垃圾渗滤液的加载磁絮凝预处理工艺研究

垃圾渗滤液是一种成分复杂多变的高浓度难处理有机废水。采用加载磁絮凝技术对垃圾渗滤液进行预处理,以提高其可生化性,便于后续生化处理的进行。研究了适宜的磁载体种类、凝聚剂和絮凝剂的加入量,以及不同pH值和药剂投加顺序的影响,并进行了磁絮凝与常规絮凝工艺的对比实验。得到的最优组合工艺为：PAC投加量5.5 g/L,磁载体投加...     

准好氧矿化垃圾反应床＋超声／芬顿联用技术处理垃圾渗滤液

针对垃圾渗滤液污染物浓度高、可生化性差等特点,采用准好氧矿化垃圾反应床＋超声／芬顿联用技术对垃圾渗滤液进行预处理。准好氧矿化垃圾床处理后渗滤液中COD、氨氮、总磷、色度的去除率分别为80％、85％、92％和85％。通过单因素实验和正交实验,确定了超声／Fenton法最佳工艺条件。经该组合工艺后,渗滤液中COD、氨氮、总磷和色度的最高去除率分别可达96％、86％、94％和95％,且出水无臭,颜色为淡黄色,BOD5／COD从0．16增至0．35左右,可生化性基本满足后续生物处理需要,且COD、总磷这2个指标达到《生活垃圾填埋场污染控制标准》（GB16889—2008）规定的排放标准。     

矿化垃圾床＋三维电极／电Fenton法处理老龄垃圾渗滤液

提出以二级矿化垃圾床为预处理单元,串联三维电极／电Fenton处理老龄垃圾渗滤液的组合工艺。矿化垃圾床处理后渗滤液中COD、氨氮、总磷、色度的去除率分别为80．55％、88．47％、98．32％和87．53％。通过单因素实验和正交实验,确定了三维电极／电Fenton法最佳工艺条件。经该组合工艺后,渗滤液中COD、氨氮、总磷和色度的最高去除率分别可达97．08％、95．24％、99．55％和96．92％,其中COD、总磷、色度这3个指标低于《生活垃圾填埋场污染控制标准》（GB16889．2008）表2规定的排放标准,为该组合工艺在实际中的应用提供重要理论依据。     

生化-调碱后垃圾渗滤液的Fenton深度处理效果

针对上海老港垃圾填埋场经过厌氧-曝气塘处理后的渗滤液难进一步处理的问题,对其采用厌氧滤池-好氧接触法、氧化钙2种方式预处理,在此预处理基础上,考察了Fenton法深度处理的效果,探讨了H2O2/Fe2+投加比、初始pH、H2O2投加量、反应时间和Fenton试剂投加方式对渗滤液COD去除效果的影响。研究发现:经过生物预处理后,渗滤液的COD和TP分别降低了24%和25%;氧化钙调碱可以进一步使COD和TP去除率分别达到42%和96%;后续Fenton深度氧化的最佳条件为:初始pH为2,H2O2投加量为2.4 g/L,H2O2/Fe2+摩尔比为5∶1,Fenton试剂一次投加,反应时间为2 h。在此条件下,渗滤液的COD从1 340 mg/L降到198 mg/L,总COD去除率达到85%。     

老港填埋场渗滤液性质随工艺变化研究

经老港填埋场渗滤液处理系统的各处理单元处理后的流出液,用不同孔径的系列膜进行了梯度分离。分离前后的渗滤液进行了TOC、TP、TN、氨氮和可溶性P等参数的测定,并建立了各参数与不同孔径膜的关系。结果表明,此工艺对老港填埋场渗滤液的处理具有一定的功效;随着处理工艺的进行,渗滤液的组成发生了较大的改变,其中细胶体部分的百分含量增加,而可溶性部分降低;渗滤液的绝大部分污染物质集中于可溶性部分,而渗滤液中的P主要与大分子的悬浮物和粗胶体结合。     

