Carbon monoxide from composting due to thermal oxidation of biomass

Emissions of carbon monoxide (CO) were observed from decomposing organic wastes and litter under laboratory, pilot composting plant, and natural conditions. Field studies included air from inside a compost heap of about 200 m3, emissions from composting of livestock wastes at a biologically operating farm, and leaf litter pile air samples. The concentration of CO was up to 120 micromol mol(-1) in the compost piles of green waste, and up to 10 micromol mol(-1) in flux chambers above livestock waste windrow composts. The mean CO flux rates were approximately 20 mg CO m(-2) h(-1) for compost heaps of green waste, and varied from 30 to 100 mg CO m(-2) h(-1) for fresh dung windrows. Laboratory studies using a temperature and ventilation-controlled substrate container were performed to elucidate the origin of CO, and included hay samples of fixed moisture content at temperatures between 5 and 65 degrees C, including nonsterilized as well as sterilized samples. The concentration of CO was up to 160 micromol mol(-1) in these experiments, and Arrhenius-type plot analyses resulted in activation energies of 65 kJ mol(-1) for thermochemically produced CO from the nonsterilized compost substrate. Sterilized samples showed dramatically reduced CO2 but virtually unchanged CO emissions, albeit at a slightly lower activation energy, likely a result of the high-temperature sterilization. Though globally and regionally these CO emissions are only a minor source, thermochemically produced CO emissions might affect local air quality in and near composting facilities.     

Weed seed viability in composted beef cattle feedlot manure

Manure composting has gained increased acceptance by the beef cattle (Bos taurus) feedlot industry in southern Alberta, Canada. Unlike fresh manure, compost is often promoted as being "weed-free." Studies were conducted with five weed species in 1997 and thirteen in 1999 to examine the effect of feedlot manure composting on weed seed viability. Weed seeds were buried in open-air compost windrows and recovered at various times during the thermophilic phase of composting. Windrow temperature and water contents were also measured. Germinability was zero for all composted weed seeds at all sampling times in 1997. However, some seeds remained viable (positive tetrazolium test denoting respiration) on Day 70. In 1999, only one of the thirteen species retained germinability on Day 21 and only two species had respiring seeds on Day 42. Time-viability relationships during composting were defined by exponential decay models. Lethal temperatures to eliminate viability was species-dependent. In 1999, four weed species were killed in the initial 7 d of composting at a lethal temperature of 39 degrees C while temperatures of > 60 degrees C were required for two species. Regression analysis on weed seed viability versus windrow temperature resulted in significant R2 values, which showed that only 17 to 29% of the variation in viability was accounted for by temperature. The lack of definitive relationships between temperature and weed seed viability demonstrated that factors other than temperature may play a role in eliminating weed seeds during composting.     

Antibiotic degradation during manure composting

On-farm manure management practices, such as composting, may provide a practical and economical option for reducing antibiotic concentrations in manure before land application, thereby minimizing the potential for environmental contamination. The objective of this study was to quantify degradation of chlortetracycline, monensin, sulfamethazine, and tylosin in spiked turkey (Meleagris gallopavo) litter during composting. Three manure composting treatments were evaluated: a control treatment (manure pile with no disturbance or adjustments after initial mixing), a managed compost pile (weekly mixing and moisture content adjustments), and vessel composting. Despite significant differences in temperature, mass, and nutrient losses between the composting treatments and the control, there was no difference in antibiotic degradation among the treatments. Chlortetracycline concentrations declined rapidly during composting, whereas monensin and tylosin concentrations declined gradually in all three treatments. There was no degradation of sulfamethazine in any of treatments. At the conclusion of the composting period (22-35 d), there was >99% reduction in chlortetracycline, whereas monensin and tylosin reduction ranged from 54 to 76% in all three treatments. Assuming first-order decay, the half-lives for chlortetracycline, monensin, and tylosin were 1, 17, and 19 d, respectively. These data suggest that managed compositing in a manure pile or in a vessel is not better than the control treatment in degrading certain antibiotics in manure. Therefore, low-level manure management, such as stockpiling, after an initial adjustment of water content may be a practical and economical option for livestock producers in reducing antibiotic levels in manure before land application.     

