不锈钢薄板拉伸、冲压成形性能的试验研究

采用德国产SCHENCKTREBELRM2 5 0电子万能试验机对SUS3 0 4不锈钢 0 .5mm薄板进行了拉伸试验 ,研究了SUS3 0 4不锈钢薄板的硬化指数 (n值 )、屈服强度 (σs)、极限强度 (σb)、均匀延伸率(δ)等机械性能 ,并分析了SUS3 0 4薄板的冲压成形性能     

RE对慢冷条件下B319铝合金组织性能的影响

利用等离子发射光谱仪、能谱仪、差分扫描量热仪 (DSC)以及金相分析等手段 ,研究了稀土 (RE)对慢冷条件下B319铝合金组织和性能的影响。研究结果表明 ,在铸件冷却速度为0 .3℃ /s的慢冷条件下 ,B319铝熔体中加入 0 .15 %RE ,可以使硅相得到一定程度的变质。随着RE加入量的增加 ,合金的抗拉强度和延伸率得以提高 ,当RE含量为 0 .15 %时 ,相对于未加RE时的情况 ,σb 和δ分别增加了 14 %和 2 3.5 %。当RE含量大于 0 .15 %时 ,出现富稀土的块状金属间化合物Ti2LaAl2 0 ,使合金的机械性能 ,尤其是塑性降低     

拉伸类冲压成形性能非线性关系评定

同时用板材的加工硬化指数n值与各向异性系数r值对极限翻边系数K_(f,c)和极限胀形系数K_(b,c)的定量预报作用和公式;K_(f,c)=1/((1+r)n+1),K_(b,c)=(1+r)n+1.从而获得了板材拉伸类冲压成形性能用r×n去作非线性关系评定的实验研究结果.     

三层复合板的r值研究

通过拉伸实验测试了不锈钢 /铝合金 /不锈钢三层复合板的厚向异性系数r,并分析了扩散退火对r值的影响及r值对板材成形性能的影响。分析表明 :扩散退火会降低r值和提高n值。用平均r值和rmin 来判断拉延危险断面的抗拉强度其误差在 6 %左右。     

AZ31B镁合金挤压工艺研究

在油炉中熔炼AZ31B镁合金 ,用熔剂保护 ,石墨模铸造圆锭。铸锭经 40 0℃× 1 2h的均匀化处理后 ,进行热挤压 ,其挤压温度为 40 0℃ ,挤压速度为 1～ 2 .5m/min ,挤压比为 1 0～ 45。共挤出了 1 1种规格的棒材、管材、型材 (工字型、槽型、角形、方形、T形等 ) ,挤压过程中均发生了动态再结晶 ,其抗拉强度σb 在 2 75～ 2 85MPa之间 ,屈服强度σ0 .2　在 2 2 0～ 2 2 5MPa之间 ,延伸率δ在 1 5 %～ 1 7%之间。所制订的工艺合理 ,挤压出的棒材、管材、型材有较好的力学性能     

润滑条件对超深冲IF钢成形性能的影响

研究了不同润滑条件下钢板FLD和LDH的变化规律。研究结果表明 :润滑影响了钢板冲压成形过程中的应变路径 ,但对FLD0 没有影响 ;润滑对LDH0 影响显著。     

镁合金净化技术研究

利用金相分析、电镜、岛津材料试验机等方法研究了不同净化工艺对镁合金力学性能、组织、断口形貌的影响。结果表明 ,对于AZ91镁合金 ,精炼剂的用量不宜超过 3 .5 % ,浇注温度应控制在 72 0～ 730℃。采用熔剂、吹氩和过滤的复合净化处理工艺可以有效清除镁熔体中的夹杂物和气孔 ,使镁合金的性能得到极大的提高。经复合净化处理后的AZ91的σb和δ可分别达到 2 0 6 .1MPa和 5 .2 1 %。金相观察表明 ,净化处理对金相组织无明显的影响 ,不改变AZ91镁合金的断裂机理 ,断口均成准解理断裂     

内蒙古夏季大气降水同位素特征及影响因素

为探明内蒙古地区夏季大气降水中δD和δ¹⁸O组成特征及其对气象因子变化的响应关系,于2017~2019年夏季采集了内蒙古阿拉善左旗、呼和浩特市市区、正蓝旗、克什克腾旗（达里湖）、通辽科尔沁左翼中旗和呼伦贝尔新巴尔虎右旗（呼伦湖）等6个区域共计82次大气降水样品,结合来自全球降水同位素观测网（GNIP）的包头、张掖等6个区域大气降水样品中δD和δ¹⁸O数据,分析了内蒙古地区大气降水中δD和δ¹⁸O变化的区域差异及其主要影响因素,结果表明：内蒙古局地大气降水中δD和δ¹⁸O值存在自西向东不断偏负的趋势,其中呼伦贝尔新巴尔虎右旗大气降水中δD和δ¹⁸O值最偏负;相对地,西部阿拉善左旗大气降水中δD和δ¹⁸O值最偏正;内蒙古地区局地大气降水线斜率和截距同样表现出自西向东逐渐偏正的变化趋势,显示二次蒸发作用的影响逐渐下降,且局地蒸发水汽团对西部地区大气降水影响明显,如位于西风环流影响区的阿拉善左旗等区域局地蒸发气团占到8月部分单次大气降水来源水汽团的100%,而7月份,东亚夏季风环流对内蒙古局地大气降水的影响最为明显;整体上,虽然区域大气湿度变化引起的二次蒸发是影响内蒙古局地大气降水过程的一个关键因素,不过大气降水量对夏季大气降水稳定同位素组成的影响最明显.即西风环流影响区大气湿度变化对氘盈余指数d值的影响程度明显强于东亚夏季风区大气湿度变化的影响,而东亚夏季风环流影响区大气降水量对d值的影响程度则相对明显.     

海州香薷对铜的蓄积及铜的毒性效应

研究了不同浓度铜对海州香薷的毒性及海州香薷对铜的蓄积结果表明0.5 mmol/kg的铜能促进海州香薷的生长,使其生物量增大.低浓度的Cu²⁺使叶绿素a含量上升,而高浓度Cu²⁺则使叶绿素a下降,但Cu²⁺对叶绿素b的影响并不明显.反映到a/b上则表现为低浓度下Cu²⁺处理会提高a/b值.海州香薷的蓄铜浓度随土壤中铜浓度的增加而升高,可达1500mg/kg,达到了超量积累植物的标准.铜对SOD、POD活性的影响也表现为低浓度的刺激效应和高浓度的抑制效应,最高值出现在0.5 mol/kg.     

城市区粗糙度z0对大气扩散参数影响的研究

本文介绍了城市区粗糙度z_0对大气扩散参数σ影响的研究,给出了城市粗糙度zo的计算公式,同时,从对σ扩增的想法出发,研究确定了当粗糙度z_0增加时,σ的扩增系数η在不同稳定度的计算方法。最后给出了用扩增系数η计算的σ值,计算值与实测值比较一致。这可以用已知平原区的σ值,推算出城市地区的σ值,因此在大气扩散计算中是有实用价值的。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.