河道底泥陶粒烧制的工艺条件及性能研究

探讨以河道底泥、污水污泥、黏土为原料制作陶粒的最佳烧制工艺条件,利用单因素实验对陶粒性能进行比较分析,利用X射线衍射(XRD)、扫描电子显微镜(SEM)对微观结构进行表征分析。结果表明:以河道底泥烧制陶粒是可行的,预热温度和时间的控制将影响陶粒的轻质化,烧结温度应接近陶粒低共熔点,通过改变烧结时间可获得不同类型陶粒。烧制高强陶粒时,在陶粒体系低共熔点温度环境下延长烧结时间比单纯提高烧结温度更恰当。以预热温度400℃、预热时间20min、烧结温度1 175℃、烧结时间25min为烧制条件制作的河道底泥陶粒具有良好的性能,堆积密度为620kg/m~3,表观密度为1 125kg/m~3,筒压强度约为0.7MPa,吸水率达36.27%。     

响应面分析法优化造纸污泥吸附剂除磷工艺

以造纸厂废水污泥为原料,采用微波加热法制备造纸污泥吸附剂。利用制备的造纸污泥吸附剂对模拟含磷废水进行了吸附研究,探讨了吸附时间、投加量、pH值、转速和温度等因素对除磷效果的影响,并采用响应面设计法优化吸附工艺条件。结果表明,获得了最佳除磷工艺条件为吸附时间97 min,投加量6.9 g/L,pH=6,转速200 r/min,温度30℃,在此条件下磷的去除率可达99%以上。因此,造纸污泥吸附剂对磷的吸附效果良好,具有重要的实际应用价值。     

复合沸石滤料的制备及其性能测试

以活化后的天然斜发沸石为主要原料,添加粘合剂、成孔剂等制备出孔隙率高、比表面积大的球型复合沸石滤料。通过正交实验得到最优工艺组合条件为ω沸石粉∶ω粘合剂∶ω成孔剂=55%∶35%∶10%,活化温度为150℃,活化时间为3 h。制备的成品堆积密度为674 kg/m3,筒压强度为4.32 MPa,显气孔率59.02%。较陶粒相比,该滤料用于曝气生物滤池在挂膜启动与稳定运行阶段,均具有较高的氨氮去除效果,且挂膜微生物量高,更适宜作为曝气生物滤池的载体。     

新型铁碳微电解填料制备与除磷性能评价

针对传统铁碳填料处理污水活性低的问题,通过均质化-碳化-成型工艺制备新型铁碳微电解填料,采用SEM-EDS、XRD等方法对制备填料进行了表征,探讨了新型填料除磷机理;同时,开展了填料制备条件优化及生活污水除磷性能评价研究。结果表明,新型填料(Fe-C)由于焦油经高温碳化处理可在海绵铁表面及内部孔道形成大量铁碳微原电池,提高了电化学反应速率,其磷脱除率显著高于传统填料(Fe/C);在焦油/铁比(Tar/Fe)为0.3、碳化温度为950℃、恒温时间为0 min、黏结剂质量分数为30%、900℃焙烧90 min条件下,制备的填料除磷性能最佳,除磷效率达98%,可实现含磷废水达标排放。     

采用配方均匀设计法利用脱水污泥制备陶粒的研究

长期以来,对城市污水处理后产生的污泥处置一直是环保的难题,传统的处理处置方法均存在诸多问题,寻求一种好的处理处置污泥方法迫在眉睫。针对目前的问题运用带约束条件的配方均匀设计方法对粉煤灰-脱水污泥陶粒配方进行实验设计,运用三叶回转窑进行小试。研究了陶粒组分中粉煤灰、污泥、黏土的比例对烧成陶粒堆积密度、颗粒强度的影响;确定了最佳物料配比,使陶粒的性能测试指标均符合GB/17431.2-1998标准的规定。实验结果表明:烧制陶粒湿比例下脱水污泥用量达45%,干比例污泥用量15.2%,污泥减量化和资源化效果显著;陶粒浸出毒性实验结果表明各项指标均低于浸出液中危害成分浓度限值,达到了污泥无害化的效果;粉煤灰、污泥和黏土的优化质量(干)比例为79%,15.2%,5.8%;陶粒的堆积密度为600 kg/m3,筒压强度2.2 MPa,1 h吸水率10.2%,粒型系数1.3。     

