微生物淋滤法去除城市污泥中重金属的效果

以广州市城市污泥作为培养介质,利用以硫代硫酸钠作为生长基质进行生命活动的氧化亚铁硫杆菌(T.f]和氧化硫硫杆菌(T.t)来淋滤去除污泥中的重金属,研究了不同底物含量及不同驯化污泥接菌量对重金属去除效果的影响.结果表明,在无驯化污泥接种的条件下,最佳基质投配率为10 g·L-1;驯化污泥接种培养可以缩短污泥的酸化周期,并且在相同投配比条件下,接种培养较不接种培养的去除效果明显提高.驯化污泥接种量为10%、投配比为7 g·L-1时,污泥中主要超标元素Cu、Zn、Cd和Ni的去除率分别达到67.2%,88.9%,82.4%,和68.4%.同时,处理后污泥中的重金属含量可满足污泥农用的国家标准.     

阴极pH控制对电动去除电镀污泥重金属的影响

采用电动修复装置,选用电镀污泥作为试验材料,试验设计了3个不同pH值的阴极缓冲液处理,施加直流电压32 V,运行7 d,研究了不同pH值阴极缓冲液对电镀污泥电动修复过程的影响.结果表明,阴极缓冲液pH值的变化,影响了电动过程中电流大小,pH较低时,电流较大;pH较高时,电流较小.电动修复后,各处理电镀污泥重金属的电动修复效果不同,其中,pH值控制为3时,Ni、Cu、Zn和Cr的去除率分别达到70%、59%、30%和29%,而Pb的去除率在pH值控制为5时去除率达46%.各处理截面重金属浓度较实验前都有不同程度的降低,其中Cu、Pb和Ni在不同污泥截面分布较均匀,而Cr和Zn在各截面分布波动较大.电动修复对各种形态的重金属都有不同程度的去除,对可交换态和铁锰氧化物态的去除效果较差,对碳酸盐结合态和残渣态有明显去除,有机硫化物态去除效果一般.     

污泥土地利用对土壤中重金属形态的影响

土地利用是资源化利用城市污水厂污泥的有效途径，随污泥中的营养成分一起进入土壤中的还有其中的重金属元素，它们有可能成为一种环境安全的隐患。本实验所用的土壤为污泥经过无害化及稳定化处理后，与上海潮滩沙土按不同比例(干污泥质量比)混配而成。种植前后分别对沙土、污泥及混配土的重金属含量及形态进行测试。选择几种花卉植物，如菊花(Calendula officinalis）等进行植物种植试验，一个生长季后对植物中的重金属含量及形态进行测试。应用Tessler连续提取法，对污泥中的重金属进入土壤后，土壤中重金属的含量、赋存状态等方面的规律进行研究，发现污泥的土地利用会明显增加土壤中的重金属含量，而且重金属的形态也有明显的变化，可交换态和碳酸盐结合态的重金属含量有明显的增加；如长期使用，则必须采取相应的措施，以消除有害的影响。     

AB工艺减少污泥重金属的效果

在AB工艺中,利用A段活性吸附去除重金属从而降低B段污泥中重金属含量,使其达到农用标准（GB4284-84酸性土壤控制标准）。利用小型污水处理实验场,模拟研究了AB工艺A段中重金属的去除情况,对AB运行控制参数进行优化探讨,以使A段能有效去除大部分重金属,并尽可能降低有毒有害污泥产量。结果表明：溶解氧质量浓度控制在0.5mg·L-1,污泥质量浓度调节为约500mg·L-1时,Cu2＋去除率可达87.6%,Zn2＋的去除率为78.7%,Ni2＋去除率为51%。当污泥质量浓度在1000～1500mg·L-1时,A段处理后污泥沉降性能好转,对重金属离子的去除有较好的效果,且不过多截留污水中的有机物。且B段剩余污泥中的Cu2＋、Zn2＋、Ni2＋含量都基本达到酸性土壤污泥农用控制标准。因此,适当控制AB工艺相关参数条件,利用A段活性污泥去除大部分重金属,降低B段产泥中重金属含量,达到农业控制标准是可行的,污泥经处理后进行土地资源化利用可成为我国污泥处置与利用的一种有效途径。     

