料液浓度对鸭粪中温厌氧消化的影响

在中温35±1 ℃、pH为中性条件下,采用10 L玻璃瓶作为反应器对料液浓度分别为2%、6%、10%和15%的4组鸭粪溶液进行厌氧消化实验,系统运行30 d,分析了厌氧消化过程中的COD、pH、挥发性脂肪酸(VFA)和产气量的变化.结果表明,调节料液浓度至合适的水平对鸭粪厌氧消化过程非常重要,调节鸭粪进料浓度至6%,可...     

金属铁铝对混凝强化初沉污泥中温厌氧消化的影响简

选取FeCl₃和AlCl₃·6H₂O作为混凝剂对城市污水进行一级强化混凝处理,降低二级生物处理的进水负荷,减少污水生物处理系统的能量消耗。主要研究混凝过程投加的金属盐对一级强化混凝产生的初沉污泥中温厌氧消化的影响。和剩余污泥相比,初沉污泥更适合厌氧消化处理,污泥降解性能和产气性能更高。当采用城市污水一级强化混凝处理时,污泥中的金属和金属盐水解引起的pH降低,使混凝强化初沉污泥的厌氧消化受到一定抑制。随着污泥中铝含量的降低和铁含量的增加,厌氧消化的COD降解率和挥发性固体（VS）降解率逐渐升高,生物气产量逐渐增大,产气速率加快。当混凝强化初沉污泥只含有铁时（铁含量为10.16 mg/L）,混凝强化初沉污泥厌氧消化效果最好,产气稳定,而且产气速率高,生物气产量为237 mL,生物气甲烷含量为55.5%,降解单位VS产气量为0.80 L/g,均高于其他含铝的混凝强化初沉污泥。污泥中的铁对初沉污泥厌氧消化的抑制作用远远小于铝的作用,说明铁盐适合用于城市污水的一级强化混凝处理。     

碳氮比对鸭粪中温厌氧消化的影响

在中温(35±1)℃、6%的料液浓度、pH为中性条件下,采用10 L玻璃瓶作为反应器对碳氮比(C/N)分别为15、20、25和35的4组鸭粪溶液进行厌氧消化实验,系统运行30 d,分析了厌氧消化过程中的COD(化学需氧量)、pH、VFA(挥发性脂肪酸)和产气量的变化。结果表明,碳氮比是影响鸭粪厌氧消化过程的重要因素,调节鸭粪碳氮比至25,可以使其厌氧消化获得最佳的产气效果,COD去除率为24.06%,原料干物质产气率为0.178 m3/kg,产气中甲烷含量为71.5%,产甲烷率为0.127 m3/kg。     

接种比对餐厨垃圾干式厌氧发酵启动的影响

针对不同接种比对餐厨垃圾干式厌氧发酵启动的影响,对比分析了VS接种比分别为0.36和0.90两种情况下,餐厨垃圾干式厌氧发酵启动过程中pH、NH4-N、COD、VFA、甲烷含量等指标的变化。实验结果表明,启动初期2组样品pH分别快速降至4.74和5.68,均呈酸化状态,经碱液调整后,接种比为0.36的处理仍无法正常产气,接种比为0.90的处理,pH逐步提高,系统正常运行,经72 d的发酵实验,COD去除率达90.29%,甲烷含量高于60%的沼气产量达255.4 L,分析可见,VS接种比是干式厌氧发酵处理的重要参数;此外,与传统湿式厌氧发酵处理相比,餐厨垃圾干式厌氧发酵在较高的VFA和氨氮浓度下,仍能正常运行,采用干式厌氧发酵技术处理餐厨垃圾是可行的。     

Implications of urine-to-feces ratio in the thermophilic anaerobic digestion of swine waste.

