粪便中温好氧堆肥过程有机物的降解研究

为了生态厕所的推广使用、便于操作和节约能耗,多采用无加热的设施,即在自然条件下(对于小型生态厕所,接近中温条件)的好氧堆肥处理.了解中温好氧堆肥过程有机物的降解特性,对于生态厕所的推广使用和简化设计、操作等具有重要意义.采用密闭式好氧堆肥反应器,模拟中温(35℃)的堆肥温度,以新鲜锯末为空白载体,在含水率为60％以及连...     

新型堆肥生物反应器人粪便堆肥功效的评价

利用以锯末为载体的Bio-Lux S15型生态卫生设备,对人粪便进行了连续性堆肥实验,考察了BOD₅、粪大肠菌和蛔虫卵的灭活以及最终产品N、P和K等肥料成分的含量。实验结果表明,最初30 d,BOD₅的累积去除率由27％快速增加到50％,之后的30 d维持在50％左右,随后下降至40％左右。生态卫生设备中维持50～60℃的温度是杀灭粪便病原微生物的适宜条件,可保证粪便投入后在24 h内,粪大肠菌的灭活率达到99.99％,蛔虫卵的灭活率在2 h内达100%。对反应周期内载体的N、P和K等肥料成分的分析结果表明,反应过程中3种肥分都持续积累,在反应末期,按TN、P₂O₅和K₂O计算的3种肥分最终分别达到25.1、123.4和2.0 g/kg,基本上达到了农用肥料的国家标准,表明以锯末为载体的反应器具有良好的堆肥效果。     

初始温度对人粪便好氧堆肥过程的影响

温度是好氧堆肥过程中需要控制的一个重要因素。不同的初始温度直接影响了堆肥过程中微生物活性及有机物的降解。为了研究初始温度对粪便好氧堆肥过程的影响,采用序批式好氧堆肥反应器,以新鲜锯末为载体,控制含水率在55%~60%的范围左右并强制通风的好氧条件下,进行了初始温度分别为25、35、45和55℃,20 d为一个周期好氧堆肥实验,研究了不同初始温度条件下堆肥过程有机物降解、氮的迁移转化及种子发芽指数的变化。结果表明,初始的高温度会抑制堆肥反应的进行,但初始温度越高,水解效果越显著;初始的高温有利于COD的去除,最终COD的去除率分别为88.2%、89.3%、92.0%和89.9%。初始高温对种子发芽率有抑制作用,同时延迟了堆肥的腐熟期。     

猪粪堆肥发酵菌种的分离筛选及特性研究

从多种样品材料中分离筛选出8株能以猪粪为基质生长的菌种,对其中4株菌(8B、8C、8E、2B)进行了初步分类鉴定,并对它们发酵猪粪培养基的特性作了研究.结果表明,这4株菌均属于芽孢杆菌属,其中8C、2B菌种生长最好,8B次之,而8E菌种则不适合作为发酵菌种;对培养基采取完全灭菌对菌种生长繁殖是有利的,间歇灭菌和不灭菌效果相对较差,甚至会对菌种产生不利影响;pH值的变化在一定程度上反映出微生物生长繁殖能力的强弱;较低的pH值不利于微生物菌种生长.     

Impact of phosphate additive on organic carbon component degradation during pig manure composting

