Ultrafiltration tests for the reutilization of greenhouse wastewater

Abstract

A lab‐scale experiment was performed using two different pore‐size ultrafiltration membranes to investigate the removal efficiency of Tomato Mosaic Virus (ToMV), retainability of pollutant and nutrients, and flow characteristics. From the experiment, it may be concluded that ultrafiltration can be used effectively to eliminate ToMV. Tests with a 30K pore‐size ultrafiltration membrane achieved 99% virus removal efficiency and a 5K membrane practically removed 100% of the virus in greenhouse wastewater. Nutrient analysis indicated that all the essential nutrients could be retained and re‐utilized.     

Phosphate recovery from greenhouse wastewater

A study was conducted to investigate the suitability of phosphate recovery from greenhouse wastewaters by using precipitation/crystallization process. More than 90% of the phosphate could be removed from the greenhouse wastewater. Various calcium phosphate salts were obtained in the process; hydroxyapatite [Ca5(PO4)3OH] could be the main product from the precipitates. Phosphate removal was affected by the presence of magnesium ion in wastewaters. An increase of magnesium concentrations in wastewaters decreased phosphate removal rates. The chemical contents of precipitates in terms of calcium, magnesium and phosphate were affected by calcium to magnesium molar ratio. Higher calcium contents were obtained at wastewaters with high calcium to magnesium molar ratio. An addition of magnesium did not affect the potassium contents in the precipitates. K-struvite, MgKPO4 x 6H2O, was not the major product in the precipitate, even with addition of a large quantity of magnesium.     

甲胺生产废水中氨氮资源化的试验研究

利用MgSO4·7H2O和Na2HPO4·12H2O作为试验药剂,通过正交试验和单因素优化试验,对化学沉淀法处理甲胺生产废水中氨氮的工艺条件进行优化.结果表明,在pH=9.4、反应时间15 min、搅拌速度150 r/min、Mg:N(摩尔比值)=1.1、P:N(摩尔比值)=1.0时,化学沉淀法处理300 mL甲胺生产废水,氨氮去除率维持在92%以上,COD去除率可达37%以上.同时为验证工艺条件适应性和沉淀物(MgNH4PO4)作为农作物肥料使用的价值性,对最优条件下得到的沉淀物进行研究.与MgNH4PO4纯度为100%相比,沉淀物MgNH4PO4纯度达到86%以上.因此,化学沉淀法处理氨氮不仅具有良好的效果,而且得到的MgNH4PO4含有较高N、P,可以用作农作物肥料.     

Fenton法处理石化废水混凝泥及其剩余液的氧化回用研究

运用Fenton法氧化石化废水混凝泥,考察了体系pH、H2O2投加量、H2O2与Fe2+的摩尔比(简称H2O2/Fe2+)、反应时间等因素对氧化效果的影响,并将氧化后的剩余液回用作混凝剂,用于石化废水的混凝,考察了其连续多次氧化回用后的混凝效果.结果表明.混凝泥的最佳Fenton法氧化条件;pH为3,H2O2投加量为0...     

Treatment of greenhouse wastewater using constructed wetlands.

Five wetland designs, based on conventional surface flow (SF) and subsurface flow (SSF) approaches, were assessed for nitrogen and phosphorus removal from greenhouse wastewater. Results indicated none of the individual designs assessed was capable of providing the highest treatment effect for all nutrients of concern; however, the SF wetland emerged as the most appropriate design for the treatment of greenhouse wastewater. The highest mean phosphorus reduction of 65% was observed in the unplanted SF wetlands. Peak nitrate reductions of 54% were observed in the 15-cm deep SF wetlands and ammonia removal of 74% was achieved in the unplanted SF wetlands. Nitrate concentration in the greenhouse effluent can be reduced to acceptable levels for the protection of freshwater aquatic life (i.e., less then 40 ppm) using a loading rate of 1.65 g NO3-N/m2/day and a design water depth of 30 cm or greater. Based on available literature and the results of this research project, a multistage design, consisting of an unplanted pre-treatment basin followed by a 25 to 35 cm deep surface flow marsh with open water components, is recommended.     

