油页岩灰渣浸取铝酸钠溶液试验研究

以油页岩废渣为原料,通过酸浸法浸取油页岩灰渣中的铝酸钠溶液.采用焙烧活化方法将废渣中含铝的低活性晶体物质活化为高活性半晶体或非晶体物质,利用酸浸法浸取焙烧后的高活性含铝废渣,得到铝液;依据试验分析了影响酸浸法浸取铝酸钠溶液的主要影响因紊为焐烧温度、焙烧时间、浸取酸浓度和浸取温度;得出酸浸法的最佳工艺参教:活化温度850℃,活化时间3 h,选用酸浓度40%,浸取温度60℃,此时油页岩废渣铝浸取率为75%.     

碱熔法回收废催化剂中的钴、钼和铝

采用碱熔法从废钴钼催化剂中回收钴、钼和铝。该方法的工艺过程为 :将废催化剂与纯碱按质量比 1∶1 8混合 ,在焙烧温度 90 0℃条件下 ,焙烧 2h ;用 2倍于熔块的沸水浸取30min ;用稀硫酸调浸取液 pH至 6 ,浸取液中的铝形成氢氧化铝被回收 ;然后除盐并回收钼酸钠 ;使酸浸黑渣中的钴形成氢氧化钴并脱水氧化成为氧化钴。用该工艺回收铝、钼和钴 ,其回收率可达 95 %以上 ,回收产品的纯度可达 97%以上。     

从含铬铝泥中回收铝的新工艺

采用"打浆水洗除Cr(Ⅵ)—电渗析除Cr(Ⅵ)—碱浸提铝—碳酸化分解法精制Al_2O_3"的新工艺处理含铬铝泥(以下简称铝泥),并回收Al_2O_3。实验结果表明:铝泥在70℃下经3次打浆水洗后,w(Na_2CrO_4)(以干铝泥计)降至5.0%;采用电渗析除Cr(Ⅵ)工艺可有效去除铝泥中以结合态和结晶态形式存在的Na_2CrO_4,在55 V直流电压下电渗析6h后铝泥中的w(Na_2CrO_4)降至0.98%;在碱浸温度为100℃、碱浸时间为3 h、NaOH质量浓度为150 g/L的优化碱浸条件下,铝浸出率(以Al_2O_3计)高达90.0%;经3次碳酸化分解处理后,Al_2O_3产品的纯度达98.65%,满足GB/T 24487-2009《氧化铝》中的一级标准,Al_2O_3回收率为96.37%。     

生态修复植物蜈蚣草中砷的回收

采用管式炉高温热解-NaOH-Na₂CO₃混合液碱浸-CuSO₄·5H₂O沉淀的方法回收生态修复植物蜈蚣草中的砷,最终得到产品砷酸铜。该方法的最佳工艺条件为：热解温度600 ℃,热解时间30 min,CaO加入量（CaO与蜈蚣草的质量比）8%; m（NaOH）∶m（Na₂CO₃）=1∶3,碱浸温度70 ℃, 碱浸时间2 h, 固液比1∶10; 沉淀反应pH 5, 沉淀反应温度70 ℃。采用该方法处理生态修复植物蜈蚣草,得到产品砷酸铜的纯度为93%,砷回收率达88%。     

砷华废渣的综合利用

采用氧化焙烧-软锰矿浆吸收、磁化焙烧-磁选、酸浸工艺处理砷华废渣.氧化焙烧的适宜条件为焙烧温度650 ℃,焙烧时间60 min,废渣粒径97 μm.磁化焙烧的适宜条件为焙烧温度550 ℃,焙烧时间30 min.酸浸的适宜条件为硫酸质量分数20%.经全流程实验,硫以MnSO4*H2O的形式回收,产品质量达到工业级硫酸锰一级标准.铁回收率为84.8%,锌回收率为80.9%,处理后废渣中银含量达246 g/t.处理过程产生的废弃物中砷较为稳定.     

电镀污泥中铜和镍的回收

采用硫酸酸浸#x02014;铜镍分离#x02014;净化除杂#x02014;沉淀制取硫酸镍的工艺从电镀污泥中回收铜和镍,分别采用硫化钠沉淀法和铁粉置换法研究电镀污泥酸浸液中铜和镍的分离效果。实验结果表明,硫化钠沉淀法对铜和镍的分离效果较好,其最优工艺条件为：硫化钠加入量为理论需求量的1.2倍,硫化钠沉淀温度60℃,硫化钠沉淀时间30min。利用本回收工艺制得的硫酸镍产品中镍的质量分数为18%,镍的回收率达80%以上,铜的回收率达90%以上。     

