废弃印刷线路板中铜的两步浸出工艺优化

以化学-生物两步浸出工艺回收废弃印刷线路板(WPCBs)中的金属,利用钢铁酸洗废水作为化学浸出的浸出剂,后续生物浸出则采用嗜酸性氧化亚铁硫杆菌作为浸出微生物,探究了WPCBs中铜浸出率和酸洗废水中铁去除率的影响因素。利用响应面分析法对铜浸出的条件进行优化,得出转速553.43 r·min~(-1)、温度42.57℃、投加量20.23 g·L~(-1)、颗粒尺寸1.80 mm为最佳浸出条件,此条件下铜浸出率预测值为100.08%。铜化学浸出动力学模型符合湿法冶金中液固相反应的"收缩核动力学模型",相关系数可以达到0.98以上,过程主要受残留固体膜层的控制。生物浸出实验表明,WPCBs投加量对嗜酸性氧化亚铁硫杆菌毒性影响较大,抑制作用较强,对铜浸出和铁去除均有不利影响,实验表明最适的投加量为60 g·L~(-1)。     

氧化亚铁硫杆菌浸铜作用研究

为研究氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,简称A.f)对铜浸出的作用,从某煤堆积水中分离得到A.f菌,利用该菌对铜进行浸出实验,设置3个处理,3个处理的浸出液分别为9 K培养基(简称S),成熟菌液(简称MS)和过滤除菌液(简称FS)。结果表明,3个处理中铜都得到了浸出,浸出铜浓度按S、FS和MS依次递增分别为4 433、5 377和6 296 mg/L;浸出初期,MS中的铜,浸出速度最快,过滤除菌液中次之,而培养基中的速度比较稳定,比前两者均慢,24 h后三者浸铜速度趋近一致;三者中pH、Eh变化相似,pH均先升高至3.4左右保持相对稳定,Eh均先迅速下降至280 mV后保持稳定。由实验可知,氧化亚铁硫杆菌主要在浸出初期促进了铜的浸出,且菌液中溶解氧氧化Fe2+以及酸性条件下氧化Cu0对铜的浸出作用不容忽视。     

氧化亚铁硫杆菌浸出线路板中铜及过程中铁的变化研究

从煤堆积水中分离得到氧化亚铁硫杆菌,利用该菌种对线路板中的Cu进行了浸出实验.研究了不同线路板粉末添加量对浸出效果的影响,在220 mL溶液中添加量为2.2、4.4 g时Cu的浸出率很快达到了90%,而添加量为11.0、22.0 g时浸出率表现了缓慢上升,在15 d左右达到了90%.观察了浸出过程中铁浓度及价态的变化,结果表明,浸出初期随着添加量的增加,Fe2 增加明显,但是随着浸出时间的推移,Fe3 、Fe2 和总Fe都呈现降低趋势.     

氧化亚铁硫杆菌浸铜研究及胞外多聚物的作用

为了获得氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,A.f)以及胞外多聚物(extracellular polymeric sub-stances,EPS)对铜浸出的作用结果,进行了透析袋实验,设置2个处理,2者的浸出液均为成熟菌液,但一个将铜片装入透析袋中以隔离A.f及EPS与铜的直接接触。结果表明:(1)菌液的处理和加透析袋的处理中铜都得到了浸出,240 h铜的浸出浓度分别为6 796 mg/L和1 366 mg/L,可知A.f及EPS与铜片直接接触能促进铜的浸出;(2)透析袋的处理中Fe3+保持较高浓度,说明Fe3+与EPS络合后被阻挡在透析袋外面从而不能与铜反应,可知EPS在A.f浸铜中起了媒介载体的作用;(3)2者的SEM图表明无透析袋的处理A.f与铜在实验初期发生了吸附,实验后期则无,实验初期铜快速浸出是由于传质距离短,而后期速度变缓是由于传质距离增大。     

氧化亚铁硫杆菌菌液脱除SO_2的实验研究

对比了酸性水溶液、酸性Fe3+溶液、含Fe3+的氧化亚铁硫杆菌菌液的SO2脱除效果,分析了氧化亚铁硫杆菌在SO2脱除过程中的主要作用。结果表明:(1)在实验的进气SO2浓度范围内,酸性水溶液对SO2的吸收仅为物理吸收,反应进行到60min时,SO2脱除率均降至15%以下,溶液不再具有SO2脱除能力。(2)对酸性水溶液、酸性Fe3+溶液和含Fe3+的氧化亚铁硫杆菌菌液3种吸收液而言,在实验的进气SO2浓度范围内,进气SO2浓度越高,SO2脱除率越低;Fe3+初始质量浓度为4.44g/L时,SO2脱除效果较好。(3)氧化亚铁硫杆菌在SO2脱除过程中,直接氧化作用不明显,其主要作用是将Fe2+氧化为Fe3+,维持溶液中Fe3+的浓度,这种间接氧化的作用对SO2的有效脱除非常重要。     

氧化亚铁硫杆菌浸出线路板中铜的研究

从煤堆积水中分离得到氧化亚铁硫杆菌,利用该菌种对线路板中的铜进行了浸出实验.研究了不同线路板粉末添加量对浸出效果的影响,观察了浸出过程中pH和氧化还原电位(Eh)的变化,结果表明添加量为10 g/L和20 g/L时,在15 d内线路板Cu几乎全部浸出,而50g/L和100g/L在15 d内亦有较高的浸出效率,并呈持续上升趋势.     

