Release of polychlorinated dibenzo-p-dioxins and dibenzofurans by setting off fireworks.

Selected pyrotechnic articles were set off under laboratory conditions. Residues and vapors of smoke as well as unburnt charges were analyzed for polychlorinated dibenzo-p-dioxins, dibenzofurans (PCDD/F) and their precursors chlorinated benzenes and phenols. The contamination of the selected products with these organic xenobiotics proved to be very variable. Remains of fireworks contained octachlorinated dioxins and furans up to 142 ng I-TEQ/kg as well as hexachlorobenzene in the range of 0.05 to 1,400 mg/kg. The deflagration of detonating compositions usually resulted in a dispersion of contaminants, whereas continuously burning flare compositions partially led to a thermal decomposition of organic pollutants. A significant rate of formation of polychlorinated dioxins and furans was observed when setting off blue-lightning rockets and fountains. Further investigations revealed that even high temperatures during the deflagration of black powder charges could not suppress the formation of PCDD/F from appropriate precursors.     

Dioxin concentrations in sediments of the Baltic Sea--a survey of existing data

Recent survey results for polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs, dioxins) in Baltic Sea sediments from Finland, Sweden and Denmark were merged with previously published Baltic Sea data. Regional distribution of concentration levels, differences in congener patterns, and temporal changes in sediment profiles were examined. One of the main objectives was to study if any major point sources for different PCDD/F congeners could be identified on a regional scale, based on sediment records. The survey confirmed the impact of chlorophenol production derived highly chlorinated PCDF-congeners on the total toxicity in sediments in the Gulf of Finland near the Kymijoki river estuary. Signatures of other point sources or combined point sources pertinent to specific industry branches or particular production processes (such as pulp bleaching, vinyl chloride production, thermal processes) may be discerned. However, the findings did not support any of the known point sources significantly influencing those congeners that are most abundant in Baltic herring and salmon. Instead, regional distributions in the Baltic Sea indicate that atmospheric deposition may act as a major source for those congeners and especially for 2,3,4,7,8-PeCDF. There were clear indications of declines in levels in sediment in some areas, but generally the levels of highly chlorinated PCDD/Fs on the northern coast of the Gulf of Finland were still high when compared with other areas of the Baltic Sea. Major areas with data gaps cover the south-eastern and eastern coastal regions of the Baltic Proper and the southern Gulf of Finland.     

Formation of aromatic chlorinated compounds catalyzed by copper and iron

This study shows the catalyzing effects of iron and copper on the formation of chlorinated compounds such as chlorobenzenes (ClBzs), chlorophenols (CIPhs), polychlorinated dibenzo-p-dioxins (PCDDs) and dibenzofurans (PCDFs). Both total concentrations and congener distributions have been studied. The parameters and conditions varied during the combustion tests were the complete and incomplete combustion and the metal and chlorine addition. The incomplete combustion promoted the formation of organic chlorinated compounds in flue gas particles. Highly chlorinated congeners of PCDD/F were dominant in the flue gas particles, whereas the importance of lower chlorinated congener were increased in the gas phase. In the complete combustion conditions the concentrations of PCDD/Fs increased when the degree of chlorination were high, nevertheless the concentrations of tetra and penta PCDD/Fs were higher in the gas phase than the concentrations in the fly ash particles. Organic chlorine promoted the formation of chlorinated compounds more effectively than inorganic chlorine, which instead promoted the formation of PCDD/Fs in the gas phase, especially with copper catalyst. Different concentration levels of chlorinated compounds were observed in the gas phase and in particles when the chlorine source and combustion conditions were varied from incomplete to optimum conditions. Both copper and iron seem to have a catalytic effect on PCDD/F formation.     

