武汉市小型燃煤锅炉改燃气初探

为了解决武汉市大气环境污染问题，近几年将逐步以清洁的气体燃料（四川天然气）代替燃煤，大批的燃煤锅炉将被燃气锅炉取代。在限制使用燃煤锅炉、普及发展燃气锅炉的阶段，可将具有改造条件的燃煤锅炉改燃气，因此，对武汉市小型燃煤锅炉改造实施过程中的若干问题进行了讨论。     

湿式电除尘器在燃煤电站治理PM_(2.5)中的应用前景

颗粒物特别是细颗粒物(PM2.5)的排放严重影响环境和人类健康,燃煤电站作为PM2.5的重要排放源之一,应加强排放控制。湿式电除尘器作为烟气终端处理设备,可有效脱除燃煤电站烟气中PM2.5。介绍了使用湿式电除尘器脱除PM2.5及其他大气污染物的基本原理,总结了其在国内外燃煤电站的发展历程及应用情况,最后阐述了湿式电除尘器在国内燃煤电站的发展前景。     

燃煤发电机组电除尘器节能减排改造实践

介绍了高频电源相较于传统工频电源的优越性,并以某燃煤电厂4#机组(600MW)电除尘器高频电源改造项目为例,分析并讨论了高频电源在燃煤机组上的应用特点及节能减排效果,为中国燃煤机组电除尘器节能提效改造提供了借鉴。     

燃煤电厂重金属排放与周边土壤重金属污染评价

为研究燃煤电厂重金属排放对周边土壤重金属污染的影响,测定了某燃煤电厂烟囱入口烟气中Cd、Cr、Hg、Ni、Pb、As含量,同时根据当地气象及地形条件,在燃煤电厂周边采集19个土壤样品,分析了土壤中重金属含量及分布情况,并对其污染程度进行评价.结果表明,燃煤电厂烟气中6种重金属元素的质量浓度为0.02～2.00μg/m3...     

浙江省燃煤电厂强制性地方标准制定及实施影响研究

为探讨《燃煤电厂大气污染物排放标准》(DB33/2147—2018)实施所来带的影响,对比分析了DB33/2147—2018与现行的《火电厂大气污染物排放标准》(GB 13223—2011)中燃煤发电锅炉的大气污染物控制要求,详细分析了DB33/2147—2018的主要特点,如加严了污染物的有组织排放限值,增加了排放绩效要求和无组织排放控制要求等。DB33/2147—2018实施后将有利于燃煤电厂的监督执法,同时也会大幅减少燃煤电厂的污染物排放;更会对燃煤电厂、监测单位等产生重要影响。     

中小型燃用烟煤层燃炉NO_x排放特征分析

以86台中小型燃烟煤层燃炉(≤65 MW)的燃料特性分析数据和NOx排放实测数据为基础,通过统计分析方法,研究了锅炉出力、过量空气系数、燃煤挥发分、燃煤氮含量对NOx排放浓度的影响,分析了我国中小型燃烟煤层燃炉NOx的排放与管理控制现状。结果表明,中小型燃用烟煤层燃炉NOx平均排放浓度为324.6 mg/m3;锅炉出力对NOx排放浓度不具有显著影响;燃煤挥发分增高,NOx排放浓度降低;过量空气系数和燃煤氮含量增大,NOx排放浓度增高;并建议在国家层面上尽快制订燃煤锅炉NOx排放标准限值。     

燃煤工业锅炉排放二氧化硫对大气的污染及工业固硫型煤的应用

本文论述了我国燃煤工业锅炉排放ＳＯ２对大气污染的状况及发展趋势,以及应用工业固硫型煤控制燃煤工业锅炉对大气的污染。燃煤工业锅炉燃烧工业固硫型煤时,可明显地降低ＳＯ２和烟尘的排放量,并节约煤炭。在当前及今后相当长的时期内,推广和发展工业固硫型煤,是防治燃煤工业锅炉大气ＳＯ２污染的一条投资少、见效快、简便易行的实用措施,其经济效益及环境效益相当可观。     

中小型燃用烟煤层燃炉NOx排放特征分析

以86台中小型燃烟煤层燃炉（≤65 MW）的燃料特性分析数据和NOx排放实测数据为基础,通过统计分析方法,研究了锅炉出力、过量空气系数、燃煤挥发分、燃煤氮含量对NOx排放浓度的影响,分析了我国中小型燃烟煤层燃炉NOx的排放与管理控制现状。结果表明,中小型燃用烟煤层燃炉NOx平均排放浓度为324.6 mg/m^3;锅炉出力对NOx排放浓度不具有显著影响;燃煤挥发分增高,NOx排放浓度降低;过量空气系数和燃煤氮含量增大,NOx排放浓度增高;并建议在国家层面上尽快制订燃煤锅炉NOx排放标准限值。     

