应用在线传感器实现前置反硝化工艺生物脱氮的过程控制

为了实现前置反硝化工艺硝化反硝化反应的过程控制,系统地研究了硝化反硝化过程中DO、pH和ORP的变化规律,并考察了它们作为硝化反硝化过程控制参数的可行性.结果表明,pH值在缺氧区的变化分为下降型和上升型,从而指示系统反硝化反应进行的程度以及内循环回流量是否充足;缺氧区末端ORP值和硝酸氮浓度具有较好的相关性;好氧区第1格室的DO浓度可以指示进水氨氮负荷高低;pH值在好氧区的变化也可分为下降型和上升型,可指示系统硝化反应进行的程度、曝气量和碱度是否充足;好氧区末端ORP值与出水氨氮、硝酸氮浓度具有很好的相关性.在此基础上建立了硝化反硝化反应在线控制系统,从而实现曝气量、内循环回流量和外碳源投加量的在线控制,提高系统出水水质、降低运行费用.图7表1参8     

Advanced nitrogen removal by pulsed sequencing batch reactors (SBR) with real-time control

The feasibility of pH and oxidation reduction potential (ORP) as on-line control parameters to advance nitrogen removal in pulsed sequencing batch reactors (SBR) was evaluated. The pulsed SBR, a novel operational mode of SBR, was utilized to treat real municipal wastewater accompanied with adding ethanol as external carbon source. It was observed that the bending-point (apex and knee) of pH and ORP profiles can be used to control denitrification process at a low influent C/N ratio while dpH/dt can be used to control the nitrification and denitrification process at a high influent C/N ratio. The experimental results demonstrated that the effluent total nitrogen can be reduced to lower than 2 mg/L, and the average total nitrogen (TN) removal efficiency was higher than 98% by using real-time controll strategy.     

供氧方式对SBR法硝化过程控制的影响

采用SBR法对不同供氧方式下硝化过程的控制进行研究，结果表明：在曝气量恒定的条件下，DO和PH值可联合作为硝化时间的控制参数，但ORP无法单独作为控制参数，在DO恒定的情况下，DO无法作为控制参数；PH值在硝化过程中缓慢下降或趋于稳定，当硝化反应结束时突然升高，因此，PH值可作为硝化时间较好的控制参数；ORP的硝化初期快速升高，然后升高的速度愈来愈慢，直至趋于平稳，对硝化结束的指示作用不是很明显，无法单独作为控制参数；为维持硝化过程中DO的恒定，曝气量将逐渐减小，只要系统污泥浓度和所要控制的DO水平相同，任何浓度的原水在硝化结束时调节的最小曝气量都是相同的，因此，将曝气量下限值的控制方法与PH值控制相结合，可使SBR硝化时间的控制更稳定可靠。     

Advanced nitrogen removal using pilot-scale SBR with intelligent control system built on three layer network

Since eutrophication has become increasingly severe in China, nitrogen and phosphorous have been the concern of wastewater treatment, especially nitrogen removal. The stabilization of the intelligent control system and nitrogen removal efficiency were investigated in a pilot-scale aerobic-anoxic sequencing batch reactor (SBR) with a treatment capacity of 60 m³/d. Characteristic points on the profiles of dissolved oxygen (DO), pH, and oxidation reduction potential (ORP) could exactly reflect the process of nitrification and denitrification. Using the intelligent control system not only could save energy, but also could achieve advanced nitrogen removal. Applying the control strategy water quality of the effluent could stably meet the national first discharge standard during experiment of 10 months. Even at low temperature (t = 13°C), chemical oxygen demand (COD) and total nitrogen (TN) in the effluent were under 50 and 5 mg/L, respectively.     

Simultaneous denitrifying phosphorus accumulation in a sequencing batch reactor

In order to achieve simultaneous nitrogen and phosphorus removal in the biological treatment process, denitrifying phosphorus accumulation (DNPA) and its affecting factors were studied in a sequencing batch reactor (SBR) with synthetic wastewater. The results showed that when acetate was used as the sole carbon resource in the influent, the sludge acclimatized under anaerobic/aerobic operation had good phosphorus removal ability. Denitrifying phosphorus accumulation was observed soon when fed with nitrate instead of aeration following the anaerobic stage, which is a vital premise to DNPA. If DNPA sludge is fed with nitrate prior to the anaerobic stage, the DNPA would weaken or even disappear. At the high concentration of nitrate fed in the anoxic stage, the longer anoxic time needed, the better the DNPA was. Induced DNPA did not disappear even though an aerobic stage followed the anoxic stage, but the shorter the aerobic stage lasted, the higher the proportions of phosphorus removal via DNPA to total removal.     

