生物膜反应器连续处理餐饮废水

用生物膜反应器连续处理餐水能有效降低废水中的ＢＯＤ及ＣＯＤ浓度。研究了水力停留时间对有机物去除率的影响,结果表明当水力停留时间大于７．８ｈ时,废水的ＣＯＤ,ＢＯＤ及ＴＳＳ的去除率均高于９０％。实验操作时,水力停留时间应略大于５．７ｈ。     

Treatment of high-strength pet food wastewater using two-stage membrane bioreactors.

A two-stage membrane bioreactor was used to treat dissolved-air-flotation pretreated, high-strength pet food wastewater characterized by oil and grease concentrations of 50 000 to 82 000 mg/L and total chemical oxygen demand (COD) and five-day biochemical oxygen demand (BOD5) concentrations of 100 000 and 80 000 mg/L, respectively, to meet stringent surface discharge criteria (i.e., BOD5, total suspended solids [TSS], and ammonium-nitrogen [NH4(+)-N] of < 10 mg/L at an overall hydraulic retention time of 6.3 days). Organic contaminants were removed primarily in the first stage, followed by almost complete removal of ammonia in the second stage. Despite a rise in poorly biodegradable COD in the second stage, overall removal of TSS, BOD5, COD, and ammonia was 100, 99.9, 95.2, and 99.7%, respectively, thus readily achieving the required criteria. Consistent nitrite accumulation over a period of more than 100 days, even at dissolved oxygen concentrations of more than 2.5 mg/L, was remarkable. A residual alkalinity requirement for nitrification was quantified. Membrane performance was extensively studied in this work.     

Treatment of food industry waste by bench-scale upflow anaerobic sludge blanket-anoxic-aerobic system.

An upflow anaerobic sludge blanket (UASB)-anoxicaerobic system was used for treatment of tomato and bean processing wastewater. At various hydraulic retention times, ranging from 0.7 to 5 days, excellent removal of chemical oxygen demand (COD), biochemical oxygen demand (BOD), total suspended solids (TSS), ammonia-nitrogen (NH4-N), and total Kjeldahl nitrogen was achieved with final effluent BOD/TSS/NH4N concentrations of less than 15/15/1 mg/L. Biogas yield in the UASB reactor varied from 0.33 to 0.44 m3/kgCODremoved. The kinetics of anaerobic treatment were investigated. The yield coefficient was 0.03 gVSS/gCOD; maximum specific growth rate was 0.24 day(-1); Monod half velocity constant was 135 mgCOD/L; and specific substrate utilization rate was 3.25 gCOD/gVSS x d. Nitrification and denitrification kinetics were studied in batch experiments, and the rates were comparable with those in the continuous flow system.     

Simultaneous nitrification-denitrification and clarification in a pseudoliquified activated sludge system.

This paper describes results from a pilot study of a novel wastewater treatment technology, which incorporates nutrient removal and solids separation to a single step. The pseudoliquified activated sludge process pilot system was tested on grit removal effluent at flowrates of 29.4 to 54.7 m3/d, three different solid residence times (SRT) (15, 37, and 57 days), and over a temperature range of 12 to 28 degrees C. Despite wide fluctuations in the influent characteristics, the system performed reliably and consistently with respect to organics and total suspended solids (TSS) removals, achieving biochemical oxygen demand (BOD) and TSS reductions of > 96% and approximately 90%, respectively, with BOD5 and TSS concentrations as low as 3 mg/L. Although the system achieved average effluent ammonia concentrations of 2.7 to 3.2 mg/L, nitrification efficiency appeared to be hampered at low temperatures (< 15 degrees C). The system achieved tertiary effluent quality with denitrification efficiencies of 90 and 91% total nitrogen removal efficiency at a total hydraulic retention time of 4.8 hours and an SRT of 12 to 17 days. With ferric chloride addition, effluent phosphorous concentrations of 0.5 to 0.8 mg/L were achieved. Furthermore, because of operation at high biomass concentrations and relatively long biological SRTs, sludge yields were over 50% below typical values for activated sludge plants. The process was modeled using activated sludge model No. 2, as a two-stage system comprised an aerobic activated sludge system followed by an anoxic system. Model predictions for soluble BOD, ammonia, nitrates, and orthophosphates agreed well with experimental data.     

Advanced extraction and lower bounds for removal of pollutants from wastewater by water plants.