西安市市政污水厂剩余污泥中重金属形态特征及潜在生态风险评价

采用现场采样及室内分析方法,研究了西安市剩余污泥的基本理化性质,污泥中重金属元素的含量、赋存形态及迁移特征,并对市政污泥土地利用的潜在生态风险进行了评价。结果表明:西安市剩余污泥整体pH呈中性(6.24~8.12),具有高有机质(46.71%~72.41%)、高N(6.18%~6.94%)、高P(1.71%~4.21%)、低K(1.02%~2.03%)的特点,具有很好的土地利用价值;污泥中重金属(除Pb、Mn、Co外)及As整体含量高于《土壤环境质量标准》的二类标准(pH=6.5~7.5),但除Zn、Ni、Hg超过《农用污泥中污染物控制标准》酸性土壤(pH6.5)最高允许含量外,其余重金属及As均低于该标准值;西安市污泥中重金属的形态分布主要由重金属元素的性质决定,污泥中各重金属的迁移或稳定性顺序(F1+F2)为Cu(19.38%)Cr(21.2%)Pb(47.76%)Co(50.22%)Ni(54.63%)Mn(61.53%)Zn(74.21%);修正潜在生态风险评价结果表明,西安市剩余污泥重金属综合污染程度处于重度水平,污泥土地利用时重金属污染的潜在生态风险水平为严重,其中Hg为其首要贡献者,其次是Zn和Ni。     

污泥农用后土壤中重金属形态的转化

污泥农用后,土壤中重金属的形态会发生转化.用土柱模拟实际土壤,采用棕壤和褐土两种土壤类型,分别施人生活污泥和工业污泥.混合后,对土柱进行淋洗,经过7次淋洗后,测定土柱中0～10 cm均匀混合层中重金属各形态的含量,然后再与污泥和土壤混合后重金属形态不发生变化时重金属的总量相比较,得出污泥农用后土壤中重金属形态的转化规律.结果表明:Cu主要向碳酸盐结合态和残渣态转化,Pb向铁锰氧化物结合态转化,Zn向碳酸盐结合态转化.     

可控湿法氧化聚沉工艺对城市污泥中重金属的稳定化影响

采集了长沙市污水厂的剩余污泥（S1）和湿法氧化聚沉工艺处理的深度脱水污泥（S2）,对比分析了处理前后污泥的形貌变化及重金属Zn、Cu、Pb、Cd、Hg和As的形态分布,初步探讨了重金属稳定化机理,对脱水污泥中重金属Zn、Cu、Pb、Cd、Hg和As进行了稳定性评估.结果表明,脱水污泥中重金属的总量均低于我国污泥农用标准中的酸性限值,符合B级污泥泥质要求.处理后,污泥中Zn、Cu、Pb、Cd、Hg和As主要以硫化物有机结合态和残渣态（稳定态）存在,不稳定态在不同程度上向稳定态发生了转变,Cu、Hg的增幅最大,达21.1%.S2中重金属的生物可利用性较S1都有显著的降低,平均降幅达73.1%,S2中重金属的生物可利用性顺序为：Zn〉Pb〉Cu〉Cd〉As〉Hg.污泥经过湿法氧化聚沉工艺处理后,污泥中重金属Zn、Cu、Pb、Cd、Hg和As得到了明显的稳定化,为污泥后续资源化、安全化提供了科学依据.     

植物对污泥的响应及根系对重金属的活化作用

为了研究植物对污泥的改良作用及植物根系对重金属的活化作用,在温室盆栽条件下对生长于污泥中的几种耐性植物遏蓝菜属(Thlaspi goesingense)、羽叶鬼针草(Bidens maximowicziana Oett)、酸模(Rumex acetosa L.)、紫苜蓿(Medicogo sativa L.)和印度芥茉(Indian mustard)的植物干重、体内重金属(Cu、Zn、Pb、Cd)的含量、叶片中叶绿素含量和植物根系对重金属的活化率做了研究。结果表明,生长于污泥中的植物其干重比对照均有不同程度的增加,其中羽叶鬼针草与对照相比差异极显著;不同植物对不同重金属的吸收量亦不同;各种植物叶片中的叶绿素含量变化不同,与对照相比,差异不显著;遏蓝菜对Cu、Zn的活化率最高,印度芥茉对Cd的活化率最高。     

