An efficient technology to treat heavy metal--lead--contaminated soil by microwave radiation

Microwave (MW) technology can be used to vitrify contaminated soil wastes and immobilize heavy metal ions in soils. More than 93% of the Pb(II)-contaminated soil was vitrified to a glass/ceramic formation after 30 min of MW radiation. In a 6-year study, the Pb(II) concentration of the vitrified soil in the leaching test was less than 1.0 mg/l, which is substantially below the USEPA regulatory limit of 5.0 mg/l.     

Application of two organic wastes in a soil polluted by lead: effects on the soil enzymatic activities

The effects of adding a crushed cotton gin compost (CCGC) and a poultry manure (PM) on the enzymatic activities of a Typic Xerofluvent soil polluted with Pb were studied in the laboratory. Three hundred grams of sieved soil (<2 mm) were mixed with PM at a rate of 10% or CCGC at a rate of 17.2%, applying to the soil the same amount of organic matter with each organic amendment. Urease, protease-BBA, beta-glucosidase, alkaline phosphatase, and arylsulfatase activities were measured at four different incubation times (1, 7, 15, and 45 d) in soils containing seven concentrations (100, 250, 500, 1000, 2500, 5000, and 8000 mg kg-1) of Pb, and in the same soils amended with CCGC and PM. In all treatments and incubation times, the inhibition percentage of soil enzyme activities by Pb was lower in soils amended with the PM and CCGC than in nonamended soils, and it differed with the organic amendment. In this respect, the in the 8000 mg Pb kg-1 treatment at the end of the incubation period, the protease-BBA activity inhibition percentage was lower (14.7 and 33.9% lower, respectively) in CCGC- than in PM-amended soils. Since the adsorption capacity of Pb was higher in CCGC- than the PM-amended soils, the addition of organic wastes with higher humic acid concentration is more beneficial for remediation of soils polluted with Pb.     

超声波去除农用污泥中重金属的试验研究

污水处理厂污泥中的重金属浓度高是污泥农用的主要障碍。为了降低农用污泥中的重金属含量,以Cu、Zn、Ni、Pb为对象,研究了超声波对其的影响。结果表明:超声对污泥中重金属有一定的溶出作用。当超声时间为30min时,溶解状态Cu、Zn、Ni、Pb的析出率分别为42.1%、37.5%、12.7%、14.7%;总的析出率分别为52.7%、44.7%、23.6%、71%。其中析出的Pb大部分以胶体状态存在,而溶解状态只占很少一部分。其他几种金属则以溶解状态为主。     

In situ soil treatments to reduce the phyto- and bioavailability of lead, zinc, and cadmium

A study was established near a former Zn and Pb smelter to test the ability of soil amendments to reduce the availability of Pb, Zn, and Cd in situ. Soil collected from the field was amended in the lab with P added as 1% P-H3PO4, biosolids compost added at 10% (referred to hereafter as "compost"), and a high-Fe by-product (referred to hereafter as "Fe") + P-triple superphosphate (TSP) (2.5% Fe + 1% P-TSP) and incubated under laboratory conditions at a constant soil pH. Changes in Pb bioavailability were measured with an in vitro test and a feeding study with weanling rats. Field-amended and incubated soils using these plus additional treatments were evaluated using the in vitro extraction and tall fescue (Festuca arundinacea Schreb. cv. Kentucky-31) metal concentration. Reductions were observed across all parameters but were not consistent. In the feeding study, the 1% P-H3PO4 and compost treatments resulted in a decrease of 26% in rat tissue Pb concentration compared with the control soil. The 2.5% Fe + 1% P-TSP showed a 39% decrease. The 1% P-H3PO4 treatment caused the greatest reduction in in vitro extractable Pb from field samples (pH 2.2) with a measured reduction of 66%, while the compost treatment had a 39% reduction and the 2.5% Fe + 1% P-TSP treatment a 50% reduction. The in vitro extraction (pH 1.5) run on field samples showed no reduction in the compost or Fe treatments. The 1% P-H3PO4 treatment was the most effective at reducing plant Pb, Zn, and Cd.     

