Enhancement of batch waste activated sludge digestion by microwave pretreatment.

Batch anaerobic digesters were used to stabilize microwave (MW)-irradiated waste activated sludge (WAS). A low temperature range (50-96 degrees C) MW irradiation was applied. Effects of pretreatment temperature (T) and intensity (I), concentration (C) and percentage of sludge pretreated (PT) were investigated in a multilevel factorial statistical design containing 54 mesophilic batch reactors by monitoring cumulative biogas production (CBP). Variance analysis (ANOVA) determined that the most important factors affecting WAS solubilization were temperature, intensity, and sludge concentration. Improvements in CBP from WAS were significantly affected by sludge percentage pretreated, temperature, and concentration. Pretreatment resulted in 3.6 +/- 0.6 and 3.2 +/- 0.1 fold increases in soluble to total chemical oxygen demand (SCOD/TCOD) at high and low sludge concentrations, respectively. WAS, microwaved to 96 degrees C, produced the greatest improvement in CBP with 15 +/- 0.5 and 20 +/- 0.3% increases over controls after 19 d of digestion at low and high WAS concentrations. Dewaterability of microwaved sludge was enhanced after anaerobic digestion.     

Comparison of mechanical pretreatment methods for the enhancement of anaerobic digestion of pulp and paper waste activated sludge

The conventional anaerobic digestion process, requiring long solids retention times (SRTs) to digest solids, is currently viewed as impractical for the pulp and paper industry because of high capital costs associated with the construction of new digesters. Recent developments in sludge solubilization technology could be promising in reducing digester size, which also allows for the potential use of decommissioned tanks, both of which can reduce the capital cost. Three pretreatment technologies for use with anaerobic digestion were tested on laboratory-scale to investigate their feasibility. The SRTs in all three digesters systematically decreased from 20 to 3 days. The reference digester was fed waste activated sludge (WAS) to serve as the control at the same SRTs. The other digesters were fed WAS that had been preconditioned using mechanical shearing, sonication, or high-pressure homogenization technology. Anaerobic digestion with high-pressure homogenization produced as much methane at 3-day mean SRT as that from the reference digester operated at 20-day SRT. Therefore, a new digester can theoretically be 85% smaller than a conventional digester. An added benefit of WAS to methane conversion is the recovery of nutrients nitrogen and phosphorus.     

Simultaneous nitrification and denitrification of municipal wastewater in aerobic membrane bioreactors.

Simultaneous nitrification-denitrification (SND) of municipal wastewater was investigated in a laboratory-scale membrane bioreactor (MBR) operated at two different hydraulic retention times (HRTs), 0.5 and 1 day, dissolved oxygen 3.0 to 0.5 mg/L, and solids retention time (SRT) between 28 and 120 days. The organic loading rate (OLR) (0.11 to 0.64 kg chemical oxygen demand [COD]/m3/d) and influent soluble COD (SCOD)/ total Kjeldahl nitrogen (TKN) ratio (5 to 19) were varied by the addition of glucose. The ammonia-nitrogen and TKN removals were over 97%, and total nitrogen removal was approximately 89% in the MBR. The maximum specific nitrification rates (98 mg N/d/g VSS) and specific denitrification rates (81 mg N/d/g VSS) occurred at an SCOD/TKN ratio of 9.1. The optimum conditions for maximum total nitrogen removal by SND in a single reactor MBR have been found to be low dissolved oxygen (< 0.6 mg/L) and high OLR (approximately 0.64 kg COD/m3/d) at an HRT of 0.5 day and SRT of approximately 85 days.     

Performance and stability of two-stage anaerobic digestion.

The stability, capacity, and solids destruction efficiency of single versus two-stage anaerobic digestion was studied in bench-scale reactors using combined waste activated and primary sludge. Laboratory staged mesophilic digesters showed an improved volatile solids and volatile suspended solids destruction efficiency over a single-stage system (at the same total solids retention time [SRT]) of approximately 3.2 and 5.8 percentage points, respectively. To quantify stability and capacity, a new digester monitoring method was introduced that measured the digester maximum acetate utilization capacity, V(max,ac), and was used to investigate the potential for digester instability at different transient loadings. The ratio of the V(max,ac) value to the estimated acetate production rate for a given digester loading was termed the acetate capacity number (ACN). Values greater than 1.0 indicate excess acetate utilization capacity. The first stage of the laboratory two-stage mesophilic system (10-day SRT for each stage) had an ACN number of 1.3 compared with a value of 1.8 for the single-stage 20-day SRT digester. Thus, while a staged mesophilic system can improve solids destruction efficiency, it demonstrates a lower capacity for metabolizing highly variable loads.     