不同进水有机物浓度下移动床生物膜反应器(SBMBBR)脱氮除磷特性

考察了不同进水有机物浓度下厌氧/好氧序批式移动床生物膜反应器（SBMBBR）污染物去除特性,实验结果表明,SBMBBR能够实现低碳源污水中氮和磷的同步去除,在进水TN和TP浓度分别为116.7 mg.L-1和11.5 mg.L-1、COD浓度为456 mg.L-1的条件下,TN和TP去除率分别达到94.3%和92.2%以上.反应器除磷是基于常规生物除磷和反硝化除磷过程实现的,脱氮主要是基于好氧段发生的同时硝化反硝化（SND）作用而完成.由于生物膜内部存在的DO扩散梯度,在好氧阶段混合液DO浓度不断提高的条件下反应器内具有良好SND反应的发生.进水COD浓度由149 mg.L-1提高至456 mg.L-1的过程中,反应器硝化效果不变,反硝化和除磷效果改善.反应器在好氧阶段pH值基本维持在7.0—7.1之间,为各类菌群的生长创造了条件.碱度变化较pH值更能反映硝化和反硝化反应发生的程度.反应器中微生物相丰富,生物膜以丝状菌为骨架,其上附着大量的球状菌和杆状菌,而悬浮活性污泥中丝状菌较少,形成了由细菌、真菌到原生动物和后生动物的复杂的生态体系,为系统取得稳定的污水处理效果提供了有效的保证.     

实时控制技术在污水生物处理中的研究进展

针对目前污水处理厂采用固定时间控制策略所暴露出的问题，从污水生物处理反应机理上分析了溶解氮（DO），氧化还原电位（ORP）和pH值作为污水生物处理实时控制参数的可行性，得出污水处理过程中反应器内DO，ORP和pH的变化可以间接反应有机物降解和脱氮除磷过程，因此，在理论上可以应用DO，ORP和pH作为实时控制参数控制污水处理过程，综述了当前国内外应用DO，ORP和pH作为实时控制参数控制污水处理过程的研究进展，并分析了目前我国在此研究方向存在的问题，指出进一步加强对污水处理实时控制技术应用基础研究的必要性和紧迫性，并使其与智能控制技术相结合，最终实现污水处理自动化，参27     

SBR短程硝化的实现、维持及稳定性

以模拟生活污水为研究对象,控制SBR反应器内pH值在7.5～8.5的条件下,实现了短程硝化生物脱氮工艺,NO2--N/NOx--N的比率始终维持在90%以上,同时发现pH值和DO浓度变化特征曲线在短程硝化过程中具有良好的重现性。另外,保持DO浓度在0.5～1.0mg/L,硝化时间为5.5h,可较好的维持短程硝化生物脱氮过程,且经过1个月的运行硝化类型没有发生改变,亚硝酸盐积累率仍保持在90%以上。在此基础上,研究了系统对COD和NH4+-N浓度的抗冲击负荷能力。结果表明,该系统具有较强的抗冲击能力。     

曝气复氧对富营养化水体底泥氮磷释放的影响

采用实验室模拟，研究了曝气复氧对富营养化水体底泥氮磷释放的影响，结果表明，①溶解氧是影响底泥氮磷释放的重要因素，厌氧状态会加速底泥氮磷的释放。②正常条件下曝气复氧可以有效的控制底泥总磷的释放；曝气条件下高pH值无法控制底泥总磷的释放，搅动会对底泥总磷的释放产生轻微的影响，上覆水总磷浓度较高时底泥会发生吸磷现象，而温度则影响较小。③正常条件下曝气复氧可以控制比较封闭水体底泥氨氮的释放；曝气条件下温度对底泥氨氮和总氮的释放影响较大，即温度越高，抑制氨氮和总氮的释放效果越好，且低温会导致底泥氨氮和总氮的大量释放；曝气条件下搅动导致底泥释放更多的氨氮和总氮。     