Phosphate, as an additive to composting, could significantly reduce ammonia emission and nitrogen loss but may also cause adverse effects on the degradation of organic matter. However, there is little information about the influence of pH change, salt content, and phosphate on different organic fraction degradation during composting with the addition of phosphate at a higher level. In this study, the equimolar phosphoric acid (H₃PO₄), sulfuric acid (H₂SO₄), and dipotassium phosphate (K₂HPO₄) were added into pig manure composting with 0.25 mol mass per kilogram of dry matter basis addition amount to evaluate the effect of H⁺, PO₄^3?, and salinity on carbon component transformation and organic matter degradation. The results showed that both H₃PO₄ and K₂HPO₄ additives could lead to shorter duration in the thermophilic phase, lower degradation of lignocellulose, and lesser carbon loss compared to CK, even though had different pH, i.e., acidic and alkaline conditions, respectively. Besides, the addition of H₃PO₄, H₂SO₄, and K₂HPO₄ could increase the degradation of soluble protein and lipid during composting. Redundancy analysis demonstrated that the variation in different organic carbon fractions was significantly correlated with the changes of pH and the presence of PO₄^3?, but not with SO₄^2? and electrical conductivity, suggesting that pH and phosphate were the more predominant factors than salinity for the inhibition of organic matter degradation. Taken together, as acidic phosphate addition produces a true advantage of controlling nitrogen loss and lower inhibition of organics transformation during composting, the expected effects may result in more efficient composting products.

     

土霉素残留对猪粪堆肥过程中理化性质的影响

为探讨土霉素残留对猪粪堆肥过程的影响,以猪粪和锯末为原料,设置土霉素初始残留质量浓度分别为0、10、50、100、150 mg/kg的5个处理,进行为期30 d的好氧堆肥,研究土霉素对堆肥过程中温度、含水率、水溶性NH4+-N、水溶性NO3- -N、水溶性有机碳(DOC)的变化影响.结果表明:(1)土霉素残留加速了温度的下降,不利于温度的上升.(2)土霉素初始残留质量浓度为100、150 mg/kg不利于堆肥过程中水分的散失,并且会造成堆肥结束后堆体的高含水率.(3)土霉素抑制了堆肥过程中微生物对有机氮的分解及硝化细菌的硝化作用,其中150mg/kg处理的土霉素抑制作用最显著.(4)堆肥结束后,0、10、50、100、150 mg/kg处理的DOC分别为3 815.65、3 461.88、3 429.28、3 231.18、2 782.09mg/kg.0 mg/kg处理的DOC高于其他4个处理,且与150 mg/kg处理之间差异显著,表明土霉素抑制了堆肥过程中微生物对有机碳的利用,其中150 mg/kg处理的土霉素抑制作用最显著.     

猪粪堆肥中铜锌与腐殖质组分的结合竞争

为研究猪粪堆肥中铜锌与腐殖质组分的结合竞争,以猪粪和秸秆为堆腐原料,进行了为期36 d的好氧堆肥实验,研究猪粪堆肥过程中腐殖质组分(胡敏酸和富里酸)、胡敏酸结合态铜锌、富里酸结合态铜锌含量的变化。结果表明,堆肥结束后,腐殖化程度提高,胡敏酸碳含量增加394.4%,富里酸碳含量降低64.9%,腐殖化指数从0.24增加到3.33;随着堆肥的进行,胡敏酸结合态铜锌含量分别增加394.3%和56%,而富里酸结合态铜锌含量分别下降17.5%和28.4%;相关分析表明,胡敏酸结合态铜、富里酸结合态锌与胡敏酸、富里酸碳含量及腐殖化指数均成显著相关(P<0.01);堆肥过程中,胡敏酸结合态铜与富里酸结合态铜之比大于1,而胡敏酸结合态锌与富里酸结合态锌小于1,另外,胡敏酸中的Cu/Zn大于1,而富里酸中的Cu/Zn小于1,表明在腐殖质中铜主要与胡敏酸结合,而锌主要与富里酸结合。研究揭示了猪粪堆肥中重金属铜锌与不同腐殖质组分的结合竞争关系,为畜禽粪便堆肥土地利用的风险评估和风险控制提供科学依据。     

The emission of volatile compounds during the aerobic and the combined anaerobic/aerobic composting of biowaste