美国燃煤污染防治技术

近年来,美国控制燃煤污染成效显著,这是与美国有关减少燃煤污染的措施、技术分不开的。本文综述了目前美国采用的和正在开发的烟气净化技术,其中包括脱硫、脱氮、除尘,或同时脱硫、脱氮等技术现状和发展趋向,这对于改进我国燃煤污染控制技术工作或许有借鉴之处。     

广州市燃煤电厂PM_(2.5)扩散模拟及控制策略研究

近年来广州市的雾霾天气频发,能见度大幅降低,燃煤电厂排放的PM2.5被认为是重要的影响因子之一。基于稳态高斯高架连续点源模型在不利于大气扩散的气象条件下,对广州市周边31个燃煤电厂的颗粒物污染扩散进行模拟。结果表明:当东南风、南风、东风为主导风向时,装机容量较大的红海湾、平海、妈湾、铜鼓、沙角C、珠海A等燃煤电厂均在广州的上风向地区,这些燃煤电厂排放的PM2.5会增加广州城区PM2.5浓度。同时,根据PM2.5贡献率调整发电系数,对燃煤电厂的发电运行进行管理,为未来有效控制PM2.5浓度提供了新思路。     

选煤脱除氟、砷的研究

研究了采自西南3省、1市17个选煤厂的原煤和洗精煤样品,分析了灰分、氟和砷含量,探讨了选煤脱除氟、砷的机理和影响因素。结果表明,选煤能有效降低煤中氟、砷的含量,应用前景广阔。     

A Computer Plot for a High Temperature Psychrometric Chart

This paper presents results of multivariate regression models developed to estimate the properties and cost of U.S. coals washed for varying degrees of sulfur removal using commercially available physical coal preparation processes. The models allow washed coal characteristics to be predicted from information on coal origin, heating value, ash, and sulfur content. The models were developed by first "processing" each of the 710 coals in the U.S. Bureau of Mines (USBM) coal washability data base through a coal preparation plant computer model which optimizes plant performance to achieve a desired washed coal quality. Washability data are adjusted to account for the inefficiencies of coal washing equipment, and the actual coal sizes treated by various plant wash streams. Since different plant designs may be capable of achieving a given level of sulfur removal, three nominal levels of plant complexity (Levels 2, 3, 4) were included to identify the most economical alternative. The washed coal characteristics thus derived were then analyzed using standard statistical techniques to develop regression equations linking washed coal properties and cost to raw coal properties for each of 18 geographical regions encompassing the entire U.S. These regression models are incorporated in the Advanced Utility Simulation Model (AUSM) to estimate the economic potential of coal washing as a sulfur abatement strategy, in conjunction with other options available to coal-fired power plants. Modeling results for Pennsylvania showed that washed coals frequently were selected as part of a cost-effective control strategy, accounting for 10 to 30 percent of the total emissions reduction, and that "local coal" restrictions significantly increase the use of washed coal as an SO₂ control strategy. Hypothetical requirements for mandatory coal cleaning, however, were found to be costly and ineffective.     

Preparation of coal slurry with organic solvents

In this study, various organic solvents were used to prepare coal slurries and the rheological and thermal properties of coal-organic solvent slurries were examined. Solvents with molecules containing unpaired electrons (high basicity) show high extraction power and cause swelling of coal. Therefore, coal-organic solvent slurries usually showed higher viscosities compared to coal-water slurry. In addition, coal slurries prepared by alcohols and cyclohexanone demonstrated lower settling rates but a high specific sedimentation volume presumably because these solvents swelled coal particles well and led to the formation of weak gel structures in the bulk. In addition, ethanol and cyclohexanone are capable of breaking a considerable amount of hydrogen bonds in coal and subsequently opening up the structures. Thus, more surface area is available for combustion and the combustion rate of coal slurries was increased.     