Influence of combustion conditions on the PCDD/F-, PCB-, PCBz- and PAH-concentrations in the post-combustion chamber of a waste incineration pilot plant

Experiments at a pilot scale waste incinerator (0.5 MW thermal power) showed that the conditions in the post-combustion chamber (650-900 degrees C) are strongly influencing the formation of chlorinated and non-chlorinated aromatics. Non-optimal combustion conditions resulted in increased concentrations of mono- to trichlorinated dibenzo-p-dioxins (PCDD), dibenzofurans (PCDF) and polycyclic aromatic hydrocarbons (PAH), while chlorinated benzenes (PCBz), polychlorinated biphenyls (PCB) and the higher chlorinated PCDD/F are only weakly affected or even decrease. The changes in concentration of the compounds investigated over a time span of hours gave hints on 'memory effects' in this combustion zone. For mono- and dichlorinated benzenes, a high correlation (r2 = 0.80) with the international toxicity equivalent (I-TEQ) value of PCDD/F was observed. As recently has been demonstrated, this correlation can be utilized for an indirect on-line measurement of the I-TEQ by a novel laser mass spectrometric technique (REMPI-TO-FMS).     

PCBs and PCDD/Fs in lake sediments of Grosser Arbersee, Bavarian Forest, South Germany

Despite their environmental importance, there are still relatively few historical studies of the environmental occurrence of polychlorinated biphenyls (PCBs), polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs), especially in middle Europe. Trends in PCBs and PCDD/Fs were, therefore, assessed in lake sediments of the Grosser Arbersee over the past 130 years (1860-1990). Ballschmiter-PCB concentrations (congeners # 28, 52, 101, 138, 153, 180) increased between 1946 and 1972 from 4.2 to 32.0 microg kg(-1) dry wt, but have since decreased to 25.6 microg kg(-1) dry wt. High chlorinated PCB congeners reached their maxima earlier (1968-1972) than low chlorinated congeners (1985-1991). These trends were consistent with patterns expected from the production and use of PCBs and their precursors. PCDD/F concentrations increased between 1950 from 0.6 microg kg(-1) dry wt to 2.3 microg kg(-1) dry wt in 1977, falling to 1.7 microg kg(-1) dry wt by 1993. PCDF concentrations exceeded those of PCDD until 1968, but afterwards PCDDs (especially OCDD) were predominant. These patterns suggest that domestic heating and waste combustion were the most likely sources, but pollution from local industries, such as metal smelting and glass production, might also have been involved. The data provide a valuable case study from central Europe which confirms the overall declining trends of PCB and PCDD/F contamination shown elsewhere.     

Levels of PCDDs and PCDFs in Korean river sediments and their detection by biomarkers

Polychlorinated dibenzo-p-dioxins (PCDDs) and dibenzofurans (PCDFs) are a group of toxic halogenated aryl hydrocarbons inducing various physiological disorders against biological organisms. Here, we investigated their levels in sediment samples taken from 12 different rivers in Korea. The levels of PCDD/PCDFs in sediment samples were expressed as concentrations and international TEQ values. Among 17 PCDD/PCDFs selected as target compounds in this study, the 1,2,3,4,7,8-HxCDD and OCDD were found in all river sediments with significant variation in various congener profiles of PCDD/PCDFs in sediments. PCDD/PCDFs could be monitored by sensitive biomarkers using insect immune system. Out of 12 river sediment samples, the biomarkers reported four spots (up, middle, and down Singil sites and Ansan) as putative contamination areas. When comparing both chemical and biological monitoring results, two methods agreed three spots of Singil as contamination areas (above 10ppt levels) as well as six river sediment samples as relatively less-contaminated areas, but differed in the results in Ansan and Miho, probably due to relative non-specificity of biomarkers. Despite some disparity between bio- and chemical monitoring results, the biomarkers can be recommended as a device warning the contamination of dioxins in the environment because of a fast and inexpensive detection method.     