蚯蚓-稻壳炭联合堆肥对工业污泥中重金属的影响研究

蚯蚓堆肥相关研究多集中在生活污泥方面,对工业污泥的探索较少。该研究以马鞍山某钢铁污水处理站污泥为例,添加不同比例稻壳炭(2%、4%、8%),设置污泥单独堆肥、稻壳炭与污泥堆肥以及蚯蚓-稻壳炭联合污泥堆肥试验,探索蚯蚓与稻壳炭联合堆肥对工业污泥中重金属形态和生物有效性的影响。研究表明,(1)相比污泥单独堆肥,稻壳炭联合污泥堆肥能增加污泥pH、EC、TP和降低TOC、TN,而蚯蚓联合稻壳炭堆肥污泥可增加TN,并进一步增加污泥EC、TP,显著降低污泥的pH、TOC。(2)稻壳炭堆肥中重金属Zn、Cu、Pb、Cd含量因浓缩效应而上升;而蚯蚓联合稻壳炭堆肥,重金属含量显著下降,添加4%稻壳炭时,重金属Zn、Cu、Pb、Cd质量分数达到最小值,分别为856.64、137.10、158.92、15.48mg·kg-1。(3)重金属形态分析表明,随着稻壳炭比例增加,稻壳炭堆肥中重金属Zn、Cu、Pb、Cd的交换态和碳酸盐结合态转化为残渣态及铁锰氧化态的比例增大,添加8%稻壳炭时DTPA提取的有效态重金属质量分数最低,分别为705.72、47.95、50.43、4.47 mg·kg-1;蚯蚓-稻壳炭联合堆肥会使得污泥中重金属交换态、碳酸盐结合态、铁锰结合态和有机结合态均向残渣态转化,添加4%稻壳炭与蚯蚓的协同转化能力最大,Zn、Cu、Pb、Cd有效态重金属质量分数分别为629.84、38.63、36.76、1.63mg·kg-1,说明稻壳炭添加入蚯蚓堆肥可进一步降低工业污泥中重金属有效性,使重金属钝化。本研究可为稻壳炭联合蚯蚓堆肥处理工业污泥提供参考和科学依据。     

泉州城市污泥中重金属赋存形态和生物有效性分析

本文以泉州市几种有代表性的污泥为研究对象,通过分析各污泥中重金属总量和形态分布以及污泥中重金属有效态与总量的相关性,探讨重金属生物有效性与总量的关系,为后续的研究提供基础依据;将污泥重金属总量及形态情况与《农用污泥中污染物控制标准》（GB4284—84）进行比较,提出污泥农用可行性的合理建议.     

镉胁迫对吊兰生长与土壤酶活性的影响

选用观赏植物吊兰进行盆栽试验,研究了吊兰对Cd的耐性、高浓度Cd胁迫对土壤酶活性以及土壤有效态Cd含量的影响.结果表明,随着Cd浓度的不断提高,脲酶活性显著下降.过氧化氢酶和蔗糖酶活性在Cd浓度为10 mg.kg-1的时候均达到了顶峰,而土壤磷酸酶活性则在Cd浓度为50 mg.kg-1的时候最大.4种土壤酶对重金属的敏感顺序为:脲酶>磷酸酶>蔗糖酶>过氧化氢酶.吊兰对Cd具有很强的耐性,在1500 mg.kg-1Cd胁迫浓度范围内,吊兰对Cd的耐性指数均大于50%.土壤有效态Cd与土壤Cd添加量和土壤酶活性呈显著相关性,可将土壤有效态Cd含量和土壤酶活性这两类指标作为镉污染土壤的评价指标.     

Eco-friendly approach for leaching out heavy metals from sewage sludge

Sewage sludge contains rich organic matter and nutrients essential for the growth of plants but the presence of toxic heavy metals restricts its land application. To overcome this, the study aims an eco-friendly approach for leaching out heavy metals. Sewage sludge from sewage treatment plant, Chennai, India was characterised. The analysis of total heavy metal concentration was done by digesting in nitric acid and different forms were extracted by community bureau of reference sequential method. Heavy metals: As, Cd, Cr, Cr, Ni, Pb and Zn were determined using inductively coupled plasma optical emission spectrometry Perkin Elmer Optima 5300 DV. The experimental set-up for heavy metal leaching was held for five consecutive days at different concentrations of humic acid (0.1%, 0.5% and 1%) at varied pH (5–9). Results revealed that at the end of fifth day at pH 8, 1% humic acid is capable of leaching out 75.5% cadmium, 66.0% nickel, 52.0% lead, 51.2% zinc, 31.2% copper and 8.5% cadmium from sewage sludge. Statistically positive correlation (0.7088) existed between the percentage of heavy metals leached out and the sum of soluble and reducible fractions. Thus, from ecological point of view, humic acid can be used to leach out heavy metals from sewage sludge serving the need in restoration of soil fertility upon land application.     

纳米零价铁颗粒去除水中重金属的研究进展

重金属是毒性大、难降解、易累积的环境污染物,纳米零价铁作为一种新型功能修复材料在去除水体和土壤中重金属方面有着广阔的应用前景.本文综述了纳米零价铁颗粒去除水中重金属的研究进展,包括纳米零价铁的常用制备方法及特性、去除效能、对不同重金属的去除机理以及发展前景和今后的研究方向,以期为该领域的深入研究提供借鉴并拓展新的思路.     