2种UASB的ANAMMOX与反硝化协同作用对比研究

采用2套UASB-ANAMMOX反应器处理垃圾渗滤液,其中反应器2具有生物膜,对反应器在有机环境下的ANAMMOX与反硝化协同作用进行对比研究。在稳定期,反应器1和反应器2对氨氮、亚硝氮、TIN、COD的平均去除率分别为95.7%、95.9%、77.3%、70.3%和97.4%、96.4%、87.2%、74.8%。反应器1对TIN和COD最大容积去除率为112.2和107.7 g/(m3.d),反应器2对TIN和COD最大容积去除率为120.5和119.9 g/(m3.d)。结果表明,过高的负荷会对反应器产生抑制作用,且当抑制产生后协同作用难以恢复到原来水平。在厌氧氨氧化与反硝化协同作用良好时,pH值和碱度均存在特征性变化。总体上,反应器2比反应器1具有更强的厌氧氨氧化与反硝化协同作用和抗负荷冲击能力。     

A cascade of anoxic and oxic fluidized bed biofilm reactors for treatment of synthetic municipal wastewater

In this study, a cascade of anoxic and oxic fluidized bed biofilm reactors system was carried out to treat synthetic municipal wastewater. The parameters of the influent flow rates and C/N ratios were discussed. System performance was acceptable for chemical oxygen demand (COD), ammonia, and total nitrogen removal. A decrease of ammonia and total nitrogen removal efficiencies, however, was observed when the influent flow rates increased to 5.04 and 6.12 1 h(-1). Total nitrogen removal decreased at the influent C/N ratio of 3:1. The measured ratios of COD reduction in the anoxic column to nitrogen removal through nitrification-denitrification were 3.7, 3.5, 3.3, and 3.1 g COD/g(-1) N on average when the influent C/N ratios changed from 6:1 to 3:1. The observed sludge yield (Yobs) was 0.169 g VSS g COD(-1) because of perfect denitrification in the anoxic column and the relatively long solids retention time.     

凤眼莲去除垃圾渗滤液中的COD、NH3-N和TP

在静态水培实验条件下,对不同浓度垃圾渗滤液条件下凤眼莲的生长状况及其净化效果进行了研究。结果表明,在高浓度(COD 3 546.7 mg/L、NH3-N 527.5 mg/L、TP 8.02 mg/L)垃圾渗滤液条件下(HCL)凤眼莲全部被毒害致死,在中浓度(COD 1 233.3 mg/L、NH3-N 182.9 mg/L、TP 2.83 mg/L)垃圾渗滤液条件下(MCL)生长状况差,生物量减少为实验前的32.6%。在低浓度(COD 660.0 mg/L、NH3-N 99.7 mg/L、TP 1.59 mg/L)垃圾渗滤液条件下(LCL)能够正常生长,且对低浓度垃圾渗滤液有较好的净化效果。24 d后COD、NH3-N和TP的去除率分别为85.9%,99.8%和84.8%。COD与NH3-N均达到《生活垃圾填埋场污染控制标准(GB16889-2008)》排放标准,TP达到《地表水环境质量标准(GB 3838-2002)》Ⅳ类排放标准。     

Treatment and detoxification of a sanitary landfill leachate

The leachate from an old sanitary landfill (Gramacho Metropolitan Landfill, Rio de Janeiro) was characterized and submitted to coagulation and flocculation treatment followed by ozonation and ammonia stripping. The performance of the treatment was assessed by monitoring the removal of organic matter (COD and TOC), ammonium nitrogen and metals. Detoxification was assessed by determining acute toxicity, using the following organisms: Vibrio fisheri, Daphnia similis, Artemia salina and Brachydanio rerio. Membrane fractionation was employed to infer the range of molecular masses of the pollutants found in the effluent, as well as the toxicity associated to these fractions. Of the techniques under investigation, coagulation and flocculation followed by ammonia stripping were the most effective for toxicity and ammonium nitrogen removal. Membrane fractionation was effective for COD removal; however, acute toxicity was almost the same in all the fractionated samples. Ozonation was moderately effective for COD removal, but significant toxicity removal was only attained when high ozone doses were used.     