厌氧除磷同步脱氮及影响因素研究

采用鸡粪污泥为种泥,在厌氧混合连续流反应装置内进行厌氧还原磷产生磷化氧功能菌的富集,进行硝酸盐、硫酸盐、不同碳源和氮源条件下厌氧除磷效率的研究,并考察磷化氧的生成与硝酸、总磷、氨氮去除的关系.结果表明,(1)SO_4~(2-)-S适宜的投加量为26 mg·L~(-1),不投加NO_3~--N.水中含有氧化态的无机物在厌氧条件下与磷争夺[H]导致厌氧除磷的效率下降.(2)合适的碳源为葡萄糖1 000 mg·L~(-1),纤维素不适合作为碳源,合适的氮源为蛋白胨500 mg·L~(-1),水中含有的还原糖和有机氮源促进磷化氧的生成.(3)pH值控制在6.5～7.0的范围,最适宜的生长温度在35℃左右.(4)氨氮的去除率随着总磷的去除率而增加,在厌氧条件下可达到同时脱氮除磷的效果.磷的去除由厌氧除磷菌还原磷生成磷化氧完成,氨氮由生成氮气或生成蛋白质来去除.     

Characteristics of pollutants behavior in a stormwater constructed wetland during dry days

A stormwater wetland treating non-point source pollution (NPS) from a 64 ha agricultural watershed was monitored over a period of five months. The results indicated that pH and dissolved oxygen (DO) were increased in the wetland due to the algal growth. The highest total suspended solids (TSS) concentration was observed in the aeration pond due to the resuspension of solids, decreased in the wetland. The respective decreases in total nitrogen (TN) and total kjeldahl nitrogen (TKN) were 15.9% and 28.7% on passing through the wetland. The nitrate and ammonia were increased by 45.4% and decreased by 79.9%, respectively. These variations provided strong evidence for the existence of nitrification. The total phosphorus (TP) and phosphate had respective reductions of 52.3% and 58.2% over the wetland. The total chemical oxygen demand (TCOD) and soluble chemical oxygen demand (SCOD) were also decreased. Generally, the TN, TP and phosphate removal efficiencies were positive. These positive removal efficiencies were mainly due to microbial activities, uptake by plants, and chemical precipitation at high pH. Negative removal efficiencies can be caused by continuous rainfall activities, with short antecedent dry days (ADDs) and unstable hydraulic conditions, some other biogeochemical transformations and algal growth also being important parameters.     

Enhanced nutrients removal from municipal wastewater through biological phosphorus removal followed by partial nitritation/anammox

Conventional biological removal of nitrogen and phosphorus is usually limited due to the lack of biodegradable carbon source, therefore, new methods are needed. In this study, a new alternative consisting of enhanced biological phosphorus removal (EBPR) followed by partial nitritationanammox (PN/A), is proposed to enhance nutrients removal from municipal wastewater. Research was carried out in a laboratory-scale system of combined two sequencing batch reactors (SBRs). In SBR1, phosphorus removal was achieved under an alternating anaerobic-aerobic condition and ammonium concentration stayed the same since nitrifiers were washed out from the reactor under short sludge retention time of 2–3 d. The remaining ammonium was further treated in SBR2 where PN/A was established by inoculation. A maximum of nitrogen removal rate of 0.12 kg N?m^–3?d^–1 was finally achieved. During the stable period, effluent concentrations of total phosphorus and total nitrogen were 0.25 and 10.8 mg?L^–1, respectively. This study suggests EBPR-PN/A process is feasible to enhance nutrients removal from municipal wastewater of low influent carbon source.

Open image in new window

     

Research on polyhydroxyalkanoates and glycogen transformations: Key aspects to biologic nitrogen and phosphorus removal in low dissolved oxygen systems

