生产性UASB反应器的中温高温交替启动运行过程

处理柠檬酸废水的UASB反应器因所处地区季节气温相差较大,可在中温和高温条件下交替启动运行.反应器在中温条件下启动,串联使用的两级UASB反应器的COD去除率达到77%～86%;当气温升高反应器内水温达到44℃～45℃时,反应器升温进入高温启动运行阶段,两级UASB反应器的COD去除率达到84%～93%;UASB反应器停产38d后,进行了中温再启动,COD去除率达到82%～96%.本文报道了生产性UASB反应器中温、高温交替启动运行的过程,以及中温和高温厌氧颗粒污泥的特性.     

厌氧高温消化法处理柠檬酸废水

用厌氧高温消化法处理柠檬酸废水,原废水的COD_(cr)10000～25000mg/L,BOD_5000～15000mg/L,pH4～5左右,经治理后,COD_(cr)去除率大于85%,BOD_5去除率大于90%,pH6～9,为废水后续处理达标奠定了良好的基础.     

UASB处理生物柴油废水的效果研究

采用升流式厌氧污泥床(UASB)工艺处理地沟油回收制备生物柴油废水,通过试验研究了UASB反应器各个阶段对该类废水的处理效果,并考察了甲基磺酸、对甲基苯磺酸两种预酯化催化剂对该类废水处理效果的影响。结果表明:当进水COD为15g/L、容积负荷为15kg/(m3·d)时,UASB反应器COD的去除率稳定在87%左右,出水VFA为4~6mmol/L,沼气产量为16.8L/d;当容积负荷稳定在5kg/(m3·d),进水甲基磺酸浓度为5500mg/L时,UASB反应器COD的去除率达83%以上,进水对甲基苯磺酸浓度为1 000mg/L时,UASB反应器COD的去除率为58.3%,从废水处理的难易程度角度考虑,建议采用甲基磺酸为预酯化催化剂。     

UASB-SBR处理工艺试验研究

介绍了升流式厌氧污泥床反应器 (UASB) -序批式活性污泥法 (SBR)处理淀粉废水的工艺 ,详细叙述了该类废水的特点、试验系统组成、UASB的启动到污泥颗粒化的过程 ,以及处理效果。试验结果表明该处理系统具有耐冲击负荷 ,处理效果稳定 ,运行管理简单 ,运行成本低等特点。废水经颗粒化UASB稳定处理后 ,出水COD可降到 5 0 0mg/L以下 ,然后经SBR稳定处理后 ,出水COD可降到 10 0mg/L以下     

UASB-A/O耦合工艺处理高含氮印染废水中试

通过现场中试考察了UASB-A/O耦合工艺分类处理印染废水的效果. 在前处理废水UASB进水流量为0.065 m3/h,染色废水UASB进水流量为0.260 m3/h,同时A/O工艺混合液回流比为200%的情况下,该耦合工艺对印染废水中污染物去除效果最好:最终出水ρ(COD_Cr)<200 mg/L,ρ(NH₃-N)<10 mg/L,ρ(TN)<15 mg/L;染色废水和前处理废水在耦合工艺的UASB段都实现了高效厌氧氨化,染色废水厌氧出水ρ(NH₃-N)占ρ(TN)的比例稳定在80%以上,前处理废水稳定在85%以上,并且在常温厌氧条件下也可以实现较好的氨化效果;通过调整前段UASB的运行参数可有效实现对VFAs(挥发性脂肪酸)的调控,使之为缺氧反硝化提供充足的高品质碳源,以达到高效脱氮的目的;耦合工艺对印染废水中的PVA(聚乙烯醇)有较好的处理效果,UASB段对PVA的去除率在10%~40%之间,A/O段对PVA的去除率稳定在60%以上.      

厌氧处理乙酸丁酯废水的实验研究

乙酸丁酯废水是一种重要的化工原料,每生产一顿乙酸丁酯可产生140kg废水,本实验利用3L上流式厌氧污泥床UASB反应器在中温条件下处理高浓度乙酸丁酯废水。当UASB反应器稳定运行时,进水CODcr=10000mg／L时,容积负荷可达到13kgCOD／（m^3d）,水力停留时间24h,COD去除率可以达到80％以上,出水COD小于2000mg／L。通过本试验取得的良好试验效果,为处理乙酸丁酯废水找出了可行的途径。     

UASB-氧化沟工艺处理啤酒废水

介绍了采用UASB 氧化沟工艺处理啤酒废水的工程应用。工程运行表明 ,啤酒废水在进水SS、CODCr、BOD5分别为 32 5mg L、136 0mg L、810mg L的条件下 ,经UASB 氧化沟工艺处理后 ,外排废水SS、CODCr、BOD5浓度分别为6 0mg L、5 1mg L、15 1mg L。该工艺具有占地面积小 ,处理效果好 ,运行费用低等特点 ,能广泛应用于啤酒废水处理的实际工作中     

厌氧UASB-混凝沉淀法处理高浓度屠宰废水

应用UASB混凝沉淀法对高浓度屠宰废水的处理进行了试验研究。用UASB反应器处理屠宰废水,CODCr容积负荷可达6.8g(L·d),CODCr去除率达93%左右,并对UASB出水投加一定量的混凝剂PFS和助凝剂MZ,实验表明:系统出水达到《肉类加工工业水污染物排放标准》(GB1345792)二级标准。     

UASB工艺对饮料废水去除效果

采用UASB工艺在饮料废水去除COD的效果,废水水质为CODCr≤3000mg/L,处理出水CODCr≤600mg/L。工程实践表明该处理系统具有处理效果稳定,运行管理简便,运行费用低等优点。     

高浓度有机硫废水的厌氧生物除臭处理

采用升流式厌氧污泥床反应器(UASB)去除蛋氨酸合成时产生的恶臭有机硫废液的恶臭气味.试验结果显示,UASB可以有效地去除废水中的主要恶臭物质甲硫基丙醛.在进水中甲硫基丙醛浓度高达8000mg/L的情况下,经两级串联的UASB处理后,其去除率达100%,而且使废水的恶臭消失.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...