Thermophilic anaerobic digestion of swine manure represents a potential waste treatment technology to address environmental concerns, such as odor emissions and removal of pathogenic microorganisms. However, there are concerns relative to the stability of this process when swine manure is the sole substrate. In this study, the potential of biogas production from swine manure as the sole substrate under thermophilic (50 degrees C) conditions was investigated in the laboratory, to determine whether separation of urine and feces as part of the waste collection process would benefit anaerobic digestion. Effluent from a continuously stirred tank reactor was used as the inoculum for batch tests, in which the substrate contained three different concentrations of urine (urine-free, as-excreted urine-to-feces ratio and double the as-excreted urine-to-feces ratio). Inocula were acclimated to these same urine-to-feces ratios to determine methane production. Results show that both urine-free and as-excreted substrates were not inhibitory to anaerobic inocula. Anaerobic microorganisms can be readily acclimated to substrate with double the as-excreted urine concentration, which contained nitrogen concentrations up to 7.20 g/L. Cumulative methane production reached similar levels in the batch tests, regardless of the substrate urine concentration.     

低强度超声波预处理对厨余垃圾厌氧消化的影响

以厨余垃圾为研究对象,实验研究产气效率、pH、SCOD、甲烷浓度及生物降解率5个参数的变化趋势,比较低强度超声波处理对厨余垃圾厌氧消化产气特性的影响,结果表明:(1)低强度超声波处理对厨余垃圾厌氧消化产生明显效果,在不同的超声波强度(100、175和250 W)或处理时间(20和40 min)下,产气效率、累计产气量、pH下降幅度、SCOD增加幅度随处理时间和超声功率增加而增加;在超声波强度250 W和处理时间60 min下出现抑制作用;(2)在超声波强度250 W和处理时间40 min条件下,超声波对厨余垃圾厌氧消化增强效果最明显,累计产气量由未处理的3 513 mL提高至5 007 mL,提高42.6%,甲烷气体浓度由51.25%提高至58.8%,生物降解率由58.11%提高至73.5%.     

餐厨垃圾高温厌氧消化

在中试规模下,研究餐厨垃圾高温厌氧消化试验,通过监测餐厨垃圾厌氧消化过程中产气量、气体组成等产气情况和消化液中pH值、SCOD、NH4+-N、VFAs等化学指标含量变化,确定餐厨垃圾厌氧消化的最大有机负荷,并分析餐厨垃圾高温厌氧消化技术的可行性,结果表明,在工程上餐厨垃圾单独进行高温厌氧消化产甲烷具有技术可行性,但难以保证系统长时间安全稳定运行;餐厨垃圾厌氧消化正常运行时最大有机负荷可达2.551 kg VS/(m3.d);当系统有机负荷为2.551 kg VS/(m3.d)时,每天每千克VS最高可产生甲烷量0.622 m3;氨氮对餐厨垃圾厌氧消化产甲烷影响明显;餐厨垃圾中固有Na+含量对厌氧消化产甲烷影响不明显。     

Inhibition of residual <Emphasis Type="Italic">n</Emphasis>-hexane in anaerobic digestion of lipid-extracted microalgal wastes and microbial community shift

Converting lipid-extracted microalgal wastes to methane (CH₄) via anaerobic digestion (AD) has the potential to make microalgae-based biodiesel platform more sustainable. However, it is apparent that remaining n-hexane (C₆H₁₄) from lipid extraction could inhibit metabolic pathway of methanogens. To test an inhibitory influence of residual n-hexane, this study conducted a series of batch AD by mixing lipid-extracted Chlorella vulgaris with a wide range of n-hexane concentration (～10 g chemical oxygen demand (COD)/L). Experimental results show that the inhibition of n-hexane on CH₄ yield was negligible up to 2 g COD/L and inhibition to methanogenesis became significant when it was higher than 4 g COD/L based on quantitative mass balance. Inhibition threshold was about 4 g COD/L of n-hexane. Analytical result of microbial community profile revealed that dominance of alkane-degrading sulfate-reducing bacteria (SRB) and syntrophic bacteria increased, while that of methanogens sharply dropped as n-hexane concentration increased. These findings offer a useful guideline of threshold n-hexane concentration and microbial community shift for the AD of lipid-extracted microalgal wastes.     

Overview of anaerobic treatment: thermophilic and propionate implications.