In this paper, a study was conducted on the effect of polyhydroxyalkanoates (PHA) and glycogen transformations on biologic nitrogen and phosphorus removal in low dissolved oxygen (DO) systems. Two laboratory-scale sequencing batch reactors (SBR1 and SBR2) were operating with anaerobic/aerobic (low DO, 0.15–0.45 mg·L^-1) configurations, which cultured a propionic to acetic acid ratio (molar carbon ratio) of 1.0 and 2.0, respectively. Fewer poly-3-hydroxybutyrate (PHB), total PHA, and glycogen transformations were observed with the increase of propionic/acetic acid, along with more poly-3-hydroxyvalerate (PHV) and poly-3-hydroxy-2-methyvalerate (PH2MV) shifts. The total nitrogen (TN) removal efficiency was 68% and 82% in SBR1 and SBR2, respectively. In the two SBRs, the soluble ortho-phosphate (SOP) removal efficiency was 94% and 99%, and the average sludge polyphosphate (poly-P) content (g·g-MLVSS^-1) was 8.3% and 10.2%, respectively. Thus, the propionic to acetic acid ratio of the influent greatly influenced the PHA form and quantity, glycogen transformation, and poly-P contained in activated sludge and further determined TN and SOP removal efficiency. Moreover, significant correlations between the SOP removal rate and the (PHV+ PH2MV)/PHA ratio were observed (R²>0.99). Accordingly, PHA and glycogen transformations should be taken into account as key components for optimizing anaerobic/aerobic (low DO) biologic nitrogen and phosphorus removal systems.     

人工湿地脱氮途径及其影响因素分析

简述了人工湿地脱氮模型。各种形态的氮在人工湿地系统中可以通过氨的挥发、植物吸收、介质沉淀吸附以及微生物硝化/反硝化作用等过程被去除。讨论了各脱氮途径对人工湿地脱氮的贡献,在大多数人工湿地的pH条件下,湿地地面氨挥发可以忽略,湿地植物叶片氨挥发量尚不清楚。湿地介质的直接吸附是短期的。植物在湿地脱氮过程中起了重要作用,但一般认为植物直接吸收和存储只占湿地脱氮的一小部分,一般低于30%。微生物的硝化/反硝化作用,是人工湿地脱氮的最主要的形式。讨论了影响人工湿地硝化作用的主要因素:溶解氧,pH和温度。大多数人工湿地的pH适合硝化作用,溶解氧和温度对湿地硝化作用的影响最大。温度不仅影响微生物的硝化作用,而且可以间接地影响植物的生长从而影响人工湿地的脱氮性能。     

Sludge fermentation liquid addition attained advanced nitrogen removal in low C/N ratio municipal wastewater through short-cut nitrification-denitrification and partial anammox

• Sludge fermentation liquid addition resulted in a high NAR of 97.4%. • Extra NH₄⁺-N from SFL was removed by anammox in anoxic phase. • Nitrogen removal efficiency of 92.51% was achieved in municipal wastewater. • The novel system could efficiently treat low COD/N municipal wastewater. Biological nitrogen removal of wastewater with low COD/N ratio could be enhanced by the addition of wasted sludge fermentation liquid (SFL), but the performance is usually limited by the introducing ammonium. In this study, the process of using SFL was successfully improved by involving anammox process. Real municipal wastewater with a low C/N ratio of 2.8–3.4 was treated in a sequencing batch reactor (SBR). The SBR was operated under anaerobic-aerobic-anoxic (AOA) mode and excess SFL was added into the anoxic phase. Stable short-cut nitrification was achieved after 46d and then anammox sludge was inoculated. In the stable period, effluent total inorganic nitrogen (TIN) was less than 4.3 mg/L with removal efficiency of 92.3%. Further analysis suggests that anammox bacteria, mainly affiliated with Candidatus_Kuenenia, successfully reduced the external ammonia from the SFL and contributed approximately 28%–43% to TIN removal. Overall, this study suggests anammox could be combined with SFL addition, resulting in a stable enhanced nitrogen biological removal.     

生物脱氮处理过程中氮素转化规律的研究

以肉类加工废水为研究对象,采用ABR-改进型SBR组合工艺分析其脱氮处理过程中的氮素转化规律,确定ABR最佳水力停留时间为6-8h,氨氮增长速率在90%-196%及SBR最佳运行工况.     