微波强化有机改性膨润土对磷的吸附特性研究

利用十六烷基三甲基溴化铵(CTMAB)在微波辐射条件下对浙江临安膨润土进行改性,制得有机改性膨润土,利用其含磷模拟废水进行处理,考察了不同的工艺条件如有机改性剂用量、微波辐射强度、辐照时间、吸附时间、改性膨润土投加量、pH值对废水中磷去除效果的影响。结果表明:在有机改性剂用量为3 mmol/g,微波辐照强度为96 W/g,微波辐照时间8 min为最佳制备条件。改性膨润土用量为12 mg/L,反应时间为15 min,溶液pH为7及常温条件下,改性膨润土对浓度为50 mg/L的含磷废水去除率达到97.3%,吸附符合Freundlich吸附等温方程。     

陶粒处理含磷污水的研究进展

陶粒以其经济低廉、结构稳定、吸附能力强、易于操作和可循环利用等特点,近年来在水污染治理方面显示出诸多优势而倍受关注。主要综述了陶粒在处理含磷废水方面的应用;详细分析了陶粒对磷的吸附机制,包括陶粒主要组分对磷的吸附机制、吸附动力学模型和等温吸附模型;概括了各项影响因素,包括吸附过程中陶粒粒径、磷初始浓度、温度、吸附时间、pH、共存离子等对陶粒吸附除磷的影响,并对实际应用中存在的问题提出解决思路,建议对陶粒进行微观除磷机制深入研究,为陶粒制备工艺的不断改进提供理论依据。最后,展望了开发陶粒的努力方向及其发展前景,提出了开发成本低廉、高吸附性能、抗干扰、易再生、磷资源可回收陶粒是未来研究的重点。     

改性锰砂滤料处理高铁锰煤矿矿井水

采用KMnO4溶液浸渍法制备了新型改性锰砂滤料,研究了滤料表面性能和过滤处理高铁锰矿井水的效果。结果表明,锰砂滤料除铁锰性能优于石英砂、陶粒以及瓷砂,采用KMnO4溶液浸渍能够提高锰砂滤料的过滤性能,最优的浸渍浓度为5%。5%KMnO4改性锰砂滤料过滤处理高铁锰矿井水的最佳工艺参数为：过滤周期24 h,反冲洗强度3.2 L/（s.m2）,反冲洗时间5 min;通过比表面积测试分析和SEM表征分析发现,KMnO4溶液浸渍能够提高锰砂滤料比表面积,并在锰砂滤料表面形成了氧化膜,从而提高除铁除锰效果,而且浸渍液浓度越高,这种作用越明显。     

多孔硅酸钙滤料吸附床除磷试验研究

以多孔硅酸钙滤料为吸附载体处理含磷的二沉池出水.通过静态吸附试验和动态吸附试验,研究了滤料粒径及投加量、初始pH、反应时间、温度以及滤料填充高度对除磷效果的影响.在静态吸附试验中,取初始磷质量浓度为4.98 mg/L的含磷废水100 mL,当多孔硅酸钙滤料粒径为4～14目,投加量为1.0g,吸附时间为2.5h,温度为25℃,溶液初始pH为7.0～9.0时,磷的去除率可达95％以上,出水磷满足《城镇污水处理厂污染物排放标准》(GB 18918-2002)的一级A标准(≤0.5 mg/L).动态吸附试验表明,在长期运行条件下,多孔硅酸钙滤料吸附床能持续有效地去除污水中的磷,综合考虑吸附率和运行费用,选择水力停留时间为30 min,滤料填充高度为60 cm为宜.     

铁屑粉煤灰组合处理含磷废水

实验研究了铁屑粉煤灰组合处理含磷废水的除磷效果.通过单因素实验,考查了铁屑粉煤灰质量比、反应时间、pH值和投加量对除磷效果的影响.实验结果表明,该法除磷的最优条件为铁屑和粉煤灰的质量比为2∶1,反应时间为20 min,pH值为6,投加量为20 g/L.在最优实验条件下磷的去除率达到了97.5％.对比了该法和粉煤灰吸附法与传统铁屑法的除磷效果.与单一粉煤灰吸附法和传统铁屑法除磷的结果相比较,铁屑粉煤灰组合除磷的方法具有明显优势.     