The capacity to reach lower bounds for extraction of pollutants from wastewater by four floating aquatic macrophytes--water hyacinth (Eichhornia crassipes), water lettuce (Pistia stratiotes), salvinia (Salvinia rotundifolia), and water primroses (Ludvigia palustris)--is investigated. It is shown that the following lower bounds can be established for wastewater purification with water hyacinth: biochemical oxygen demand (BOD), 1.3 mg/L; chemical oxygen demand (COD), 11.3 mg/L; total suspended solids (TSS), 0.5 mg/L; turbidity, 0.7 NTU; ammonia, 0.2 mg/L; and phosphorus, 1.4 mg/L. Also, the following lower bounds can be established for wastewater purification with water lettuce: BOD, 1.8 mg/L; COD, 12.5 mg/L; TSS, 0.5 mg/L; turbidity, 0.9 NTU; ammonia, 0.2 mg/L; and phosphorus, 1.6 mg/L. These lower bounds were reached in 11- to 17-day experiments that were performed on diluted wastewater with reduced initial contents of the tested water quality indicators. As expected, water hyacinth exhibited the highest rates and levels of pollutant removal, thereby producing the best lower bounds of the water quality indicators. Given the initially low levels, BOD was further reduced by 86.3%, COD by 66.6%, ammonia by 97.8%, and phosphorus by 65.0% after 11 days of a batch experiment. The capacity of water plants to purify dilute wastewater streams opens new options for their application in the water treatment industry.     

Degradation of 2,4-dichlorophenol by combining photo-assisted Fenton reaction and biological treatment.

The photo-Fenton reaction effect on the biodegradability improvement of 100 mg/L solution of 2,4-dichlorophenol (DCP) has been investigated. Biochemical oxygen demand (BOD) at 5 and 21 days, BODn/ chemical oxygen demand (COD) and BODn/total organic carbon (TOC) ratios, average oxidation state, and inhibition on activated sludge were monitored. For 50 mg/L hydrogen peroxide and 10 mg/L iron(II) initial concentrations and 40 minutes of reaction time in the photo-Fenton process, the biodegradability of the pretreated solution, measured as BOD5/COD ratio, was improved from 0 for the original DCP solution up to 0.18 (BOD21/COD = 0.24). At that point, all DCP was eliminated from the solution. To study the effect of the pretreatment step, the biological oxidation of pretreated solutions was tested in two semicontinuous stirred tank reactors, one operated with activated sludge and one with biomass acclimated to phenol. Results showed that more than 80% TOC removal could be obtained by codigestion of the pretreated solution with municipal wastewater. Total organic carbon removals of approximately 60% were also obtained when the sole carbon source for the aerobic reactors was the pretreated solution. The hydraulic retention times used in the bioreactors were of the same order of magnitude as those used at domestic wastewater treatment plants (i.e., between 12 and 24 hours). Kinetic studies based on pseudo-first-order kinetics have also been carried out. Constants were found to be in range 0.67 to 1.7 L x g total volatiles suspended solids(-1) x h(-1).     

Delivery and frequency distributions of combined wastewater collection system wet and dry weather loads

Combined wastewater collection systems continue to serve as a common urban conveyance method in urban areas of Europe and older urban areas of the United States. This study uses combined wastewater collection system monitoring data from the urbanizing Liguori catchment and channel in Cosenza (Italy) to illustrate event-based delivery and distribution of conveyed pollutant indices. Motivated by recent European Union (EU) discharge control legislation, this study specifically differentiates the event-based delivery of these indices between dry and wet-weather flows. Although the relatively steady to diurnal-variable delivery phenomena in dry weather flows are known, transport limiting phenomena for wet-weather hydrology and mass delivery typically are not known for the same catchment. Limiting categories of transport for a pollutant phase are generated by variables such as flow volume and duration, stream power, hydrograph parameters, and previous dry hours (PDH). Transport limitations of wet and dry weather events from the 414-ha catchment were analyzed and characterized as limited by mass indices (first-order, first flush transport) or limited by flow (zero-order transport). Results indicated significant concentration differences between mass- and flow-limited events. Higher concentrations were associated with mass-limited events. Frequency distributions of flow, total suspended solids (TSS), chemical oxygen demand (COD), and five-day biochemical oxygen demand (BOD5) were consistently exponential for wet-weather and mass-limited events. In contrast, flow, TSS, and BOD5 concentrations were distributed normally for flow-limited events. Results indicated a reasonable linear relationship between discharged TSS, COD, and BOD5 (biochemical oxygen demand) for Liguori Channel discharges into the Crati River. Wet-weather event transport was predominately mass-limited for TSS, COD, and BOD5.     

