Photocatalytic decolourization of reactive dyes

The photocatalytic degradation of reactive dyes with solar-irradiated TiO2 was investigated in these experiments which showed that: (1)the decolourization efficiency are determined by pH value, catalyst amount and light intensity; (2) the reactive dyes decolourized rapidly (cleavageld be biologically degradated more easily, the toxicity decreased considerably after photodegradation.The results demonstrated that the photocatalytic process would become an efficient and safe method for colour wastewater treatment and would be very useful for explaining the reaction mechanism and decolourising structure-reactivity relationship. of the azo linkage), but the intermediates needed more time to transform to further degradation products, and finally to produce CO2; (3) the main products were identified to be alkanes and alkyl amines which cou     

TiO2纳米膜光催化深度处理城市污水的实验研究

采用溶胶-凝胶方法制备光催化性能优良的TiO2纳米膜,应用X射线衍射仪分析了TiO2纳米膜的结构,探讨了铁离子和贵金属Ag、Pt掺杂对TiO2纳米膜光催化降解性能的影响,研究了TiO2纳米膜及掺杂改性TiO2纳米膜对生物二级处理系统出水中有机物光催化去除的性能。贵金属Ag、Pt掺杂提高了TiO2纳米膜光催化性能,而铁离子掺杂则降低了其催化性能。未掺杂的TiO2纳米膜使二级出水的COD下降8.9%,而贵金属Ag、Pt掺杂的TiO2纳米膜则使COD分别下降19.4%和22.3%。实验结果表明TiO2纳米膜有优良的光催化降解性能,TiO2纳米膜有广阔的应用前景。     

锰过氧化物酶的固态发酵及其对染料的脱色作用

采用稻壳作为基质,利用裂褶菌F17固态发酵产锰过氧化物酶(MnP),通过正交实验对发酵条件进行优化,并对5种不同结构类型的染料进行脱色.结果显示,含水率、温度、Mn2 、Cu2 对裂褶菌F17产MnP有显著影响;MnP发酵的最优化条件为稻壳27g、黄豆粉3g、MnSO40.4mg·g-1、含水率150%、接种量50%、培养温度22℃,pH不调节,优化后酶活达到16.39 U·g-1,比优化前的酶活9.20 U·g-1提高了78.2%.优化后的发酵体系对染料刚果红、茜素红、Poly R-478、中性红和结晶紫的24h脱色率分别达到92.6%、90.3%、93.1%、87.3%和95.6%.     

非离子表面活性剂在人工光源辐照下的光催化降解

在光催化氧化对5种典型非离子表面活性剂（NIS）和实际印染废水中NIS的去除效果的实验中,未见TiO₂有明显催化作用．光解30min,几种NIS的光降解率均达60％以上．NIS的光降解速率受NIS浓度和DO的影响较小;pH值降低有利于NIS的光降解,而在中性或弱酸性条件下,NIS光降解效率仍较好;投加H₂O₂可提高NIS的光降解速率,最适投加量为4.4×10^-4mol/L．对于实际印染废水,NIS的光降解去除率比生化法高且处理时间短得多,同时对COD、MBAS亦有较好的去除效果,表明光催化氧化是一项很有前途的NIS处理技术．     

负载型纳米TiO2/AC对偶氮染料的光催化降解研究

以钛酸四丁酯和粒状活性炭(AC)为主要原料,采用溶胶-凝胶-浸渍法制备出负载型纳米TiO2/AC催化剂.在流化床反应器中分别对2种典型的偶氮类染料橙黄G、活性艳红X-3B模拟废水进行了光催化降解研究,探讨了pH值、外加氧化剂对光催化降解率的影响,并对催化剂进行了回收再生利用试验.结果表明,TiO2/AC催化剂具有良好的光催化活性、吸附特性及可再生性,60 min后对2种染料反应的光催化降解率分别可达到99.71%和97 12%,反应180 min后的TOC去除率分别达到81.54%和81.99%;反应后TiO2/AC催化剂回收率大于95%,经焙烧再生后对橙黄G反应60 min的光催化降解率仍高达95.93%.     

硫氯共掺杂g-C3N4纳米片光催化降解染料

采用气泡模板法制备了硫氯共掺杂的g-C₃N₄纳米片,通过XRD、FT-IR、XPS、SEM、UV-vis DRS和PL等手段对样品进行了表征,利用可见光照射下光催化降解罗丹明B（RhB）来评价其催化性能.结果表明,改性后的硫氯共掺杂的g-C₃N₄纳米片具有更大的比表面积,电子-空穴的分离效率提高,并且掺杂引起了能带结构的改变,使降解RhB的氧化基团从单一的·O₂^-变为·O₂^-和·OH双氧化基团,极大地提高了降解能力,制备的硫氯共掺杂g-C₃N₄纳米片对RhB的降解速率常数达到了0.01683min^-1,是纯氮化碳的5.5倍.     