Formation and inhibition of chloroaromatic micropollutants formed in incineration processes

The formation pathways for chlorinated aliphatic and chlorinated aromatic compounds in technical incineration processes are reviewed. It is shown that acetylene is converted to chloroaromatic compounds including PCDD/F in a special flow reactor by catalytic activity of CuCl2 in the temperature regime of a post-combustion zone of technical incinerators. Mechanistic pathways begin with chlorination of acetylene. Dichloroacetylene is further condensed to C-4 and C-6 units. Hexachlorobenzene is the dominant aromatic compound and a likely precursor to chlorinated phenols and PCDD/F. Two specific mechanisms of formation of chlorinated aromatic compounds including PCDD/F have been advanced. Both mechanisms begin with the formation of dichloroacetylene from flame pyrolysis products like acetylene. Condensation of dichloroacetylene is mediated by copper species via metallacyclic intermediates and/or a catalytic cycle involving copper stabilized trichlorovinyl radicals. The final pathways of conversion of chlorinated benzenes to PCDD/F via chlorophenols are under active investigation.     

Photodegradation of PCDD/Fs adsorbed on spruce (Picea abies (L.) Karst.) needles under sunlight irradiation

Spruce (Picea abies (L.) Karst.) needles were exposed to exhaust gas containing polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) generated by combustion of polyvinyl chloride, wood, high-density polyethylene, and styrene. Photodegradation of PCDD/Fs adsorbed on spruce needles under sunlight irradiation was studied. The photodegradation of PCDD/Fs follows pseudo-first-order reaction kinetics, with photolysis half-lives ranging between 40 and 100 h. The photolysis rates of PCDF congeners are higher than PCDD congeners with the same chlorinated substitutions. Higher chlorinated PCDD/Fs tend to photolyze slowly. The wax components in spruce needles may act as proton donors and accelerate the photolysis rate. C-Cl cleavage through the addition of protons to PCDD/F molecules may be an important route for PCDD/Fs photodegradation.     

Urea as a PCDD/F inhibitor in municipal waste incineration

Emissions of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) from municipal waste incineration have been widely studied because of their extensive toxicity, and many efforts have been made to restrict their emissions. Although a number of chemical compounds have been shown in laboratory-scale tests to inhibit the formation of PCDD/Fs, few have been tested in pilot- or full-scale plants. This work evaluates the effect of urea as a PCDD/F inhibitor in a pilot-scale incinerator that uses refuse-derived fuel (RDF). The decomposition of urea under the test conditions was also studied using detailed kinetic modeling. An aqueous solution of urea was injected into the flue gas stream after the furnace at approximately 730 degrees C, with varied urea concentrations and flue gas residence times used between the furnace and the sampling point. The results demonstrate that urea can successfully inhibit PCDD/F formation in waste incineration if concentrations and injection points are properly adjusted. The kinetic model showed that urea can be rapidly decomposed under appropriate flue gas conditions, indicating that in addition to the urea molecule itself, decomposition products of urea can also be responsible for the reduction of PCDD/F production during incineration.     

Urea as a PCDD/F Inhibitor in Municipal Waste Incineration

ABSTRACT

Emissions of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) from municipal waste incineration have been widely studied because of their extensive toxicity, and many efforts have been made to restrict their emissions. Although a number of chemical compounds have been shown in laboratory-scale tests to inhibit the formation of PCDD/Fs, few have been tested in pilot- or full-scale plants. This work evaluates the effect of urea as a PCDD/F inhibitor in a pilot-scale incinerator that uses refuse-derived fuel (RDF). The decomposition of urea under the test conditions was also studied using detailed kinetic modeling. An aqueous solution of urea was injected into the flue gas stream after the furnace at ~730 °C, with varied urea concentrations and flue gas residence times used between the furnace and the sampling point. The results demonstrate that urea can successfully inhibit PCDD/F formation in waste incineration if concentrations and injection points are properly adjusted. The kinetic model showed that urea can be rapidly decomposed under appropriate flue gas conditions, indicating that in addition to the urea molecule itself, decomposition products of urea can also be responsible for the reduction of PCDD/F production during incineration.     