Composting of vinasse and cotton gin waste by using two different systems

Two composts were obtained by co-composting of a concentrated depotassified beet vinasse and cotton gin waste using two different aeration systems: static aerated pile (forced aeration provided by a blower whom operated in the positive mode) and windrow (turned pile). The composting mixtures were cotton gin trash (55%) and vinasse (45%) (dry weight). In static pile, the total amount of vinasse was added at the beginning of the process whereas, in windrow two additions of vinasse were performed. Differences in temperature changes between both composting systems were found: a faster increase of temperature in the windrow (54 °C at 7 days) than in the static pile (45 °C at 21 days) was observed. Probably in the static pile system, the compaction of the substrates made difficult the correct distribution of the air inside the pile. Moreover, after the second addition of vinasse a new thermophilic phase was started in windrow. The different aeration systems and the way of addition of vinasse could cause differences in organic matter (OM) degradation and in weight (22.6% for the static pile and 26.7% for the windrow) and gas losses during the process. Nevertheless, the composts obtained by the two systems had a high fertilizer value (25.1 g kg⁻¹ N; 3.2 g kg⁻¹ P₂O₅; 21.4 g kg⁻¹ K₂O; C/N8) for compost obtained in static pile and (16.2 g kg⁻¹ N; 3.4 g kg⁻¹ P₂O₅; 16.1 g kg⁻¹ K₂O; C/N 12) for compost obtained in the windrow). A high degree of stability was reached in the final composts. Composting of vinasse with cotton gin waste serves two objectives, disposal of wastes and recycling of waste components.     

Convenience improves composting and recycling rates in high-density residential buildings

Increasing volumes of solid waste, implicated in environmental pollution and health problems, are central to the current environmental crisis. In two randomized field experiments, we demonstrate that convenience dramatically boosts recycling and composting rates in multi-family dwellings and university residences. When compost bins were placed on each floor in a multi-family residence, instead of on the ground floor, composting rates increased by 70%, diverting 27 kilograms of compost from the landfill per unit per year. When recycling stations were placed just meters from suites in student residences, instead of in the basement, recycling increased by 147% (container), and 137% (paper), and composting increased by 139%, diverting 23, 22, and 14 kilograms of containers, paper, and compost, respectively, from the landfill per person per year. Simply making recycling and composting convenient can significantly increase waste diversion, and as such this single intervention has important implications for waste management and environmental policy.     

Carbon turnover and ammonia emissions during composting of biowaste at different temperatures

The effects of different process temperatures (40, 55, and 67 degrees C) during composting of source-separated household waste were studied in a 200 L compost reactor at an oxygen concentration of 16%. The overall decomposition measured as carbon mineralization, decomposition of different carbon constituents, and the dynamics of nitrogen mineralization and the microbial community, are reported. Ammonia emissions at 67 degrees C were more than double those at lower temperatures, and they were lowest at 40 degrees C. The decomposition rate, measured as CO2 emission, was highest at 55 degrees C. Decomposition of crude fat was slower at 40 degrees C than at 55 and 67 degrees C. The peak in microbial biomass was largest in the run at 40 degrees C, where substantial differences were seen in the microbial community structure and succession compared to thermophilic temperatures. Biowaste composting can be optimized to obtain both a high decomposition rate and low ammonia emissions by controlling the process at about 55 degrees C in the initial, high-rate stage. To reduce ammonia emissions it seems worthwhile to reduce the temperature after an initial high-temperature stage.     

Composting and compost application in China

The current situation of municipal solid waste (MSW) and sewage sludge production (in terms of volume as well as composition) in China is introduced. Composting and compost application in China are reviewed. In China, the production of municipal solid waste and sewage sludge is changing rapidly along with economic development. Composting is mainly applied for treating MSW, about 20% of the total amount of MSW being disposed. MSW composting is mainly co-composted with night soil or sewage sludge. Compost is used in agriculture, forestry and horticulture. Compost application is the key factor influencing the composting development in China. To promote composting and compost application in China, a state-wide survey on the production, composition and physical and chemical properties of MSW and sewage sludge should be carried out. More effort should be made to develop low cost and high efficient composting technologies according to China's conditions. The environmental impact of compost application should also be given more attention.     

