问歇曝气周期对低C/N比污水生物脱氮的影响

研究了间歇曝气生物脱氮工艺中,曝气周期和污水的c/N比对脱氮效率的影响,以及氧化还原电位(ORP)变化规律.中试试验结果表明,TN污泥负荷为0.05 kg/(kg MLVSS.d)时,间歇曝气系统的硝化反应所需曝气时间与总反应时间比至少要在0.5以上,一周期内搅拌时间不宜超过1 h;反硝化过程中难以找到ORP曲线突变点,因此,在低c/N比污水生物脱氮中ORP难以作为工程控制参数;由于原水的碳氮比太低,TN去除率只有35%～40%左右,为提高脱氮效率有必要投入外加碳源.     

Swine wastewater treatment using attached-growth and suspended-growth two stage sequencing batch reactors with real-time control.

Two two-stage sequencing batch reactors (TSSBR), one attached-growth and one suspended-growth, were operated under three levels of wastewater concentration (approximately 4,000, 2,000 and 500 TOC mg/L), respectively, to compare the pH and ORP (oxidation-reduction potential) patterns and system performance. In both TSSBR systems, the pH and ORP profiles varied with organic loading yet exhibited consistent patterns with distinctive features suitable for real-time control. For all runs at the three levels of influent, both systems achieved similar levels of treatment for BOD5, TOC and TSS of over 97.5, 93.4, and 97.3%, respectively. The attached-growth system out performed the suspended-growth system in achieving the same levels of treatment at much shorter aeration cycle times. The treatment efficiency for NO3(-)-N and PO4(-3) was greatly affected by the carbon content in the wastewater, and the best treatment was achieved during the TOC approximately 4,000 mg/L runs with final effluent at 4.0 and 21.3 mg/L, respectively.     

The ORP and pH profiles during simultaneous nitrification and denitrification of low carbon municipal wastewater

The ORP and pH profiles and the stability of Simultaneous Nitrification and Denitrification (SND) for low carbon municipal wastewater treatment were investigated under the different aeration modes in Sequencing Batch Reactor (SBR). The results showed that the 92% removal efficiency for TN, the smallest average level of ORP and both of the variation of ORP and pH values are achieved in Intermittent Aeration (IA) with 0.5 aeration fraction and high air-on frequency. These results suggested that IA with small aeration fraction and high air-on frequency favourable for the stable SND. The average level of ORP fluctuation range and the stability of ORP and pH values are all beneficial for the stable and complete degree of SND.     

Optimization of enhanced biological phosphorus removal after periods of low loading.

Enhanced biological phosphorus removal is a well-established technology for the treatment of municipal wastewater. However, increased effluent phosphorus concentrations have been reported after periods (days) of low organic loading. The purpose of this study was to evaluate different operating strategies to prevent discharge of effluent after such low-loading periods. Mechanisms leading to these operational problems have been related to the reduction of polyphosphate-accumulating organisms (PAOs) and their storage compounds (polyhydroxy alkanoates [PHA]). Increased effluent phosphorus concentrations can be the result of an imbalance between influent loading and PAOs in the system and an imbalance between phosphorus release and uptake rates. The following operating conditions were tested in their ability to prevent a reduction of PHA and of overall biomass during low organic loading conditions: (a) unchanged operation, (b) reduced aeration time, (c) reduced sludge wastage, and (d) combination of reduced aeration time and reduced sludge wastage. Experiments were performed in a laboratory-scale anaerobic-aerobic sequencing batch reactor, using acetate as the carbon source. Without operational adjustments, phosphorus-release rates decreased during low-loading periods but recovered rapidly. Phosphorus-uptake rates also decreased, and the recovery typically required several days to increase to normal levels. The combination of reduced aeration time and reduced sludge wastage allowed the maintenance of constant levels of both PHA and overall biomass. A mathematical model was used to explain the influence of the tested operating conditions on PAO and PHA concentrations. While experimental results were in general agreement with model predictions, the kinetic expression for phosphorus uptake deviated significantly for the first 24 hours after low-loading conditions. Mechanisms leading to these deviations need to be further investigated.     