Difficulties in achieving low propionate concentrations in anaerobically treated effluents are frequently reported in the literature (Ahring, 1994; Kugelman and Guida, 1989; Rimkus et al., 1982), especially at thermophilic temperatures, with concentrations as high as 1000 to 9600 mg/L sometimes produced. This paper will detail the effect of several variables on the performance of both mesophilic and thermophilic regimes. Studies concerning the effect of the following four important factors on performance are included: reactor configuration, inorganic nutrient supplementation, substrate characteristics, and the unique role of microbial consortia proximity in enhancing performance. Reactor configuration modifications, essential nutrient additions, and the importance of close microbial proximity were all found to contribute to improvement in thermophilic anaerobic digestion in all the studies. It was found that, in substrates that shunt significant amounts of the electron donor through propionate, performance was critically related to reactor optimization, with propionate removal efficiency considerably improved using intact upflow anaerobic sludge blanket granules, less so in a homogenized granule slurry blanket, and noticeably reduced even more when the completely stirred reactor configuration of homogenized granules was used. The critical importance of extremely close microbial consortia proximity in maintaining hydrogen intermediates at very low levels to efficiently convert propionate to hydrogen and acetate was demonstrated. Compared to mesophilic digestion, thermophilic digestion manifested elevated levels of propionate, except in the nonmixed reactors, which had close microbial consortia proximity. The reactor configuration with the best results was the anaerobic digestion elutriated phased treatment (ADEPT) scheme, in which the raw sludge was elutriated of its fermenting volatile fatty acids, as they are generated in a short 5- to 8-day solids retention time (SRT) in one reactor and the elutriate then metabolized by passing up through a methanogenic granule or slurry blanket (with its close microbial consortia proximity) in a separate reactor with a 20- to 50-day SRT. Loading rates and performance of the ADEPT reactor configuration were superior to the standard continuously stirred tank reactor, and ADEPT thermophilic temperatures allowed higher organic loading rates without high propionate concentrations in the effluent.     

耐酸厌氧消化污泥处理餐厨垃圾简

采用耐酸驯化的厌氧消化污泥处理餐厨垃圾,在酸性条件下（pH=4.5）,对实验装置容积负荷从1.0 kg VS/（m³·d）分9次逐级增加到5.0 kg VS/（m³·d）的过程进行了跟踪监测,并较深入地研究了驯化污泥代谢活性和处理效果。实验结果表明,pH 4.5的耐酸厌氧消化污泥,最佳投加负荷约为4.5 kg VS/（m³·d）,此负荷下容积产气率,CH₄含量平均值均达最大,分别为1.68 m³/（m³·d）,75.0%。耐酸厌氧消化装置持续增料运行46 d,产甲烷菌仍能保持较高的活性,其COD去除率范围为40.4%~75.0%,仍能保持pH 7.2时处理效果的65.0%~91.8%,表明在低pH、低碱度下实现稳定的产甲烷过程是可行的。     

不同粒径零价铁(ZVI)对污水污泥H2S和CH4释放速率的影响

考察了不同粒径零价铁(ZVI),包括200目普通铁粉(200m-ZVI)、800目超细铁粉(800m-ZVI)和纳米铁粉(nZVI,粒径=20 nm),对污水污泥的硫化氢和甲烷释放速率的影响。研究发现:(1)在22 d内,添加0.1%的200m-ZVI使污泥的硫化氢释放速率提高48.0%,而添加0.1%的800-ZVI和nZVI,则使污泥的硫化氢释放速率分别降低33.1%和77.1%;(2)不同粒径ZVI均可以提高污泥沼气中的甲烷浓度,且依次为nZVI>800m-ZVI>200m-ZVI;(3)在23 d内,添加0.1%的200m-ZVI和nZVI使污泥的甲烷累计产生量分别提高了15.5%和40.6%,而添加0.1%800m-ZVI则使甲烷产生量降低了12.5%。nZVI可以有效控制污泥的硫化氢释放,并显著提升污泥在厌氧发酵过程的产甲烷速率。     

Biohydrogen production from dairy manures with acidification pretreatment by anaerobic fermentation