High-solids anaerobic digestion of municipal sludge pretreated by thermal hydrolysis

High-solids anaerobic digestion can consistently achieve 55 to 60% volatile solids destruction after thermal hydrolysis pretreatment, which reduces its viscosity and increases the fraction of soluble organic matter. For feed sludge with total solids concentrations between 6.8 and 8.2%, the process is stable at hydraulic retention times of 9 to 12 days, significantly increasing the treatment capacity of existing digesters or, in treatment plants without spare capacity, helping to postpone, reduce, or even avoid costly infrastructure investments. Process stability is related to the high concentration of soluble organic matter in the digesters. High-solids temperature-phased digestion appears to be superior to high-solids mesophilic digestion, with respect to process flexibility and stability, biosolids stabilization, and biogas generation, although ammonia inhibition may have occurred. Implementation of high-solids digestion could significantly reduce operation and maintenance costs of solids-handling operations.     

低强度超声波预处理对厨余垃圾厌氧消化的影响

以厨余垃圾为研究对象,实验研究产气效率、pH、SCOD、甲烷浓度及生物降解率5个参数的变化趋势,比较低强度超声波处理对厨余垃圾厌氧消化产气特性的影响,结果表明:(1)低强度超声波处理对厨余垃圾厌氧消化产生明显效果,在不同的超声波强度(100、175和250 W)或处理时间(20和40 min)下,产气效率、累计产气量、pH下降幅度、SCOD增加幅度随处理时间和超声功率增加而增加;在超声波强度250 W和处理时间60 min下出现抑制作用;(2)在超声波强度250 W和处理时间40 min条件下,超声波对厨余垃圾厌氧消化增强效果最明显,累计产气量由未处理的3 513 mL提高至5 007 mL,提高42.6%,甲烷气体浓度由51.25%提高至58.8%,生物降解率由58.11%提高至73.5%.     

Degradation of 2,4-dichlorophenol by combining photo-assisted Fenton reaction and biological treatment.

The photo-Fenton reaction effect on the biodegradability improvement of 100 mg/L solution of 2,4-dichlorophenol (DCP) has been investigated. Biochemical oxygen demand (BOD) at 5 and 21 days, BODn/ chemical oxygen demand (COD) and BODn/total organic carbon (TOC) ratios, average oxidation state, and inhibition on activated sludge were monitored. For 50 mg/L hydrogen peroxide and 10 mg/L iron(II) initial concentrations and 40 minutes of reaction time in the photo-Fenton process, the biodegradability of the pretreated solution, measured as BOD5/COD ratio, was improved from 0 for the original DCP solution up to 0.18 (BOD21/COD = 0.24). At that point, all DCP was eliminated from the solution. To study the effect of the pretreatment step, the biological oxidation of pretreated solutions was tested in two semicontinuous stirred tank reactors, one operated with activated sludge and one with biomass acclimated to phenol. Results showed that more than 80% TOC removal could be obtained by codigestion of the pretreated solution with municipal wastewater. Total organic carbon removals of approximately 60% were also obtained when the sole carbon source for the aerobic reactors was the pretreated solution. The hydraulic retention times used in the bioreactors were of the same order of magnitude as those used at domestic wastewater treatment plants (i.e., between 12 and 24 hours). Kinetic studies based on pseudo-first-order kinetics have also been carried out. Constants were found to be in range 0.67 to 1.7 L x g total volatiles suspended solids(-1) x h(-1).     

Effect of a starch-rich industrial wastewater on the acid-phase anaerobic digestion process.

This research investigated the effect of varying the starch-rich, industrial-wastewater component of mixtures with municipal wastewater fed to an anaerobic digester. A laboratory-scale, completely-mixed anaerobic digester was operated at an HRT of 30 h, an SRT of 10 d, and an ambient temperature of 21.5 +/- 1.5 degrees C. The industrial-to-municipal ratios tested were 1:3, 1:1, 3:1, and 100% industrial by volume. Steady-state, acidogenic conditions were achieved for all runs, except 100% industrial. The pH was observed to drop substantially as the industrial constituent of the feed increased. Net volatile fatty acids (VFA) production reached a plateau of approximately 800 mg/L at ratios of 1:1 and higher, while volatile suspended solids (VSS) reduction steadily increased as the industrial component rose. The specific VFA and soluble chemical oxygen demand (SCOD) production rates leveled off at approximately 0.070 mgVFA/ mgVSS.d and 0.124 mgSCOD/mgVSS.d, respectively, for all the mixtures investigated, except for 100% industrial. In this latter case, both rates dropped dramatically. Finally, acetic and propionic acid concentrations fell as the industrial proportion of the mixture increased. This was compensated by a rise in butyric acid production.     

