障碍物对瓦斯爆炸冲击波影响研究

为研究障碍物对瓦斯爆炸冲击波传播规律的影响,利用水平管道式气体——粉尘爆炸实验装置,测试并分析障碍物数量、尺寸和壁面粗糙程度对瓦斯爆炸冲击波超压、冲击波传播规律的影响。结果表明:障碍物对瓦斯爆炸过程中冲击波传播规律具有重要影响。障碍物存在时,改变了爆炸冲击波的传播规律,提高了冲击波超压的最大峰值压力,且随着障碍物数量和尺寸的增加,这种激励作用越明显。随着壁面粗糙程度的增大,瓦斯爆炸冲击波超压明显增大。研究结果对井下巷道瓦斯爆炸冲击波的防治具有一定的指导意义。     

煤矿巷道瓦斯爆炸传播规律及破坏效应分析

井下瓦斯爆炸的影响因素众多,随机性强,分析和研究瓦斯爆炸的传播规律只有通过巷道模拟实验的方法。通过对爆炸过程中爆炸压力、温度、速度等相关参数随时间、空间的变化规律的分析,进一步研究瓦斯爆炸的机理和破坏效应,在煤矿生产过程中采取合适的阻隔防爆技术措施,减少瓦斯爆炸带来的损失。     

H型通风巷道瓦斯爆炸及泄爆过程模拟研究

为探究在H型巷道中瓦斯爆炸及泄爆过程中压力及风流流态的变化,运用Fluent对瓦斯爆炸冲击波破坏巷道正常通风的过程进行仿真模拟;对比分析爆炸前后巷道内CO2摩尔分数、温度及流体的运动方式,得到爆炸冲击波在巷道内的传播特征.研究结果表明:爆炸冲击波经巷道壁面反射后与正向冲击波叠加,增大了叠加区域的压力值;爆炸冲击波改变了...     

瓦斯爆炸火焰波在分叉管路中的传播规律

笔者在研究分叉管路中瓦斯爆炸火焰波传播特征的基础上,分析了管路分叉对瓦斯爆炸过程中火焰传播规律的重要影响。研究结果表明,管道分叉时,管道分叉处为一扰动源,诱导附加湍流,气流湍流度增大,使瓦斯爆炸过程中火焰的传播速度迅速提高,分叉管路支管中火焰在前端是增大的,然后迅速减小;而分叉管直管端口封闭反射对直管管段火焰传播影响很小(端口距各测点较远),火焰在分叉管路直管管段范围是加速的。因此,在矿井开拓中,应尽可能减少不必要的巷道分叉。在巷道分叉处采取保护措施,减少爆炸造成的损失。研究结果对指导现场如何防治瓦斯爆炸,减轻瓦斯爆炸的威力具有重要作用。     

瓦斯爆炸波在转弯巷道内传播特征的模拟

通过对淮南矿区某一掘进巷道瓦斯爆炸的数值模拟,得到了转弯巷道内瓦斯爆炸波的传播特征。对煤矿井下转弯巷道瓦斯爆炸波的传播规律的研究,有利于预防、抑制瓦斯爆炸事故发生,对确定爆炸后救灾决策和防灾减灾工作具有重大意义。     

巷道截面积突变情况下瓦斯爆炸冲击波传播规律的研究

瓦斯爆炸冲击波传播规律是研究冲击波的破坏和伤害机理的前提及依据,笔者利用流体动力学、爆炸动力学理论对巷道截面积突变情况下瓦斯爆炸冲击波传播规律进行理论分析,建立巷道截面积突变情况下冲击波传播的数学模型,得到了冲击波波阵面压力和其他空气动力学参数的表达式,从而得到冲击波波阵面压力过巷道截面积突变面时的变化规律。研究成果丰富了瓦斯爆炸冲击波传播规律理论,对井下瓦斯爆炸安全评价以及制定防灾减灾措施提供了理论基础。     

瓦斯爆炸冲击波在角、并联巷道内传播规律对比研究

瓦斯爆炸冲击波在传播过程中的传播特性不仅与瓦斯体积分数、温度等条件有关,还与网络结构有关.为探究冲击波超压在对称角联网络结构内的变化特征、角联分支对主巷道内冲击波传播的影响等问题,结合实际巷道尺寸,对对称角、并联网络巷道进行了瓦斯爆炸过程的数值模拟.结果表明:受角联分支影响,分支后的巷道内冲击波衰减幅度大于并联网络中对应各点,且与角联分支距离越近,影响越大;角联分支对角联分叉前、后巷道内冲击波二次超压产生一定影响;与并联网络相比,角联网络中冲击波到达角联分叉后的超压峰值出现时间更晚;角联网络中角联分叉后各点冲击波超压峰值均低于并联网络中对应各点.     