氧化亚铁硫杆菌的筛选、生长特性及其橡胶再生研究

从大西洋底死火山口土壤中筛选出一株硫杆菌,经16S rDNA鉴定为氧化亚铁硫杆菌。研究了初始底物Fe2+浓度,初始pH,接种量对其生长的影响,确定了其最佳的生长的条件:在30℃、170 r/min条件下,最适底物Fe2+浓度为9 g/L,最佳初始pH为2.5,最适接种量为10%(体积分数)。探讨了氧化亚铁硫杆菌对天然硫化橡胶的脱硫再生,橡胶的SEM分析、FTIR图谱及EDS图谱研究表明氧化亚铁硫杆菌对硫化胶粉的硫交联键有断裂或转化作用,脱硫率达52.6%,氧化亚铁硫杆菌对天然橡胶具有一定的再生作用。     

氧化亚铁硫杆菌浸提废旧线路板铜的浸出率与时间的关系

探讨氧化亚铁硫杆菌SW-02(Thiobacillus ferrooxidans SW-02)浸提废旧印刷线路板Cu的适宜浸出时间,对Cu的浸出率与时间的关系进行了研究。通过摇瓶培养的方式,在30℃,摇床转速为170 r/min条件下进行浸出实验,按不同时间间隔取样测定溶液Cu2+浓度,pH值与氧化还原电位。分析发现,线路板加入量在30 g/L及以上时,浸出40 h后浸出反应停止,而线路板加入量在15 g/L时,浸出40 h后Cu的浸出率达到70%,继续浸出,浸出率不再显著增加。研究结果表明,铜的适宜浸出时间为40 h。     

微生物代谢与Fe3+催化氧化脱除烟气中SO2的研究

利用自制的鼓泡反应器,进行了含氧化亚铁硫杆菌的酸性铁溶液脱除烟气中SO2的实验研究.结果表明,细菌直接脱硫的效果较差;Fe3 在脱硫实验过程中既有催化作用,又有氧化作用;细菌主要起氧化Fe2 为Fe3 的作用,再通过Fe3 脱硫.Fe3 存在一个最佳质量浓度,在7～8 g/L左右.当初始Fe3 质量浓度为7.37 g/L时,脱硫10 h,其效率仍高达80%.     

微生物沥浸法去除底泥中的重金属

以硫酸亚铁盐为底物,培养以氧化亚铁硫杆菌为主要菌种的土著沥滤微生物,采用批式方法对湘江长沙段底泥进行微生物沥浸实验。实验结果表明,底物投加量与底泥固体浓度比(Sd/Sc)为1.5时已能满足底泥的微生物沥浸要求,进一步研究发现底泥固体浓度为13%、底物投加量为19.5 g/L、沥浸时间为6 d时,底泥中超标重金属Cd、Zn和Cu的去除率可分别达到83.1%、75.3%和61.2%;沥浸后底泥中大部分重金属以残渣态存在,且含量低于农用污泥中污染物控制标准,其中硫化物有机结合态Cu浸出较Zn、Cd需更低的pH,且Cu以间接机理浸出为主;以Fe2+为底物的沥浸体系中,黄铁矾的重吸附或共沉淀是沥浸实验后期重金属浸出率下降的原因之一。     

Optimization of Height of Release of Air Pollutants

A number of key projects in the Environmental Protection Agency (EPA) particulate R&;D program having applicability to industry are presented. For electrostatic precipitators (ESP) there is presented the result of work on large diameter discharge electrodes which provide a decrease in penetration of up to a factor of 4 when compared to conventional small diameter electrodes. Also discussed is the multistage ESP which provides a collection efficiency that would require a collecting plate area 4 or 5 times larger with conventional ESP technology. The E-SOX technology makes use of the multistage concept to free up space in the ESP for SO₂ removals of up to 90%. Electrostatically augmented fabric filtration provides a reduction in pressure drop of about 5 0% as compared to conventional fabric filtration. Wind tunnel modeling of windbreaks for material storage piles indicates a potential for providing engineering design data that would allow significant emission reduction caused by wind erosion     

Investigation of the characteristics of the reflectivity of clouds

This paper investigates some of the reflectivity characteristics that clouds (when modelled as solid bodies) must exhibit to be compatible with observations that the reflecting surface of a cloud (i) appears almost equally bright across its face, (ii) is brightest when the cloud is opposite to the Sun but decreases in brightness as the cloud moves to other positions and (iii) increases in brightness with increasing optical thickness of the cloud in the observer's line of sight. These observations, respectively, are shown to imply that the peak value of the bidirectional total reflectivity from a cloud surface (i) increases in inverse proportion to the cosine of the angle between the Sun and the normal to the cloud surface, as the incident angle increases, (ii) appears to be directed back in the direction of the incident radiation, and (iii) increases as optical thickness of the cloud in the observer's line of sight increases. The results could have application in many fields (e.g. modelling diffuse radiance distributions for cloudy skies).     