Background, aim, and scope  

Hydrogen is a clean and efficient energy source and has been deemed as one of the most promising carriers of new energy for the future. From an engineering point of view, producing hydrogen by mixed cultures is generally preferred because of lower cost, ease of control, and the possible use of organic waste as feedstock. The biological hydrogen production has been intensively studied in recent decades. So far, most investigates of biohydrogen production are still confined to using pure carbohydrates and carbohydrate-rich wastewater. Nowadays, the large amounts of livestock manure, which come from cattle feedlots, poultry, and swine buildings, are causing a major environmental issue because it has become a primary source of odors, gases, dust, and groundwater contamination. The increasingly stringent requirements for pollution control on livestock manures are challenging the scientific community to develop new waste treatment strategies. Thus, there is a pressing need to develop nonpolluting and renewable energy source utilizing the organic waste (e.g., livestock manure). It is well known that anaerobic digestion had successfully been used for the disposal of manures to produce methane in the last two decades. Recently, an alternative strategy has been developed to convert livestock manures (e.g., dairy manures) to biohydrogen as a high value-added clean energy source instead of methane. However, little information is available on hydrogen production from dairy manure via the mixed anaerobic microbe. As far as we know, the hydrogen production is habitually accompanied with production of volatile fatty acids (VFAs), such as acetate, butyrate, and propionate, which are also an optimal feedstock for production of methane by anaerobic digestion. Provided that the biohydrogen production from dairy manure is further combined with the anaerobic digestion of the effluent from the producing hydrogen reactor that would be a one-stone two-bird paradigm, it not only produces a clean and readily usable biologic energy but also cleans up simultaneously the environment in a sustainable fashion.     

污泥与餐厨垃圾联合厌氧发酵产氢余物产甲烷条件优化研究

研究了21、37和47 d产甲烷物料代替新鲜污泥接种于污泥与餐厨垃圾联合厌氧发酵产氢余物的厌氧发酵产甲烷情况,发现接种47 d产甲烷物料的消化系统在最佳接种量50%条件下的产甲烷效能显著优于接种新鲜污泥的消化系统,不仅提高了产甲烷率,还大大缩短了消化时间。并且3种消化系统产甲烷率和比产甲烷率均为47 d37 d21 d,分别为3.78、3.88、6.15 mL/g和0.172、0.277、0.559 mL/(g·d),完成产甲烷过程的消化时间为47 d37 d21 d。在一定的消化时间范围内,产甲烷菌被驯化时间越长,接种于产氢余物中的产甲烷效能越好。     

Illumina sequencing-based analysis of a microbial community enriched under anaerobic methane oxidation condition coupled to denitrification revealed coexistence of aerobic and anaerobic methanotrophs

Methane is produced in anaerobic environments, such as reactors used to treat wastewaters, and can be consumed by methanotrophs. The composition and structure of a microbial community enriched from anaerobic sewage sludge under methane-oxidation condition coupled to denitrification were investigated. Denaturing gradient gel electrophoresis (DGGE) analysis retrieved sequences of Methylocaldum and Chloroflexi. Deep sequencing analysis revealed a complex community that changed over time and was affected by methane concentration. Methylocaldum (8.2%), Methylosinus (2.3%), Methylomonas (0.02%), Methylacidiphilales (0.45%), Nitrospirales (0.18%), and Methanosarcinales (0.3%) were detected. Despite denitrifying conditions provided, Nitrospirales and Methanosarcinales, known to perform anaerobic methane oxidation coupled to denitrification (DAMO) process, were in very low abundance. Results demonstrated that aerobic and anaerobic methanotrophs coexisted in the reactor together with heterotrophic microorganisms, suggesting that a diverse microbial community was important to sustain methanotrophic activity. The methanogenic sludge was a good inoculum to enrich methanotrophs, and cultivation conditions play a selective role in determining community composition.     