聚合硫酸铁/高锰酸钾/二氧化氯组合工艺用于聚氯乙烯废水回收的工程化研究

采用聚合硫酸铁复配高锰酸钾混凝结合二氧化氯氧化的组合工艺成功解决了某厂聚氯乙烯生产废水回收工艺CODMn不达标问题。工程运行结果表明,当原水CODMn=30～48 mg/L,浊度=25～46 NTU时,在CFe=16.8 mg/L,CKMnO4=45 mg/L,CClO2=20 mg/L的条件下,出水CODMn<10 mg/L,浊度<0.5 NTU,达到工业循环补给水的水质要求。     

The effects of magnesium and ammonium additions on phosphate recovery from greenhouse wastewater

Phosphorus recovery from greenhouse wastewater, using precipitation-crystallization, was conducted under three levels of calcium concentration, 304 mg/L (7.6 mmol/L), 384 mg/L (9.6 mmol/L), and 480 mg/L (12 mmol/L), and also with additions of ammonium and magnesium into the wastewater. Jar test results confirmed high phosphate removal, with more than 90% of the removal achieved with a pH as low as 7.7. Under the low calcium concentration, ammonium addition affected the chemical reactions at pH lower than 8.0, where struvite was produced; when the pH was raised to 8.8, other calcium compounds dominated the precipitation. Under the medium calcium concentration, ammonium and magnesium addition helped struvite precipitation in the low pH range. Hydroxyapatite (HAP) was the main product. Under the high calcium concentration, ammonium addition showed no effects on the precipitation.     

Reduction of greenhouse gases from anaerobic piggery wastewater treatment by bromochloromethane in Taiwan

This work establishes methods of reducing the amount of methane produced from the anaerobic treatment of piggery wastewater by either reducing the storage time before solid/liquid separation or inhibiting the activity of methanogens in anaerobic wastewater treatment system. Experimental results showed these two methods can be adopted effectively to reduce methane production resulting from anaerobic piggery wastewater treatment. First, the wastewater must be processed using solid/liquid separation immediately after washing pig houses. This process can reduce by 62% the biogas production and indirectly decrease the methane production from the anaerobic wastewater treatment reactor. Second, adding 10 mg L(-1) bromochloromethane (BCM) daily into the anaerobic wastewater treatment reactor can significantly reduce the amount of biogas and methane produced during the anaerobic fermentation process. Furthermore, biogas production can be completely inhibited after 4 days. Adding BCM (< or =10 mg L(-1)) to wastewater only slightly affected the efficiency of the anaerobic wastewater treatment process. Results in this study can provide the basis for further research on reduction of the amount of methane produced from anaerobic wastewater treatments.     

Purification effects of two eco-ditch systems on Chinese soft-shelled turtle greenhouse culture wastewater pollution

The present study used an eco-ditch system that employed Eichhornia crassipes, Bacillus subtilis, and Bellamya aeruginosa (E–B–B) during the summer and fall (high temperature) seasons and a second eco-ditch system that employed Elodea nuttallii, a compound microbial preparation called “EM bacteria”, and Hypophthalmichthys molitrix (E–E–H) during the winter and spring (low temperature) seasons successively to purify the discharged wastewater produced by Chinese soft-shelled turtle greenhouse cultivation. The wastewater was sampled, and the dynamic changes in the major nutrient pollutant indicators over several months were analysed. After the E–B–B and E–E–H eco-ditch purification systems were operated for nearly 140 days each, the following results were observed: the total nitrogen (TN) removal rates in the wastewater were 75 % and 69 %, respectively; the total phosphorus (TP) removal rates were 82 % and 86 %, respectively; the NH₄ ⁺-N removal rates were 91 % and 75 %, respectively; the chemical oxygen demand (CODcr) decreased 54 % and 44 %, respectively; the dissolved oxygen (DO) contents increased nearly 3 to 4 times; and the wastewater was maintained at neutral or alkaline pH values. The wastewater physical traits gradually changed from being yellow, brown, and muddy to being pale yellow, slightly turbid, and odourless. Both eco-ditch systems were observed to have a relatively favourable effect on the purification of Chinese soft-shelled turtle aquaculture wastewater. The continuous use of both eco-ditch systems could result in a year-round purification effect on Chinese soft-shelled turtle greenhouse aquaculture wastewater; therefore, this method has good prospects for promotion and application.     

