase of temperature in the windrow (54 °C at 7 days) than in the static pile (45 °C at 21 days) was observed. Probably in the static pile system, the compaction of the substrates made difficult the correct distribution of the air inside the pile. Moreover, after the second addition of vinasse a new thermophilic phase was started in windrow. The different aeration systems and the way of addition of vinasse could cause differences in organic matter (OM) degradation and in weight (22.6% for the static pile and 26.7% for the windrow) and gas losses during the process. Nevertheless, the composts obtained by the two systems had a high fertilizer value (25.1 g kg⁻¹ N; 3.2 g kg⁻¹ P₂O₅; 21.4 g kg⁻¹ K₂O; C/N8) for compost obtained in static pile and (16.2 g kg⁻¹ N; 3.4 g kg⁻¹ P₂O₅; 16.1 g kg⁻¹ K₂O; C/N 12) for compost obtained in the windrow). A high degree of stability was reached in the final composts. Composting of vinasse with cotton gin waste serves two objectives, disposal of wastes and recycling of waste components.