用副产盐酸和劣质高岭土制备聚合氯化铝

开发出一种用废盐酸和劣质高岭土生产聚合氯化铝的方法。分别考察了焙烧温度，焙烧时间，盐酸用量以及酸浸时间对铝浸出率的影响。试验结果表明；依照该工艺生产的聚合氯化铝，其各项指标符合GB15892-95标准。     

酸浸—萃取—沉淀法回收废锂离子电池中的钴

采用酸浸—萃取—沉淀法回收废锂离子电池中的钴。实验结果表明:废锂离子电池在600℃下煅烧5 h可将正极材料上的有机黏结剂与正极活性物质分离;正极活性物质在Na OH溶液浓度为2.0 mol/L、n(Na OH)∶n(铝)=2.5、碱浸温度为20℃的条件下碱浸反应1 h后,铝浸出率达99.7%;已除铝的正极活性物质在硫酸浓度为2.5 mol/L、H_2O_2质量浓度为7.25 g/L、液固比为10、酸浸温度为85℃的条件下酸浸反应120 min,钴浸出率高达98.0%;酸浸液在p H为3.5、萃取剂P507与Cyanex272体积比为1∶1的条件下,经2级萃取,钴萃取率为95.5%;采用H_2SO_4溶液反萃后在硫化钠质量浓度为8 g/L、反萃液p H为4的条件下沉淀反应10 min,钴沉淀率达99.9%。     

高炉渣制备聚硅酸硫酸铝铁混凝剂

以高炉渣为原料,分别采用酸浸及碱浸-酸化工艺得到铁、铝离子及聚硅酸,再将铁、铝离子引入聚硅酸制得聚硅酸硫酸铝铁(PSAFS)混凝剂。考察了PSAFS的聚合条件对焦化废水混凝效果的影响,并与市售混凝剂进行了对比。实验结果表明:PSAFS的最佳制备条件为n(Al+Fe)∶n(Si)=0.53,混凝剂p H=1,熟化时间0.5 h,熟化温度60℃;PSAFS加入量为4 m L/L时,混凝效果最好,对焦化废水的浊度和COD的去除率分别达到98.9%和74.5%;PSAFS的性能优于市售的3种混凝剂。     

用含锌废催化剂制备纳米氧化锌

以含锌废催化剂为原料,经酸浸、除杂、锌粉置换、合成等工艺制得碱式碳酸锌,再经过滤、洗涤、干燥、煅烧制备纳米氧化锌。考察了酸浸工艺硫酸溶液含量和液固比(硫酸与含锌废催化剂的质量比)对锌浸出率的影响,以及煅烧温度对纳米氧化锌质量的影响。实验结果表明:在硫酸质量分数为30%、液固比为5的最佳酸浸工艺条件下,锌浸出率为92%;在最佳煅烧温度为400℃的条件下,氧化锌质量分数大于95%,比表面积大于50 m2/g;纳米氧化锌颗粒大小均匀,平均粒径小于50 nm。     

Distribution of Cd,Ck, Pb and Zn in Soil and Vegetation Compartments in Stands of Five Boreal Tree Species in N.E. Sweden

Concentrations and total quantity of cadmium (Cd), cupper (Cu),lead (Pb) and zink (Zn) were determined in biomass and soil compartments in a replicated tree species experiment with 27-yr-old stands growing on former farmland in N.E. Sweden. Sequentialextractions of soil samples were performed in order to estimate the exchangeable and an organically bound fraction of each element. The tree species included were Picea abies (L.)H. Karst., Pinus sylvestris L., Pinus contorta Dougl., Larix sibirica Ledeb., and Betula pendula Roth.Tree species influenced the rate of removal of Cu, Pb and Zn incase of stemwood harvesting, and of Cd, Cu and Zn in the case ofwhole-tree harvesting. B. pendula and P. abies had higher quantities and average concentrations of Zn in the biomass. For all species, >50% of the Zn in the stems was found in the bark. P. abies and L. sibirica had higher quantities of Cu in the biomass than the other species.P. abies and P. contorta had high quantities of Cd inthe biomass in relation to the other species. Branches and stembark contained high concentrations of Cd and Pb in relation to foliage and stemwood. Dead branches had especially high concentrations of Pb. The high accumulation rate of Zn in thebiomass of B. pendula was related to a low exchangeable amount of Zn in the A horizon. In the superficial centimeters ofthe A horizon, a depletion similar to that found for Zn was detected for Cu, whereas for Cd and Pb, no correlations were found between quantities of elements in the trees and element pools in the soil.     

