Impact of separating dairy cattle excretions on ammonia emissions

About 80% of dairy cattle N intake is excreted in urine and feces. Urinary-N is about 75% urea, whereas fecal-N is mostly organic. Urinary-N (urea) can only be volatilized when it is hydrolyzed to ammonia (NH3) in a process catalyzed by urease, which is predominantly found in feces. Minimizing contact between urine and feces may be an effective approach to reducing urea hydrolysis and subsequent NH3 emissions. Previous studies have reported 5 to 99% NH3 emissions mitigation within barns from separation of feces and urine. The objective ofthis study was to compare NH3 emissions mitigation via separation of urine and feces in postcollection storage to a conventional scrape manure handling method where urine and feces are comingled. Laboratory scale studies were conducted to evaluate NH3 emissions from simulated postcollection storag of three waste streams: (i) idealistically separated feces and urine (no contact between urine and feces), (ii) realistically separated urine and feces (limited contact of urine and feces), and (iii) conventionally scraped manure (control). From the results of these studies, NH3 losses ranking in descending order was as follows: aggregate of realistically separated waste streams (3375.9 +/- 54.8 mg), aggregate of idealistically separated urine and feces (3047.0 +/- 738.0 mg), and scrape manure (2034.0 +/- 106.5 mg), respectively. Therefore, on the basis of these results, the extra effort of separating the waste streams would not enhance mitigation of NH3 losses from postcollection storage of the separated waste streams compared to the conventional scrape manure collection system.     

Functional classification of swine manure management systems based on effluent and gas emission characteristics

Gaseous emissions from swine (Sus scrofa) manure storage systems represent a concern to air quality due to the potential effects of hydrogen sulfide, ammonia, methane, and volatile organic compounds on environmental quality and human health. The lack of knowledge concerning functional aspects of swine manure management systems has been a major obstacle in the development and optimization of emission abatement technologies for these point sources. In this study, a classification system based on gas emission characteristics and effluent concentrations of total phosphorus (P) and total sulfur (S) was devised and tested on 29 swine manure management systems in Iowa, Oklahoma, and North Carolina in an effort to elucidate functional characteristics of these systems. Four swine manure management system classes were identified that differed in effluent concentrations of P and S, methane (CH4) emission rate, odor intensity, and air concentration of volatile organic compounds (VOCs). Odor intensity and the concentration of VOCs in air emitted from swine manure management systems were strongly correlated (r2 = 0.88). The concentration of VOC in air samples was highest with outdoor swine manure management systems that received a high input of volatile solids (Type 2). These systems were also shown to have the highest odor intensity levels. The emission rate for VOCs and the odor intensity associated with swine manure management systems were inversely correlated with CH4 and ammonia (NH3) emission rates. The emission rates of CH4, NH3, and VOCs were found to be dependent upon manure loading rate and were indirectly influenced by animal numbers.     

Methane production during storage of anaerobically digested municipal organic waste

Anaerobic digestion of source-separated municipal organic waste is considered feasible in Denmark. The limited hydraulic retention in the biogas reactor (typically 15 d) does not allow full degradation of the organic waste. Storage of anaerobically digested municipal organic waste can therefore be a source of methane (CH4) emission that may contribute significantly to the potential global warming impact from the waste treatment system. This study provides a model for quantifying the CH4 production from stored co-digested municipal organic waste and estimates the production under typical Danish climatic conditions, thus quantifying the potential global warming impact from storage of the digested municipal organic waste before its use on agricultural land. Laboratory batch tests on CH4 production as well as temperature measurements in eight full-scale storage tanks provided data for developing a model estimating the CH4 production in storage tanks containing digested municipal organic waste. The temperatures measured in separate storage tanks on farms receiving digested slurry were linearly correlated with air temperature. In storage tanks receiving slurry directly from biogas reactors, significantly higher temperatures were measured due to the high temperatures of the effluent from the reactor. Storage tanks on Danish farms are typically emptied in April and have a constant inflow of digested material. During the warmest months the content of digested material is therefore low, which limits the yearly CH4 production from storage.     

