Q235钢在海洋铁细菌作用下的腐蚀行为研究

采用开路电位、电化学极化曲线、电化学阻抗谱(EIS)等方法研究了海洋铁细菌作用下Q235钢的腐蚀行为与腐蚀机理。扫描电子显微镜(SEM)形貌分析结果表明有大量的杆状铁细菌附在Q235钢铁表面。在海洋微生物的影响下,Q235钢的开路电位变小,腐蚀倾向与腐蚀率变大。EIS结果表明在海洋铁细菌作用下Q235钢的交流阻抗模值减少,而且大大降低了Q235钢的极化电阻和表面膜的电阻。微生物的附着促进了钢材表面的溶解,使其表面氧化膜层消失,进而形成了疏松不致密的生物膜层,从而加速了其腐蚀进程。     

黑色金属材料在长江淡水中的腐蚀行为

通过现场暴露试验,获得了2种碳钢、3种不锈钢及1种不锈钢与碳钢复合板材料在武汉长江淡水中的4年腐蚀试验结果,总结了它们的腐蚀行为。结果表明,Q235和16Mn碳钢在武汉长江中有较高的腐蚀率和明显的点蚀,稳定腐蚀率为0．055mm／a;暴露4a,奥氏体不锈钢304和316L没有明显腐蚀,而马氏体不锈钢430有较明显的点蚀和缝隙腐蚀;马氏体不锈钢0Crl3Ni5Mo与Q345c复合钢板在长江淡水中使用4a后,OCrl3Ni5Mo发生严重的点蚀,说明马氏体不锈钢在淡水中的应用应慎重。     

黑色金属材料在长江淡水中的腐蚀行为

通过现场暴露试验,获得了2种碳钢、3种不锈钢及1种不锈钢与碳钢复合板材料在武汉长江淡水中的4年腐蚀试验结果,总结了它们的腐蚀行为。结果表明,Q235和16Mn碳钢在武汉长江中有较高的腐蚀率和明显的点蚀,稳定腐蚀率为0.055 mm/a;暴露4 a,奥氏体不锈钢304和316L没有明显腐蚀,而马氏体不锈钢430有较明显的点蚀和缝隙腐蚀;马氏体不锈钢0Cr13Ni5Mo与Q345C复合钢板在长江淡水中使用4 a后,0Cr13Ni5Mo发生严重的点蚀,说明马氏体不锈钢在淡水中的应用应慎重。     

两种不锈钢在冷却塔冷凝酸液中的耐蚀性能

目的分析304不锈钢和316L不锈钢在电厂冷却塔内海水及烟气形成的模拟冷凝酸液环境中的耐蚀性能。方法利用浸泡试验和电化学试验方法测试两种不锈钢在模拟冷凝酸液中的腐蚀形貌、腐蚀率和极化曲线。结果 304不锈钢在模拟冷凝酸液中的耐蚀性能较差,其腐蚀率及钝态稳定性受冷凝酸液pH值的影响较大;316L不锈钢在模拟冷凝酸液中的耐蚀性能较好,其腐蚀率及钝态稳定性受冷凝酸液pH值的影响较小。结论 316L不锈钢在冷却塔冷凝酸液中的耐蚀性能明显优于304不锈钢。     

海水中阴极极化对X80钢应力腐蚀及氢脆敏感性的影响

目的研究不同p H值海水中阴极极化对X80管线钢应力腐蚀及氢脆的抑制作用。方法采用慢应变速率拉伸试验、电化学测试、微观组织观察等分析方法。结果 X80钢在天然海水中的析氢电位约为-940m V(vs.SCE,下同),海水p H为3.5时析氢电位发生正移。其应力腐蚀敏感性与极化电位有很大关系,随着极化电位负移,X80钢的氢脆敏感性增加。天然海水中当极化电位负于-950 m V时,断口出现准解理断裂特征形貌。在-1050 m V极化电位下,钢材进入氢脆断裂区发生脆性断裂。海水p H为3.5时,-900 m V钢材有发生氢脆的危险。结论与天然海水相比,X80钢在p H为3.5的酸性海水中具有较高的应力腐蚀敏感性,两种海水介质中X80钢的应力腐蚀敏感性均随极化电位负移而增加。     