Microalgae growth using high-strength wastewater followed by anaerobic co-digestion

Integration of algal biofuel production to wastewater anaerobic digestion infrastructure has the potential to increase biogas production, decrease high and variable internal nitrogen loads, and improve sludge digestibility and dewaterability. In this research, two species of microalgae, Spirulina platensis and Chlorella sp., were grown on sludge centrate and a centrate and nitrified wastewater effluent mixture. Harvested algae were co-digested with waste activated sludge (WAS) at varying ratios. High-growth (6.8 g m(-2) x d(-1)), nitrogen (36.5 g m(-3) x d(-1)), and phosphorus (6.5 g m(-3) x d(-1)) uptake rates were achieved with Chlorella on centrate. No growth was observed with S. platensis under the same conditions; however, both organisms grew well on the centrate and effluent mixture. Co-digestion of algae with WAS improved volatile solids reduction. Although co-digestion with S. platensis improved biosolids dewaterability, Chlorella had a slight negative effect on dewaterability compared to WAS alone. The efficiency of energy conversion from photons to biogas generated from Chlorella was estimated at 1.4%.     

Simultaneous nitrification-denitrification and clarification in a pseudoliquified activated sludge system.

This paper describes results from a pilot study of a novel wastewater treatment technology, which incorporates nutrient removal and solids separation to a single step. The pseudoliquified activated sludge process pilot system was tested on grit removal effluent at flowrates of 29.4 to 54.7 m3/d, three different solid residence times (SRT) (15, 37, and 57 days), and over a temperature range of 12 to 28 degrees C. Despite wide fluctuations in the influent characteristics, the system performed reliably and consistently with respect to organics and total suspended solids (TSS) removals, achieving biochemical oxygen demand (BOD) and TSS reductions of > 96% and approximately 90%, respectively, with BOD5 and TSS concentrations as low as 3 mg/L. Although the system achieved average effluent ammonia concentrations of 2.7 to 3.2 mg/L, nitrification efficiency appeared to be hampered at low temperatures (< 15 degrees C). The system achieved tertiary effluent quality with denitrification efficiencies of 90 and 91% total nitrogen removal efficiency at a total hydraulic retention time of 4.8 hours and an SRT of 12 to 17 days. With ferric chloride addition, effluent phosphorous concentrations of 0.5 to 0.8 mg/L were achieved. Furthermore, because of operation at high biomass concentrations and relatively long biological SRTs, sludge yields were over 50% below typical values for activated sludge plants. The process was modeled using activated sludge model No. 2, as a two-stage system comprised an aerobic activated sludge system followed by an anoxic system. Model predictions for soluble BOD, ammonia, nitrates, and orthophosphates agreed well with experimental data.     

Combined anaerobic/aerobic digestion: effect of aerobic retention time on nitrogen and solids removal

A combined anaerobic/aerobic sludge digestion system was studied to determine the effect of aerobic solids retention time (SRT) on its solids and nitrogen removal efficiencies. After the anaerobic digester reached steady state, effluent from the anaerobic digester was fed to aerobic digesters that were operated at 2- to 5-day SRTs. The anaerobic system was fed with a mixture of primary and secondary sludge from a local municipal wastewater treatment plant. Both systems were fed once per a day. The aerobic reactor was continuously aerated with ambient air, maintaining dissolved oxygen level at 1.1 +/- 0.3 mg/L. At a 4-day or longer SRT, more than 11% additional volatile solids and 90% or greater ammonia were removed in the aerobic digester, while 32.8 mg-N/L or more nitrite/nitrate also was measured. Most total Kjeldahl nitrogen removal was via ammonia removal, while little organic nitrogen was removed in the aerobic digester.     

污泥加热预处理对中温厌氧消化的影响

对污泥加热预处理给中温厌氧混合消化和污泥单独消化带来的影响进行了研究.研究结果表明,污泥加热预处理有利于提高混合消化对 COD 的去除率,尤其是 SCOD 的去除率由 77%增长到 93%,但不利于 TS 和 VS 的去除;而对污泥单独消化,预处理则不利于有机物的去除.采用加热预处理后的污泥进样,混合消化和污泥单独消化的甲烷产气量均有所提高.     