The effect of phosphogypsum on greenhouse gas emissions during cattle manure composting

Phosphogypsum (PG), a by-product of the phosphate fertilizer industry, reduces N losses when added to composting livestock manure, but its impact on greenhouse gas emissions is unclear. The objective of this research was to assess the effects of PG addition on greenhouse gas emissions during cattle feedlot manure composting. Sand was used as a filler material for comparison. The seven treatments were PG10, PG20, PG30, S10, S20, and S30, representing the rate of PG or sand addition at 10, 20, or 30% of manure dry weight and a check treatment (no PG or sand) with three replications. The manure treatments were composted in open windrows and turned five times during a 134-d period. Addition of PG significantly increased electrical conductivity (EC) and decreased pH in the final compost. Total carbon (TC), total nitrogen (TN), and mineral nitrogen contents in the final composted product were not affected by the addition of PG or sand. From 40 to 54% of initial TC was lost during composting, mostly as CO(2), with CH(4) accounting for <14%. The addition of PG significantly reduced CH(4) emissions, which decreased exponentially with the compost total sulfur (TS) content. The emission of N(2)O accounted for <0.2% of initial TN in the manure, increasing as compost pH decreased from alkaline to near neutral. Based on the total greenhouse gas budget, PG addition reduced greenhouse gas emissions (CO(2)-C equivalent) during composting of livestock manure by at least 58%, primarily due to reduced CH(4) emission.     

Open windrow composting of polymers: an investigation into the rate of degradation of polyethylene

The compostability of degradable polymers under open windrow composting conditions is explored within this paper. Areas for consideration were the use of, and impacts of, degradable polyethylene (PE) sacks on the composting process and the quality of the finished compost product. These factors were investigated through polymer weight loss over the composting process, the amount of polymer residue and chemical contaminants in the finished compost product, the windrow temperature profiles and a bioassay to establish plant growth and germination levels using the final compost product. This trial also included a comparative study of the weight loss under composting conditions of two different types of ‘degradable’ polymer sacks currently on the European market: PE and a starch based product. Statistical analysis of the windrow temperature profiles has led to the development of a model, which can help to predict the expected trends in the temperature profiles of open compost windrows where the organic waste is kerbside collected using a degradable PE sack.     

Persistent organic pollutants in source-separated compost and its feedstock materials--a review of field studies

Composting and the application of compost to the soil follow the principle of recycling and sustainability. Compost can also have a positive effect on physical, chemical, and biological soil parameters. However, little is known about the origin, concentration, and transformation of persistent organic pollutants (POPs) in compost. We therefore compiled literature data on some priority POPs in compost and its main feedstock materials from more than 60 reports. Our data evaluation suggests the following findings. First, median concentrations of Sigma 16 polycyclic aromatic hydrocarbons (PAHs), Sigma 6 polychlorinated biphenyls (PCBs), and Sigma 17 polychlorinated dibenzo-p-dioxins and -furans (PCDD/Fs) were higher in green waste (1803, 15.6 microg/kg dry wt., and 2.5 ng international toxicity equivalent [I-TEQ]/kg dry wt.) than in organic household waste (635, 14.6 microg/kg dry wt., and 2.2 ng I-TEQ/kg dry wt.) and kitchen waste (not available [NA], 14.9 microg/kg dry wt., 0.4 ng I-TEQ/kg dry wt.). The POP concentrations in foliage were up to 12 times higher than in other feedstock materials. Second, in contrast, compost from organic household waste and green waste contained similar amounts of Sigma 16 PAHs, Sigma 6 PCBs, and Sigma 17 PCDD/Fs (1915, 39.8 microg/kg dry wt., and 9.5 ng I-TEQ/kg dry wt., and 1715, 30.6 microg/kg dry wt., and 8.5 ng I-TEQ/kg dry wt., respectively). Third, concentrations of three-ring PAHs were reduced during the composting process, whereas five- to six-ring PAHs and Sigma 6 PCBs increased by roughly a factor of two due to mass reduction during composting. Sigma 17 PCDD/Fs had accumulated by up to a factor of 14. Fourth, urban feedstock and compost had higher POP concentrations than rural material. Fifth, the highest concentrations of POPs were usually observed in summer samples. Finally, median compost concentrations of POPs were greater by up to one order of magnitude than in arable soils, as the primary recipients of compost, but were well within the range of many urban soils. In conclusion, this work provides a basis for the further improvement of composting and for future risk assessments of compost application.     