钢铁材料在黄河三门峡水库中的腐蚀行为

目的获取典型钢铁材料在黄河三门峡水库中长期暴露的腐蚀结果和腐蚀行为。方法采用暴露腐蚀试验,将1种碳钢、3种低合金钢和3种不锈钢材料在三门峡水库中暴露1,2,5,8 a,用金相显微镜测量各材料的点蚀深度,观察腐蚀形貌,并计算其腐蚀速率。结果在三门峡水库中暴露8 a,碳钢和低合金钢的腐蚀行为基本相同,4种钢暴露1 a的平均腐蚀速度接近,为0.047~0.050 mm/a,暴露1~8 a,Q235B的平均腐蚀速度为0.040 mm/a,X70,X80和D36钢的平均腐蚀速度与Q235B相差不大,分别为0.039,0.034,0.037 mm/a。暴露1 a后,0Cr13表面有蚀点,最大点蚀深度为0.010 mm,暴露8 a后,0Cr13试样的边角、钻孔处出现溃烂、穿孔。暴露8 a后,304和316L的最大点蚀深度均小于0.1 mm。结论 Q235B,X70,X80,D36在黄河三门峡水库中的腐蚀行为基本相同,它们在第1年的腐蚀速度较大,暴露1 a后腐蚀速度略有降低。0Cr13腐蚀严重,暴露8 a,发生腐蚀溃烂、穿孔现象。304和316L在三门峡水库中有很好的耐蚀性。     

45#钢和Q235在不同水环境中的腐蚀行为研究

目的研究碳钢在不同水环境条件下的腐蚀行为。方法通过开展45#钢及Q235两种典型的碳钢材料在淡海水交替、海水及淡水自然环境下2年的暴露试验,将三种环境下材料的腐蚀形貌、腐蚀速率进行对比,总结3种材料在不同水环境下的腐蚀规律,对其腐蚀机理进行了简要的探讨,并对其长周期的腐蚀行为进行预测。结果对45#钢来说,淡海水环境对其的影响是海水环境下的92%,淡水环境的影响是海水环境下的46%;对Q235来说,淡海水环境对其的影响是海水环境下的88%,淡水环境的影响是海水环境的53%。结论碳钢在海水环境下耐蚀性最差,在淡海水交替自然环境下次之,在淡水环境下的耐蚀性能最好。     

几种合金涂层在变电站土壤中的腐蚀行为研究

目的研究Al,Al Si,Ni Al,316L不锈钢四种合金涂层在变电站土壤及其溶液中的腐蚀行为。方法采用高速电弧喷涂方法在Q235钢表面上分别制备纯Al,Al Si,Ni Al,316L不锈钢合金涂层,通过对四种涂层钢在湖南220 k V毛家塘变电站中进行埋样和土壤溶液里的电化学实验,研究四种涂层在变电站土壤及其溶液中的耐蚀性能,并利用扫描电子显微镜(SEM)和X射线电子能谱(EDS)对埋样的腐蚀产物进行观察和分析。结果 Al Si涂层具有最好的耐土壤腐蚀性,其次是Ni Al涂层和316L不锈钢涂层,而纯铝涂层长时间埋地容易鼓泡,耐土壤腐蚀性不佳。结论四种合金涂层显著提高了Q235钢的耐蚀性,可用于接地网材料防腐。     

两种不锈钢在港口海水环境中的腐蚀行为和规律研究

目的研究304和316L不锈钢在我国不同港口海水全浸区浸泡不同周期后的腐蚀规律。方法进行港口海域实海全浸试验,利用三维视频拍摄、质量损失分析及图像处理等手段,对比分析不锈钢在青岛、舟山、三亚港口海水全浸区的腐蚀形貌、腐蚀速率、腐蚀深度和海生物附着面积。结果两种不锈钢表面以点蚀和缝隙腐蚀为主,304不锈钢表面还产生严重的隧道腐蚀。不同港口海水中,304和316L不锈钢的腐蚀速率均较低,316L不锈钢的耐蚀性优于304不锈钢。三港口海域不锈钢表面形貌的差异明显,三亚试样表面海生物附着最多,舟山试样表面附着大量泥沙,三亚港口海域不锈钢的腐蚀速率小于舟山港口海域。结论不同港口海水环境对不锈钢表面海生物种类及附着面积的影响显著,而不锈钢表面状态直接影响其腐蚀形貌。     

碳钢和耐候钢在盐雾环境下的腐蚀行为研究

目的研究Q235钢和耐候钢在3.5%(质量分数)NaCl盐雾/干燥循环加速腐蚀试验中的腐蚀过程,比较它们的耐腐蚀性。方法采用腐蚀失重分析、X-射线衍射分析、扫描电镜观测和电化学测试等进行研究。结果 Q235钢和耐候钢的锈层没有明显的保护作用,但耐候钢的耐蚀性略优于Q235钢。结论在模拟海洋大气环境中,该耐候钢没有优越性,说明该耐候钢不适用于海洋大气环境中。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.