煅烧温度和添加剂对提高煤矸石中氧化铝溶出率的实验研究

煤矸石是煤炭在开采、洗选过程中产生的固体废弃物,其中二氧化硅、氧化铝和碳占到矸石总量的90%以上,又是一种可以利用的资源。实验以山西潞安煤矿的洗矸为原料,采用SEM、IR和XRD等分析测试手段对不同煅烧温度下的煤矸石进行微观形貌、化学键变化和矿物组成的分析研究,确定氧化铝的活化温度区间;并根据煤矸石的活化机理,选择提高氧化铝溶出率的添加剂。实验结果为：煤矸石中氧化铝的活化温度区间为600～850℃;酸浸过程中添加氟化钠可以打开煤矸石中的SiO₂—Al₂O₃,使氧化铝溶出率达到90%以上,和通常条件下氧化铝的溶出率相比提高20%左右。本研究为煤矸石高值利用提取氧化铝提供了技术基础,也为粉煤灰等低铝含量矿物的开发利用提供借鉴。     

Comparative assessment of coal tars obtained from 10 former manufactured gas plant sites in the eastern United States

A comparative analysis was performed on eleven coal tars obtained from former manufactured gas plant sites in the eastern United States. Bulk properties analyzed included percent ash, Karl Fisher water content, viscosity and average molecular weight. Chemical properties included monocyclic- and polycyclic-aromatic hydrocarbon (PAH) concentrations, alkylated aromatic concentrations, and concentrations of aliphatic and aromatic fractions. It was found that there was at least an order-of-magnitude variation in all properties measured between the eleven coal tars. Additionally, two coal tars obtained from the same manufactured gas plant site had very different properties, highlighting that there can be wide variations in coal tar properties from different samples obtained from the same site. Similarities were also observed between the coal tars. The relative chemical distributions were similar for all coal tars, and the coal tars predominantly consisted of PAHs, with naphthalene being the single-most prevalent compound. The C(9-22) aromatic fraction, an indicator of all PAHs up to a molecular weight of approximately 276 gmole(-1), showed a strong power-law relationship with the coal tar average molecular weight (MW (ct)). And the concentrations of individual PAHs decreased linearly as MW (ct) increased up to ca. 1000 gmole(-1), above which they remained low and variable. Implications of these properties and their variation with MW (ct) on groundwater quality are discussed. Ultimately, while these similarities do allow generalities to be made about coal tars, the wide range of coal tar bulk and chemical properties reported here highlights the complex nature of coal tars.     

Volatile Organic Compounds from Coal Tar and Soil Vapor Samples at MGP Sites

This study characterized organic compounds found in New York State manufactured gas plant (MGP) coal tar vapors using controlled laboratory experiments from four separate MGP sites. In addition, a limited number of deep (0.3–1.2 m above coal tar) and shallow (1.2–2.4 m above coal tar) soil vapor samples were collected above the in situ coal tar source at three of these sites. A total of 29 compounds were consistently detected in the laboratory-generated coal tar vapors at 50°C, whereas 24 compounds were detected at 10°C. The compounds detected in the field sample results were inconsistent with the compounds found in the laboratory-generated samples. Concentrations of compounds in the shallow soil vapor sample were either non-detectable or substantially lower than those found in deeper samples, suggesting attenuation in the vadose zone. Laboratory-generated data at 50°C compared the (% non-aromatic)/(% aromatic) ratio and indicated that this ratio may provide good discrimination between coal tar vapor and common petroleum distillates.     

天然矿物固硫剂及其对煤粉燃烧的影响

选取CaCO₃、Ca(OH)₂质量配比＝3∶2作为主固硫剂,用钙基固硫剂质量的2％的Na₂CO₃对其改性,利用蛭石作为固硫添加剂。在Ca/S＝2.25的情况下,通过固硫实验考察了主固硫剂以及添加剂的加入对固硫率的影响。实验结果表明,煤粉掺入该固硫剂在950℃下燃烧0.5 h,固硫率可以达到85％。还对添加不同固硫剂的煤粉进行热重实验,分析其对煤粉燃烧特性及动力学参数的影响。结果表明,固硫添加剂的加入不但能提高固硫率,还有利于煤的燃烧,减少灰渣的处理量。     

Variations in concentrations and compositions of polycyclic aromatic hydrocarbons (PAHs) in coals related to the coal rank and origin

The release of unburnt coal particles and associated polycyclic aromatic hydrocarbons (PAHs) may cause adverse impacts on the environment. This study assessed variations in the concentration and composition of PAHs in a set of fifty coal samples from eleven coal basins worldwide. The maximum PAH concentrations at high volatile bituminous rank were recorded in samples from a single basin. Considering the entire sample set, the highest PAH concentrations were in fact found outside of this rank range, suggesting that the maceral composition and thus the coal’s origin also influenced PAH concentrations. The examination of the PAH compositions revealed that alkylated 2-3 ring PAHs remain dominant compounds irrespective of coal rank or origin. Multivariate analysis based on PAH and maceral content, bulk and maturity parameters allowed the recognition of seven groups with different rank and origin within the coal sample set.