Decrease in water-soluble 17beta-Estradiol and testosterone in composted poultry manure with time

Little attention has been paid to the environmental fate of the hormones 17beta-estradiol and testosterone excreted in animal waste. Land application of manure has a considerable potential to affect the environment with these endocrine disrupting compounds (EDCs). Composting is known to decompose organic matter to a stable, humus-like material. The goal of the present study was to quantitatively assess levels of water-soluble 17beta-estradiol and testosterone in composting chicken manure with time. Chicken layer manure was mixed with hay, straw, decomposed leaves, and starter compost, adjusted to approximately 60% moisture, and placed into a windrow. A clay-amended windrow was also prepared. Windrows were turned weekly, and temperature, oxygen, and CO(2) in the composting mass were monitored for either 133 or 139 d. Commercial enzyme immunoassay kits were used to quantitate the levels of 17beta-estradiol and testosterone in aqueous sample extracts. Water-soluble quantities of both hormones diminished during composting. The decrease in 17beta-estradiol followed first-order kinetics, with a rate constant k = -0.010/d. Testosterone levels declined at a slightly higher rate than 17beta-estradiol (i.e., k = -0.015/d). Both hormones could still be measured in aqueous extracts of compost sampled at the conclusion of composting. The decline in water-soluble 17beta-estradiol and testosterone in extracts of clay-amended compost was not statistically different from normal compost. These data suggest that composting may be an environmentally friendly technology suitable for reducing, but not eliminating, the concentrations of these endocrine disrupting hormones at concentrated animal operation facilities.     

Does municipal solid waste composting make economic sense?

Currently there is widespread interest on the part of local Governments in incorporating municipal solid waste (MSW) composting into their integrated solid waste management systems. However, there is little information on the costs of MSW composting and how those costs compare with the costs of alternative forms of waste disposal (especially traditional land disposal). This article begins to fill this information gap by reporting the results of a survey of 19 MSW composting facilities around the United States. Results indicate that MSW composting generally costs around $50 per ton, and that very few facilities receive any revenues from the sale of compost to offset operating costs. Additional economic analysis indicates that, at present, MSW composting cannot be justified on financial grounds in most parts of the US, but may be competitive with land disposal where the cost of landfilling is high (such as the north-east).1998 Academic Press     

Electromagnetic induction methods applied to an abandoned manure handling site to determine nutrient buildup

Movement of nutrients from livestock manure handling sites has the potential to negatively impact the environment. This study was conducted using electromagnetic induction (EMI) measurements to develop apparent soil electrical conductivity (EC(a)) maps to identify regions of nutrient buildup beneath an abandoned compost site. A trailer-mounted EM-38 coupled with a global positioning satellite system was towed across an area used for composting of feedlot manure. The resulting EC(a) maps were compared with known locations of compost rows confirming the alignment of row locations with high EC(a) regions. The identified rows were cored and compared with the region between the rows. The identified rows with a compost history demonstrated significant (P < 0.05) increases in soluble salts (1.6 times greater), NO3 (6.0 times greater), and Cl (2.0 times greater) compared with the area between the rows at a 1.5-m depth. Image processing techniques were used to display yearly changes that were associated with nutrient movement and transformations in the soil beneath the site. Correlations between EMI measurements and soil core analyses for NO3-N, Cl, and EC provided ancillary support for the EMI methods. The use of EMI for mapping of sites having a history of livestock waste application was effective in delineating high nutrient buildup areas and for observing spatial EC(a) changes over time.     