Influence of temperature and time on phosphorus removal in swine manure during batch aeration

This study was conducted to investigate the effects of temperature and time on the mechanisms of phosphorus removal in swine manure during aeration. Removal of soluble orthophosphates significantly increased with aeration time and temperature. Successive significant ortho-P removals were observed between days one and nine but no significant additional removals were recorded thereafter. Removals were significantly higher at temperatures of 20 and 25 degrees C than at temperatures of 5, 10, and 15 degrees C and ranged between 22.9 to 31.0%. Insoluble inorganic phosphorus also changed significantly with aeration time and temperature and with a similar trend as soluble orthophosphates. The pH of the manure explained 92 and 87% of the content of insoluble inorganic phosphorus at lower temperatures (5, 10, 15 degrees C) and at higher temperatures (20, and 25 degrees C), respectively. Organic phosphorus and aerobes growth patterns were similar to that of soluble orthophosphates removal. The rapid growth of aerobes was most probably the principal factor behind a rapid soluble ortho-P removal above 15 degrees C. The contribution of inorganic phosphates to the removal of soluble orthophosphates was approximately 61% while that due to organic P was approximately 35%. Precipitation was found to be the principal mechanism governing removal of soluble ortho-P in swine manure during aeration treatments.     

Performance evaluation of a 'sequential-batch' temperature-phased anaerobic digestion (TPAD) scheme for producing Class A biosolids.

Laboratory studies were conducted to evaluate the performance and operational stability of a Temperature-Phased Anaerobic Digestion (TPAD) system modified to operate in the sequential-batch mode. The system fed with a 40:60 mixture (dry weight) of primary sludge (PS) and waste activated sludge (WAS) at 5.5% solids showed stable performance with minimum variation in operational parameters such as biogas production, VFA to alkalinity ratio, pH, and foam accumulation at system retention times as short as 12 days. The maximum volatile solids removal (VSR) of 52.5% was achieved at a system retention time of 16 days. The system did not show any effects of "shock loading" at the retention times studied and outperformed a "conventional" mesophilic system operated at a longer retention time. The system was effective in reducing the densities of pathogenic indicator organisms in the biosolids to levels lower than those specified by U.S. EPA for Class A designation.     

Microwave enhanced advanced oxidation process for treating dairy manure at low pH

This study investigated the treatment of dairy manure using the microwave enhanced advanced oxidation process (MW-AOP) at pH 2. An experimental design was developed based on a statistical program using response surface methodology to explore the effects of temperature, hydrogen peroxide dosage and heating time on sugar production, nutrient release and solids destruction. Temperature, hydrogen peroxide dosage and acid concentration were key factors affecting reducing sugar production. The highest reducing sugar yield of 7.4% was obtained at 160°C, 0 mL, 15 min heating time, and no H(2)O(2) addition. Temperature was a dominant factor for an increase of soluble chemical oxygen demand (SCOD) in the treated dairy manure. The important factors for volatile fatty acids (VFA) production were microwave temperature and hydrogen peroxide dosage. Temperature was the most important parameter, and heating time, to a lesser extent affecting orthophosphate release. Heating time, hydrogen peroxide dosage and temperature were significant factors for ammonia release. There was a maximum of 96% and 196% increase in orthophosphate and ammonia concentration, respectively at 160°C, 0.5 mL H(2)O(2) and 15 min heating time. The MW-AOP is an effective method in dairy manure treatment for sugar production, nutrient solubilisation, and solids disintegration.     

Laboratory-scale comparison of anaerobic-digestion alternatives.

Laboratory-scale digesters were used to perform side-by-side evaluations of alternative digestion systems including thermophilic-mesophilic-phased digestion (TPAD), acid/methane-phased digestion, mesophilic digestion, and the performance of the thermophilic stage of TPAD alone. Total detention times in the systems evaluated varied from 8 to 20 days. Temperatures in the mesophilic stage of TPAD were varied from 35 to 43.3 degrees C and temperatures in the thermophilic stage were varied from 55 to 58.9 degrees C. The purpose of the study was to evaluate volatile solids (VS) reduction and thickening properties of the different systems. Parameters evaluated included solids, volatile acids, gas production and quality, various chemical constituents of the sludge, and thickening properties using polymer and ferric chloride plus polymer. The TPAD systems were found capable of higher VS destruction at total detention times of 10 and 12.5 days compared to single-stage mesophilic or thermophilic digestion at 15 to 20 days. A laboratory-scale thickening test was performed to evaluate thickening properties. Based on obtaining 95% capture in the test, the polymer demand of mesophilic and acid-methane-phased digestion was the lowest. The TPAD system required approximately 180% of the dosage of the mesophilic sludge and thermophilic sludge required approximately 310% of the dosage. Temperatures of 40.5 and 43.3 degrees C in the mesophilic stage of TPAD were found to increase the polymer requirement and decrease the VS reduction of the TPAD system. Higher temperatures (above 56.1 degrees C) and lower detention times (less than 15 days) in the thermophilic digesters seemed to result in problems with degradation of volatile acids, particularly propionic acid.     