以剩余污泥水解酸化液为外加碳源的污水生物脱氮

为解决低碳氮比污水生物脱氮过程反硝化碳源不足的问题,利用剩余污泥水解酸化液为外加碳源,通过具有曝气段与非曝气段的一体化曝气生物滤池（BAF）,研究低碳氮比污水生物脱氮的性能与工艺条件。实验结果表明,预处理后的水解酸化液VFAs为3134．9～5251．4mg／L、ThODVFAs／COD为59．87％～91．85％,适合作为生物脱氮的外加碳源;水解酸化液的投配量、进水TN浓度对系统生物脱氮效果的影响较大,气水比、曝气段与非曝气段比例对系统的硝化和反硝化性能有重要的影响;在温度为25±1℃,水解酸化液COD平均为7555．1mg／L,进水TN、NH4-N和COD分别平均为43．88mg／L、39．04mg／L和56．8mg／L,碳源与污水投配的流量比为1：75的条件下,当BAF水力停留时间（HRT）为8h、曝气段与非曝气段比例为3：3、气水比为10：1、回流比为2：1时,NH4-N和TN的去除率分别超过98％和75％,出水COD平均为28．6mg／L。研究指出,剩余污泥水解酸化液经过预处理后可用作低碳氮比污水生物脱氮的外加碳源,有效地提高了反硝化效果,并不会造成二次污染,同时又可以实现剩余污泥的减量化和资源化。     

Oxidation-reduction potential changes in aeration tanks and microprofiles of activated sludge floc in medium- and low-strength wastewaters.

Real-time control of aeration tank operation is key to high-efficiency pollutant removal and energy savings. One of the aims of this study was to examine the potential for using redox potential (oxidation-reduction potential [ORP]) to indicate wastewater quality online in aeration tanks treating medium (chemical oxygen demand [COD] of 70 to 150 mg/L) and low (COD of 15 to 30 mg/L) pollutant-concentration wastewaters. The field-scale data provide a good relationship between ORP values and nutrient removal along the length of the aeration tanks. The ORP values increased dramatically as organic matter was removed along the aeration tanks, indicating the improvement of the bulk liquor redox status. Dissolved oxygen higher than 1.0 mg/L was necessary for good biodegradation and improvement of the liquid redox status. Nitrification occurred at higher ORP values (380 to 420 mV) than was the case for organic substrate oxidation (250 to 300 mV). The microprofiles obtained from microelectrode measurements substantiate the heterogeneity of the microbial processes inside activated sludge flocs. Because of microbial oxygen utilization, the aerobic region in the activated sludge floc was limited to the top layer (0.1 to 0.2 mm) of the activated sludge aggregate present in medium-strength wastewater, with an anoxic zone dominating inside the flocs. When dissolved oxygen in the bulk water was higher than 4.0 mg/L, the anoxic zone inside the floc disappeared. At low wastewater pollutant concentrations, the ORP and dissolved oxygen inside the activated sludge aggregates were higher than those from medium-strength wastewater. The prospect of using ORP as an online control approach for aeration tank operation and the potential reasons for activated sludge floc size varying with pollutant strengths are also discussed.     

生物脱氮工艺控制优化策略的研究进展

针对传统的单污泥生物脱氮系统具有所需反应器体积大、硝化反硝化效率低及对进水COD利用率低等一系列问题 ,总结了提高生物脱氮工艺效率的在线控制策略 ,如曝气控制、外投碳源控制和污泥龄控制 (SRT) ,为当前污水厂在工艺设计一定的限制性条件下进行在线优化以满足日益严格的排放标准提供了重要保证。     

SBR法短程硝化-反硝化生物脱氮工艺的研究

针对目前传统生物脱氮工艺存在的问题 ,结合国内外在该方向的研究现状 ,以实际豆制品废水为研究对象 ,控制反应器内混合液温度在 31± 0 .5℃的条件下 ,实现了短程硝化 反硝化生物脱氮工艺 ,NO-2 N NOx N的比率始终维持在90 %以上。并在此试验基础上 ,考察了曝气时间对反应器内氮形态变化的影响及系统对进水COD和NH3 N浓度的抗冲击负荷能力。结果显示 ,曝气时间对硝化效果影响较大 ,同时 ,本工艺具有较强的抗冲击负荷能力。     

Swine wastewater treatment in a two stage sequencing batch reactor using real-time control

A laboratory scale two-stage sequencing batch reactor (TSSBR) was used to study the effectiveness of pH as a real-time control parameter in swine wastewater treatment. A Ringlace media was inserted into the A/O (Anoxic/Oxic) reactor for bacteria immobilization. The TSSBR was subjected to three levels of organic loading. The pH and ORP (Oxidation Reduction Potential) patterns obtained were consistent with distinct features, enabling the real-time control strategy to effectively set a flexible aeration time pending on influent concentration, hence resulting in flexible cycle time and HRT (Hydraulic Retention Time) for the system. The real-time process ensured a removal efficiency of over 99% and 95%, respectively, for ammonia and TOC (Total Organic Carbon). For NO3(-)-N and PO4(-3), the run with influent TOC = 4,000 mg/L yielded the most efficient removal of 61% and 95%, respectively. Test results suggest that pH can be a viable tool for on-line real-time control of a biological treatment process.     