The biological treatment of landfill leachate using a simultaneous aerobic and anaerobic (SAA) bio-reactor system

A set of simultaneous aerobic and anaerobic (SAA) bio-reactor system was used for the removal of organic pollutants and ammonia in the landfill leachate generated from Datian Shan Landfill in Guangzhou, China. The influent concentrations of COD and NH(4)(+)-N were 1000-3300 and 80-230 mg L(-1), respectively. The average effluent concentrations of COD and NH(4)(+)-N were 131 and 7 mg L(-1), respectively. The concentrations of COD and NH(4)(+)-N had reached the Chinese second grade effluent standard (COD<300 mg L(-1), NH(4)(+)-N<25 mg L(-1)) for this kind of wastewater. Gas chromatogram-mass spectrum (GC/MS) analysis was used to measure the organic pollutants in the landfill leachate. About 87 organics were detected in this landfill leachate, and 16 of them belong to the list of environmental priority pollutants established by the US Environmental Protection Agency. About 31 of the 87 organic pollutants were completely removed by the SAA bio-reactor, the concentrations of further 14 organic pollutants were reduced by more than 80%, and the removal efficiencies of the other 25 organic pollutants were over 50%.     

Biodegradation of polychlorinated biphenyls using biofilm grown with biphenyl as carbon source in fluidized bed reactor

This study investigated the use of biofilms in the biodegradation of polychlorinated biphenyls. The biofilm used was developed on modified cement particles using mixed microbial culture isolated from PCB-contaminated soil. The biofilm formed was first acclimatized to PCBs by feeding the reactor alternately with biphenyl and PCBs. The acclimatized biofilm was tested on simulated PCB-contaminated water containing Aroclor 1260 by using a three-phase fluidized-bed reactor operated in batch mode. The initial batch run yielded 80+/-2.38% PCB removal from medium in one day and 91+/-1.34% in 5 days. The percent PCB removal gradually increased in the succeeding runs reaching 92+/-2.48% in one day and a steady state value of 95+/-2.01% in 5 days from batch eight onwards. PCB removal from the medium was highest during the first day reaching 80-92%. The sudden decrease in PCB concentration was attributed to an initial adsorption of the PCB on the biofilm and then the compound was degraded gradually. Yellow intermediates were observed as the pH of the medium decreased. These intermediate products were further metabolized as indicated by the disappearance of the yellow substance.     

改良型慢滤池处理垃圾渗滤液

为了对慢滤池处理垃圾渗滤液工艺的基本参数进行研究,实验采用改良的小试规模的慢滤池模型,处理来自济南生活垃圾卫生填埋场中后期年龄段高浓度的垃圾渗滤液。重点考察活性炭粉末添加层的厚度、细粗滤料配比以及滤料层上部水层的高度等诸多因素对系统去除污染物效果的影响。实验结果表明,在垃圾渗滤液经过预处理进入慢滤池系统之后,此时调节细粗滤料配比例为2,水层高度为30 cm,活性炭粉末添加层厚度为1 cm,使得系统对各种污染的整体去除效果较好。此时,氨氮、总磷、浊度、色度和COD的去除率分别为75%、65%、90%、97%和81%。     

多孔矿物载体厌氧固定床处理有机废水研究

通过天然浮石和塑料多孔空心球而制成复合式多孔矿物载体应用于厌氧固定床反应器中,研究反应器挂膜性能,以及处理生活污水、啤酒废水效果,应用扫描电镜观察生物膜微生物相的形态结构.结果表明,反应器挂膜69 d后COD去除率稳定在70%以上,初次启动成功;处理生活污水中平均COD去除率为61.72%;处理啤酒废水中COD去除率高...     

凤眼莲去除垃圾渗滤液中的COD、NH_3-N和TP

在静态水培实验条件下,对不同浓度垃圾渗滤液条件下凤眼莲的生长状况及其净化效果进行了研究。结果表明,在高浓度（COD 3 546.7 mg/L、NH3-N 527.5 mg/L、TP 8.02 mg/L）垃圾渗滤液条件下（HCL）凤眼莲全部被毒害致死,在中浓度（COD 1 233.3 mg/L、NH3-N 182.9 mg/L、TP 2.83 mg/L）垃圾渗滤液条件下（MCL）生长状况差,生物量减少为实验前的32.6%。在低浓度（COD 660.0 mg/L、NH3-N 99.7 mg/L、TP 1.59 mg/L）垃圾渗滤液条件下（LCL）能够正常生长,且对低浓度垃圾渗滤液有较好的净化效果。24 d后COD、NH3-N和TP的去除率分别为85.9%,99.8%和84.8%。COD与NH3-N均达到《生活垃圾填埋场污染控制标准（GB16889-2008）》排放标准,TP达到《地表水环境质量标准（GB 3838-2002）》Ⅳ类排放标准。     