Ammonia stripping of biologically treated liquid manure

A prerequisite for efficient ammonia removal in air stripping is that the pH of the liquid to be stripped is sufficiently high. Swine manure pH is usually around 7. At pH 7 (at 20°C), only 0.4% of ammonium is in ammonia form, and it is necessary to raise the pH of swine slurry to achieve efficient ammonia removal. Because manure has a very high buffering capacity, large amounts of chemicals are needed to change the slurry pH. The present study showed that efficient air stripping of manure can be achieved with a small amount of chemicals and without strong bases like NaOH. Slurry was subjected to aerobic biological treatment to raise pH before stripping. This facilitated 8 to 32% ammonia removal without chemical treatment. The slurry was further subjected to repeated cycles of stripping with MgO and Ca(OH)(2) additions after the first and second strippings, respectively, to raise slurry pH in between the stripping cycles. After three consecutive stripping cycles, 59 to 86% of the original ammonium had been removed. It was shown that the reduction in buffer capacity of the slurry was due to ammonia and carbonate removal during the stripping cycles.     

降低聚丙烯酰胺尾气氨含量的可行性研究

在聚丙烯酰胺生产过程中,利用硫酸吸收含氨的工艺尾气所产生的废液不具有利用价值。改进后的治理措施为:水解工艺尾气从塔底部经过循环被吸收液吸收,吸收液直接与含氨气体逆向接触,含氨污染物进入液相,被吸收液吸收、中和并从气体中除去,然后进入塔上部除雾段,除去气体中携带的雾沫,以确保气体净化效率。经除氨处理后的气体被加工成成品。该工艺可以减小处理气体量,并降低了处理难度。     

山东省南四湖流域三次产业排污与全省平均水平比较研究

运用2001-2009年的阶段统计数据,选取单位农业增加值——农药、化肥使用量,单位工业增加值——工业废水排放量、工业COD排放量、工业氨氮排放量,第三产业增加值——生活废水排放量、COD排放量、氨氮排放量等系列水环境排污指标,对南四湖流域和山东省的产业排污状况进行了比较分析。分析结果显示:南四湖流域的工业排污总体上已得到良好的控制,但农业和第三产业还有待加强,南四湖流域内不同地市间存在一定差异性,今后的环保控制重点可因地制宜地选择。     

Determination of phosphorus speciation in dairy manure using XRD and XANES spectroscopy

Intensive manure application is an important source of diffuse phosphorus (P) pollution. Phosphorus availability from animal manure is influenced by its chemical speciation. The major objective of this study was to investigate the P speciation in raw and anaerobically digested dairy manure with an emphasis on the calcium (Ca) and magnesium (Mg) phosphate phases. Influent and effluent from an on-farm digester in Wisconsin were sampled and sieved, and the 25 to 53 microm size fraction was dried for X-ray powder diffraction (XRD) and P K-edge X-ray absorption near edge structure (XANES) analyses. Struvite (MgNH4PO4.6H2O) was identified in both the raw (influent) and anaerobically digested (effluent) manure using XRD. Qualitative analysis of P K-edge XANES spectra indicated that the Ca orthophosphate phases, except dicalcium phosphate anhydrous (DCPA) or monetite (CaHPO4), were not abundant in dairy manure. Linear combination fitting (LCF) of the P standard compounds showed that 57.0 and 43.0% of P was associated with DCPA and struvite, respectively, in the raw manure. In the anaerobically digested sample, 78.2% of P was present as struvite and 21.8% of P was associated with hydroxylapatite (HAp). The P speciation shifted toward Mg orthophosphates and least soluble Ca orthophosphates following anaerobic digestion. Similarity between the aqueous orthophosphate (aq-PO4), newberyite (MgHPO4.3H2O), and struvite spectra can cause inaccurate P speciation determination when dairy manure is analyzed solely using P K-edge XANES spectroscopy; however, XANES can be used in conjunction with XRD to quantify the distribution of inorganic P species in animal manure.     