Simultaneous nitrification, denitrification, and phosphorus removal in single-tank low-dissolved-oxygen systems under cyclic aeration.

Simultaneous nitrification and denitrification (SND or SNdN) may occur at low dissolved oxygen concentrations. In this study, bench-scale (approximately 6 L) bioreactors treating a continuous feed of synthetic wastewater were used to evaluate the effects of solids retention time and low dissolved oxygen concentration, under cyclic aeration, on the removal of organics, nitrogen, and phosphorus. The cyclic aeration was carried out with repeated cycles of 1 hour at a higher dissolved oxygen concentration (HDO) and 30 minutes at a lower (or zero) dissolved oxygen concentration (LDO). Compared with aeration at constant dissolved oxygen concentrations, the cyclic aeration, when operated with proper combinations of HDO and LDO, produced better-settling sludge and more complete nitrogen and phosphorus removal. For nitrogen removal, the advantage resulted from the more readily available nitrate and nitrite (generated by nitrification during the HDO period) for denitrification (during the LDO period). For phosphorus removal, the advantage of cyclic aeration came from the development of a higher population of polyphosphate-accumulating organisms, as indicated by the higher phosphorus contents in the sludge solids of the cyclically aerated systems. Nitrite shunt was also observed to occur in the LDO systems. Higher ratios of nitrite to nitrate were found in the systems of lower HDO (and, to less dependency, higher LDO), suggesting that the nitrite shunt took place mainly because of the disrupted nitrification at lower HDO. The study results indicated that the HDO used should be kept reasonably high (approximately 0.8 mg/L) or the HDO period prolonged, to promote adequate nitrification, and the LDO kept low (< or =0.2 mg/L), to achieve more complete denitrification and higher phosphorus removal. The above findings in the laboratory systems find strong support from the results obtained in full-scale plant implementation. Two plant case studies using the cyclic low-dissolved-oxygen aeration for creating and maintaining SND are also presented.     

Numerical simulation of a fine-grained denitrification layer for removing septic system nitrate from shallow groundwater

One of the most common methods to dispose of domestic wastewater involves the release of septic effluent from drains located in the unsaturated zone. Nitrogen from such systems is currently of concern because of nitrate contamination of drinking water supplies and eutrophication of coastal waters. It has been proposed that adding labile carbon sources to septic distribution fields could enhance heterotrophic denitrification and thus reduce nitrate concentrations in shallow groundwater. In this study, a numerical model which solves for variably saturated flow and reactive transport of multiple species is employed to investigate the performance of a drain field design that incorporates a fine-grained denitrification layer. The hydrogeological scenario simulated is an unconfined sand aquifer. The model results suggest that the denitrification layer, supplemented with labile organic carbon, may be an effective means to eliminate nitrogen loading to shallow groundwater. It is also shown that in noncalcareous aquifers, the denitrification reaction may provide sufficient buffering capacity to maintain near neutral pH conditions beneath and down gradient of the drain field. Leaching of excess dissolved organic carbon (DOC) from the denitrification layer is problematic, and causes an anaerobic plume to develop in simulations where the water table is less than 5-6 m below ground surface; this anaerobic plume may lead to other down gradient changes in groundwater quality. A drain field and denitrification layer of smaller dimensions is shown to be just as effective for reducing nitrate, but has the benefit of reducing the excess DOC leached from the layer. This configuration will minimize the impact of wastewater disposal in areas where the water table is as shallow as 3.5 m.     

SFBR工艺顺序进行硝化和反硝化的动力学研究

采用序半连续式反应器(sequencing fed-batch reactor,简称SFBR)对人工合成废水顺序地进行硝化和反硝化动力学进行了研究.硝化和反硝化所用微生物为活性污泥.反应器在不同的操作条件进行操作,获得了用于确定动力学常数的数据;获得动力学参数um=0.05 h-1,KNO=2.0 mg/L,y=0.47 mg X/mg N,a=0.001 h-1.类似地确定了反硝化动力学参数kD=0.01 h-1和KD,NO=0.4 mg/L.在一定范围内硝化和反硝化速率随着氨浓度和硝酸盐浓度的增加而增加.实验数据表明,硝化和反硝化的动力学符合Monod动力学方程.     