矿井瓦斯爆炸高速气流的破坏和伤害特性研究

针对煤矿瓦斯爆炸事故频发现状,基于爆炸动力学、流体动力学理论对巷道受限空间瓦斯爆炸冲击波波阵面后高速气流的传播特性进行分析,建立高速气流压力和速度关系的数学模型。结合在实验巷道中瓦斯爆炸高速气流压力实验数据,拟合瓦斯爆炸高速气流速度和传播距离的计算公式,其结果表明,井下瓦斯爆炸事故高速气流的传播速度随传播距离的增加而减小。依据我国陆地地面风力等级划分标准比照可得瓦斯爆炸高速气流的等级为飓风级,对井下人员伤害巨大。该研究成果为控制和预防瓦斯爆炸破坏和伤害事故扩大及事故应急救援提供了理论依据。     

矿井瓦斯煤尘爆炸传播数值模拟研究

基于连续相、燃烧、颗粒相数理方程建立瓦斯煤尘爆炸传播数理模型,并应用连续相、颗粒相计算方法,依据大型巷道瓦斯爆炸、瓦斯煤尘爆炸传播实验数据,借助普遍应用的流场模拟平台,成功开发瓦斯、煤尘爆炸数值模拟系统。该系统可有效地模拟煤矿瓦斯、煤尘的爆炸事故过程,对瓦斯爆炸的爆燃转爆轰、煤尘是否参与爆炸、爆炸冲击传播速度、衰减规律以及爆炸灾害的波及范围都能进行较准确的模拟。     

不同曲率弯曲巷道弯角近区爆炸冲击波传播特性研究

为研究爆炸冲击波在不同曲率弯曲巷道弯角近区的传播规律,采用有限元方法建立爆炸模型,分析爆炸冲击波传播特性及其变化过程。研究结果表明,弯曲角度改变了巷道内冲击波超压分布,巷道内爆炸冲击波是巷道壁面反射叠加增强作用与传播距离衰减效应综合作用的结果,在爆源近区反射叠加作用占主导地位,使峰值压力出现极值;随着传播距离的增加,冲击波衰减占主导地位,峰值超压随距离呈现为线性衰减。     

爆炸冲击波在多级穿廊结构坑道内传播规律的数值分析

数值模型尺寸参照总参工程兵科研三所所建的穿廊结构坑道实体模型,采用ANSYS/LS-DYNA建立三维穿廊端部不同开闭的数值模型,得出冲击波在多级穿廊结构坑道内的传播规律,并与长直坑道内爆炸冲击波传播规律进行对比分析。结果表明多级穿廊结构端部开放坑道对爆炸冲击波的削弱作用非常显著,一级穿廊结构削弱冲击波强度62％,级数越高,削弱效果越明显;端部封堵时冲击波反射效果明显。     

爆炸荷载下地铁隧道损伤规律研究

地铁在运营中存在诸多风险,特别是外爆炸带来的危害尤为突出。为避免由此产生的风险,需对地铁隧道在外部侧爆炸瞬时强荷载作用下隧道衬砌结构损伤效应进行研究,进而对隧道衬砌结构的损伤程度作出判断。以西安地铁6号线工程为依托,利用ANSYS/LS-DYNA软件建立有限元模型,分析外爆炸荷载作用下应力波的传播规律;选取地面侧爆角度和隧道埋置深度2个因素建立分析工况,研究了外爆炸荷载下隧道衬砌结构的受力状态规律,隧道埋深15,18 m相较埋深12 m衰减了20,125个微应变;同时直观地对隧道衬砌结构的损伤程度进行分析。开展该项研究为地铁隧道结构抗爆防护设计提供了理论依据,具有较高的技术、经济和社会效率。     

Computer-aided modeling of the protective effect of explosion relief vents in tunnel structures

This paper aims at contributing to the efficient design of explosion protection systems against confined explosions. The issue addressed concerns the quantitative estimation of the protective effect of explosion relief vents in the case of confined explosions inside tunnels. A series of virtual experiments performed by computer simulation, revealed how the number of vents, their diameter, as well as the angle between the vents and the tunnel, influences the blast wave attenuation. The computational study was performed considering a complicated large-scale tunnel configuration with branches on its half portion. The purpose was the calculation of the attenuation effect due to the presence of vents by comparing the total explosion-specific impulse developing at antidiametric positions inside the tunnel. Simulations were carried out via a three-dimensional numerical model built in the computational fluid dynamics code CFX 5.7.1, which has been validated in previous papers against experimental overpressure histories data demonstrating reasonable performance. Computer results showed that the use of branch vents provides an effective method for shock wave attenuation following an explosion, whereas their statistical elaboration revealed that the attenuation is mainly affected by the number of vents and their diameter. In contrast, the angle between the side vents and the main tunnel appeared to slightly affect the pressure wave weakening. Eventually, the quantitative influence of the above parameters was effectively illustrated in functional diagrams, so that the total attenuation effect may be promptly estimated, if the design variables are known. In addition, two statistical models with reasonable fitting to the calculated data are proposed, which express the attenuation effect as a dependent variable of the design variables including their interactions.     