Season and bedding impacts on ammonia emissions from tie-stall dairy barns

Federal and state regulations are being promulgated under the Clean Air Act to reduce hazardous air emissions from livestock operations. Few data are available on emissions from livestock facilities in the USA and the management practices that may minimize emissions. The objective of this study was to measure seasonal and bedding impacts on ammonia emissions from tie-stall dairy barns located in central Wisconsin. Four chambers each housed four Holstein dairy heifers (approximately 17 mo of age; body weights, 427-522 kg) for three 28-d trial periods corresponding to winter, summer, and fall. A 4x4 Latin Square statistical design was used to evaluate four bedding types (manure solids, chopped newspaper, pine shavings, and chopped wheat straw) in each chamber for a 4-d ammonia monitoring period. Average ammonia-N emissions (g heifer(-1) d(-1)) during summer (20.4) and fall (21.0) were similar and twice the emissions recorded during winter (10.1). Ammonia-N emissions accounted for approximately 4 to 7% of consumed feed N, 4 to 10% of excreted N, and 9 to 20% of manure ammonical N. Cooler nighttime temperatures did not result in lower ammonia emissions than daytime temperatures. Ammonia emissions (g heifer(-1) d(-1)) from chambers that contained manure solids (20.0), newspaper (18.9), and straw (18.9) were similar and significantly greater than emissions using pine shavings (15.2). Chamber N balances, or percent difference between the inputs feed N and bedding N, and the outputs manure N, body weight N, and ammonia N were 105, 90, and 89% for the winter, summer, and fall trials, respectively. Relatively high chamber N balances and favorable comparisons of study data with published values of ammonia emissions, feed N intake, and manure N excretion provided confidence in the accuracy of the study results.     

基于三角白化权函数的城市工业污染灰色聚类评估——以江苏省为例

以工业＂三废＂（废气、废水和固体废弃物）为研究对象,选取废气、二氧化硫、烟尘、粉尘、废水、化学需氧量（COD）、氨氮、固体废弃物和危险废弃物等9个具体指标建立城市工业污染评价指标体系。基于三角白化权函数,将江苏省13个城市的工业污染情况分成不同灰类进行综合聚类评估。研究表明,受规模效应、结构效应和广义技术效应的影响,南京、苏州和无锡属于相对严重污染,常州、镇江、扬州、泰州、南通、淮安和徐州属于一般污染,盐城、宿迁和连云港属于相对轻微污染。     

中温厌氧消化垃圾焚烧发电厂渗滤液的试验研究

采用逐渐提高有机负荷的半连续进料方式,研究中温(35℃左右)条件下,猪粪为接种物,厌氧消化焚烧发电厂垃圾渗滤液的消化规律。试验以5%为单位,由5%体积负荷渗滤液起开始填料,逐步提高至35%的体积负荷。试验进行的7个负荷,消化系统pH值稳定在7.2~7.8之间,碱度、氨氮浓度较高,分别在7803~17948 mg/L、673~1630 mg/L之间,为系统提供了良好的酸碱缓冲环境。低负荷时,VFA值较低,生物气中甲烷含量稳定在60%左右;高负荷时,随着渗滤液的加入,VFA值波动较大,甲烷含量也随VFA值的变化起伏波动(25%负荷时,甲烷含量出现峰值,高达75.5%)。消化系统共进料2800 mL渗滤液(即197.3 gCODCr),累计产气量83086 mL,平均每gCODCr产沼气约421.1 mL(平均gCODcr产甲烷约273.7 mL)。进水渗滤液CODCr浓度为70472 mg/L,实验结束时,消化液CODCr浓度降至3373 mg/L,CODCr去除率高达95.2%。     

Geographic information system based manure application plan

A geographic information system (GIS) based manure application plan has been developed for the site-specific application of animal waste to agricultural fields in the Westbrook sub-catchment of the Murray-Darling Basin, south-east Queensland, Australia. Sites suitable for animal waste application were identified using a GIS based weighted linear combination (WLC) model. The degree of land suitability for animal waste application was determined using a range of social, economic, environmental, and agricultural factors. As eutrophication and toxic blue-green algae blooms are a known problem in the catchment, the manure application rates were limited to the rate of crop phosphorus removal. Maximum manure application rate was calculated spatially by taking the crop nutrient (P2O5) requirement and the manure nutrient (P2O5) content into account. The environmental suitability of the fields receiving animal waste was considered in prescribing the final application rate of solid and liquid manures generated by local animal production facilities. The degree of site suitability of the agricultural fields was also used to suggest manure management practices to minimise the socio-environmental risks and increase the nutrient use efficiency of the applied manure. The amount of ammonium nitrogen (NH4-N) that would be added to the soil by satisfying the P2O5 requirement using manure sources was also calculated and an applied NH4-N map was created. This map could be used to assist farmers identify additional nitrogen requirements after manure application.     