固定化藻膜去除水中氮磷的模拟研究

针对富营养化水体生物修复和污水深度处理氮磷的去除,将细颤藻、水绵、水网藻、栅裂藻固定在纤维填料上,形成固定化藻膜。用固定化藻膜处理模拟富营养化湖水、实际富营养化湖水、城市污水二级出水、低质量浓度生活污水,考察固定化藻膜去除氮磷的效果。实验结果表明,固定化藻膜具有良好的去除磷、氨氮能力,对水中有机物去除也有一定的促进作用。对TP质量浓度小于5.0mg·L-1,NH4 -N质量浓度小于34.0mg·L-1的污染水体,四种藻膜都有良好的去除氮磷能力,其中栅裂藻去除TP、NH4 -N的能力最强。综合除污能力和藻细胞的可固定性,水绵应是最佳的备选藻种。研究结果显示,固定化藻膜具有良好的除污性能,预示了悬浮载体将在水体生物修复、氧化塘污水处理方面具有重要的潜在应用价值。     

Biological removal of selenate in saline wastewater by activated sludge under alternating anoxic/oxic conditions

Removal of selenate in saline wastewater by activated sludge was examined. Sequencing batch reactor was operated under alternating anoxic/oxic conditions. Above 97% removal of soluble selenium (Se) was achieved continuously. Major Se removal mechanism varied depending on the length of aeration period. Various Se-reducing bacteria likely contributed to coordinately to Se removal. Selenium (Se)-containing industrial wastewater is often coupled with notable salinity. However, limited studies have examined biological treatment of Se-containing wastewater under high salinity conditions. In this study, a sequencing batch reactor (SBR) inoculated with activated sludge was applied to treat selenate in synthetic saline wastewater (3% w/v NaCl) supplemented with lactate as the carbon source. Start-up of the SBR was performed with addition of 1–5 mM of selenate under oxygen-limiting conditions, which succeeded in removing more than 99% of the soluble Se. Then, the treatment of 1 mM Se with cycle duration of 3 days was carried out under alternating anoxic/oxic conditions by adding aeration period after oxygen-limiting period. Although the SBR maintained soluble Se removal of above 97%, considerable amount of solid Se remained in the effluent as suspended solids and total Se removal fluctuated between about 40 and 80%. Surprisingly, the mass balance calculation found a considerable decrease of Se accumulated in the SBR when the aeration period was prolonged to 7 h, indicating very efficient Se biovolatilization. Furthermore, microbial community analysis suggested that various Se-reducing bacteria coordinately contributed to the removal of Se in the SBR and main contributors varied depending on the operational conditions. This study will offer implications for practical biological treatment of selenium in saline wastewater.     

N2O emission from a sequencing batch reactor for biological N and P removal from wastewater

Nitrous oxide （N2O） is a greenhouse gas that can be released during biological nitrogen removal from wastewater. N2O emission from a sequencing batch reactor （SBR） for biological nitrogen and phosphorus removal from wastewater was investigated, and the aims were to examine which process, nitrification or denitrification, would contribute more to N2Oemission and to study the effects of heterotrophic activities on N2O emission during nitrification. The results showed that N2O emission was mainly attributed to nitrification rather than to denitrification. N2O emission during denitrification mainly occurred with stored organic carbon as the electron donor. During nitrification, NaO emission was increased with increasing initial ammonium or nitrite concentrations. The ratio of N2O emission to the removed ammonium nitrogen （N2O- N/NH4-N） was 2.5% in the SBR system with high heterotrophic activities, while this ratio was in the range from 0.14% to 1.06% in batch nitrification experiments with limited heterotrophic activities.     

Control of sludge settleability and nitrogen removal under low dissolved oxygen condition

Low dissolved oxygen (DO) is an energy-saving condition in activated sludge process. To investigate the possible application of limited filamentous bulking (LFB) in sequencing batch reactor (SBR), two lab-scale SBRs were used to treat synthetic domestic wastewater and real municipal wastewater, respectively. The results showed that prolonging low DO aeration duration and setting pre-anoxic (anaerobic) phase were effective strategies to induce and inhibit filamentous sludge bulking, respectively. According to the sludge settleability, LFB could be maintained steadily by adjusting operation patterns. Filamentous bacteria content and sludge volume index (SVI) were likely correlated. SVI fluctuated dramatically within a few cycles when around 200 mL·g^-1, where altering operation pattern could change sludge settleability in spite of the unstable status of activated sludge system. Energy consumption by aeration reduced under low DO LFB condition, whereas the nitrification performance deteriorated. However, short-cut nitrification and simultaneous nitrification denitrification (SND) were prone to take place under such conditions. When the cycle time kept constant, the anoxic (anaerobic) to aerobic time ratio was determining factor to the SND efficiency. Similarity keeping aerobic time as constant, the variation trends of SND efficiency and specific SND rate were uniform. SBR is a promising reactor to apply the LFB process in practice.