Interactive effects of nitrogen and phosphorus loadings on nutrient removal from simulated wastewater using Schoenoplectus validus in wetland microcosms

The concentrations of nutrients (N and P) in the wastewater and loading rate to the constructed wetlands may influence the nutrient removal from the secondary-treated municipal wastewater using wetland plants. Three loading rates of N (low 5.7, medium 34.3 and high 103 mg N d(-1)) and two of P (low 3.4 and high 17.1 mg P d(-1)) were studied in simulated secondary-treated municipal wastewater using Schoenoplectus validus (Vahl) A. L?ve & D. L?ve in the vertical free surface-flow wetland microcosms. After 70-d growth, there were significant interactive effects of N and P on the total, above-ground and root biomass. The below-ground biomass (rhizome and root) was negatively affected by the high N treatment. The tissue concentrations of N increased with an increase in N additions and decreased with an increase in P applications, whereas the tissue concentrations of P increased with an increase in P additions and decreased with an increase in N applications at the low P treatment, but increased at the high P treatment. Significant interactive effects of N and P loadings were found for the removal efficiencies of NH(4) and P, but not that of NO(x). The plant uptake, substrate storage and other losses (e.g. denitrification and formation of organic film) had similar contribution to N removal when N loading was relatively low. The P storage by substrate was the main contribution to P removal when P loading was high, but plant uptake was the major factor responsible for P removal when P loading was low and N loading was high. The high nutrient availability and optimum ratio of N:P are required to stimulate growth of S. validus, resulting in preferential allocation of resources to the above-ground tissues and enhancing the nutrient removal efficiencies, but the high N concentration in wastewater may hamper the growth of S. validus in constructed wetlands.     

A novel design for anaerobic chemical oxygen demand and nitrogen removal from leachate in a semiaerobic landfill

The removal capacity of carbon and nitrogen from an artificial leachate was evaluated by using laboratory-scale columns, and a design was proposed to remove nitrogen more efficiently from a semiaerobic landfill. Five columns (i.e., two artificial municipal waste columns under anaerobic and semiaerobic conditions, an artificial construction waste column under semiaerobic conditions, and two crushed stone columns under anaerobic and semiaerobic conditions) were used. The influent load rates of organics [g chemical oxygen demand (COD)/m3 x day], NH4+, NO3- and aeration conditions for the columns were varied, and the removal capacities of the columns for COD, NH4+-N, and NO3--N were measured. Among the packed column materials, crushed stone was shown to be most effective in removing COD, NH4+ N, and NO3--N from artificial leachate. Average removal rates of crushed column under the semiaerobic condition (column D) for COD and NH4+-N were estimated at about 150 g COD/m3 x day and 20 g COD/m3 x day, while those of crushed column under anaerobic condition (column E) for COD and NO3--N at about 400 and 150 g COD/m3 x day, respectively. It also was found that denitrification and nitrification reactions in column D occurred at the same time, and the ratio of denitrification to nitrification was estimated to be about 80%. Therefore, an anaerobic structure, which could be attached to the bottom of a main pipe in a semiaerobic landfill, is suggested to remove nitrogen and organic substances more effectively.     

Alternative solid carbon source from dried attached-growth biomass for nitrogen removal enhancement in intermittently aerated moving bed sequencing batch reactor

The feasibility of using dried attached-growth biomass from the polyurethane (PU) foam cubes as a solid carbon source to enhance the denitrification process in the intermittently aerated moving bed sequencing batch reactor (IA-MBSBR) during the treatment of low COD/N containing wastewater was investigated. By packing the IA-MBSBR with 8 % (v/v) of 8-mL PU foam cubes saturated with dried attached-growth biomass, total nitrogen removal efficiency of 80 % could be achieved for 10 consecutive cycles of operation when the intermittent aeration strategy of consecutive 1 h of aeration followed by 2 h of non-aeration period during the REACT period of the IA-MBSBR was adopted. Negligible release of ammonium nitrogen (NH₄ ⁺–N) and slow-release of COD from the dried biomass would ensure that the use of this solid carbon source would not further burden the treatment system. The slow-releasing COD was found to have no effect in promoting the assimilation process and would also allow the carbon source to be used for many cycles of operation. The ‘carbon-spent’ PU foam cubes could be reused by merely drying at 60 °C at the end of the operational mode. Thus, the dried attached-growth biomass formed on the PU foam cubes could be exploited as an alternative solid carbon source for the enhancement of denitrification process in the IA-MBSBR.     