Novel passive co-treatment of acid mine drainage and municipal wastewater

A laboratory-scale, four-stage continuous-flow reactor system was constructed to test the viability of high-strength acid mine drainage (AMD) and municipal wastewater (MWW) passive co-treatment. Synthetic AMD of pH 2.6 and acidity of 1870 mg L(-1) as CaCO3 equivalent containing a mean 46, 0.25, 2.0, 290, 55, 1.2, and 390 mg L(-1) of Al, As, Cd, Fe, Mn, Pb, and Zn, respectively, was added at a 1:2 ratio with raw MWW from the City of Norman, OK, to the system which had a total residence time of 6.6 d. During the 135-d experiment, dissolved Al, As, Cd, Fe, Mn, Pb, and Zn concentrations were consistently decreased by 99.8, 87.8, 97.7, 99.8, 13.9, 87.9, and 73.4%, respectively, pH increased to 6.79, and net acidic influent was converted to net alkaline effluent. At a wasting rate of 0.69% of total influent flow, the system produced sludge with total Al, As, Cd, Cr, Cu, Fe, Pb, and Zn concentrations at least an order of magnitude greater than the influent mix, which presents a metal reclamation opportunity. Results indicate that AMD and MWW passive co-treatment is a viable approach to use wastes as resources to improve water quality with minimal use of fossil fuels and refined materials.     

Biosolid colloid-mediated transport of copper, zinc, and lead in waste-amended soils

Increasing land applications of biosolid wastes as soil amendments have raised concerns about potential toxic effects of associated metals on the environment. This study investigated the ability of biosolid colloids to transport metals associated with organic waste amendments through subsurface soil environments with leaching experiments involving undisturbed soil monoliths. Biosolid colloids were fractionated from a lime-stabilized, an aerobically digested, and a poultry manure organic waste and applied onto the monoliths at a rate of 0.7 cm/h. Eluents were monitored for Cu, Zn, Pb, and colloid concentrations over 16 to 24 pore volumes of leaching. Mass-balance calculations indicated significantly higher (up to 77 times) metal elutions in association with the biosolid colloids in both total and soluble fractions over the control treatments. Eluted metal loads varied with metal, colloid, and soil type, following the sequences Zn = Cu > Pb, and ADB > PMB > LSB colloids. Colloid and metal elution was enhanced by decreasing pH and colloid size, and increasing soil macroporosity and organic matter content. Breakthrough curves were mostly irregular, showing several maxima and minima as a result of preferential macropore flow and multiple clogging and flushing cycles. Soil- and colloid-metal sorption affinities were not reliable predictors of metal attenuation/elution loads, underscoring the dynamic nature of transport processes. The findings demonstrate the important role of biosolid colloids as contaminant carriers and the significant risk they pose, if unaccounted, for soil and ground water contamination in areas receiving heavy applications of biosolid waste amendments.     

Utilization of pulp and paper industrial wastes to remove heavy metals from metal finishing wastewater

Two pulp and paper industrial wastes, lime mud (LM) and recovery boiler ash (RB), have low moisture contents, low heavy metal contaminations and contain various carbonate compounds which contribute to a high pH. Metal finishing wastewater (MF-WW) has a low pH, high levels of TDS and high contaminations from Cr, Cu, Pb and Zn. The heavy metals from MF-WW were removed by sorption and precipitation mechanisms. LM gave better results in removing heavy metals from MF-WW than RB. At a reaction time of 45 min, the maximum removal efficiencies for Cr (93%) and Cu (99%) were obtained at 110 g L⁻¹ of LM, but at 80 g L⁻¹ for Pb (96%) and Zn (99%). Treatment with LM gives a higher sludge volume than with RB. However, the leachability of heavy metals from LM is lower. Leachability of heavy metals in the sediment for all selected treatment conditions is within government standards.     