The correlation of total and extractable heavy metals from soil and domestic sewage sludge and their transfer to maize ( Zea mays L.) plants

A study to understand the mobility and transport of heavy metals (HMs) from soil and soil amended with sewage sludge to maize plants was carried out. The total and ethylenediaminetetraaceticacid (EDTA)-extractable HMs in agricultural soil and untreated domestic sewage sludge samples, and the correlation between the total and extractable metals in soil and sewage sludge were carried out. Pot experiments were performed to study the transfer of HMs to maize grains, grown in soil (control) and in soil amended with sewage sludge (test samples). The total and extractable HMs in soil, sewage sludge, and maize grains were analysed by FAAS/ETAAS (flame atomic absorption spectrometer/electrothermal atomic absorption spectrometer) after digestion in microwave oven. Statistically significant correlations were obtained between the total contents of Cu, Cd, As and their respective extractable fractions in soil, while in domestic wastewater sludge (DWS) the better correlation was observed only for Ni and Cd. The edible part of maize plants (grains) from test samples presented high concentration of Zn, Pb, Ni, Cd, Cu, As, and Cr concentrations (80.7–85.6, 3.8–3.95, 2.35–2.5, 0.75–0.82, 3.21–3.29, 0.23–0.27, and 0.22–0.29?mg?kg^?1, respectively). Good correlations were found between metals in exchangeable fractions of both soil and DWS and total metals in control and test samples of maize grains. The transfer factor of all HMs from DWS to maize grains was also determined.     

Efficient removal of heavy metals from electroplating wastewater using polymer ligands

Poly(hydroxamic acid)-poly(amidoxime) chelating ligands were synthesized from poly(methyl acrylate-co-acrylonitrile) grafted acacia cellulose for removing toxic metal ions from industrial wastewaters. These ligands showed higher adsorption capacity to copper (2.80 mmol?g⁻¹) at pH 6. In addition, sorption capacities to other metal ions such as iron, zinc, chromium, and nickel were also found high at pH 6. The metal ions sorption rate (t_1/2) was very fast. The rate of adsorption of copper, iron, zinc, chromium, nickel, cobalt, cadmium and lead were 4, 5, 7, 5, 5, 8, 9 and 11 min, respectively. Therefore, these ligands have an advantage to the metal ions removal using the column technique. We have successfully investigated the known concentration of metal ions using various parameters, which is essential for designing a fixed bed column with ligands. The wastewater from electroplating plants used in this study, having chromium, zinc, nickel, copper and iron, etc. For chromium wastewater, ICP analysis showed that the Cr removal was 99.8% and other metal ions such as Cu, Ni, Fe, Zn, Cd, Pb, Co and Mn removal were 94.7%, 99.2%, 99.9%, 99.9%, 99.5%, 99.9%, 95.6% and 97.6%, respectively. In case of cyanide wastewater, the metal removal, especially Ni and Zn removal were 96.5 and 95.2% at higher initial concentration. For acid/alkali wastewater, metal ions removing for Cd, Cr and Fe were 99.2%, 99.5% and 99.9%, respectively. Overall, these ligands are useful for metal removal by column method from industrial wastewater especially plating wastewater.     

Preparation and characterisation of green clay-polymer nanocomposite for heavy metals removal

ABSTRACT

Natural polymer Moringa oleifera seed as coagulant and bentonite clay as adsorbent were used for preparing novel composite coagulant. Results obtained from FTIR, SEM, TEM and P-XRD show that the bentonite clay and M. oleifera seed biopolymers physico-chemically interact with each other during the preparation of clay-polymer composite. The FTIR results show that the major functional groups present in bentonite clay and M. oleifera seed are integrated at nano levels in the novel composite to remove heavy metals from aqueous systems. The coagulo-adsorption using clay-polymer composite may be used for the adsorption of heavy metals ions from the aqueous systems. It becomes possible due to the structural characteristics of the clay crystallites together with the functional attraction of the biopolymer and it results in the formation of clay-polymer metal complexes. The clay-polymer nano-composite of M. oleifera seed and bentonite clay showed considerable cadmium, chromium and lead removal property.     

Heavy metals from soil and domestic sewage sludge and their transfer to Sorghum plants

We studied the mobility and transport of heavy metals such as Cu, Zn, As, Cd, Cr, Ni, and Pb, from soil and soil amended with sewage sludge to sorghum plants. The total and ethylenediaminetetraacetic acid (EDTA) extractable heavy metals in agricultural soil and untreated domestic sewage sludge (DWS) samples were determined. The correlation between the total and extractable metals in soil and sewage sludge was investigated. The total and extractable heavy metals in soil, sewage sludge and sorghum grain were analysed by flame and electro thermal atomic absorption spectrometer (FAAS/ETAAS), after digestion in microwave oven. Statistically good correlations were obtained between the total contents of all heavy metals and their respective extractable fractions in soil and domestic wastewater sludge. Transfer factors of all heavy metals from domestic sewage sludge to sorghum grains were determined.