Trends of PCDD/F and PCB concentrations and depositions in ambient air in Northwestern Germany

Time series of polychlorinated dioxins and furans (PCDD/F) and polychlorinated biphenyls (PCB) in ambient air of a large conurbation in North-Western Germany are presented and analyzed. The trend of PCDD/F concentrations, starting from as early as 1988, shows a pronounced decrease by at least one order of magnitude, demonstrating that the emission reductions were effective. The PCDD/F depositions also have decreased by a factor of 5 since 1992. However, both trends have leveled out since 2005. Time series of PCB concentrations and depositions starting in 1994 show only slight decreases for the concentrations and almost no decrease for the depositions. From the decay rates following first order kinetics, half-lives in the order of 5-15 years for the PCDD/F and 15-31 years for the sum of the six indicator PCB could be calculated, which are much longer than the half-lives estimated from their reactivity towards the OH radical. Apparently, small fresh emissions (PCDD/F), considerable secondary emissions and evaporation from contaminated soils slow down their decay in the atmosphere of big conurbations. Analyzing the decay rates of individual PCB congeners shows that the lower chlorinated and more volatile ones are removed faster than the higher chlorinated congeners, probably via gas phase reactions with the OH radical. It can be concluded from the present study that the input of PCDD/F and PCB into the food chain via the air path will continue for another one or two decades in big conurbations.     

Mutagenicity of anaerobic fenitrothion metabolites after aerobic biodegradation

Previous studies have revealed that the mutagenicity of fenitrothion increases during anaerobic biodegradation, suggesting that this insecticide's mutagenicity could effectively increase after it pollutes anaerobic environments such as lake sediments. To investigate possible changes to the mutagenicity of fenitrothion under aerobic conditions after it had already been increased by anaerobic biodegradation, batch incubation cultures were maintained under aerobic conditions. The mutagenicity, which had increased during anaerobic biodegradation, decreased under aerobic conditions with aerobic or facultative bacteria, but did not disappear completely in 22 days. In contrast, it did not change under aerobic conditions without bacteria or under continued anaerobic conditions. These observations suggest that the mutagenicity of anaerobically metabolized fenitrothion would not necessarily decrease after it arrives in an aerobic environment: this would depend on the presence of suitable bacteria. Therefore, fenitrothion-derived mutagenic compounds may pollute the water environment, including our drinking water sources, after accidental pollution of aerobic waters. Although amino-fenitrothion generated during anaerobic biodegradation of fenitrothion was the principal mutagen, non-trivial contributions of other, unidentified metabolites to the mutagenicity were also observed.     

Resembling a “natural formation pattern” of chlorinated dibenzo-p-dioxins by varying the experimental conditions of hydrothermal carbonization

Until several years ago dioxins were considered as just an unwanted by product of anthropogenic activities and stigmatized as the symbol of man-made environmental pollution. Natural processes, such as forest fires, can emit dioxins, but compared to industrial processes, usually very low quantities are emitted. However after a case of food contamination occurred in the United States of America in 1996 caused by kaolinitic clay a discussion on the provenience started. Besides the relatively high concentration also an unusual PCDD/F distribution pattern was found in these ball clay samples. This specific pattern related to none of the known anthropogenic sources for these contaminants and, in relation to a supposed natural formation, later it was named “natural formation pattern”. Hydrothermal carbonization (HTC) can transform biomass within hours into a brown coal-like product which resembles naturally occurring coal formation. HTC can also transform an already present PCDD/F contamination in a way to obtain a “natural formation pattern” characterized by an unusual high ratio between 1,2,3,7,8,9-HxCDD and 1,2,3,6,7,8-HxCDD and the absence of almost all chlorinated dibenzofurans. By varying the experimental conditions of the HTC process applied to sewage sludge samples contaminated with PCDD/Fs from anthropogenic sources, beside the “natural formation pattern” at a temperatures of 255 °C, a remarkable increase of the toxicity based on WHO–TEQ was observed.     

Concentrations of polychlorinated dibenzo-p-dioxins and polychlorinated dibenzofurans in soil in the vicinity of a landfill

Estonia still has no waste incineration facilities, which would act as substantial sources of dibenzo-p-dioxins (PCDDs) and dibenzofurans (PCDFs) pollution. As landfill fires may serve as sources of dioxins, we focused on the concentrations of PCDD and PCDF in soil samples taken in the vicinity of the landfill located at south-east Estonia in the course of our inventory. Concentrations of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) were studied in five soil samples taken in the vicinity of the Laguja landfill in south-east Estonia. The four soil samples were taken in southern, eastern, western and northern parts not further than 300 m from the landfill, and one sample was taken at the distance of 3 km from the landfill. The PCDD/F concentrations in all soil samples were at background level (0.64-2.33 pg I-TEQ WHO/g dry weight). To maintain this situation, the administrator of the landfill must avoid landfill fires, which are one of the reasons for the generation of dioxins and furans.     