Treatment efficiency and stoichiometry of a high-strength graywater.

The transit mission wastewater may represent a future graywater, in which toilet waste is separated from other household waste streams, and dilution water is minimal. A loading rate study indicated that denitrification is stoichiometrically limited, and nitrification was kinetically limited. Denitrification stoichiometry was developed by deriving hypothetical molecular formulas of organic carbon inputs to be represented by the relative proportions of carbon, hydrogen, oxygen, and nitrogen. The derived stoichiometry was validated against experimental data by adjusting the values of fe and fs and multiplying the total dissolved organic carbon loss across the system by the overall R equation and then comparing the total nitrogen removed in the reaction to experimentally observed total nitrogen removal. The nitrification stoichiometry was similarly validated by multiplying the R equation by the ammonium-nitrogen removed and then comparing the NO(x)-N formed in the equation to actual NO(x)-N production values. The fs values for the denitrifying and nitrifying bacteria were 0.33 and 0.15, respectively.     

低COD/N-NH_4比废水的同时硝化反硝化生物处理策略

从生化反应计量学出发 ,提出了对低 COD/ N- NH4比废水可以通过控制营养配比、调控溶解氧浓度和控制生物硝化及生物反硝化 ,经过 NO- 2 途径进行同时硝化反硝化的生物处理策略。对香港低 COD/ N- NH4比的垃圾渗漏水用同时硝化反硝化处理的成功实例进行了讨论     

Hydraulic residence time effects on performance of an activated sludge unit treating wastewater containing dichlorophenol.

Wastewaters containing chlorophenol compounds are difficult to treat by biological means because of the toxic effects of those compounds on microorganisms. To investigate the adverse effects of chlorophenols on microorganisms, synthetic wastewater containing 2,4 dichlorophenol (DCP) was biologically treated in an activated sludge unit at different hydraulic residence times (HRTs) between 5 and 40 hours, whereas the feed chemical oxygen demand (COD), DCP concentrations, and sludge age were kept constant at 2500 +/- 50 mg/L, 150 mg/L, and 20 days, respectively. The resazurin method based on dehydrogenase activity was used for assessment of the feed and effluent wastewater toxicity. Percent COD, DCP, and toxicity removals increased, and the effluent COD, DCP, and toxicity levels decreased with increasing HRT. Biomass concentration in the aeration tank increased with increasing HRT because of low levels of DCP at high HRT levels, resulting in high COD, DCP, and toxicity removals. The sludge volume index decreased with increasing HRT, yielding well-settling organisms as a result of low levels of toxicity and high concentrations of active cells. Percent DCP and COD removals decreased with increasing specific DCP loading rate. The rates of DCP and COD removals showed a maximum at a low DCP concentration of 6 mg/L in the aeration tank, corresponding to a 25-hour HRT.     

优化控制SBR工艺处理养猪废水中试研究

采用优化控制SBR工艺对北京某种猪场的养殖粪尿污水进行了中试处理研究。所建立的自控系统通过ORP实时曲线上的“硝酸盐膝点”和pH实时曲线上的“氨谷点”分别对碳源投加和曝气时间进行优化控制,实现根据水质变化适当补充所需碳源,并有效节省曝气能耗。中试反应器10个月的连续运行结果表明,系统对于氨氮和COD的去除率分别达到97%和95%。     

High carbon monoxide concentrations during the rainy season in Campo Grande, in central Brazil

This work describes an event of unusually large mixing ratios of carbon monoxide, CO, observed during a typical rainy season time period in central Brazil, when concentrations are expected to be at low levels. CO measurements were performed in Campo Grande (20.02 degrees S; 54.5 degrees W), from July 2001 to October 2002, covering entire periods of the dry and wet seasons. From January to June, average CO was 131 parts per billion by volume (ppbv). During November/December, average CO is about 180 ppbv. On November 13, 521.9 and 565.6 ppbv were observed. It is shown that for this special event, in which there was practically no fire activity at or near the site, air parcels reaching the site were enriched with fire products from regions much further north, near the equatorial region, where the fire activity is delayed in time, compared to central Brazil.