Anaerobic treatment with methane recovery of agricultural and village wastes

To provide more efficient utilization of village wastes and agricultural residues and eliminate pollution from current practices anaerobic treatment of such wastes with methane recovery is proposed. This paper describes studies to determine the performance of anaerobic composting for such wastes.Composting of three waste types was investigated: (a) agricultural residues, (b) Village solid waste and 1:1 mixture of (a) and (b). Three 150 gallon reactors with periodic leachate recycling were used for anaerobic composting while three 50 gallon reactors produced an aerobic compost from the same wastes. Reactors were maintained for six months simulating the time between growing seasons. Volatile solids destruction ranged from 10.3 to 38.7%. Biogas production was ranged from 1350 to 1420 1 per k of volatile solids destroyed with a methane content of 55 to 70%. Leachate was monitored throughout for: pH, alkalinity, total and ammonia nitrogen, COD, TOC, total solids, volatile solids and four metals. MPN data was collected for various bacterial groups (total plate count, anaerobic cellulose decomposers, and anaerobic acid producers) to monitor increases and declines in the leachate bacterial population. Physical and chemical testing provided comparisons between finished anaerobic compost and aerobic compost from the same three waste samples.     

Effect of selected and non-selected urban waste compost on the initial growth of corn

Brazil produces approximately 242,000 t of waste per day, 76% of it being dumped outdoors and only 0.9% recycled, including composting, which is an alternative still little known in Brazil. In search of a better destination for residues produced by domestic activities, composting stands as a feasible alternative. Organic compost from waste may be used for various purposes, among which are soil recovery, commercial production, pastures, lawns and reforestry and agriculture. However, the quality of the compost determines the growth and the development of plants. The effect of compost made from urban waste on corn plant (Zea mays L.) growth was investigated. Two types of compost were used: the selected compost (SC), produced from organic waste selectively collected; and the non-selected compost (NSC), taken from a 15-year-old cell from the Canabrava land-fill, located in Salvador, Bahia, Brazil (altitude 51 m, 12°22′–13°08′S, 38°08′–38°47′W). Corn was seeded in polyethylene pots, with soil-compost mixing substrate in the proportion of 0, 15, 30, 45 and 60 t ha⁻¹ equivalent doses. Chemical analyses of the compost and growth properties of the plant like chlorophyll content; height and stem diameter; aerial and radicular dry biomasses, were used to evaluate compost quality. Plants cultivated with SC presented a superior gain, being of 52.5% in stem diameter, 71.1 and 81.2% in root and stem biomasses, respectively. Chlorophyl content alterations were observed in plants from treatments using 30 t compost ha⁻¹ dose onwards. Conventional and multivariate statistical methods were used to evaluate these results. The beneficial action of organic compost in plant growth was confirmed with this research.     

Fate of coliform bacteria in composted beef cattle feedlot manure

The link between livestock production, manure management, and human health has received much public attention in recent years. Composting is often promoted as a means of sanitizing manure to ensure that pathogenic bacteria are not spread to a wider environment during land application. In a two-year study (1998 and 1999) in southern Alberta, we examined the fate of coliform bacteria during windrow composting of cattle (Bos taurus) manure from feedlot pens bedded with cereal straw or wood chips. Numbers of total coliforms (TC) and Escherichia coli declined as the composting period progressed. In 1998, TC levels (mean of both bedding types) were log10 7.86 cells g(-1) dry wt. for raw manure on Day 0, log10 3.38 cells g(-1) by Day 7, and log10 1.69 cells g(-1) by Day 14. More than 99.9% of TC and E. coli was eliminated in the first 7 d when average windrow temperatures ranged from 33.5 to 41.5 degrees C. The type of bedding did not influence the numbers of TC or E. coli. Dessication probably played a minor role in coliform elimination, since water loss was low (< 0.07 kg kg(-1)) in the first 7 d of composting. However, total aerobic heterotroph populations remained high (> 7.0 log10 CFU g(-1) dry wt., where CFU is colony forming units) throughout the composting period, possibly causing an antagonistic effect. Land application of compost, with its nondetectable levels of E. coli compared with raw manure, should minimize environmental risk in areas of intensive livestock production.     

Comparison of heavy metals content in compost against vermicompost of organic solid waste: Past and present

Disposal of the municipal organic solid waste is a serious problem worldwide. Composting is one of the most preferred methods of solid waste management practice, principally due to the high percentage of organic material in the waste composition. Composting has advantages over land-filling and incineration in Mauritius because of lower operational costs, less environmental pollution, beneficial use of the end product, high humidity and organic content of household waste. Vermicomposting is a comparatively enhanced method in composting, and involves the stabilization of organic solid waste through earthworm consumption that converts the waste into earthworm castings. In both composting and vermicomposting processes, the presence of heavy metals and different toxics substances limits its land use without processing. The production and application of compost potentially contaminate the environment with heavy metals. There is a high-degree of consensus in the past and present literatures that composting increases metal concentrations but whether similar changes in metal concentration and availability occur during vermicomposting has not been fully resolved. This review deals with various total metal contents present in composting compared to that present in vermicomposting of organic solid wastes from past and present years.     