A simple kinetic model of PCDD/F formation by de novo synthesis

A simple fixed-bed reactor model is used to describe experimental data about the formation of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/F) from fly ash carbon. The heterogeneous oxidation of graphite-like carbon is represented by a reaction which is first order in carbon and one half order in oxygen. The same orders of reaction are assumed to be valid for PCDD/F formation, such that the oxidation of fly ash carbon would have three parallel channels leading to COx, PCDD and PCDF. In addition, PCDD/F degradation by oxygen is considered and appropriate rate constants were fitted to simulate the experimental data. The effects of water vapour and particulate copper on PCDD/F formation are included. As a result, an overall kinetic model of PCDD/F formation is obtained which describes most of the experimental data with reasonable accuracy. The main reaction channel, COx formation, needs to be understood more completely, in order to interpret PCDD/F reaction pathways better. The model can be extended to include other chlorinated aromatics and the gas/particle partitioning of the semivolatiles. It provides a basis for the qualitative and quantitative interpretation of fixed-bed and flow reactor results and it is hoped to be applicable to industrial installations like waste incinerators and metal smelters.     

Polychlorinated dibenzo-p-dioxins and dibenzofurans in soils and sediments from Daliao River Basin, China

Polychlorinated dibenzo-p-dioxins and polychlorinated dibenzofurans (PCDD/F) were analyzed in surface sediments and top soils collected from 30 sites in Daliao River Basin. The concentrations of PCDD/F ranged from 0.28 to 29.01 ng TEQ kg(-1) dw (mean value, 7.45 ng TEQ kg(-1)dw) in sediments, and from 0.31 to 53.05 ng TEQ kg(-1)dw (mean value, 7.00 ng TEQ kg(-1)dw) in soils. PCDD/F pollution in sediments from the mid- and downstream sections of Hun River was found to be relatively heavy, and the levels of PCDD/F contamination in paddy soils were generally higher than those of upland soils. Using multivariate statistical analysis, the PCDD/F homologue and congener profiles of all soil and sediment samples were compared with those of suspected PCDD/F sources. The results showed that, PCDD/F contamination in most sediments of Hun River should mainly originated from the production of organochlorine chemicals, while metal smelting was the important potential source of PCDD/F in the drainage area of Taizi River. PCDD/F contamination in paddy soils should be simultaneously attributed to the polluted water irrigation and the organochlorine pesticide application.     

Identification of surrogate compounds for the emission of PCdd/F (I-TEQ value) and evaluation of their on-line real-time detectability in flue gases of waste incineration plants by REMPI-TOFMS mass spectrometry

Correlations between products of incomplete combustion (PIC), e.g., chloroaromatic compounds, can be used to characterise the emissions from combustion processes, like municipal or hazardous waste incineration. A possible application of such relationships may be the on-line real-time monitoring of a characteristic surrogate, e.g., with Resonance-Enhanced Multiphoton Ionization-Time-of-Flight Mass Spectrometry (REMPI-TOFMS). In this paper, we report the relationships of homologues and individual congeners of chlorinated benzenes (PCBz), dibenzo-p-dioxins (PCDD), dibenzofurans (PCDF) and phenols (PCPh) to the International Toxicity Equivalent (I-TEQ) of the PCDD/F (I-TEQ value) in the flue gas and stack gas of a 22 MW hazardous waste incinerator (HWI). As the REMPI detection sensitivity is decreasing with the increase of the degree of chlorination, this study focuses on the lower chlorinated species of the compounds mentioned above. Lower chlorinated species, e.g., chlorobenzene (MCBz), 1,4-dichlorobenzene, 2,4,6-trichlorodibenzofuran or 2,4-dichlorophenol, were identified as I-TEQ surrogates in the flue gas. In contrast to the higher chlorinated phenols, the lower chlorinated phenols (degree of chlorination <4) were not reliable as surrogates in the stack gas. The identified surrogates are evaluated in terms of their detectability by REMPI-TOFMS laser mass spectrometry. The outcome is that MCBz is the best suited surrogate for (indirect) on-line measuring of the I-TEQ value in the flue gas by REMPI-TOFMS. The correlation coefficient r of the MCBz concentration to the I-TEQ in the flue gas was 0.85.     