工业园区污水处理工艺的运行及完善探讨

本文对某工业园区的综合废水处理工艺开展了连续两年的运行调查,进行了其工艺完善及提标改造的技术探讨。研究表明,改造前该污水处理装置的出水COD、BOD5、总磷、SS均能达到排放标准,而唯独出水氨氮处理效果差,难以达到一级排放标准要求。通过增设预处理水解装置、生物氧化装置导流墙容积比改进、生物塘深度处理工艺完善后,能够保证出水氨氮的处理效果且能达到一级A排放标准。     

Assessment of manure phosphorus export through turfgrass sod production in Erath County, Texas

A best management practice (BMP) for exporting manure phosphorus (P) in turfgrass sod from the North Bosque River (NBR) watershed in central Texas was assessed using a geographic information system (GIS). The NBR watershed has a mandate to reduce the total annual P load to the NBR by 50% as a result of total maximum daily load regulation. Since dairy waste applications to fields are identified as the major nonpoint source of P to the river, innovative BMPs, such as export of manure P in turfgrass, will be needed to achieve the 50% reduction. However, methods are needed to evaluate the feasibility of these innovative management practices prior to their implementation. A geospatial database of suitable turfgrass production sites was developed for Erath County using GIS. Erath County largely encompasses the upper portion of the NBR watershed. Information from field experiments, production practices, and ground-truthing was used to search, analyze, and verify a geospatial database developed from national and regional sources. The integration and analyses of large databases supports the search by turf producers for sites suitable for turfgrass sod production in Erath County. In addition, GIS enables researchers and regulators to estimate manure P exports and reduced P loading due to implementation of the manure export BMP on a county scale. Under optimal conditions 198,000 kg manure P yr(-1) could be used and 114,840 kg manure P yr(-1) exported from the NBR watershed through implementation of a system using dairy manure to produce turfgrass sod. This is the equivalent of the manure P applied from 10,032 dairy cows yr(-1) and exported from 5808 dairy cows yr(-1). Application of GIS to large-scale planning and decision-making transcends traditional field-scale applications in precision agriculture.     

Oxygen distribution and potential ammonia oxidation in floating, liquid manure crusts

Floating, organic crusts on liquid manure, stored as a result of animal production, reduce emission of ammonia (NH3) and other volatile compounds during storage. The occurrence of NO2- and NO3- in the crusts indicate the presence of actively metabolizing NH3-oxidizing bacteria (AOB) which may be partly responsible for this mitigation effect. Six manure tanks with organic covers (straw and natural) were surveyed to investigate the prevalence and potential activity ofAOB and its dependence on the O2 availability in the crust matrix as studied by electrochemical profiling. Oxygen penetration varied from <1 mm in young, poorly developed natural crusts and old straw crusts, to several centimeters in the old natural crusts. The AOB were ubiquitously present in all crusts investigated, but nitrifying activity could only be detected in old natural crusts and young straw crust with high O2 availability. In old natural crusts, total potential NH3 oxidation rates were similar to reported fluxes of NH3 from slurry without surface crust. These results indicate that old, natural surface crusts may develop into a porous matrix with high O2 availability that harbors an active population of aerobic microorganisms, including AOB. The microbial activity may thus contribute to a considerable reduction of ammonia emissions from slurry tanks with well-developed crusts.     

Toxicity of ozonated animal manure to the house fly, Musca domestica

Swine manure slurries were ozonated at a dosage of 1 g/L and tested for their toxicity to the house fly (Musca domestica). The observed toxicity of ozonated swine manure was consistent and independent of origin of the swine manure. A dose (dilution) response curve was performed. A 50% dilution in the ozonated swine manure slurry resulted in 90% reduction in toxicity. Neither the synthetic nor ozonated synthetic swine manure, both of which contained higher concentrations of formaldehyde and three other unidentified carbonyl compounds than the ozonated swine manure, were toxic to the flies. Ozonated swine manure slurry was centrifuged and passed through a 0.45-microm filter. The liquid phase was as toxic as the unfiltered slurry; as such, the toxicant appears to be present in liquid phase. Neither ammonia, hydrogen sulfide, formaldehyde, nor other simple aldehydes appeared to be the toxic agent. The toxic agent appears to be a polar chemical compound and is concentrated in the urine. Several possible compounds have been identified. The toxicity of untreated and ozonated manure slurries from different livestock was compared. Six animal manure slurries (beef and dairy cattle, horse, poultry, sheep, and swine) were ozonated (dosage of 1 g/L) and tested for toxicity to the house fly. Ozonated dairy cattle manure slurry showed 78% mortality after 72 h, whereas ozonated swine manure slurry achieved a 100% mortality rate in 48 h. Neither the unozonated dairy nor swine manure slurries, nor any of the other raw or ozonated manure slurries, were toxic to the flies.     