改性膨润土作为垃圾渗透液防渗层的实验研究

本文以天然钠基膨润土为原料,采用水溶液聚合法,在室温条件下,通过改性聚丙烯酰胺对膨润土进行直接插层改性,制备了一种新型聚丙烯酰胺改性膨润土防渗材料。以此防渗材料作为防渗层,选用沈阳大辛填埋场的垃圾渗透液为处理对象,在动态实验下,就其对实际垃圾渗滤液中主要污染物去除的有效性和控制垃圾渗滤液渗透的可行性进行研究。抗渗性能测试结果表明,改性膨润土防渗性能较好,渗透系数为1．0×10^-7cm/s,达到固体废物填埋场的防渗材料国家标准1．0×10^-7cm／s的使用要求。改性膨润土防渗层对COD、氨氮、重金属离子去除效果较好,吸附作用较强,COD和氨氮最大去除率分别达到81％和91％,TFe、Zn^2＋和TCr的最大去除率分别达到71％、58％和73％。实验结果验证了本研究所制备的改性膨润土防渗材料具有优良的抗渗、截污性能。     

固定化微生物法去除模拟渗滤液中氨氮的研究

采用固定化微生物曝气生物滤池（I-BAF）技术成功处理了模拟垃圾渗滤液,探讨了pH和溶解氧（DO）对系统脱氮性能的影响。结果表明,固定化微生物曝气生物滤池反应系统启动迅速,运行稳定,可以有效去除模拟垃圾渗滤液中的有机物和氨氮,其去除率分别达到97.1%和99.9%。在pH为7.5～8.5之间,DO 4.0 mg/L左右的条件下对模拟垃圾渗滤液中氮的去除最为有利,同步硝化反硝化效率以及总氮去除率均达到最高,分别为96.2%和94.3%。这主要是由于I-BAF系统中大孔载体提供了厌氧-兼氧-好氧的微环境,使硝化和反硝化反应在同一个反应器内发生,共同作用实现模拟垃圾渗滤液中总氮的去除。     

垃圾渗滤液处理工艺运行参数优化与技术比较

垃圾渗滤液是公认的一种成分复杂且难以处理的高浓度有机废水,笔者在北京市海淀区六里屯垃圾填埋场通过2007—2010年垃圾渗滤液处理的工程实践,以COD和氨氮的去除率为指标,研究了不同的垃圾渗滤液处理工艺组合,以及不同运行参数条件下对垃圾渗滤液的处理效果。结果表明,在中温UASB和A/O的平均水力停留时间(HRT)缩短1/3的情况下,通过改进A/O段曝气方式,优化系统的pH、DO等运行参数,用MBR替代絮凝工艺,使整个组合工艺对COD的年平均去除率达到了94.3%,氨氮的去除率维持在99.5%以上,出水氨氮稳定在10 mg/L以内,而改造前的COD与氨氮的年平均去除率仅为82.2%与55.3%。与改造前的UASB+A/O+絮凝工艺组合相比,改造后的UASB+A/O+MBR工艺组合具有更高的污染物去除能力、更好的抗缓冲性和稳定性。     

Hybrid zero valent iron (ZVI)/H2O2 oxidation process for landfill leachate treatment with novel nanosize metallic calcium/iron composite

A novel nanosize metallic calcium/iron dispersed reagent was synthesized and tested as coagulant/catalyst in a hybrid zero valent iron (ZVI)/H₂O₂ oxidation process to treat leachate. Two different types of leachates, one from municipal solid waste (MSW) tipping hall (MSWIL) and second from an MSW landfill site (MSWLL), were collected and characterized. The morphology, elemental composition, and mineral phases of the nano-Ca/CaO and nano-Fe/Ca/CaO were characterized by scanning electron microscopy–electron dispersive spectroscopy (SEM-EDS) and x-ray powder diffraction (XRD) analysis. The coagulation process with 2.5 g L^?1 nano-Ca/CaO attained 64.0, 56.0, and 20.7% removal of color, chemical oxygen demand (COD), and total suspended solids (TSS) in MSWLL. With only 1.0 g L^?1 of nano-Fe/Ca/CaO, relatively high color, COD and TSS removal was achieved in MSWLL at 67.5, 60.2, and 37.7%, respectively. The heavy metal removal efficiency reached 91–99% after treatment with nano-Fe/Ca/CaO in both leachate samples. The coupling process, using 1.0 g L^?1 of nano-Fe/Ca/CaO and 20 mM H₂O₂ doses, achieved enhancement removal of color, COD, and TSS, up to 95%, 96%, and 66%, respectively, without initial pH control. After this treatment, the color, COD, TSS, and heavy metals were significantly decreased, fitting the Korean discharge regulation limit. A hybrid coupled zero valent iron (ZVI)/H₂O₂ oxidation process with novel nanosized metallic calcium/iron dispersed reagent proved to be a suitable treatment for dealing with leachate samples.