Programs assessing implementation and effectiveness of state forest practice rules and BMPs in the West

The major forest nonpoint source control programs in the West are largely regulatory, either under forest practices acts (California, Idaho, New Mexico, Nevada, Oregon, and Washington) or a streamside management act (Montana). These programs and the specific rules they enforce continue to undergo intensive scrutiny. Still, the questions are the same for these regulatory programs as for states that base nonpoint source control on voluntary BMPs (Arizona, Colorado, Utah, Wyoming). Are the rules or BMPs being applied, and are they effective in reducing nonpoint source pollution to levels that protect beneficial uses of water? The level of debate about forestry in the West has resulted in detailed monitoring and research to answer these questions. In the past, state agencies have assumed levels of BMP compliance based on the percent of operations without enforcement actions. These estimates are being replaced by statistically valid and reproducible monitoring of forest practices rules and BMP compliance levels. BMP effectiveness is being assessed using both qualitative and quantitative methods. This can involve field assessments, process-based research, and control watershed studies. Some trend monitoring is also beginning. With the regional implementation rate for forestry BMPs at about 94% and rising, it is likely that effectiveness testing will continue to be a priority and consume the majority of assessment resources for this region.     

High Immobilization of NH4+ in Danish Heath Soil Related to Succession,Soil and Nutrients: Implications for Critical Loads of N

During recent decades heathlands havechanged into grasslands in regions with high atmosphericnitrogen deposition. In regions with intermediatedeposition level (e.g., Denmark) changes have been lesspronounced which may be due to delay or decrease inresponse of the ecosystem. The mor layer (O horizon) mayplay an important role for this delay due to high sinkstrength for N. In this study, the capacity for netNH₄ ⁺ immobilization and mineralization wasstudied during short- and long-term incubations (2–36 days)of mor samples from Danish dry inland heaths. High short-term capacity for net NH₄ ⁺ immobilization wasfound to be a general characteristic of Danish heath morlayers both under heather (Calluna vulgaris) andcrowberry (Empetrum nigrum ssp nigrum), the latterdominating late stages in heathland succession. The netNH₄ ⁺ immobilization was higher under youngcompared to old or dead vegetation, and higher on lessnutrient poor soils than on extremely nutrient poor soils.The addition of N, P and C stimulated CO₂ productionand net NH₄ ⁺ immobilization, but not net Nmineralization. The immobilization of ¹⁵NH₄ ⁺caused release of dissolved organic N, increased N anddecreased C/N ratio in the microbial biomass, and indicatedgrowth of microorganisms with other metabolic abilitiesthan the indigenous population. No evidence was obtained ofstabilization of immobilized ¹⁵NH₄ ⁺ intosoil organic matter during the experiment. On background ofthe results and current knowledge it was concluded that therecognition of the high capacity for net NH₄ ⁺immobilization in mor layers does not allow for a raiseof critical loads for N for northern dry inland heaths.     

Starch-plastic materials—Preparation,physical properties,and biodegradability (a review of recent USDA research)

Recent starch-plastic research at the National Center for Agricultural Utilization Research is reviewed and related worldwide efforts are noted. Properties of starch that influence its formulation and performance in plastics are discussed. Methods are given for preparation of starch-poly(methyl acrylate) graft copolymer, starch-poly(ethylene-co-acrylic acid), and starch-poly(ethylene-co-acrylic acid)-polyethylene plastics. Their physical properties are discussed, as is degradability by enzymes or amylolytic organisms from soil, ponds, and streams.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

Application of Cellulose Microfibrils in Polymer Nanocomposites

Cellulose microfibrils obtained by the acid hydrolysis of cellulose fibers were added at low concentrations (2–10% w/w) to polymer gels and films as reinforcing agents. Significant changes in mechanical properties, especially maximum load and tensile strength, were obtained for fibrils derived from several cellulosic sources, including cotton, softwood, and bacterial cellulose. For extruded starch plastics, the addition of cotton-derived microfibrils at 10.3% (w/w) concentration increased Young’s modulus by 5-fold relative to a control sample with no cellulose reinforcement. Preliminary data suggests that shear alignment significantly improves tensile strength. Addition of microfibrils does not always change mechanical properties in a predictable direction. Whereas tensile strength and modulus were shown to increase during addition of microfibrils to an extruded starch thermoplastic and a cast latex film, these parameters decreased when microfibrils were added to a starch–pectin blend, implying that complex interactions are involved in the application of these reinforcing agents.     