Contamination time effect on lead and cadmium fractionation in a tropical coastal clay

The capability of a tropical coastal clay to immobilize lead (Pb) and cadmium (Cd) was investigated in laboratory batch sorption tests conducted under acidic, neutral, and slightly alkaline conditions. The contact time was extended to 65 d. The distribution of Pb and Cd among various sorbed phases was examined using a sequential extraction technique. The sorbed phases were fractionated into the exchangeable, carbonate, reducible, organic, and residual fractions. There were only small changes in the total Pb and Cd sorption beyond a 1-d sorption period. The metal fractionation results show that the amount of Pb and Cd in various fractions changed with sorption time, and the changes were pH-dependent. These changes could be attributed to mineral dissolution and transformation or redistribution of the sorbed phases. Transformation of the sorbed phases resulted in increasing Pb and Cd retention in the more persistent fractions with time, at the expense of reductions in the loosely bound fractions. Nevertheless, Pb and Cd fractionation in the solid phase appeared to reach equilibrium within the 65-d sorption period. These Pb and Cd fractionation results reflect the effect of contamination time on the heavy metal lability and bioavailability in the subsurface environment.     

Effects of wood bark and fertilizer amendment on trace element mobility in mine soils, Broken Hill, Australia: implications for mined land reclamation

Soil amendments can immobilize metals in soils, reducing the risks of metal exposure and associated impacts to flora, fauna and human health. In this study, soil amendments were compared, based on "closed system" water extracts, for reducing metal mobility in metal-contaminated soil from the Broken Hill mining center, Australia. Phosphatefertilizer (bovine bone meal, superphosphate, triple superphosphate, potassium orthophosphate) and pine bark (Pinus radiata) were applied to two soils (BH1, BH2) contaminated with mining waste. Both soils had near neutral to alkaline pH values, were sulfide- or sulfate-rich, and contained metal and metalloid at concentrations that pose high environmental risks (e.g., Pb = 1.25 wt% and 0.55 wt%, Zn = 0.71 wt% and 0.47 wt% for BH1 and BH2, respectively). The addition of fertilizers and/or pine bark to both soil types increased water extractable metals and metalloids concentrations (As, Cd, Cu, Fe, Mn, Pb, Sb, Zn) compared with nonamended soils. One or more of the elements As, Cd, Cu, Mn, Pb, and Zn increased significantly in extracts of a range of different soil+pine bark and soil+fertilizer+piner+pine bark tests in response to increased pine bark doses. By contrast, Fe and Sb concentrations in extracts did not change significantly with pine bark addition. Solution pH was decreased by phosphate fertilizers (except for bovine bone meal) and pine bark, and pine bark enhanced dissolved organic carbon. At least in the short-term, the application of phosphate fertilizers and pine bark proved to be an ineffective method for controlling metal and metalloid mobility in soils that contain admixtures of polymetallic, polymineralic mine wastes.     

Response of soil microbiological activities to cadmium,lead, and zinc salt amendments

Heavy metal pollution of soil has been recognized as a major factor impeding soil microbial processes. From this perspective, we studied responses of the soil biological activities to metal stress simulated by soil amendment with Zn, Pb, and Cd chlorides. The amounts of heavy metal salts added to five metal-polluted soils and four nonpolluted soils were selected to match the total metal concentrations typically found in polluted soils of the Silesia region of Poland. From the perspective of soil quality, metal mobility in amended soils could not be described by simple functions of pH or organic matter. Reaction of Pb with the soil caused strong immobilization with less than 1% of the Pb amendment recovered by 0.01 M CaCl2 extractions. Immobilization of Cd was also significant, whereas immobilization of the Zn amendment was much weaker than that of Cd or Pb. The Zn amendment had substantial inhibitory effect on soil dehydrogenase, acid and alkaline phosphatase, arylsulfatase, urease, and nitrification potential. Generally, Cd and Pb had limited or stimulatory effect on most of these biological activities, with an exception of Pb strongly inhibiting soil urease. The effect of the metal amendments on biological activities could not be satisfactorily accounted for by metal toxicity because no strong relationship was observed between extractable metal content and the degree of inhibition. The Zn amendment had a significant effect on soil pH, resulting in confounding effects of pH and Zn toxicity on activities. Metal amendment experiments seem to be of limited utility for meaningful assessment of metal contamination effects on soil quality.     

