粉煤灰-石灰中温烟气脱硫和蒸汽活化的机理

实验研究了粉煤灰 -石灰吸收剂经 150℃和400～800℃蒸汽处理后 ,其固硫能力的改善程度 ,并借助扫描电镜、X射线衍射分析技术对蒸汽活化机理进行分析 .粉煤灰 -石灰的一次硫化样品经 150℃蒸汽处理后 ,CaO转化为 Ca(OH)₂,石灰颗粒发生破碎 ,粉煤灰颗粒表面粘附了大量的含钙微粒 ,从而大大增加了吸收剂的有效反应表面积 ,在 400～800℃的脱硫反应温度下使其转化率比未处理吸收剂的转化率提高了 0.8～ 1.5倍 .150℃蒸汽处理方式比 400～800℃蒸汽处理方式的效果好 .     

贝壳流化床燃烧脱硫的试验研究

采用添加脱硫剂和空白试验对比的方法,对两种贝壳和一种石灰石在流化床中的脱硫特性进行了试验研究.结果表明,在流化床条件下,河蚌壳的脱硫性能优于石灰石和贻贝壳.3种脱硫剂在试验范围内的脱硫效率随钙硫比增加而增加,当钙硫比为2.5时,河蚌壳的脱硫效率达到最高;河蚌壳在950～1000℃范围内脱硫效率随温度升高而升高,在1000℃时,脱硫效率达到72.96%,其他两种脱硫剂的脱硫效率随温度升高而下降.比较试样煅烧后的微孔直径发现,河蚌壳的微孔直径大于0.1靘,而另外两种脱硫剂的微孔直径小于0.05靘的占有很大份额,表明脱硫剂微孔直径对脱硫性能有重要影响.     

热活化赤泥脱硫剂的制备及其脱硫性能研究

赤泥具有多孔结构并富含钙基组分可有效用于烟气脱硫。针对赤泥长期堆存后活性降低的问题,以烧结法赤泥和活性炭为原料,通过热活化法制备活化赤泥脱硫剂(ARMD)以提高其脱硫效果。在活化赤泥脱硫剂的制备过程中,考察了活性炭与赤泥配比(C/R)、温度、活化时间等条件对其脱硫效率的影响。确定ARMD的最佳制备条件为:C/R=1∶20,热活化温度900℃,热活化时长15 min,且当p H值为4.5时,赤泥脱硫效率可达86.9%。采用BET、SEM和XRD对ARMD进行表征,同时考察不同p H值下铁离子的浓度及ARMD脱硫性能。结果表明:脱硫后ARMD中出现了β-Fe OOH,其具有较高的比表面积及发达的孔容,为钙基反应提供了巨大空间,进一步提升了ARMD的脱硫性能。     

人工钙基脱硫剂活性和温度特性的研究

脱硫剂的活性和温度特性是影响沸腾炉煤燃烧脱硫效率的两个重要因素。实验表明,以石灰石为有效成分的人工钙基脱硫剂的反应活性是石灰石的2—3倍,且在800℃—1100℃较宽的温度范围内保持这一水平.本文以石灰石和两种人工脱硫剂试样(含固硫渣和不含固硫渣)为研究对象,应用管式反应炉、扫描电子显微镜和压汞仪等对样品进行了一系列宏观与微观的对比实验,探讨了人工脱硫剂的活性和温度特性.结果表明,在人工脱硫剂成型过程中人为形成的大孔分布改善了反应气体的扩散,从而提高了它的反应活性。而且大孔和固硫渣的共同作用还削弱了晶粒膨胀和烧结的不利影响,从而使其最佳脱硫温度较石灰石向高温区移动了近200℃.此外本文还讨论了最佳温度的相对性。     

不同反应气氛下冶金粉尘的脱硫研究

在50～650℃的温度区间内进行了冶金粉尘在不同反应气氛条件下的硫化穿透实验,结果表明,反应温度与反应气氛对冶金粉尘脱硫有较大的影响.大于350℃时,不管在何种反应气氛下,冶金粉尘脱硫能力在中等或中等偏上;在大于500℃时,冶金粉尘有很好的反应活性,其硫容量接近或达到相应气氛下的理论计算值;冶金粉尘在中性与还原性气氛下的脱硫能力比其在氧化性气氛下的脱硫能力强;冶金粉尘是干法脱硫工艺中很有发展前景的脱硫剂.     

