动力工业废物处理与综合利用

X773.01 200402385 氨水洗涤脱除CO2温室气体的机理研究/刁永发…(清华大学热能工程系,煤的清洁燃烧国家重点实验室)∥环境科学学报/中科院生态环境研究中心.-2003,23(6).-753-757 环图X-9 利用氨水洗涤电厂模拟烟气中的CO2温室气体,在合适的操作条件下,可以实现很高的CO2脱除率(达到95%以上);当入口CO2体积分数分别为10%、12%、14%,氨水吸收CO2的脱除率超过90%时,进口CO2体积分数对氨水吸收CO2脱除率的影响不大;随着氨水浓度的增加,氨水吸收CO2 的吸收速率和达到平衡状态时CO2的脱除率都要增大;氨水洗涤CO2温室气体的动力学研究表明: 在实验所涉及的温度区间内,其化学反应符合Ar- rhenius规律。图7表1参6     

填料塔中DBU溶液对CO2脱除率的实验研究

温室效应日益受到各国政府和科学家的关注,如何实现CO2捕集成为温室气体减排的关键.本文通过搭建吸收CO2的填料塔,研究1,8-二氮杂双环[5,4,0]十一碳-7-烯(DBU)溶液浓度、DBU溶液流量、气体流量、液气比、入口CO2浓度、气体温度和填料层高度对CO2脱除率的影响.结果发现CO2脱除率随DBU溶液浓度、DBU溶液流量和液气比的增大而增大;随气体流量和入口CO2浓度的增加而下降;气体温度在30~40℃时,CO2脱除率达到最高;填料层高度对CO2脱除率也有一定影响,随着填料层高度的增加,CO2脱除率只有小幅增大,因此实际应用中要综合考虑脱除率和经济性,选择合适的填料高度.     

温度对喷氨同时脱碳脱硫率影响的试验研究

利用氨气加水蒸汽喷射方法脱除燃煤锅炉模拟烟气中的CO2和SO2气体,烟气中CO2和SO2气体的体积分数分别为12％和0．25％．设定水蒸气温度50℃恒定,以确保反应器中水蒸汽的含湿量较低,其化学反应温度在25℃～95℃之间变化,同时喷入氨气与水蒸气的混合气体,其脱碳脱硫率随反应时间的变化表明：反应温度为55℃～60℃时,CO2和SO2的最大脱除率分别达到70％和95％．对化学反应产物进行FTIR试验,表明其反应产物主要是碳酸铵盐和硫酸铵盐的混合物．配合BET解吸试验,结果表明：在低含湿量条件下,采用喷氨方法,脱除电厂烟气中的CO2和SO2气体过程中,CO2气体除了被氨吸收发生化学反应,生成(NH4)2SO4和NH4HCO3晶体外,还被吸附在(NH4)2SO4和NH4HCO3晶体的空隙里．     

DBU醇溶液对CO_2吸收量的影响研究

本文考察了CO2体积分数、温度、气体流量、吸收液喷雾量、DBU体积分数等因素对CO2吸收量的影响.研究结果表明:各因素对CO2吸收量的影响大小顺序为CO2体积分数温度气体流量吸收液喷雾量DBU体积分数,DBU醇溶液喷雾吸收CO2的最佳条件是CO2体积分数15%、温度30℃、气体流量2.7 L·min-1、吸收液喷雾量30 m L·min-1、DBU体积分数5%,此时CO2吸收量为1.095 mol·mol-1.     

负载量对氨水吸收CO2的影响规律及添加剂的作用研究

进行了氨法脱碳过程中吸收剂中CO2负载量对CO2脱除率影响的实验研究.结果发现,CO2脱除率随着负载量的增大而显著减小,高负载量(≥0.4)时,增加吸收液中总氨质量分数(吸收液中所有包含氨分子和铵离子的物质,并统一换算成NH3的质量分数)并不能有效地提高CO2的脱除率.同时,分别对有机和无机添加剂进行筛选,选取哌嗪(PZ)和十二水磷酸钠(Na3PO4·12H2O)对吸收剂中高CO2负载鼍条件下的氨水溶液进行改性.实验结果表明,当哌嗪(PZ)浓度与总氨浓度之比为0.08,在吸收荆中CO2负载量为0.4、0.5和0.6的条件下,CO2脱除率可分别提高29.4%、31.0%和21.7%;当Na3PO4·12H2O浓度与总氨浓度之比为0.10,在吸收剂中CO2负载量为0.4、0.5和0.6的条件下,CO2脱除率可分别提高11.0%、11.7%和17.1%.     