Evaluation of zeolite for control of odorants emissions from simulated poultry manure storage

Poultry operations are associated with emissions of aerial ammonia (NH3), volatile organic compounds (VOCs), and odor, and the magnitude of emissions is influenced by manure management practices. As a manure treatment additive, zeolites have been shown to have the potential to control NH3. Because of their properties it is also expected that zeolites could effectively adsorb VOCs and odor. The effectiveness of zeolite in controlling odor and VOCs was qualitatively evaluated in this controlled laboratory study involving simulated poultry manure storage. In the first two trials, zeolite was topically applied on nearly fresh laying hen manure at the rates of 0, 2.5, 5, and 10% (by weight). In the third trial, zeolite was topically applied at 5% with each addition of fresh manure into the storage vessel. Headspace samples from the emission vessels were collected with solid phase microextraction (SPME) and analyzed on a multidimensional-gas chromatograph-mass spectrometry-olfactometry (MDGC-MS-O) system for identification and prioritization of poultry manure odorants. Acetic acid, butanoic acid, isovaleric acid, indole, and skatole were consistently controlled in the headspace, with the reduction rate being proportional to the zeolite application rate. Dimethyl trisulfide and phenol were consistently generated, and with a few exceptions, the rate of generation was proportional to the application rate. Average reduction of the odor caused by all odorants evaluated with SPME-GC-O was 67% (+/-12%) and 51% (+/-26%) for the two topical applications, respectively, while no significant reduction of VOCs and odor was detected for the layered application.     

Quantitative sustainability assessment of remanufacturing waste reinforcing steel

Construction is a major contributor to the solid waste stream globally and various recycling strategies are being evaluated to recover valuable resources. As a novel strategy, remanufacturing waste reinforcing steel bar (rebar) pieces from concrete waste to produce nails was applied on an industrial scale to prove the technical feasibility, where a group of alternatives were developed based on commercially available industrial machinery. The calculated economic and environmental feasibility values are sufficiently high for industrial application, and the most appropriate remanufacturing technological alternative was identified. The sustainability equation was solved to find the social feasibility and overall remanufacturing sustainability index. Rebar waste remanufacturing has a high triple-bottom-line sustainability index of 0.885. Based on the proposed process, small remanufacturing companies can be developed, thereby aiding employment and human development by earning profit of 1904–8880 USD/day. The findings of this study are beneficial to decision makers in government and industry and are globally relevant because concrete waste is ubiquitous worldwide.     

Final treatment for cattle manure using immobilized microalgae. II. Influence of the recirculation

Some studies have been done dealing with cattle manure treatment, but literature scarcely reports the use of immobilized microalgae as final treatment of this waste. Recently, a complete technology for cattle manure treatment was established, including immobilized microalgae. The influence of the recirculation in the efficiency of the immobilized microalgae process was evaluated.     

滨海新区大港农业非点源污染状况研究简

立足天津市滨海新区大港农业背景情况,采用适宜的方法,分别从种植业、畜禽养殖和水产养殖业三方面分析非点源污染物排放量。结果表明：2010年大港地区农业非点源主要污染物COD排放量为377.67 t,氨氮排放量为72.33 t,畜禽养殖排放的污染已占农业非点源污染的一半以上。在此基础上,分别从优化畜禽养殖的养殖模式、种植业科学施用化学品、水产养殖合理投放饲料等方面提出了大港地区农业非点源污染控制的对策。     

上海市污泥集装化运输可行性研究

随着上海市生活垃圾集装化运输系统的逐步完善和发展,上海市污泥的集装化运输逐渐被提上日程。本文通过对上海市中心城区的10座城市污水处理厂的污泥产量、污泥含水率、污泥运输道路和装卸环境等进行系统调研,综合分析和研究了上海市各污水处理厂污泥集装化运输的可行性,并进一步研究了污泥性质对集装化运输的影响。结果表明,上海市中心城区仅白龙港污水处理厂含水率约为60%的深度脱水污泥符合污泥集装化运输的要求;深度脱水污泥性质较为稳定,对各种钢材料的腐蚀性为0.00016~0.00125 mm/a,对集装化运输影响较小,但污泥释放的氨气浓度高达173.66 mg/m3,影响集装化运输,需采取水雾喷洒等措施进行控制。