Biosorption of Cu(II), Zn(II), Ni(II) and Pb(II) ions by cross-linked metal-imprinted chitosans with epichlorohydrin

Cross-linked metal-imprinted chitosan microparticles were prepared from chitosan, using four metals (Cu(II), Zn(II), Ni(II), and Pb(II)) as templates, and epichlorohydrin as the cross-linker. The microparticles were characterized by Fourier transform infrared spectroscopy, solid state (13)C nuclear magnetic resonance spectroscopy, and energy-dispersive X-ray spectroscopy. They were used for comparative biosorption of Cu(II), Zn(II), Ni(II) and Pb(II) ions in an aqueous solution. The results showed that the sorption capacities of Cu(II), Zn(II), Ni(II), and Pb(II) on the templated microparticles increased from 25 to 74%, 13 to 46%, 41 to 57%, and 12 to 43%, respectively, as compared to the microparticles without metal ion templates. The dynamic study showed that the sorption process followed the second-order kinetic equation. Three sorption models, Langmuir, Freundlich, and Dubinin-Radushkevich, were applied to the equilibrium isotherm data. The result showed that the Langmuir isotherm equation best fitted for monolayer sorption processes. Furthermore, the microparticles can be regenerated and reused for the metal removal.     

Field test of in situ soil amendments at the Tar Creek National Priorities List Superfund site

A range of soil amendments including diammonium phosphate fertilizer (DAP), municipal biosolids (BS), biosolids compost, and Al- and Fe-based water treatment residuals were tested on Pb-, Zn-, and Cd-contaminated yard soils and tailings at the Tar Creek NPL site in Oklahoma to determine if amendments could restore a vegetative cover and reduce metal availability in situ. For the yard soils, all amendments reduced bioaccessible (assessed with a physiologic-based extraction method) Pb, with reductions ranging from 35% (BS+Al, DAP 0.5%, DAP+Compost+Al) to 57% (Compost+Al). Plant Zn (Cynadon dactylon L.) and NH4 NO3-extractable Cd and Zn were also reduced by a number of amendments. For the tailings, all amendments excluding BS reduced bioaccessible Pb, with the largest reductions observed in the DAP 3% and DAP3%+BS treatments (75 and 84%). Plant growth was suppressed in all treatments that contained DAP for the first season, with the highest growth in the treatments that included compost and biosolids. In the second year, growth was vigorous for all treatments. Plant Zn and Cd and extractable metal concentration were also reduced. A number of treatments were identified that reduced bioaccessible Pb and sustained a healthy plant with reduced metal concentrations. For the yard soil, Compost+Al was the most effective treatment tested. For the tailings, BS+DAP 1% was the most effective treatment tested. These results indicate that in situ amendments offer a remedial alternative for the Tar Creek site.     

Biological aspects of metal waste reclamation with biosolids

Smelter waste deposits pose an environmental threat worldwide. Biosolids are potentialy useful in reclamation of such sites. Biological aspects of revegetation of Zn and Pb smelter wastelands using biosolids are discussed in this report. The goal of the studies was to assess to what extent biosolid treatment would support ecosystem functioning as measured by biological indicators such as enzyme activities of revegetated metal waste or plant growth. Another crucial aspect was related to the assessment of metal transfer to the ecosystem which could affect the health of local fauna and also create a food chain risk. A field experiment was conducted on a smelter waste deposit in Piekary Slaskie, Silesia, Poland, with two separate fields - established on wastes from the Welz and Doerschel smelting processes. The tested methods allowed revegetation of the fields - application of municipal biosolid at the rate 300 dry t ha(-1) combined with the incorporation of commercial lime in a mixed oxide and carbonate form at the rate of 1.5 and 30 t for Welz waste or use of a 30 cm by-product lime cap followed by incorporation of biosolid at a rate of 300 t ha(-1) for the more acidic Doerschel waste. Studies on biological activities demonstrated that the reclamation methods used are an effective way to establish new, fully-functioning ecosystems that support plant growth. They also provided strong evidence that forage crops grown on Zn, Cd and Pb contaminated sites reclaimed using lime and biosolids do not pose identified risk for wildlife and food safety.     