Chloroaromatic pollutants in mussels incubated in two finnish watercourses polluted by industry

Concentrations of different chlorinated compounds were measured in mussels incubated in two polluted watercourses, a river (the River Kymijoki) and a lake (Lake Vanaja) for four weeks in summer 1995. The sum concentrations of polychlorinated phenols (PCP) and biphenyls (PCB) were both about 1 μg/g lipid weight (lw) in Lake Vanaja mussels, while in the River Kymijoki mussels PCPs were non-detectable and PCBs were measured 120 ng/g lIw. The concentrations of toxic polychlorinated dibenzo-p-dioxin (PCDD) and dibenzofuran (PCDF) congeners ranged between <17 and 370 pg/g Iw in Lake Vanaja mussels and between <38 and 11,000 pg/g lw in the River Kymijoki mussels. Polychlorinated diphenyl ethers (PCDE) were detected in the mussels incubated in the River Kymijoki (0.4–1.1 ng/g Iw), but not in those incubated in Lake Vanaja. Polychlorinated phenoxyanisoles (PCPA) were measured 33 ng/g lw and polychlorinated phenoxyphenols (PCPP) 300 ng/g lw in the mussels incubated in the River Kymijoki. PCPAs were also detected in reference samples, which were sediment and pike from the River Kymijoki and Baltic salmon, seal and white-tailed sea eagle.     

Radionuclides and trace elements in fish collected upstream and downstream of Los Alamos national laboratory and the doses to humans from the consumption of muscle and bone

Abstract

The purpose of this study was to determine radionuclide and trace element concentrations in bottom‐feeding fish (catfish, carp, and suckers) collected from the confluences of some of the major canyons that cross Los Alamos National Laboratory (LANL) lands with the Rio Grande (RG) and the potential radiological doses from the ingestion of these fish. Samples of muscle and bone (and viscera in some cases) were analyzed for ³H, ⁹⁰Sr, ¹³⁷Cs, ^totU, ²³⁸Pu, ^239,240Pu, and ²⁴¹Am and Ag, As, Ba, Be, Cr, Cd, Cu, Hg, Ni, Pb, Sb, Se, and Tl. Most radionuclides, with the exception of ⁹⁰Sr, in the muscle plus bone portions of fish collected from LANL canyons/RG were not significantly (p<0.05) higher from fish collected upstream (San Ildefonso/background) of LANL. Strontium‐90 in fish muscle plus bone tissue significantly (p<0.05) increases in concentration starting from Los Alamos Canyon, the most upstream confluence (fish contained 3.4E‐02 pCi g^‐1 [126E‐02 Bq kg^‐1]), to Frijoles Canyon, the most downstream confluence (fish contained 14E‐02 pCi g^‐1 [518E‐02 Bq kg^‐1]). The differences in ⁹⁰Sr concentrations in fish collected downstream and upstream (background) of LANL, however, were very small. Based on the average concentrations (±2SD) of radionuclides in fish tissue from the four LANL confluences, the committed effective dose equivalent from the ingestion of 46 lb (21 kg) (maximum ingestion rate per person per year) of fish muscle plus bone, after the subtraction of background, was 0.1 ± 0.1 mrem y^‐1 (1.0 ± 1.0 μSv y^‐1), and was far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem y^‐1 (1000 μSv y^‐1). Of the trace elements that were found above the limits of detection (Ba, Cu, and Hg) in fish muscle collected from the confluences of canyons that cross LANL and the RG, none were in significantly higher (p<0.05) concentrations than in muscle of fish collected from background locations.     

Book review

The Pesticide Manual ‐ A World Compendium, 8th Edition, C.R. Worthing, Editor and S.B. Walker, Assistant Editor, British Crop Protection Council, BCPC Publications Sales, Bear Farm, Binfield, Bracknell, Berkshire RG12 5QE, England. 1987, 1100 pp., UK £50; Overseas £56. ISBN 0–948404–01–9.     

Patterns of volatile metabolites and nonvolatile trichothecenes produced by isolates of <Emphasis Type="Italic">Stachybotrys,Fusarium, Trichoderma,Trichothecium</Emphasis> and <Emphasis Type="Italic">Memnoniella</Emphasis>