Environmental assessment of two home composts with high and low gaseous emissions of the composting process

A Life Cycle Assessment (LCA) of two home composts with low and high gaseous emissions of the composting process is presented. The study focused on the gaseous emissions of the composting process. Gaseous emissions of methane, nitrous oxides, ammonia and volatic organic compounds of the composting process were experimentally measured in field real trials. The results showed that the differences in gaseous emissions between the two home composts were 4.5, 5.8 and 52 for methane, nitrous oxides and ammonia, respectively. Higher emissions of nitrous oxides and methane affected significantly the category of global warming potential, while higher emissions of ammonia affected mainly the categories of acidification potential, eutrophication potential and photochemical oxidation. The differences found in the compost emissions were attributable to the composting production management (quality and composition of waste stream, frequency mixing of waste, humidity and temperature monitoring, among others) as well as weather conditions (temperature and humidity).     

Quality assessment of composts in the Greek market: the need for standards and quality assurance

An extensive data survey and study of the Greek market for composts or products marketed as such was carried out in order to acquire a comprehensive image of the local situation, in view of the proposed operation of large municipal solid waste (MSW) composting facilities and EU legislation changes. Physical and chemical parameters (moisture, organic matter, electrical conductivity, pH and heavy metals), stability indicators (self-heating potential, germination index) and biological indicators (microbial population, pathogen indicators and selected pathogens) were analyzed for the assessment of product quality. Results revealed wide variations even within the same group of products, which is particularly significant for parameters directly related to environmental protection and public health. The heavy metal content ranged from levels exceeding the fairly lenient Greek standards to below the stringent limits for A+ class compost in Austria. About 25% of the composts examined met the heavy metal limits for the EU eco-label award. Salmonella spp. was not detected in any of the composts but Staphylococcus aureus and Clostridium perfringens were found in 17 and 96% of the composts respectively. Pathogen indicator microorganisms were present at levels above suggested limits in all the composts. The high variability of such important parameters in composts available on the Greek market suggests an urgent need for establishing quality assurance procedures and mechanisms in the country. Moreover, the wide range of limit values within EU member states suggests the need for developing EU compost quality standards, in order to harmonize the compost markets.     

Biological recycling of used baby diapers in a small-scale composting system

In Mexico used disposable diapers account for 6.5% of the urban waste that is sent to landfills, as no alternative treatment or valorization options is available. Due to their mixed organic–inorganic composition, they are usually perceived as a problematic non-biodegradable waste; nevertheless, due to their high cellulose content they could be recycled biologically in order to recover the nutrients present in them. This research assessed the feasibility of composting them along with yard waste, in 200 L bioreactors. An initial mixture of fresh trims of grass (55%), dry leaves (10%), fresh leaves (15%) and mulch (20%) was prepared and characterized to achieve an adequate C/N relationship. In the selected reactors 30% (mass basis) of previously shredded used baby diapers containing urine was added. The composting process lasted three months. Temperature, moisture, pH, nitrogen, CO₂ production, organic matter, C/N ratio, volume and mass reduction were measured and recorded periodically. The composting process was not affected by the presence of diapers. Temperature rose to 60–70 °C in the initial thermophilic phase, and reached a final plateau of 20–30 °C. The initial high temperatures allowed to eliminate the pathogens, as shown in the microbiological tests. Volume and mass of the substrates decreased more than 50% by the end of the process. Mass reduction for diapers was 87%, and only the plastic films were recovered. The final compost had good quality and accomplished with the limits set in the local regulation, except by pH, which has slightly above the set limit. It can be used as a soil amendment, as shown in the phytotoxicity tests performed using tomato. The results show that this is a feasible, affordable option for the valorization of used disposable diapers, which could be applied in small communities or daycare centers.