厌氧滤池处理纺织印染废水的中试研究

对厌氧滤池反应器处理难降解印染废水进行中试研究。结果表明,厌氧滤池反应器水力停留时间(HRT)在8.1～14.6 h之间,进水COD浓度波动较大(500～1 000 mg/L)时,对COD平均去除率为20%。印染废水的BOD5/COD由0.23提高到0.35,废水可生化性明显改善。印染废水中硫酸根浓度略有下降,去除浓度为70 mg/L左右。厌氧滤池进出水颜色明显变化,由紫红色变为蓝黑色,紫外可见光谱分析表明废水中的有机物结构发生变化。     

Slaughterhouse wastewater treatment in a full-scale system with constructed wetlands.

This work evaluated the performance of a full-scale system with wetlands for slaughterhouse (abattoir) effluent treatment in the State of Hidalgo, México. The treatment system consisted of a primary sedimentation tank, an anaerobic lagoon, and a constructed subsurface-flow wetland, in series. The wetland accounted for almost 30% of the removal of organic matter. In general, the treatment system achieved satisfactory pollutant removals, but the final effluent could not meet the Mexican environmental regulations for fecal coliform counts, five-day biochemical oxygen demand (BOD5), and total suspended solids (TSS). Overall, removal levels were 91%, 89%, and 85% for BOD5, chemical oxygen demand, and TSS, respectively. However, BOD5 in the final effluent (137 mg/L) was higher than the maximum level of 30 mg/L allowed by the regulatory agency. Although organic nitrogen removal levels were approximately 80%, the nitrogen persisted in oxidation state -3 as ammonia-nitrogen, the removal of which was only 9% in the wetland stage. On average, phosphorus removal was null, and, on occasion, the phosphorus concentration in the treated effluent was higher than that of the influent. Coliform reductions in the overall system were high (on the order of 5 logs on average), whereas the coliform removal in the wetland was between 2 to 3.5 logs. The treatment system was also effective at removing pathogens (Vibrio cholerae, Salmonella, and Shigella). Further laboratory tests with the wetland effluent suggest that post treatment in a sand filter stage followed by disinfection with sodium hypochlorite (NaOCl) could help meet the Mexican discharge regulations, particularly the criteria for coliforms and total BOD5.     

生物填料地下渗滤系统对生活污水的脱氮

将草甸棕壤、炉渣和活性污泥等基质按体积比13∶6∶1配制生物填料,研究了生物填料地下渗滤系统（subsurface wastewater infiltration system,SWIS）在不同的水力负荷和污染负荷条件下对校园生活污水的脱氮效果。场地实验结果表明,当BOD5负荷为12.0 g BOD5/（m2·d）,表面水力负荷为0.04-0.10 m3/（m2·d）时,SWIS对NH＋4-N和TN的平均去除率分别为92.4%和82.0%。当水力负荷为0.08 m3/（m2·d）,BOD5负荷9.3-16.8 g BOD5/（m2·d）时,SWIS对NH＋4-N和TN的平均去除率为92.7%和81.2%。SWIS中氧化还原电位（oxygen reduction potential,ORP）随进水水力负荷和BOD5负荷的增加而降低,脱氮效率下降。综合出水水质和处理效率,适宜的水力负荷和污染负荷分别为0.065 m3/（m2·d）和12.0 g BOD5/（m2·d）。在此条件下,SWIS的启动周期为25-30 d。出水水质均优于《城市污水再生利用-景观环境用水水质》（GB/T18921-2002）标准,且处理效果稳定,抗负荷冲击能力强。     

Swine wastewater treatment using attached-growth and suspended-growth two stage sequencing batch reactors with real-time control.

Two two-stage sequencing batch reactors (TSSBR), one attached-growth and one suspended-growth, were operated under three levels of wastewater concentration (approximately 4,000, 2,000 and 500 TOC mg/L), respectively, to compare the pH and ORP (oxidation-reduction potential) patterns and system performance. In both TSSBR systems, the pH and ORP profiles varied with organic loading yet exhibited consistent patterns with distinctive features suitable for real-time control. For all runs at the three levels of influent, both systems achieved similar levels of treatment for BOD5, TOC and TSS of over 97.5, 93.4, and 97.3%, respectively. The attached-growth system out performed the suspended-growth system in achieving the same levels of treatment at much shorter aeration cycle times. The treatment efficiency for NO3(-)-N and PO4(-3) was greatly affected by the carbon content in the wastewater, and the best treatment was achieved during the TOC approximately 4,000 mg/L runs with final effluent at 4.0 and 21.3 mg/L, respectively.     