磷石膏再生利用途径的综合评价

依据层次分析法原理,用经济、环境和资源化3个影响因素建立磷石膏资源化途径优选的递阶层次结构模型。以山东某化工厂生产磷酸产生的磷石膏为研究案例,从磷石膏组成成分与含量分析的角度出发,结合磷石膏各资源化途径的独特要求,探讨磷石膏资源化特性与资源化途径的密切关系,拟合出磷石膏的各种资源化特性,作为结构模型中的资源化因子。然后分别对模型中的3个影响因素进行定性和半定量化处理,最终实现磷石膏资源化途径优选的决策评价,为政府部门和环境管理者提供决策参考。     

Performance analysis and life cycle greenhouse gas emission assessment of an integrated gravitational-flow wastewater treatment system for rural areas

Environmental Science and Pollution Research - Due to the lack of appropriate wastewater treatment facility in rural areas, the discharging of wastewater without sufficient treatment results in...     

Application of dynamic models to estimate greenhouse gas emission by wastewater treatment plants of the pulp and paper industry

Greenhouse gas (GHG) emission in wastewater treatment plants of the pulp-and-paper industry was estimated by using a dynamic mathematical model. Significant variations were shown in the magnitude of GHG generation in response to variations in operating parameters, demonstrating the limited capacity of steady-state models in predicting the time-dependent emissions of these harmful gases. The examined treatment systems used aerobic, anaerobic, and hybrid—anaerobic/aerobic—biological processes along with chemical coagulation/flocculation, anaerobic digester, nitrification and denitrification processes, and biogas recovery. The pertinent operating parameters included the influent substrate concentration, influent flow rate, and temperature. Although the average predictions by the dynamic model were only 10 % different from those of steady-state model during 140 days of operation of the examined systems, the daily variations of GHG emissions were different up to ±30, ±19, and ±17 % in the aerobic, anaerobic, and hybrid systems, respectively. The variations of process variables caused fluctuations in energy generation from biogas recovery by ±16, ±17, and ±14 % in the three examined systems, respectively. The lowest variations were observed in the hybrid system, showing the stability of this particular process design.     

Biodegradation of wastewater nitrogen compounds in fractures: laboratory tests and field observations

Throughout several coastal regions in the Mediterranean where rainfalls rarely exceed 650 mm per year municipal treated wastewater can be conveniently reused for soil irrigation. Where the coastal aquifer supplies large populations with freshwater in such area, an assessment of ground water quality around spreading sites is needed. In this study, the efficacy of natural filtration on nitrogen degradation in wastewater spreads on the soil covering the Salento (Southern Italy) fractured limestone was quantified by using laboratory tests and field measurements. In the laboratory, effluent from municipal wastewater treatment plants was filtered through a package of fractures made by several slabs of limestone. An analysis of wastewater constituent concentrations over time allowed the decay rates and constants for nitrogen transformation during natural filtration to be estimated in both aerated and non-aerated (i.e., saturated) soil fractures. A simulation code, based on biodegradation decay constants defined in the laboratory experiments, was then used to quantify the total inorganic nitrogen removal from wastewater injected in an aquifer in the Salento region (Nardò). Here the water sampled in two monitoring wells at 320 m and 500 m from the wastewater injection site and downgradient with respect to groundwater flow was used to verify the laboratory nitrification and denitrification rates.     

城市垃圾焚烧底灰资源化处理的可行性研究

对天津某城市垃圾焚烧发电厂的垃圾焚烧底灰进行采样,测试评价了不同粒径焚烧底灰的工程特性及环境风险,并以焚烧底灰为骨料制备混凝土平板试件,分析了焚烧底灰中杂质组分对再生建筑材料的工程特性影响.研究发现,焚烧底灰的颗粒级配分布、主要元素成分及含量、砂当量、压实强度与天然建筑骨料相似,且不同粒径的焚烧底灰在使用过程中无毒性重...     

Toward better understanding and feasibility of controlling greenhouse gas emissions from treatment of industrial wastewater with activated sludge

Wastewater treatment plants (WWTPs) have been recognized as important sources for anthropogenic greenhouse gas (GHG) emission. The objective of the study was to thoroughly investigate a typical industrial WWTP in southern Taiwan in winter and summer which possesses the emission factors close to those reported values, with the analyses of emission factors, mass fluxes, fugacity, lab-scale in situ experiments, and impact assessment. The activated sludge was the important source in winter and summer, and nitrous oxide (N₂O) was the main contributor (e.g., 57 to 91 % of total GHG emission in a unit of kg carbon dioxide-equivalent/kg chemical oxygen demand). Albeit important for the GHGs in the atmosphere, the fractional contribution of the GHG emission to the carbon or nitrogen removal in wastewater treatment was negligible (e.g., less than 1.5 %). In comparison with the sludge concentration or retention time, adjusting the aeration rate was more effective to diminish the GHG emission in the activated sludge without significantly affecting the treated water quality. When the aeration rate in the activated sludge simulation was reduced by 75 %, the mass flux of N₂O could be diminished by up to 53 % (from 9.6 to 4.5 mg/m²-day). The total emission in the WWTP (including carbon dioxide, methane, and N₂O) would decrease by 46 % (from 0.67 to 0.36 kg CO₂-equiv/kg COD). However, the more important benefit of changing the aeration rate was lowering the energy consumption in operation of the WWTP, as the fractional contribution of pumping to the total emission from the WWTP ranged from 46 to 93 % within the range of the aeration rate tested. Under the circumstance in which reducing the burden of climate change is a global campaign, the findings provide insight regarding the GHG emission from treatment of industrial wastewater and the associated impact on the treatment performance and possible mitigation strategies by operational modifications.