Two different biowaste composting techniques were compared with regard to their overall emission of volatile compounds during the active composting period. In the aerobic composting process, the biowaste was aerated during a 12-week period, while the combined anaerobic/aerobic composting process consisted of a sequence of a 3-week anaerobic digestion (phase I) and a 2-week aeration period (phase II). While the emission of volatiles during phase I of the combined anaerobic/aerobic composting process was measured in a full-scale composting plant, the aerobic stages of both composting techniques were performed in pilot-scale composting bins. Similar groups of volatile compounds were analysed in the biogas and the aerobic composting waste gases, being alcohols, carbonyl compounds, terpenes, esters, sulphur compounds and ethers. Predominance of alcohols (38% wt/wt of the cumulative emission) was observed in the exhaust air of the aerobic composting process, while predominance of terpenes (87%) and ammonia (93%) was observed in phases I and II of the combined anaerobic/aerobic composting process, respectively. In the aerobic composting process, 2-propanol, ethanol, acetone, limonene and ethyl acetate made up about 82% of the total volatile organic compounds (VOC)-emission. Next to this, the gas analysis during the aerobic composting process revealed a strong difference in emission profile as a function of time between different groups of volatiles. The total emission of VOC, NH₃ and H₂S during the aerobic composting process was 742 g ton^-1 biowaste, while the total emission during phases I and II of the combined anaerobic/aerobic composting process was 236 and 44 g ton^-1 biowaste, respectively. Taking into consideration the 99% removal efficiency of volatiles upon combustion of the biogas of phase I in the electricity generator, the combined anaerobic/aerobic composting process can be considered as an attractive alternative for aerobic biowaste composting because of its 17 times lower overall emission of the volatiles mentioned.     

Effects of different ratios of pig manure to fungus residue on physicochemical parameters during composting

This study examined physicochemical parameters to assess their effectiveness as stability and maturity indicators during the process of composting pig manure and fungus residue at different ratios. The results showed that composting mixtures with all ratios of pig manure to fungus residue maintained a temperature exceeding 50 °C for more than 10 days during composting and met the requirement for pathogen destruction. The treatment containing mainly pig manure showed higher nitrogen loss and a shorter thermophilic phase and maturity time than the treatment containing mainly fungus residue. The germination index (GI) values indicated that compost maturity was achieved in the final compost with initial ratios of pig manure to fungus residue of 9:1–7:3 (GIs of 101.4%, 91.2%, and 81.3%); the ratio of 6:4 did not reach compost maturity (GI of 63.8%) and had an inhibitory effect on seed germination. The results of this study suggest that a ratio of pig manure to fungus residue of approximately 8:2 can be considered suitable for the efficient and quality composting of pig manure and fungus residue.

Implications: Co-composting of pig manure and edible fungi residue with appropriate proportion can effectively reduce the risk of environmental pollution caused by agricultural wastes, as well as achieve a safer and high-quality organic fertilizer, which can be used to improve physical and chemical properties of the soil, increase crop yields, and promote agricultural sustainable development. Therefore, technique of co-composting of pig manure and edible fungi residue has a wide prospect of application in practical production all over the world.     

接种微生物与人粪便同步连续投加对好氧堆肥效果的影响简

利用新型梨形筒式好氧堆肥反应器,在通风量为3.0 L/min,搅拌频率为5 min/h的条件下,就不接种微生物、接种土著菌种、枯草芽孢杆菌与酵母菌时人粪便连续投加好氧堆肥效果进行了对比。堆制20 d即2个运行周期中各堆体的温度、含水率、COD、总氮、pH值与GI等的变化表明,接种微生物可以显著提高堆体的升温速率与堆体平均温度、COD降解率、GI（P<0.01）,堆肥可迅速达到完全腐熟。接种土著菌种效果最为明显（P<0.01）,其后相继为枯草芽孢杆菌与酵母菌。接种土著菌种可使堆体温度在50℃以上维持18 d,第8天COD降解率达到61.17%、总氮损失率为25.75%,第6天时GI达到108.22%。     