We reported previously that trichodiene, a volatile trichothecene derivative, was produced by a Stachybotrys isolate, also known to produce highly cytotoxic, non-volatile, macrocyclic trichothecenes (satrotoxins). We investigated the relationship between the production of trichodiene and various non-volatile trichothecenes for several molds. Volatile metabolites were concentrated by adsorption on Tenax TA and analyzed by GC/MS, while non-volatile metabolites were separated by HPLC, derivatized and analyzed by GC/MS. Stachybotrys chartarum isolates producing macrocyclic trichothecenes secreted significantly larger amounts of trichodiene and other sesquiterpenes than isolates which only produced simple trichothecenes. The amounts of secreted trichodiene were relatively small in all cases. With the exception of Memnoniella, which excreted small amounts of sesquiterpenes, the other isolates produced varying amounts of sesquiterpenes, including trichodiene, as well as simple tricothecenes, no detectable trichodiene, but large amounts of griseofulvin derivatives. In Stachybotrys there is apparently a correlation between trichodiene and macrocyclic trichothecene production. In the remaining isolates, there was no simple relationship between trichodiene and non-volatile trichothecene synthesis. Trichodiene is produced in larger amounts by Stachybotrys isolates, which also produce satratoxins, but it will be difficult to utilize this metabolite to detect toxic isolates in buildings due to the relatively small amounts excreted.     

Observations on the influence of water and soil pH on the persistence of insecticides

Abstract

The pH‐disappearance rate profiles were determined at ca. 25°C for 24 insecticides at 4 or 5 pH values over the range 4.5 to 8.0 in sterile phosphate buffers prepared in water‐ethanol (99: 1 v/v). Half‐lives measured at pH 8 were generally smaller than at lower pH values. Changes in half lives between pH 8.0 and 4.5 were largest (>1000x) for the aryl carbamates, carbofuran and carbaryl, the oxime carbamate, oxamyl, and the organophosphorus insecticide, trichlorfon. In contrast, half lives of phorate, terbufos, heptachlor, fensulfothion and aldicarb were affected only slightly by pH changes. Under the experimental conditions described half lives at pH8 varied from 1–2 days for trichlorfon and oxamyl to >1 year for fensulfothion and cyper‐methrin. Insecticide persistence on alumina (acid, neutral and basic), mineral soils amended with aluminum sulfate or calcium hydroxide to different pH values and four natural soils of different pH was examined. No correlation was observed between the measured pH of these solids and the rate of disappearance of selected insecticides applied to them. These observations demonstrate the difficulty of extrapolating the pH dependent disappearance behaviour observed in homogeneous solution to partially solid heterogeneous systems such as soil.     

The chemical stability of formulations of some hydrolyzable insecticides in aqueous mixtures with hydrolysis catalysts

Abstract

The active ingredients in commercial formulations of malathion, oxamyl, carbaryl, diazinon, and chlorpyrifos diluted to “spray tank”; concentrations with buffered distilled or natural water of pH 4–9 were stable for at least 24 hr. Formulations of trichlorfon were not stable at pH 7 or above but disappearance rates were slower than for the pure chemical in homogeneous solution. Cupric ion was observed to be an effective catalyst for the hydrolysis of a variety of pure organophosphorus insecticides but did not catalyze hydrolysis of the active ingredients of the formulations examined. Increasing the dilution of the formulation increased the susceptibility of malathion, oxamyl, and carbaryl to hydrolysis.     

Organochlorine compounds in a three-step terrestrial food chain

The concentrations of 15 organochlorine chemicals (PCBs and pesticides) were studied in a Central European oak wood food chain system: Great tit (Parus major), caterpillars (Tortrix viridana, Operophtera brumata, Erannis defoliaria), and oak-leaves (Quercus robur). Juvenile tits receive organochlorines from the mother via egg transfer and, eventually to a greater extent, from the caterpillar food source during nestling period. The concentrations of PCB 153 (2,2′,4,4′,5,5′-hexachlorobiphenyl, the most abundant in this study) was found in leaf material at ca. 1 ng/g, in caterpillars 10 ng/g, and in bird eggs 170 ng/g on an average and on a dry mass basis.     

Radionuclides in deer and elk from Los Alamos national laboratory and the doses to humans from the ingestion of muscle and bone