纳米Fe_3O_4/膨润土的制备、表征及光催化降解焦化废水

以铝柱撑膨润土负载纳米Fe_3O_4制备出性能良好的复合型催化剂。结合X射线粉末衍射(XRD)、扫描电镜(SEM)和比表面孔隙分析(BET)对催化剂的晶相、比表面积和粒度进行表征。负载的纳米Fe_3O_4粒径约为20～30nm,均匀分散到膨润土表面,未发生明显的团聚。在紫外光作用下用该催化剂对焦化厂二沉池出水进行深度处理。结果表明,在催化剂投加量为0.7 g/L,pH为2.5,温度40℃,H_2O_2初始浓度为17.6mmol/L的反应条件下,二沉池出水(化学需氧量COD=140mg/L,色度=400度)经催化氧化降解后,COD和色度可分别降低到54.44 mg/L和10度,达到国家工业再生用水水质标准GB/T 19923-2005(COD≤60 mg/L,色度≤30度)。催化剂重复使用4次时,废水COD和色度去除率保持稳定。     

含酚废水光催化降解的试验研究

以主波长为254nm的紫外光灯为光源,TiO2为光催化剂,研究了对苯二酚光催化降解。建立了简单的符合拟一级的动力学模型,并进一步研究了其他因素如催化剂的活化温度、TiO2的用量以及酸度对降解率的影响。     

新型纳米材料光催化反应器研究

为了充分发挥纳米材料的光催化性能,研制了一种带有旋转叶片且可负载光催化纳米材料的光催化反应器.并以制备的纳米TiO2/硅藻土复合材料作为光催化剂、TNT生产废水为处理对象,考察了催化材料附载量、废水浓度和多次重复使用对反应器催化降解效率的影响.结果表明:附载有光催化纳米材料的反应器经过6次6h重复使用,对TNT生产废水催化降解效率仍然保持在75%以上,远高于直接分散在废水中纳米材料的处理效率(47.25%),即多次重复使用并保持高降解效率;而且可较好地避免纳米光催化材料的团聚.避免因回收造成的纳米材料光催化效率降低以及回收不完全造成的水体二次污染等现象.     

三氯乙烯在薄膜催化剂上的光催化降解动力学

研究了不同初始浓度三氯乙烯(TCE)在TiO₂薄膜催化剂上的光催化降解.结果表明,TCE在主波长为254nm的低压汞灯照射下易于发生光降解反应,而TiO₂薄膜催化剂能显著提高TCE的降解.光催化降解反应的伪一级速率常数随初始浓度的增加先升后降.在Langmuir-Hinshelwood方程基础上建立的光催化降解动力学模型包含了发生在薄膜催化剂表面的光催化氧化过程和发生的溶液体相的光降解过程,该动力学模型适用于表达低浓度有机物在薄膜催化剂上的光催化降解动力学.     

几种新型光催化水质净化反应器的探讨

综述了几种新型光催化反应器的结构、特征，讨论各反应器的应用情况和处理效果，对其优缺点进行评价。指出光催化技术与其它成熟水处理技术的耦合是光催化工艺进入实际应用的重要途径。     

Comparative study of performance efficiency for three kinds of photoreactors

ＣｏｍｐａｒａｔｉｖｅｓｔｕｄｙｏｆｐｅｒｆｏｒｍａｎｃｅｅｆｉｃｉｅｎｃｙｆｏｒｔｈｒｅｋｉｎｄｓｏｆｐｈｏｔｏｒｅａｃｔｏｒｓＷａｎｇＹｉｚｈｏｎｇ，ＦｕＹｕａｎ，ＴａｎｇＨｏｎｇｘｉａｏＳｔａｔｅＫｅｙＬａｂｏｒａｔｏｒｙｏｆＥｎｖｉｒｏ...     

Photocatalytic degradation of organochlorine compounds using TiO2 supported on fiberglass cloth

１ＩｎｔｒｏｄｕｃｔｉｏｎＯｒｇａｎｏｃｈｌｏｒｉｎｅｃｏｍｐｏｕｎｄｓａｒｅｗｉｄｅｌｙｕｓｅｄｉｎｖａｒｉｏｕｓｉｎｄｕｓｔｒｉｅｓ，ａｎｄｈａｖｅｂｅｎｒｅｐｏｒｔｅｄｔｏｃｏｎｔａｍｉｎａｔｅｒｕｎｎｉｎｇｗａｔｅｒ，ｒｉｖｅｒｓ，ｌａｋｅｓ...     