实验室有机废水的铁碳微电解预处理

采用铁碳微电解法对实验室有机废水进行小型处理实验,研究该方法的废水净化特性,并优化进水pH值、水力停留时间(HRT)和曝气量等主要运行工艺参数。通过正交实验得到最佳处理条件pH值为5,水力停留时间为6 h,曝气量为12 L·h-1。以实际最佳条件运行反应器,废水COD去除率可达到85%,废水中芳香族化合物等难降解物质得到降解,BOD5/COD由0.1提高到0.4以上,出水可生化性大幅提高。研究表明,铁碳微电解法适于处理实验室难降解有机废水,估算处理成本约为9.84元·m-3废水。     

液-液萃取处理高氯难降解有机废水

农药化工厂生产苯肼、苯唑醇、乙基氯化物过程排放的废水是高氯难生物降解有机废水,采用三辛胺作萃取剂,用液-液萃取处理,三辛胺与水中Cl-离子形成萃合物而使Cl-转移到有机相.再经高效絮凝处理后,CODCr总去除率达89.8%,Cl-总去除率达83.2%,BOD/COD比从0.02上升到0.34,可生化性大幅度提高. 废水再经河水稀释进A/O池生化处理3d后,可达标排放.负载萃取液用5%NaOH水溶液反萃取.由于萃取剂回用降低了处理费用.     

微电解与Fenton试剂预处理农药废水的试验研究

农药废水是一种典型的高浓度有机工业废水 ,有机污染物浓度高 (CODCr>10 0 0 0mg L) ,可生化性差 (氯苯农药废水BOD5 CODCr=0 .0 3 ,对邻硝基氯苯农药废水BOD5 CODCr=0 .0 5 )。采用微电解和Fenton试剂氧化两种物化手段对菊酯、氯苯和对邻硝氯苯 3种废水按比例配制而成的综合农药废水进行预处理 ,结果表明 :在废水pH为 2— 2 .5时 ,经微电解处理后 ,BOD5 CODCr比值在 0 .45以上 ,可生化性提高 ;Fenton试剂对综合农药废水CODCr去除率为 60 %左右 ,色度去除率接近 10 0 %     

复合人工湿地中低浓度有机物的去除及Monod模型模拟

以复合人工湿地工程实例为研究对象,研究了其在连续5个月内对低浓度有机污染物的深度处理效果,采用简化的Monod动力学模型对研究湿地进行模拟并验证,讨论了污染负荷与去除率的相关性以及BOD/COD比值对有机污染物降解系数的影响。研究湿地总面积为5 000 m2,进水水量为860～1 560 m3/d,水力停留时间为1.48～2.69 d,水力负荷为0.17～0.31 m/d,进水中有机污染物浓度较低(BOD53.0～25.6 mg/L;COD 22.9～89.8 mg/L)。结果表明,复合湿地组合形式对BOD5和COD的去除率分别介于37.9%～79.0%和41.0%～68.7%之间,简化的Monod模型对湿地中BOD5和COD去除的预测值与实验观测值吻合程度较好;BOD5、COD的去除率分别随着进水BOD5和COD浓度的增加而增大,而增长趋势逐渐变缓,当有机污染负荷低时,模型的K值较小;低浓度有机污染物在VSF、FWS和HSF湿地中的去除效率与有机物是否容易或者缓慢被微生物降解的性质相关性较差,这可能与人工湿地中存在的其他因素促进了有机污染物的去除有关。     

水力负荷对污水地下渗滤系统处理效果的影响

采用人工模拟的方法,研究了0.04、0.06、0.10、0.14和0.18 m3/(m2·d)5个水力负荷下污水地下渗滤系统对生活污水处理效果的影响。实验期间,SS、BOD5、COD、TN、NH4+-N和TP的进水浓度分别处于69.74~79.62、40.75~64.81、211.56~250.72、48.94~87.36、31.25~59.04和2.88~4.05 mg/L之间,出水平均浓度分别为13.63、9.66、31.53、21.08、1.90和0.10 mg/L。结果表明,地下渗滤系统对生活污水具有良好的处理效果,除TN外,其余各项指标均满足《城镇污水处理厂污染物排放标准》(GB/18918-2002)一级处理要求;当水力负荷为0.14和0.18 m3/(m2·d)时,BOD5 与TN去除率降低,出水浓度升高,受水力负荷影响明显;水力负荷对SS与COD影响作用微弱,去除率降幅较小;NH4+-N与TP则基本不受水力负荷变化影响。综合考虑渗滤系统的出水水质与日处理能力,推荐适宜水力负荷为0.10~0.14 m3/(m2·d)。     