Abstract

This paper summarizes radionuclide concentrations (³H, ⁹⁰Sr, ¹³⁷Cs, ²³⁸Pu, ^239,240Pu, ²⁴¹Am, and ^totU) in muscle and bone tissue of mule deer (Odocoileus hemionus) and Rocky Mountain elk (Cervus elaphus) collected from Los Alamos National Laboratory (LANL), Los Alamos, New Mexico, lands from 1991 through 1998. Also, the committed effective dose equivalent (CEDE) and the risk of excess cancer fatalities (RECF) to people who ingest muscle and bone from deer and elk collected from LANL lands were estimated. Most radionuclide concentrations in muscle and bone from individual deer (n = 11) and elk (n = 22) collected from LANL lands were either at less than detectable quantities (where the analytical result was smaller than two counting uncertainties) and/or within upper (95%) level background (BG) concentrations. As a group, most radionuclides in muscle and bone of deer and elk from LANL lands were not significantly higher (p<0.10) than in similar tissues from deer (n = 3) and elk (n = 7) collected from BG locations. Also, elk that had been radio collared and tracked for two years and spent an average time of 50% on LANL lands were not significantly different in most radionuclides from road kill elk that have been collected as part of the environmental surveillance program. Overall, the upper (95%) level net CEDEs (the CEDE plus two sigma for each radioisotope minus background) at the most conservative ingestion rate (50 lbs of muscle and 13 lbs of bone) were as follows: deer muscle = 0.22 mrem y^‐1 (2.2 μSv y^‐1), deer bone = 3.8 mrem y^‐1 (38 μSv y^‐1), elk muscle = 0.12 mrem y^‐1 (1.2 μSv y^‐1), and elk bone = 1.7 mrem y^‐1 (17 μSv y^‐1). All CEDEs were far below the International Commission on Radiological Protection guideline of 100 mrem y^‐1 (1000 μSv y^‐1), and the highest muscle plus bone net CEDE corresponded to a RECF of 2E‐06, which is far below the Environmental Protection Agency upper level guideline of 1E‐04.     

Radionuclides in pinon pine (Pinus edulis) nuts from los alamos national laboratory lands and the dose from consumption

Abstract

One of the dominant tree species growing within and around the eastern portion of Los Alamos National Laboratory (LANL), Los Alamos, NM, lands is the pinon pine (Pinus edulis). Pinon pine is used for firewood, fence posts, and building materials and is a source of nuts for food—the seeds are consumed by a wide variety of animals and are also gathered by people in the area and eaten raw or roasted. This study investigated the (1) concentration of ³H, ¹³⁷Cs, ⁹⁰Sr, ^totU, ²³⁸Pu, ^{239, 240}Pu, and²⁴¹ Am in soils (0‐ to 12‐in. [31 cm] depth underneath the tree), pinon pine shoots (PPS), and pinon pine nuts (PPN) collected from LANL lands and regional background (BG) locations, (2) committed effective dose equivalent (CEDE) from the ingestion of nuts, and (3) soil to PPS to PPN concentration ratios (CRs). Most radionuclides, with the exception of ³H in soils, were not significantly higher (p < 0.10) in soils, PPS, and PPN collected from LANL as compared to BG locations, and concentrations of most radionuclides in PPN from LANL have decreased over time. The maximum net CEDE (the CEDE plus two sigma minus BG) at the most conservative ingestion rate (10 lb [4.5 kg]) was 0.0018 mrem (0.018 μSv); this is far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem (1000 μSv). Soil‐to‐nut CRs for most radionuclides were within the range of default values in the literature for common fruits and vegetables.     

Degradation and sorption of imidacloprid in dissimilar surface and subsurface soils

Degradation and sorption/desorption are important processes affecting the leaching of pesticides through soil. This research characterized the degradation and sorption of imidacloprid (1-[(6-chloro-3-pyridinyl)-methyl]-N-nitro-2-imidazolidinimine) in Drummer (silty clay loam) and Exeter (sandy loam) surface soils and their corresponding subsurface soils using sequential extraction methods over 400 days. By the end of the incubation, approximately 55% of imidacloprid applied at a rate of 1.0 mg kg^?1 degraded in the Exeter sandy loam surface and subsurface soils, compared to 40% of applied imidacloprid within 300 days in Drummer surface and subsurface soils. At the 0.1 mg kg^?1 application rate, dissipation was slower for all four soils. Water-extractable imidacloprid in Exeter surface soil decreased from 98% of applied at day 1 to > 70% of the imidacloprid remaining after 400 d, as compared to 55% in the Drummer surface soil at day 1 and 12% at day 400. These data suggest that imidacloprid was bioavailable to degrading soil microorganisms and sorption/desorption was not the limiting factor for biodegradation. In subsurface soils > 40% of ¹⁴C-benzoic acid was mineralized over 21 days, demonstrating an active microbial community. In contrast, cumulative ¹⁴CO₂ was less than 1.5% of applied ¹⁴C-imidacloprid in all soils over 400 d. Qualitative differences in the microbial communities appear to limit the degradation of imidacloprid in the subsurface soils.