O2/CO2气氛下氮反应机理的研究

选取CH4、O2、CO2、Ar、NO、NH3，等气体，作为混合气和煤粉一起送入一维沉降炉内，以模拟O2／CO2气氛下煤中燃料氮、循环NO以及二者的相互作用对NO排放的影响，结果显示，在还原性气氛下NH3、HCN、CH4、CO与循环NO间的反应是NO排放下降的主要因素，且煤焦与NO的异相反应、吸附反应对NO的降解效果要明显高于氧化性气氛，同时，CO2体积分数的增加使得燃料中氮的氧化率升高，循环NO的降解率下降；氧化性气氛下随CO2体积分数的增加，燃料中氮的氧化率也增加，但循环NO的降解率升高．当CO2体积分数不变时，其对NO降解的作用随循环NO体积分数的增加愈加明显，在循环NO也不变且CO2体积分数较低时，随过量空气系数的增加，循环NO的降解率下降，而CO2体积分数较高时则出现相反情况。     

负载量对氨水吸收CO2的影响规律及添加剂的作用研究

进行了氨法脱碳过程中吸收剂中CO2负载量对CO2脱除率影响的实验研究.结果发现,CO2脱除率随着负载量的增大而显著减小,高负载量(≥0.4)时,增加吸收液中总氨质量分数(吸收液中所有包含氨分子和铵离子的物质,并统一换算成NH3的质量分数)并不能有效地提高CO2的脱除率.同时,分别对有机和无机添加剂进行筛选,选取哌嗪(P...     

氨水捕集秸秆气化燃气中CO_2的实验研究

为了从源头上减少二氧化碳排放,提高秸秆气化燃气热值,以氨水作为吸收剂,对捕集秸秆气化燃气中的二氧化碳进行了初步的实验研究,探讨了秸秆气化燃气热值与二氧化碳体积分数变化的关系。结果显示:在一定范围内,氨水浓度高、氨水流量大、秸秆气化燃气流量小对氨水吸收二氧化碳的反应更有利;在小型实验系统中,氨水浓度为9%,氨水流量为50 L/h,燃气流量为7.7 m3/h时,二氧化碳脱除率可达92.90%;当燃气中二氧化碳体积分数下降,单位体积燃气热值则增加,热值增加的百分比与二氧化碳体积分数减少量之比在1.06~1.10。     

喷雾塔中氨水吸收CO2的速率

为考察氨水细喷雾吸收CO2的能力,对喷雾塔中氨水细喷雾吸收CO2的反应过程进行了实验研究,测定了氨水吸收CO2的速率.实验结果表明,CO2的吸收速率随着氨水浓度、气体流量的升高而明显增大,随氨水流量升高也有所增加,CO2的吸收速率随CO2进口浓度的升高呈线性增加.当喷雾塔中温度低于40℃时,CO2的吸收速率随着塔内温度...     

烟气流量及二氧化碳分压对氨法减排效率的影响

减少二氧化碳的排放,进一步使其资源化,是中国乃至世界能源生产所需要解决的重大问题。氨法吸收燃煤烟气中的二氧化碳是目前国际上的一个重要研究方向,具有良好的应用前景。为考察燃煤烟气流量以及二氧化碳分压对氨法吸收燃煤烟气中二氧化碳效率的影响,文章在实验室模拟烟气采用氨法吸收烟气中CO2,选用R=50%碳化氨水作为CO2吸收剂,选择填料塔做反应器,考察了烟气流量以及CO2分压对CO2脱除率的影响。研究发现,烟气流量越小,塔内气、液反应时间越长,CO2脱除率越高。在不同烟气流量的条件下,吸收液碳化度均超过130%。混合烟气流量为1 L/min,CO2分压为0.046 MPa时,脱除率最高,反应出液碳化度最大,结晶效果最好。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.