Upflow column reactor design for dechlorination of chlorinated pulping wastes by Penicillium camemberti

A Penicillium camemberti strain isolated in our laboratory has been studied for its ability to degrade chlorinated pulping wastes, presumably containing a variety of chlorinated polyphenols. In batch tests, the highest removals (76% AOX, 61% color and 65% TOC) were obtained with 0.2 g/l feed acetate concentration. The tendency of the fungus to dechlorinate bleachery effluents better under non-shaking conditions and to attach onto surfaces suggested the use of immobilized cells rather than freely suspended ones in further exploitation of the process. An upflow glass wool packed column reactor established with this fungus could be operated for nearly two years in the laboratory. At best around 70% AOX could be removed from chlorinated pulping wastes in 7.3 h of contact with no aeration and with a minimal amount of carbon supplement (0.2 g/l). Finally, an asymptotic mathematical formula for determining Michaelis-Menten kinetic rates has been derived. The kinetic rates K(m) (the Michaelis constant or saturation constant for the substrate) and V(m) (the product of maximum rate for the enzymatic reaction and biomass concentration) were then calculated as 126.386 mg/l and 2.83017 mg/lh, respectively.     

Heavy metal removal and cyanide destruction in the metal plating industry: an integrated approach from egypt

Wastewater produced from a metal plating is a major environmental problem. Industrial auditing revealed that the main source of pollution mainly originated from rinsing water. The characterization of final effluent showed that it is highly contaminated with hazardous heavy metals and cyanide. The concentration of copper, hexavalent chromium, nickel, and cyanide in the rinsing water of metal plating department was 14.8, 40.9, 13.3, and 19 mg/l, respectively. The concentration of cyanide and zinc from the galvanizing department reached 60 and 80 mg/l. The remediation scheme included the application of in-plant control measures via changing the rinsing process followed by the destruction of cyanide and reduction of hexavalent chromium bearing wastes. The pretreated wastes were then mixed with other industrial wastes prior to a combined chemical coagulation-sedimentation using lime and/or lime in combination with ferric chloride. The results indicated that, after applying the waste minimization measures alone at the source, prior to final treatment of industrial waste, removal rates of cyanide, copper, nickel, and chromium concentrations were 23.2%, 14.9%, 32.3%, and 55.3%, respectively in the rinse water from metal plating department. Furthermore, the removal rates of cyanide and zinc in the galvanizing department reached 59.7% and 24.3. The integrated control measures and treatment scheme led to more than 99% removal of copper, nickel, chromium, and zinc, while the complete removal of cyanide was achieved in the final effluent.     

Physical properties of industrial wastes: laboratory tests

This article describes some laboratory tests performed on each kind of sludge located in an industrial wastes landfill. Measured physical properties are: field capacity, hydraulic permeability, saturation water content, effective porosity and particle-size distribution. The laboratory apparatus is described; the obtained results are analyzed to point out the possible correlations among the examined parameters. The aim of this work is to provide a data bank for industrial wastes landfills useful to perform some applications such as the evaluation of the produced leachate quantity for landfills whose wastes are similar to the ones here considered.     