接种微生物与人粪便同步连续投加对好氧堆肥效果的影响

利用新型梨形筒式好氧堆肥反应器,在通风量为3．0L／min,搅拌频率为5min／h的条件下,就不接种微生物、接种土著菌种、枯草芽孢杆菌与酵母菌时人粪便连续投加好氧堆肥效果进行了对比。堆制20d即2个运行周期中各堆体的温度、含水率、COD、总氮、pH值与GI等的变化表明,接种微生物可以显著提高堆体的升温速率与堆体平均温度、COD降解率、Ct（P〈0．01）,堆肥可迅速达到完全腐熟。接种土著菌种效果最为明显（P〈0．01）,其后相继为枯草芽孢杆菌与酵母菌。接种土著菌种可使堆体温度在50℃以上维持18d,第8天COD降解率达到61．17％、总氮损失率为25．75％,第6天时GI达到108．22％。     

Dynamics of copper and tetracyclines during composting of water hyacinth biomass amended with peat or pig manure

Composting is one of the post-treatment methods for phytoremediation plants. Due to a high potential of water hyacinth to accumulate pollutants, the physicochemical parameters, microbial activity as well as fates of copper (Cu) and tetracyclines (TCs) were investigated for the different amended water hyacinth biomass harvested from intensive livestock and poultry wastewater, including unamended water hyacinth (W), water hyacinth amended with peat (WP), and water hyacinth amended with pig manure (WPM) during the composting process. Pig manure application accelerated the composting process as evidenced by an increase of temperature, electrical conductivity (EC), NH₄-N, as well as functional diversity of microbial communities compared to W and WP treatments. Composting process was slowed down by high Cu, but not by TCs. The addition of peat significantly increased the residual fraction of Cu, while pig manure addition increased available Cu concentration in the final compost. Cu could be effectively transformed into low available (oxidizable) and residual fractions after fermentation. In contrast, less than 0.5% of initial concentrations of TCs were determined at the end of 60-day composting for all treatments in the final composts. The dissipation of TCs was accelerated by the high Cu concentration during composting. Therefore, composting is an effective method for the post-treatment and resource utilization of phytoremediation plants containing Cu and/or TCs.     

Urban carbon emission intensity under emission trading system in a developing economy: evidence from 273 Chinese cities

Environmental Science and Pollution Research - The international community has generally recognized the key role of developing countries’ cities in reducing carbon emissions, an elemental way...     

Thermal and spectroscopic analysis of organic matter degradation and humification during composting of pig slurry in different scenarios

Environmental Science and Pollution Research - In this work, different analytical techniques (thermal analysis, 13C cross-polarization magic angle spinning (CPMAS) NMR and Fourier transform...     

添加小麦秸秆对猪粪高温堆肥腐熟进程的影响

选用猪粪与小麦秸秆为堆肥原料进行高温好氧堆肥实验,研究添加小麦秸秆对猪粪高温好氧堆肥过程中堆体温度、pH值、种子发芽指数、碳氮比和养分等理化指标的影响,寻求猪粪高温堆肥时的最佳秸秆配比,旨在为猪粪快速资源化利用提供科学依据。结果表明,猪粪高温堆肥时添加小麦秸秆可以缩短进入高温发酵阶段的时间,减少氮素损失,加快C/N的降低速率,加速有毒有害物质分解。其中猪粪和小麦秸秆6∶4处理各层温度在2~5 d内上升至50℃,并持续37~46 d,在堆肥结束时,有机质和速效氮含量较堆肥初期下降幅度最小,分别为33.90%和23.76%,全氮、全磷、全钾、速效磷和速效钾含量较堆肥初期提高幅度最大,分别为13.34%、20.24%、53.19%、41.53%和16.57%。若以种子发芽指数80%作为堆肥腐熟的评价指标,猪粪和小麦秸秆6∶4配比堆肥的腐熟速度比纯猪粪快18 d,36 d即可腐熟。综合判断,实际应用中,猪粪与小麦秸秆按体积6∶4进行堆肥较为适宜。     

添加不同量的腐殖酸对猪粪堆肥中主要养分变化的影响

腐殖酸是一种可以控制堆肥氮素损失的天然固定剂,通过研究腐殖酸对猪粪堆肥过程中主要养分含量变化的影响,确定了腐殖酸的最佳加入量.结果表明,加入5%含量(占鲜猪粪重)的腐殖酸最有利于发酵反应的进行,能够促进有机质的分解,有效控制氮素损失,可使速效钾含量增加,但对有效磷的转化能力影响不大;与其他处理相比,加入5%含量的腐殖酸...     