     

废弃电子设备的资源化研究发展现状

分析了废弃电子设备的主要特点、资源化回收与利用的不同方法及其优缺点，并详细介绍了废弃电子设备机械处理的研究及工业应用现状。     

Application of reutilization technology to calcium fluoride sludge from semiconductor manufacturers

Glass ceramics were prepared from mixtures of wastes generated from refining of waste glass and semiconductor industrial wastewater sludge. The aim is then indeed to study the possible use and effects of integrating calcium fluoride (CaF2) as present in semiconductor wastewater sludge in the silica (glass) melts. CaF2 sludge was blended with a conditioner according to characteristics of the target. Calcium oxide-silicon dioxide-aluminum oxide system glass ceramics have relatively high melting points. Addition of CaF2 sludge to fluxes can significantly reduce the melting point and hence improve the kinetics of the reactions. CaF2 sludge and waste glass were co-melted in various ratios to elucidate their interactions at various heating temperatures. The results indicate that the lowest melting temperature was 1163 degrees C, obtained for the CaF2 sludge-waste glass mixture at a ratio 6:4 (wt:wt), which is significantly lower than that of CaF2 sludge (1378 degrees C). The benefits of using melting to dispose of sludge are the reduction of waste and the fixation of heavy metals. Heat treatment was used to convert the obtained glass into glass ceramics. Heavy metal leaching tests revealed that melting conditions lowered the heavy metal concentrations in the leachate to an order of magnitude lower than that in the sludge. Consequently, industrial sludge can be safely used as a fine aggregate material for a potentially wide range of construction applications.     

Assembling plant diversity mitigates greenhouse gas emissions and achieves high nitrogen removal when treating the low-C/N wastewater by constructed wetlands

Environmental Science and Pollution Research - The low carbon-to-nitrogen (C/N) ratio in wastewater will inhibit pollutant removal, and more seriously, it will cause an increment of nitrous oxide...     

膜曝气生物膜反应器处理生活污水N2O等温室气体的排放特性

针对生活污水处理减污降碳的需求,本研究采用膜曝气生物膜反应器(membrane aerated biofilm reactor, MABR)耦合厌氧氨氧化工艺处理低碳氮比生活污水,考察了水质污染物去除的同时,分析了甲烷(CH₄)、氧化亚氮(N₂O)和一氧化氮(NO)的排放特性。结果表明,MABR实现了较好的碳氮污染物去除效果,当处理进水C/N为3.00±0.14的模拟污水时,COD、NH₄⁺-N和TN去除率分别为85.24%、90.10%和64.35%;当处理进水C/N为1.67±0.07的实际污水时,COD、NH₄⁺-N和TN去除率分别为75.39%、96.39%和81.88%。MABR具有较低的CH₄和N₂O排放因子,厌氧阶段分别为(0.010 3±0.010 5)%、(0.005 0±0.005 5)%,好氧阶段分别为(0.001 5±0.001 7)%、(0.002 1±0.001 5)%,厌氧阶段是CH₄和N₂O排放的主要阶段。气态NO和气态N₂O存在正相关关系,反硝化反应可能是N₂O产生的主要路径。NO是反硝化过程N₂O产生的前体物,对反硝化过程N₂O的释放具有指示作用。     

污泥减量化与资源化研究进展

随着污水处理量增加,污泥的产生量也日益巨大.如何使污泥无害化、减量化和资源化已越来越受人们的关注.针对目前传统污泥处理与处置方法存在的问题,重点介绍了近年来污泥减量化和资源化的处理技术,并分析了新技术研究情况和应用前景,为污泥合理处理与处置提供参考.