我国南方某城市垃圾焚烧飞灰特性及固化/稳定化处置实验

我国南方某城市主要采用焚烧法处理生活垃圾,已建7个焚烧厂日产生飞灰量为101.62 t/d。文章分析了各个垃圾焚烧厂飞灰的化学组成和重金属浸出毒性,其主要成分为CaO、SiO2、MgO、Al2O3、Fe2O3、Na2O、SO3和Cl,所有焚烧飞灰都有至少一种重金属浸出浓度超标,属于危险废物。在飞灰处置出路亟待解决的背景下,实验探讨了飞灰稳定化工艺,结果表明10%的水泥添加量可以使飞灰中超标重金属(Cd、Pb和Zn)的浸出浓度满足危险废物鉴别浓度限值和安全填埋场入场浓度限值。同时,通过人体健康风险评价分析了飞灰豁免管理的可行性,并对近期和远期该城市焚烧厂飞灰的处理处置及管理提出建议。     

Glutathione Related Enzyme Levels of Freshwater Fish as Bioindicators of Pollution

The livers and kidneys of freshwater fish species, Oreochromis niloticus and Clarias lazera, collected from sewage polluted sites (Ismailia and El-Bahr El-Azam) and industrial polluted sites (Shubra and El-Tebin) of Nile River were analyzed for different antioxidant defense enzymes. The liver and kidney glutathione transferase (GST), glutathione reductase (GR) and glutathione peroxidase (GPx) were higher in O. niloticus captured from all the polluted areas compared to the control. Low GST activities were found in 33.3%, 60% and 53% in the livers and 100%, 80% and 53% in the kidneys of C. lazera captured from El-Bahr El-Azam, Shubra and El-Tebin. GR and GPx activities increased in livers and kidneys of C. lazera collected from all areas except for Shubra, in which, GPx of livers and kidneys were low in 100% of C. lazera. Metals Ni, Co, Cr, Se, Cd and Pb resulting from industrial wastes and metal mining wastes were enhanced at the polluted sites. SDS-PAGE of liver and kidney of O. niloticus and C. lazera indicated the increase in bands number and intensity of protein bands with subunit molecular weights between 30–20 KDa in polluted areas. Several enzymes from glutathione system (activity and protein) constitute a sensitive biochemical indicator of chemical pollution. Relative changes of glutathione-dependent enzymes in both fish species suggest a different susceptibility to toxins.     

Decontamination of water polluted by heavy metals with Taro (Colocasia esculenta) cultured in a hydroponic NFT system

The toxicity and bioaccumulation of two heavy metals—lead (Pb) and cadmium (Cd)—in a semi-aquatic plant, Colocasia esculenta (L. Schott), from a synthetic heavy metal solution were studied. Young plants of equal size were grown hydroponically in shallow raceways containing Hoagland medium amended with 20, 40, and 60 mg l^?1 of Pb and 2, 4, and 6 mg l^?1 of Cd. The medium containing heavy metals was allowed to flow through the raceways with a change in influent heavy metal solution on every 5th day. The experiment was continued for 20 days. A set of control raceways—one comprised of nutrient medium with heavy metal supplements, devoid of plants, and another with the plants and nutrient medium having no metal supplement—was also simultaneously run. Chlorosis in the leaves was the prominent toxicity symptom observed due to Pb and Cd on the test plants. A significant decrease in the relative growth, biomass productivity, and total chlorophyll content were noticed in the plants with an increase in concentration of metal supplement in the solution and exposure time. Both metals accumulated to higher concentrations in the roots than in shoots, suggesting that the metals were bound to the root cells and their translocation to the leaves was limited. The results of the 20-day-long experiments indicate that from a phytoremediation perspective, C. esculenta is a promising plant species for remediation of wastewater polluted with lower concentrations of Pb and Cd.     

高校实验室污染现状调查及排污管理方案研究

对某高校各实验室污染现状进行调查分析。结果表明,在所调查的16个院系中,12个院系其下属实验室存在污染物的排放,比例为75％;污染物涉及废气、废液、固体废物、噪音,其中废液与固体废物的排放量合计约11．09t／a;危险废物占国家危险废物名录所认定的47大类中的28类,比例高达59、6％。针对实验室排污的基本情况及特点,提出了“源头控制、分类收集、定点贮存、合理处置”的实验室排污管理方案。