Anaerobic digestion of raw and thermally hydrolyzed wastewater solids under various operational conditions

In this study, high-solids anaerobic digestion of thermally pretreated wastewater solids (THD) was compared with conventional mesophilic anaerobic digestion (MAD). Operational conditions, such as pretreatment temperature (150 to 170 degrees C), solids retention time (15 to 20 days), and digestion temperature (37 to 42 degrees C), were varied for the seven THD systems operated. Volatile solids reduction (VSR) by THD ranged from 56 to 62%, compared with approximately 50% for MAD. Higher VSR contributed to 24 to 59% increased biogas production (m3/kg VSR-d) from THD relative to MAD. The high-solids conditions of the THD feed resulted in high total ammonia-nitrogen (proportional to solids loading) and total alkalinity concentrations in excess of 14 g/L as calcium carbonate (CaCO3). Increased pH in THD reactors caused 5 to 8 times more un-ionized ammonia to be present than in MAD, and this likely led to inhibition of aceticlastic methanogens, resulting in accumulation of residual volatile fatty acids between 2 and 6 g/L as acetic acid. The THD produced biosolids cake that possessed low organic sulfur-based biosolids odor and dewatered to between 33 and 39% total solids. Dual conditioning with cationic polymer and ferric chloride was shown to be an effective strategy for mitigating dissolved organic nitrogen and UV-quenching compounds in the return stream following centrifugal dewatering of THD biosolids.     

The digestibility of waste activated sludges.

Laboratory digestion studies using waste activated sludges (WAS) were conducted to compare the digestion performance between anaerobic and aerobic processes. Nine samples of WAS from seven wastewater treatment plants were collected and batch-digested under both anaerobic and aerobic conditions for 30 days at 25 degrees C. The cation content of wastewater (both floc and solution phases) and solution biopolymer (protein and polysaccharide) was measured before and after digestion and compared with volatile solids destruction data. The study revealed that each digestion process was associated with a distinct biopolymer fraction, which accounted for differences in volatile solids reduction under anaerobic and aerobic conditions. The anaerobic digestion data showed strong correlations between soluble protein generation, ammonium production, percent volatile solids reduction, and floc iron (Fe). These data suggest that the amount of volatile solids destroyed by anaerobic digestion depends on the Fe content of floc. In aerobic digestion, polysaccharide accumulated in solution along with calcium and magnesium. For aerobic digestion, correlations between divalent cation release and the production of inorganic nitrogen were found. This implies that divalent cation-bound biopolymer, thought to be lectin-like protein, was the primary organic fraction degraded under aerobic conditions. The results of the study show that the cation content in wastewater is an important indicator of the material that will digest under anaerobic or aerobic conditions and that some of the volatile solids will digest only under either anaerobic or aerobic conditions.     

Toward a high-rate enhanced biological phosphorus removal process in a membrane-assisted bioreactor.

A membrane enhanced biological phosphorus removal (MEBPR) process was studied to determine the impact of hydraulic retention time (HRT) and solids retention time (SRT) on the removal of chemical oxygen demand (COD), nitrogen, and phosphorus from municipal wastewater. The MEBPR process was capable of delivering complete nitrification independent of the prevailing operating conditions, whereas a significant improvement in COD removal efficiency was observed at longer SRTs. In the absence of carbon-limiting conditions, the MEBPR process was able to achieve low phosphorus concentrations in the effluent at increasingly higher hydraulic loads, with the lowest HRT being 5 hours. The MEBPR process was also able to maintain optimal phosphorus removal when the SRT was increased from 12 to 20 days. However, at higher suspended solids concentrations, a substantial increase was observed in carbon utilization per unit mass of phosphorus removed from the influent. These results offer critical insights to the application of membrane technology for biological nutrient removal systems.     

Effects of anaerobic selector hydraulic retention time on biological foam control and enhanced biological phosphorus removal in a pure-oxygen activated sludge system.

Increased anaerobic selector hydraulic retention times (HRTs) in a high-purity oxygen activated sludge process resulted in an increase in soluble orthophosphate release and biodegradable chemical oxygen demand removal, confirming that enhanced biological phosphorus removal occurs at aeration solids retention times (SRTs) below 1.7 days. Under operating conditions that included biological foam trapping and recycling, an anaerobic selector with HRTs higher than 55 minutes resulted in a decrease in filament counts and effective foam control. Effective norcardioform control is achieved through the combination of metabolic selective pressure and increased soluble organic substrate removal in the anaerobic selector and low aeration SRT.