四氮唑废水处理工艺设计

高浓度、高盐分的四氮唑生产废水通过三效蒸发浓缩,馏出液经铁炭氧微电解和混凝预处理,再采用水解酸化一接触氧化一反应二沉主体组合工艺进行处理。研究了该工艺所需构筑物和设备的设计与选型。该工艺在正常运行条件下,处理后出水pH6～9,COD 302mg／L,BOD5 108mg／L,SS30mg／L,色度36倍,水质达到GB8978--1996（污水综合排放标准》三级标准。     

Hysteresis in Reversal of Central European Mountain Lakes from Atmospheric Acidification

Extremely high emissions of S and N compounds in Central Europe (both 280 mmol m^-2 yr^-1) declined by 70and 35%, respectively, during the last decade. Decreaseddeposition rates of SO₄ ^-2, NO₃ ^-, and NH₄ ⁺ in the region paralleled emission declines. The reduction in atmospheric inputs of S and N to mountain ecosystemshas resulted in a pronounced reversal of acidification in the Tatra Mountains and Bohemian Forest lakes. Between the 1987–1990and 1997–1999 periods, concentrations of SO₄ ^-2 and NO₃ ^- decreased (average ± standard deviation) by 22±7 and 12±7 mol L^-1, respectively, in theTatra Mountains, and by 19±7 and 15±10 mol L^-1, respectively, in the Bohemian Forest. Their decrease was compensated in part (1) by a decrease in Ca²⁺ + Mg²⁺ (17±7 mol L^-1) and H⁺ (4±6 mol L^-1), and an increase in HCO₃ ^-(10±10 mol L^-1) in the Tatra Mountains lakes, and (2) by a decrease in Al (7±4 mol L^-1), Ca²⁺ + Mg²⁺ (9±6 mol L^-1), and H⁺ (6±5 mol L^-1), in Bohemian Forest lakes. Despite the rapid decline in lake water concentrations of SO₄ ^-2 and NO₃ ^- in response to reduced S and N emissions, their present concentrations in some lakes are higher than predictionsbased on observed concentrations at comparable emission rates during development of acidification. This hysteresis in chemical reversal from acidification has delayed biological recovery of the lakes. The only unequivocal sign of biological recovery hasbeen observed in erné Lake (Bohemian Forest) where a cladoceran species Ceriodaphnia quadrangular has recentlyreached its pre-acidification abundance.     

Reconstruction of Long-Term Changes in Lake water Chemistry,Zooplankton and Benthos of a Small,Acidified High-Mountain Lake: Magic Modelling and Palaeolimnogical Analysis

Starolesnianske pleso is a small and shallow acid lake in the High Tatra Mountains, situated at 2000 m above sea level, on granitic bedrock, with sparse and thin soil cover. When detailed measurements began in the 1980s Starolesnianske pleso had pH below 5 and only one species of cladoceran zooplankton, the ubiquitous Chydorus sphaericusPalaeolimnological investigations show changes in cladoceran zooplankton and chironomid zoobenthic assemblages since about 1920 and a major change in 1970–1980. The dynamic acidification model MAGIC was used to reconstruct changes in water chemistry over the past 150 years. The results from MAGIC agree well with the sediment record; pH levels gradually decreased from 6.5 in the mid-1800s to about 5.6 in 1920 (first response in biota) to below 5.0 by 1970, and concentrations of inorganic aluminium rose dramatically beginning about 1960. In the 1990s the lake water chemistry showed clear signs of reversal in acidification brought about by a major decline in S deposition.     

Does Soil Acidification Affect Spruce Needle Chemical Composition and Tree Growth?

In 1994, a large survey of soil chemistry was undertaken in thecounty of Värmland in central Sweden (Lundström et al., 1998).The southern part of the county was affected by soilacidification whereas there were no such indications in thenorthern part. To investigate the influence of soil chemistryon the trees at the specific sites, the survey was continued byan analysis of needle chemistry (Norway spruce) which wasundertaken at 150 of the 180 sites, and of tree growth at 65 ofthe 180 sites. Growth was expressed as a ratio between expectedgrowth, estimated with a national, empirical growth model, andthe growth observed in the field. In statistical analyses,using rank correlation, PCA and PLS, there were only weakindications of an influence of soil chemistry on needlechemistry and on tree growth. A moderate correlation betweennitrogen and sulphur in needles was found, which wasinterpreted as an effect of deposition and of processes in thetree canopy. No obvious regional pattern of the growth ratiowas found, in contrast to the clear pattern of soilacidification. The statistical analysis could not with anycertainty point out any of the soil chemistry variables asespecially important for the tree growth ratio.     

Heavy Metals Removal by Biosorption and Flotation

The removal of a mixture of heavy (toxic) metal cations (copper, nickeland zinc) from liquid effluents was investigated in this study at pilotscale, using counter-current contact mode. The innovative processinvolved the abstraction of metal ions onto fungal biosorbents, followedby the application of flotation for the subsequent solid/liquid separationof biomass particles. The ability of microorganisms to remove metal ionsfrom aqueous solutions is a well-known phenomenon. Nevertheless,engineering considerations are very important in decisions, concerningthe commercial future of biosorption and practical solutions are neededfor certain problems, such as the efficient post-separation ofmetal-loaded biomass. The two processes (flotation and biosorption) caneffectively operate in combination, in what it was termed biosorptiveflotation process. The sorbents may be recycled, after appropriate elutionof metals, as well as the treated (clean) water.