光催化降解有机磷农药的研究

研究以ＴｉＯ２粉末作为光催化剂,光降解３种不同结构的有机磷农药的可行性。结果表明,有机磷农药结构不同其光降解率不同;浓度１．０×１０－４ｍｏｌ／Ｌ的４种有机磷农药,３７５Ｗ中压汞灯照射４０ｍｉｎ有机磷将完全转变为无机磷,并检测出人效磷农药催化降解的部分中间产物。研究光催化剂ＴｉＯ２的用量、空气流量、外加Ｆｅ３＋浓度对光催化降解的影响,并初步探讨了机理。     

Study on the decolorization of dyes by microorganisms

Thirteen strains of bacteria with ability of dye decolonization were isolated from activated sludge and biofilm collected from textile wastewater treatment plants, and identified as Alteromonas, Klebsiella, Pseudomonas, Enterobacter. Alcali-genes and Corynobacterium. These strains D33, D32, D4 of Alteromonas can decolorize 29 kinds of dyes with good decolorizing activities of about 2.6 mg dye/gram wet cells.h-1. The optimum pH was 7-8 and the temperature was 37℃. The growth of bacteria was 3 times better in shaking cultures than in static cultures. But the decolorization rate of dyes was 4-9 times more in the latter than in the former. The results from the examination of the reaction products of Diamond Chrome Red B and Diamond Narry Blue RRN indicated the possibility of biodegradation of these dyes by Enterobacter D17.     

负载型二氧化钛光催化降解苯胺

以紫外灯为光湖，在圆柱型光反应器中，负载在镍网上的ＴｉＯ２为催化剂，研究了水中苯胺光催化剂降解行为，结果表明苯胺的降解动力学可用Ｌａｎｇｍｕｉｒ－Ｈｉｎｓｈｅｌｗｏｏｄ方程来描述，对苯胺的浓度、介质ｐＨ、液体流速、氧气浓度和外加Ｈ２Ｏ２等因素对光催化反应的影响进行了研究，并以实验现象予以解释。     

低浓度甲苯的气相光催化降解研究

研究了较低浓度的甲苯在较短停留时间时(17s～83s)的光催化降解,考察了甲苯初始浓度、停留时间、湿度、光源和催化剂载体等因素的影响,并分析了光催化处理降解能力随甲苯负荷的变化.研究表明,在较短停留时间时,甲苯降解率随进口浓度的增大而下降,且停留时间越短,随进口浓度增大而下降的越快;在某一停留时间范围内,甲苯的降解近似遵循一级反应动力学,动力学常数随浓度的增大而增大;低浓度时甲苯的光催化降解受湿度影响较小;低压汞灯为光源时甲苯的光催化降解率显著高于黑光灯为光源时的降解率;涂覆在不锈钢网状上的光催化剂性能随载体目数的增加而提高,但不及涂覆在铝板上的光催化剂.     

Photocatalytic degradation of C. I. Reactive Red 24 solution with K6SiW11O39SnII

Environmental friendly materials, K₆SiW₁₁O₃₉Sn (SiWSn), was synthesized. SiWSn photocatalytic decomposition of C. I. Reactive Red 24 (RR24) with the UV-lamp (253.7 nm, 20 W), Xenon lamp filtered less than 390 nm light (500 W) and sun light was investigated. The results showed that RR24 solution could be effectively decolorized with the SiWSn photocatalyst. The photocatalytic degradation efficiency of RR24 with SiWSn was affected by the initial concentration of RR2 solution, the amount of SiWSn and the photolysis time. It is demonstrated that the process of photodegradation of RR24 with SiWSn is a pesudo first-order reaction, which can be described by Langmuir-Hinshelwood equation. Hydroxyl radicals and holes are both the main oxidants in the photocatalytic reaction of RR24 with SiWSn.     

Rubber sheet strewn with TiO2 particles:Photocatalytic activity and recyclability

A new method for the preparation of rubber sheet strewn with titanium dioxide particles (TiO₂-strewn sheet) is presented. This simple and low cost method is based on the use of TiO₂ powder (Degussa P25) being strewn onto the sheet made from rubber latex (60% HA) through a steel sieve. The characteristic of the TiO₂-strewn sheet was studied by using scanning electron microscopy/energy dispersive X-ray spectrometer (SEM/EDS) and X-ray diffractometer (XRD) techniques. The photocatalytic activity of TiO₂-strewn rubber sheet was evaluated using Indigo Carmine (IC) dye as a model for organic dye pollutant in water. The results showed that the TiO₂-strewn sheet could degrade IC dye solution under UV light irradiation. The effects of pH, initial concentration, and the intensity of UV light on the photodegradation were also investigated. Kinetics of the photocatalytic degradation was of the first-order reaction. The used TiO₂-strewn sheet can be recovered and reused. The recycling uses did not require any cleaning between successive uses and no decline in the photodegradation efficiency was observed compared with freshly prepared TiO₂-strewn sheet.     

TiO_2光催化降解甲基橙若干反应条件的研究

通过测定甲基橙降解的最终产物SO4 2 - 的浓度 ,研究了溶液的 pH值、初始浓度、TiO2 投加量几个条件对光催化降解甲基橙矿化速率的影响 ,并与脱色速率进行了比较 ,结果表明 :光催化降解甲基橙的矿化速率低于脱色速率。