Applying Kohonen self-organizing map as a software sensor to predict biochemical oxygen demand.

The 5 days at 20 degrees C biochemical oxygen demand (BOD5) is an important parameter for monitoring organic pollution in water and assessing the biotreatability of wastewater. Moreover, BOD5 is used for wastewater treatment plant discharge consents and other water pollution control purposes. However, the traditional bioassay method for estimating the BOD5 involves the incubation of sample water for 5 days. It follows that BOD5 is not available for real-time decisionmaking and process control purposes. On the other hand, previous efforts to solve this problem by developing more rapid biosensors had limited success. This paper reports on the development of Kohonen self-organizing map (KSOM)-based software sensors for the rapid prediction of BOD5. The findings indicate that the KSOM-based BOD5 estimates were in good agreement with those measured using the conventional bioassay method. This offers significant potential for more timely intervention and cost savings during problem diagnosis in water and wastewater treatment processes.     

水解-好氧生物法处理城市污水试验研究

采用水解 好氧工艺的原理 ,设计了将污水与污泥处理合二为一的高效组合水解池 三相生物流化床流程 ,在广州经济技术开发区进行了处理量为 1 0 0L/h的城市污水处理试验。试验结果表明 :在平均进水CODCr为 4 92 3mg/L ,BOD5为 2 4 0 9mg/L ,SS为 5 5 2 3mg/L ,NH4 N为 1 8 8mg/L ,TP为 2 0mg/L条件下 ,平均出水CODCr为 4 7 3mg/L ,BOD5为 2 2 lmg/L ,SS为 1 3 9mg/L ,NH4 N为 5 2mg/L ,TP为 1 4mg/L ,并进行了该工艺中污泥循环的初步分析 ,为该工艺处理城市污水工业化提供了技术参考。     

Preparation of biofilm electrode with Xanthomonas sp. and carbon nanotubes and the application to rapid biochemical oxygen demand analysis in high-salt condition

A Xanthomonas sp. was isolated from the sludge on the drain outlet of a pharmaceutical factory. Then, the bacterium and carbon nanotubes (CNTs) were co-attached to an oxygen electrode for rapid analysis of biochemical oxygen demand (BOD). The response current was linear with BOD values in the range 10 to 300 mg/L for standard BOD solution with a response time of 35 seconds (R = 0.9994) and 20 to 580 mg/L for pharmaceutical wastewater with a response time < or =200 seconds (R = 0.9985), which means that this modified electrode might be used for online BOD analysis of pharmaceutical wastewater. Further studies revealed that the modified electrode can be used for BOD measurement in a high-salt condition. Also, the bacterium/CNTs biofilm can maintain its activity and good performance, even after being sealed and stored at 4 degrees C for 50 days.     

上海市污水处理厂进水水质特征的统计学分析

针对上海市50座城市污水处理厂进水水质,利用实际运行数据,系统分析了水质特征以及有机物、氮、磷和悬浮物之间的概率分布和相关关系。结果表明,上海市污水中BOD5、COD、SS、NH3-N、TN和TP全年浓度分布均呈正偏态分布,月中间值分布范围分别在110~150 mg/L、260~325 mg/L、140~175 mg/L、20~30 mg/L、29~37 mg/L和3~5 mg/L。水质指标BOD5和COD、TN和TP及TN和TP之间存在显著的一元线性相关关系。进水BOD5/COD值分布在0.4~0.6之间的概率为64.6%,表明进水中生化性较好。BOD5/TN分布在4~6之间的概率为35.8%,表明进水反硝化碳源不足。BOD5/TP的平均值为32.6,且大于20的累积概率为84.1%,表明污水在处理中可以满足生物除磷的需求。TN/TP比值范围在1~25,平均值为8.6,且TN/TP>5的概率为88.1,表明进水基本满足微生物生长对氮、磷的需求。