实验室质量管理体系内部审核的实施

在实施ISO／IEC17025：1999标准《检测和校准实验室能力的通用要求》过程中，通过实验室质量管理体系内部审核的实践与系统分析，识别出内部审核实施阶段的关键环节，提出召开首次会议、收集审核证据、确定审核发现和召开末次会议的技术方法，对提高内部审核的质量和有效性、获得可靠的审核结论具有重要意义。     

Estimation of uncertainty of sampling for analysis of pesticide residues

Abstract

A computer model was used to take random samples from primary sample populations obtained from field trials to simulate the uncertainty of sampling for residue analysis of plant commodities and soil. The results indicate about 40%, 30% and 20% relative uncertainty when random samples of size 5, 10 and 25 are taken respectively, from a single lot. Therefore the sample size should be the same for establishing and enforcing legal limits.     

扬中生态环境建设的思考与实践

结合扬中生态环境的基本情况和存在的不足，进行了具体分析，对扬中未来生态建设的发展方向提出了建议及实施措施。     

An application of the theory of kinematics of mixing to the study of tropospheric dispersion

The most common technique used for numerical simulations of tracer mixing is that of the numerical solution of the advection–diffusion equation with the unresolved fluxes parameterized using the similarity theory. Despite correct predictions of the overall directions of transport, models based on a numerical solution of the advection–diffusion equation lack sufficient accuracy to correctly reproduce the coupling of mixing with small scale processes which are sensitive to the microstructure of the tracer distribution. The objective of this paper is to revisit the basic formalism employed in numerical models used to investigate atmospheric tracers. The main mathematical method proposed here is the theory of kinematics of mixing which could be applied effectively for simulations of atmospheric transport processes. At the beginning of the paper, we introduce simple mathematical transformations in order to demonstrate how complex topological structures are created by mixing processes. These idealistic flow systems are essential to explain transport properties of much more complex three-dimensional geophysical flows. An example of the application of the kinematics of mixing to the analysis of tracer transport on a planetary scale is presented in the following sections. The complex filamentary structures simulated in the numerical experiment are evaluated using some commonly applied statistical measures in order to compare the results with the data published in the literature. The results of the experiment are also analysed with the help of simple conceptual models of fluid filaments. The microstructure of the tracer distribution introduced in the paper is essential to increase our understanding of atmospheric transport and to develop more realistic parameterizations of small-scale mixing. The presented results could also be used to improve calculations of the coupling between microphysical processes and tracer mixing.     

次氯酸钠发生器的研制

介绍了电解法生产次氯酸钠的原理 ,并在原有生产工艺的基础上进行了重新设计和对设备的重新选择、改造 ,得出了各个工艺参数的最佳值 ,生产出高品质的次氯酸钠     

Comparison of methods for evaluation of activity of photocatalytic films

Objective

This work aims to investigate the correlation between the photocatalytic activity determined by methylene blue bleaching (DIN 52980), stearic acid degradation, and degradation of acetone in gas phase.

Method

The photocatalytic TiO₂ coatings included in this investigation ranged from thin commercially available coatings (Activ^TM and BioClean^TM) and ready to use suspensions (Nano-X PK1245) to lab-produced PVD and sol?Cgel coatings. XRD analysis of the photocatalytic coatings showed that all the coatings consisted of nanocrystalline anatase, although the thickness and porosity varied considerably.

Results

The study showed that the reproducibility of the activity measurements was good. However, more importantly, the investigation showed that there is a good correlation between the activities determined by the different methods even though the characteristics of the photocatalytic coatings and the organic probe molecules varied considerably.

Conclusion

The overall findings of this work suggest that there is a good correlation between the investigated methods. These results are promising for the future work concerning standardization of methods for determination of the activity of photocatalytic films.     

Impact of overexploitation of shellfish: northeastern coast of India

India has a very extensive coastline of about 7515 km, rich in diverse living resources. These resources continue to deteriorate with rampant harvesting or are altered for other uses such as aquaculture and fisheries. The present paper deals with degrading coastal habitats in northeastern India, and projects the intensity of the stress arising from the collection of tiger prawn seeds (Penaeus monodon) for aquacultural farms and molluskan shells for poultry feed and edible lime. Indiscriminate exploitation of these resources leads to a heavy reduction of the species concerned and other associated marine communities. The magnitude of such destruction has been quantified. The impacts of biodiversity loss and their after-effects on the ecobalance of this coastal system have become a matter of great concern to ecologists to maintain security and sustainability. The authors propose a public awareness program on themes relating to the importance of biodiversity for human livelihoods.