Implications: Conventional treatments (biological or physicochemical) are not sufficient anymore to reach the level of purification needed to fully reduce the negative impact of landfill leachates on the environment. This implies that new treatment alternatives species must be proposed. A coupled zero valent iron (ZVI)/H₂O₂ oxidation process proved to be a suitable treatment for dealing with leachate samples. Coagulation with nFe/Ca/CaO allows 91–99% of heavy metals removal. The coupled coagulation–oxidation process by nFe/Ca/CaO reveals excellent ability to treat leachate. After coupled treatment the color, COD, and TSS were also much lower than the discharge regulation limit.     

A calcite permeable reactive barrier for the remediation of Fluoride from spent potliner (SPL) contaminated groundwater

The use of calcite (CaCO3) as a substrate for a permeable reactive barrier (PRB) for removing fluoride from contaminated groundwater is proposed and is illustrated by application to groundwater contaminated by spent potliner leachate (SPL), a waste derived from the aluminium smelting process. The paper focuses on two issues in the implementation of calcite permeable reactive barriers for remediating fluoride contaminated water: the impact of the groundwater chemical matrix and CO2 addition on fluoride removal. Column tests comparing pure NaF solutions, synthetic SPL solutions, and actual SPL leachate indicate that the complex chemical matrix of the SPL leachate can impact fluoride removal significantly. For SPL contaminant mixtures, fluoride removal is initially less than expected from idealized, pure, solutions. However, with time, the effect of other contaminants on fluoride removal diminishes. Column tests also show that pH control is important for optimizing fluoride removal with the mass removed increasing with decreasing pH. Barrier pH can be regulated by CO2 addition with the point of injection being critical for optimising the remediation performance. Experimental and model results show that approximately 99% of 2300 mg/L fluoride can be removed when CO2 is injected directly into the barrier. This can be compared to approximately 30-50% removal when the influent solution is equilibrated with atmospheric CO2 before contact with calcite.     

Screening of physical-chemical methods for removal of organic material, nitrogen and toxicity from low strength landfill leachates

Physical-chemical methods have been suggested for the treatment of low strength municipal landfill leachates. Therefore, applicability of nanofiltration and air stripping were screened in laboratory-scale for the removal of organic matter, ammonia, and toxicity from low strength leachates (NH4-N 74-220 mg/l, chemical oxygen demand (COD) 190-920 mg O2/l, EC50 = 2-17% for Raphidocelis subcapitata). Ozonation was studied as well, but with the emphasis on enhancing biodegradability of leachates. Nanofiltration (25 degrees C) removed 52-66% of COD and 27-50% of ammonia, the latter indicating that ammonia may in part have been present as ammonium salt complexes. Biological pretreatment enhanced the overall COD removal. Air stripping (24 h at pH 11) resulted in 89% and 64% ammonia removal at 20 and 6 degrees C, respectively, the stripping rate remaining below 10 mg N/l h. COD removals of 4-21% were obtained in stripping. Ozonation (20 degrees C) increased the concentration of rapidly biodegradable COD (RBCOD), but the proportion of RBCOD of total COD was still below 20% indicating poor biological treatability. The effect of the different treatments on leachate toxicity was assessed with the Daphnia acute toxicity test (Daphnia magna) and algal growth inhibition test (Raphidcocelis subcapitata). None of the methods was effective in toxicity removal. By way of comparison, treatment in a full-scale biological plant decreased leachate toxicity to half of the initial value. Although leachate toxicity significantly correlated with COD and ammonia in untreated and treated leachate, in some stripping and ozonation experiments toxicity was increased in spite of COD and ammonia removals.