Effects of bacterial inoculum and moisture adjustment on composting of pig manure

Spent litter (a mixture of partially composted pig manure and sawdust) was taken from pig pens employing the pig-on-litter system with and without the addition of a commercial bacterial product (Odor control (OC)-organic fertilizers (OF)). A duplicate series of windrows was set up with spent litter which contained the bacterial product and a further duplicate series was set up with spent litter which did not contain the bacterial product. All four sets had their initial moisture content adjusted to 60% but one of each duplicate pair had its moisture content adjusted to 60% during the entire period of further composting in windrows. The rate of further (windrow) composting was significantly different in the litter which contained no bacterial product and which only had its moisture content adjusted at the beginning of the experiment. Decomposition was incomplete in this set even after day 91. In the three other sets, the rate of decomposition was faster and the spent litter became stabilised by day 56. This result suggests that if the bacterial product has been added during the initial pig-on-litter composting process, moisture adjustment during further (windrow) composting is not important. Conversely, if moisture was adjusted during further composting, the addition of bacterial product during initial pig-on-litter composting would be of no value. Such a finding is of remarkable significance in the further composting of spent litter since this indicates that the process could be run on a much more economical basis.     

一种新型可控堆肥反应器系统的快速好氧堆肥实验

研究自制可控堆肥反应器对城市污泥进行快速好氧堆肥的工艺效能。实验结果表明:新型堆肥反应器的可控性强。当初始入料堆体温度控制在40℃左右,含水率控制在50%左右时,堆体温度能在第3天就升至55℃以上,并维持5 d以上。含水率、pH、电导率、种子发芽指数(G I)和可挥发性固体(VS)等指标均具有良好的变化规律,均可作为堆肥腐熟度的表征和评价参数。反应器13 d即可完成一个堆肥周期,且堆肥产品的腐熟程度极高。     

Microbial activity during composting of anthracene-contaminated soil

Microbial activity of an anthracene-spiked soil mixed with kitchen waste during laboratory composting at 56-59 degrees C was studied using an in-vessel technology. The effect of old compost containing acclimated microorganisms on the composting efficiency was also investigated. Microbial succession, microbial enzyme activity, microbial diversity and anthracene removal rate were analyzed during 42 days of composting. The results demonstrated that inoculating with old compost increased the amounts of thermophilic microorganisms, but did not significantly increase anthracene removal. A microbial succession from mesophilic bacteria to thermophilic bacteria and thermophilic actinomycetes was observed during composting. Polyphenol oxidase activity decreased while catalase activity varied irregularly. Microbial diversity increased drastically when temperature elevated from 35 to 56 degrees C, but decreased when temperature maintained at 56-59 degrees C.     

Estimates of synthetic fertilizer N-induced direct nitrous oxide emission from Chinese croplands during 1980-2000

There is increasing concern that agricultural intensification in China has greatly increased N₂O emissions due to rapidly increased fertilizer use. By linking a spatial database of precipitation, synthetic fertilizer N input, cropping rotation and area via GIS, a precipitation-rectified emission factor of N₂O for upland croplands and water regime-specific emission factors for irrigated rice paddies were adopted to estimate annual synthetic fertilizer N-induced direct N₂O emissions (FIE-N₂O) from Chinese croplands during 1980-2000. Annual FIE-N₂O was estimated to be 115.7 Gg N₂O-N year⁻¹ in the 1980s and 210.5 Gg N₂O-N year⁻¹ in the 1990s, with an annual increasing rate of 9.14 Gg N₂O-N year⁻¹ over the period 1980-2000. Upland croplands contributed most to the national total of FIE-N₂O, accounting for 79% in 1980 and 92% in 2000. Approximately 65% of the FIE-N₂O emitted in eastern and southern central China.