隧道并行输气管道爆炸对邻管的冲击效应分析

针对隧道内输气管道泄漏发生爆炸对相邻管道的潜在威胁,基于泄漏率的求解,得到爆炸气体的扩散分布规律,确定蒸气云爆炸的TNT当量;利用LS-DYNA有限元软件建立隧道并行输气管道爆炸模型,分析在不同的泄漏尺寸、爆心距和风速下,邻管对爆炸冲击的动力学响应。基于峰值振速的经验公式的验证,表明所采用的管隧模型的可行性。结果表明:在内压和爆炸荷载的共同作用下,隧道内管道的等效应力和速度会出现多个峰值,有别于开敞空间的爆炸规律;泄漏尺寸越小、爆心距和风速越大,管道的动力响应越小;相比爆心距和风速,管道的动力响应峰值对泄漏尺寸的变化更敏感。研究成果可为管隧结构在极端情况下的事故预防和维护抢修提供理论指导。     

点火位置对独头巷道中瓦斯爆炸超压的影响

运用AutoReaGas爆炸仿真模拟器研究了独头巷道中点火位置对瓦斯爆炸后果的影响。结果表明,在本计算条件下,爆炸静态超压随着距离的增加而减小,爆炸动压随着距离的增大而增大,点火位置对爆炸后果有重要影响,点火位置离封闭端越近,各个测点上所得到的超压越大。     

燃气爆炸荷载下隧道砌体损伤规律与事故影响范围研究

为降低隧道内燃气爆炸时砖砌体抛射物造成人员伤亡的概率,以中缅油气管道隧道砖砌体为研究对象,建立3种不同类型砖砌体的数值模型,将燃气爆炸荷载简化为三角形荷载,基于LS-DYNA软件,研究燃气爆炸荷载下隧道砖砌体结构的损伤规律与砖砌体抛射物的潜在影响范围.研究结果表明:砖砌体在天然气爆炸荷载作用下,可能会发生整体破坏,产生...     

危险货物集装箱堆场爆炸地震效应对地下结构的安全影响分析

为了研究危险货物集装箱堆场爆炸地震效应对地下结构的安全影响,采用我国《爆破安全规程》以及美国国家公路研究所爆破理论相结合的方法,分析某危险货物集装箱堆场建设项目发生爆炸时对已建隧道的影响。建立三维模型,采用Midas GTS有限元分析软件进行数值模拟分析,经过理论分析与数据拟合,分别确定堆场各点（区域）发生爆炸时隧道壁振动速度与地表爆炸当量的计算模型,确定隧道保护条件,并分别采用隧道壁最大应力模拟计算值进行校验,为堆场选址、堆存货种种类及数量限定提供参考建议。     

A numerical study of the evolution of the blast wave shape in rectangular tunnels

When the explosion of condensed materials occurs in square or circular cross-section tunnel, the subsequent blast wave reveals two patterns: three-dimensional close to the explosive charge and one-dimensional far from the explosion. Pressure decays for these two patterns have been thoroughly studied. However, when the explosion occurs in rectangular cross-section tunnel, which is the most regular geometry for underground networks, the blast wave exhibits a third, two-dimensional, patterns. In order to assess the range of these three patterns, several numerical simulation of blast waves were carried out varying the width and the height of the rectangular cross-section as well as the mass of the charge. Laws are presented to localize the transition zones between the 3D and the 2D patterns, and between the 2D and the 1D patterns, as functions of non-dimensional width and height. The numerical results of the overpressure are compared to existing 3D and 1D laws. An overpressure decay law is proposed to represent the 2D pattern. Knowing the two transition zones and the overpressure decays within these zones, an algorithm is presented to efficiently predict an overpressure map. This algorithm is validated by comparison with experimental data.     

Dynamic pressure induced by a methane–air explosion in a coal mine

The hazardous effect of dynamic pressure and strong gas flows induced by a methane–air mixture explosion in underground coal mines is studied. The dynamic pressure effect of a methane–air explosion was analyzed by numerical simulation, in a duct and tunnel. Compared to the overpressure generated by an explosion that can act on a body, the dynamic pressure caused by the high-speed flow of the gaseous combustion products can cause serious damage as well. At the structural opening of a coal mine, the destruction caused by the dynamic pressure induced by a methane–air explosion is more serious than the overpressure. For a tube or tunnel partially filled by a methane–air mixture, the dynamic pressure is lower than the overpressure in the region occupied by the flammable mixture. Beyond the premixed region, the dynamic pressure is of the same order of magnitude as the overpressure.     

公路隧道内氢气和丙烷爆炸数值模拟对比分析

通过FLUENT软件对化学计量浓度下的等热当量的氢气和丙烷在某公路隧道内的爆炸过程进行了数值模拟,对比分析了2者的反应速率和隧道内的压力场变化。结果表明:隧道内爆炸过程中氢气反应速率比丙烷的快,爆炸发生后50 ms内的平均反应速率是丙烷的7倍;氢气爆炸产生的超压较大,最大可达451 kPa,爆炸产生的压力波迅速传播,在隧道内上下来回反射,强度逐渐减弱;丙烷爆炸产生的压力波在隧道内整体表现为向上传播,在爆炸发生150 ms内强度逐渐增大。在此种情况下,2种气体的爆炸均能够对隧道内人员造成严重伤害。