垃圾焚烧飞灰制备高温脱硫剂及其性能评价

利用不同地方的垃圾焚烧飞灰来制备高温炉内的脱硫剂,并利用热天平来研究飞灰脱硫剂(FA-脱硫剂)的固硫性能.实验结果表明,FA-脱硫剂的孔隙分布在2000nm左右,并且比生石灰具有更好的固硫能力.添加石膏后的FA-脱硫剂,其机械强度大大提高,但孔径结构变小,脱硫率也有所下降.添加10%(质量分数)水玻璃的FA-脱硫剂的机械强度相当于生石灰,脱硫效果更明显,比没有添加水玻璃时效果更好,孔径结构基本不变.这是由于水玻璃中的钠跟二氧化硫反应生成钠硫酸盐.     

燃煤流化床钙基脱硫剂对NO转变率的影响及机理

在φ150mm×1000mm流化床试验台上,温度区间840℃～960℃,研究了钙基脱硫剂品种、粒径和Ca/S比对NO转变率的影响.阐述了钙基脱硫剂使NO转变率增加机理试验发现,同等质量钙基脱硫剂使NO增加的次序为氧化钙、石灰石、方解石;Ca/S比越大,NO转变率越高;粒径为1～2mm时NO转变率最大,2～3mm时次之,0.2～1mm时最小.加入脱硫剂降低了HCl、HF、SO₂的浓度,导致O、H、HO₂浓度升高,CO的氧化反应加速,在床料、燃料灰催化作用下CO与NO的反应减慢,最终导致NO浓度升高.     

双碱法烟气脱硫工艺实验研究

在工业规模装置上对双碱法烟气脱硫工艺进行了系统实验研究了,主要考察了Na OH和Ca(OH)2浓度、烟气含尘量、钙硫比(脱硫剂中钙的摩尔数与煤中硫的摩尔数之比)、液气比(脱硫剂流量L与烟气流量G之比)、烟气温度、烟气与脱硫剂接触时间以及加氧量对脱硫效果的影响。结果表明:烟气脱硫率随Na OH浓度在5%~30%范围内的增加逐渐增加,Na OH浓度高于30%对脱硫率影响不大,Ca(OH)2浓度为10%~12%时脱硫率最高;烟气含尘量由1 600 mg/m3降低到400 mg/m3,脱硫率从95%线性降低到84%;钙硫比为1.1时脱硫效果最好;脱硫率随液气比的增加逐渐升高,当液气比高于15.5 L/m3,脱硫率变化不大;较低的烟气进口温度利于SO2的吸收,脱硫率越高;烟气与脱硫剂接触时间越长,脱硫率越高;氧气的通入将亚硫酸盐氧化为硫酸盐,提高了脱硫率,同时可避免结垢。     

草粉担载Na2CO3可逆脱硫吸附剂的制备及脱硫活性

通过浸渍方法,制备了5%～90%(质量分数)担载量Na2CO3/草粉脱硫剂.实验结果表明,较小的草粉粒度(≤0.28mm)和较低的气体流量(40mL/min)有利于SO2脱除,但是脱硫温度(70℃～300℃)对脱硫效果影响不大.利用XRD,SEM,ATR-IR等分析手段,研究了草粉改性Na2CO3脱硫吸附剂的机理.实验证明:改性Na2CO3吸附剂高效脱硫的机理主要在于吸附剂表面结构的无定形态,因而具有比较大的比表面积(12.14m2/g)和孔体积(0.093cm3/g).     

干法烟气脱硫反应的实验研究

本文建立了干法烟气脱硫反应的实验装置 ,对以氧化钙为脱硫剂的干法烟气脱硫反应进行了实验研究 ,并利用压汞仪分析反应过程中参与反应的固体颗粒的孔隙结构的变化情况 ,对干法烟气脱硫反应过程中的固体颗粒孔隙结构特性进行动态分析 ,揭示和确定了反应过程中固体颗粒孔隙结构变化规律和脱硫转化率。研究结果表明 ,孔隙结构 ,包括孔径分布、最可几孔半径等是决定和影响干法烟气脱硫反应的因素 ,其中孔隙率决定脱硫反应的最终转化率 ,孔隙分布则控制着反应的过程特性。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.