Development of expanded and core kinetic models for the gas phase formation of dioxins from chlorinated phenols

Expanded, 45 reaction, and core, 12 reaction, kinetic models have been developed that account for the major features in the homogeneous formation of polychlorinated dibenzo-p-dioxins (PCDD) from the oxidation of 2,4,6-trichlorophenol (P). The expanded and core schemes provide good agreement between experimental and calculated yields of PCDDs using the CHEMKIN combustion package or the React kinetic program, respectively. Steady-state approximations of the reaction kinetic models including radical-molecule and radical-radical formation pathways of PCDD, as well as oxidative destruction pathways of chlorinated phenoxyl radicals, reveal a competition between reactions of chlorinated phenoxyl radicals with chlorinated phenols, recombination reactions of chlorinated phenoxyl mesomers, and destruction/decomposition of phenoxyl radicals.     

Dioxins and furans formation in pilot incineration tests of sewage sludge spiked with organic chlorine

The factors affecting polychlorinated dibenzo-p-dioxins (PCDD) and polychlorinated dibenzofurans (PCDF) formation were studied in sewage sludge incineration tests carried out on a demonstrative plant. The plant includes a circulating fluidised bed furnace (FBF) and a rotary kiln furnace (RKF), operating alternatively. During the tests sewage sludge was spiked with chlorinated hydrocarbons and the operating parameters of the afterburning chamber were varied. PCDD/F were sampled in each test before the bag filter, thus collecting the above contaminants before abatement systems. From the tests it appeared that PCDD/F were always produced in more abundance in the tests carried out by FBF than by RKF. The higher PCDD/F concentrations in the tests by FBF were reached when sewage sludge was spiked with a high dosage of a surrogate organic mixture of chlorinated hydrocarbons and when the afterburning chamber was used only as transit equipment with the burner off. The distribution of the different PCDD/F homologues was compared. P5CDFs were generally the prevalent fraction, with very few exceptions for the tests by RKF at high temperature of the afterburning chamber. As for FBF tests, it was found that the PCDD/F homologue profile depends on the afterburning chamber temperature.     

Evidence for the presence of a widespread PCDD source in coastal sediments and soils from Queensland, Australia

Recent studies have demonstrated the occurrence of elevated levels of higher chlorinated PCDDs in the coastal environment of Queensland, Australia. This study presents new data for OCDD contamination and full PCDD/F profile analysis in the environment of Queensland. Marine sediments, irrigation drain sediments and topsoil were collected from sites that were expected to be influenced by specific land-use types. High OCDD concentrations were associated mainly with sediments collected near the mouth of rivers which drain into large catchments in the tropical and subtropical regions. Further, analysis of sediments from irrigation drains could be clearly differentiated on the basis of OCDD contamination, with high concentrations in samples from sugarcane drains collected from coastal regions, and low concentrations in drain sediments from drier inland cotton growing areas. PCDD/F congener-specific analysis demonstrated almost identical congener profiles in all samples collected along the coastline. This indicates the source to be widespread. Profiles were dominated by higher chlorinated PCDDs, in particular OCDD whereas 2,3,7,8-substituted PCDFs were below the limit of quantification in the majority of samples. The full PCDD/F profile analysis of samples strongly resemble those reported for lake sediments from Mississippi and kaolinite samples from Germany. Strong similarities to these samples with respect to congener profiles and isomer patterns may indicate the presence of a similar source and/or formation process that is yet unidentified.