The composition,leaching, and sorption behavior of some alternative sources of phosphorus for soils

Concerns about the sustainability of inorganic fertilizers necessitate the characterization of alternative P source materials for agronomic P-efficiencies and P losses via leaching. Firstly, this study examined nutrient compositions including P speciation of seven soil amendments: sewage sludge (SS), anaerobic digestate (AD), green compost (GC), food waste compost (FWC), chicken manure (CM), biochar, and seaweed. Secondly, soil P leaching and availability was studied on a subset of four materials (SS, AD, GC, and CM). Sorption of extracts onto columns of a test soil showed strong P retention for SS and compost, but weak P sorption for CM and especially AD, suggesting short-term leaching risks for soil applied AD. Limited P desorption with water or citrate indicated sorbed P was strongly fixed, potentially limiting crop availability. These data indicate that variation in P forms and environmental behavior should be understood to maximize P usage, but minimize leaching and soil P accumulation. Hence, different alternative P source materials need differing recommendations for their agronomic management.     

不同粒径零价铁（ZVI）对污水污泥H_2S和CH_4释放速率的影响

考察了不同粒径零价铁（ZVI）,包括200目普通铁粉（200m-ZVI）、800目超细铁粉（800m-ZVI）和纳米铁粉（nZVI,粒径=20 nm）,对污水污泥的硫化氢和甲烷释放速率的影响。研究发现：（1）在22 d内,添加0.1%的200m-ZVI使污泥的硫化氢释放速率提高48.0%,而添加0.1%的800-ZVI和nZVI,则使污泥的硫化氢释放速率分别降低33.1%和77.1%;（2）不同粒径ZVI均可以提高污泥沼气中的甲烷浓度,且依次为nZVI〉800m-ZVI〉200m-ZVI;（3）在23 d内,添加0.1%的200m-ZVI和nZVI使污泥的甲烷累计产生量分别提高了15.5%和40.6%,而添加0.1%800m-ZVI则使甲烷产生量降低了12.5%。nZVI可以有效控制污泥的硫化氢释放,并显著提升污泥在厌氧发酵过程的产甲烷速率。     

Co-digestion of sewage sludge and dewatered residues from enzymatic hydrolysis of sugar beet pulp

Sugar beet pulp residues (SBPR) from hydrolysis and dewatering of beet pulp were co-digested with municipal sewage sludge (MSS). The highest biogas yields of nearly 512 dm³/kg VS_fed (volatile solids fed) were achieved for SBPR, treated both as the monosubstrate and as a mixture with MSS (1 : 1 by weight). Simultaneously, the highest methane production of 348 dm³ CH₄/kg VS_fed was determined when the sewage sludge was co-digested with 35% SBPR. The analysis of digestate showed that neither ammonia nor volatile fatty acids destabilized the biogas production.

Implications:?Processing of sugar beet pulp into bioethanol via enzymatic hydrolysis and microbial fermentation has become increasingly attractive. However, in this process, only the liquid fraction derived from hydrolysis is subjected into alcoholic fermentation, whereas the remaining solid fraction needs to be utilized. This study demonstrated that sugar beet pulp residues after bioethanol production can successfully be co-digested with sewage sludge to increase biogas productivity of anaerobic digesters located at wastewater treatment plants.     

Anaerobic digestion of thermal-alkaline–pretreated cephalosporin bacterial residues for methane production

Optimum anaerobic conditions of cephalosporin bacterial residues after thermal-alkaline pretreatment were determined by orthogonal experiments. And through biochemical methane potential tests (BMPs) for cephalosporin bacterial residues, the ability for bacterial degradation of cephalosporin was also evaluated. The thermal-alkaline pretreatment with the optimum values of 6% NaOH at 105 °C for 15 min significantly improved digestion performance. With the thermal-alkaline pretreatment, the specific methane yield of the pretreated cephalosporin bacterial residue increased by 254.79% compared with that of the un-pretreated cephalosporin bacterial residue. The results showed that anaerobic digestion of thermal-alkaline–pretreated cephalosporin bacterial residues could be one of the options for efficient methane production and waste treatment.

Implications: This work investigates the thermal-alkaline pretreatment of cephalosporin bacterial residues, which can increase their methane yield by 254.79% compared with no pretreatment. The digestion performance is significantly improved under the condition of 6% NaOH at 105 °C for 15 min. The results show that anaerobic digestion of thermal-alkaline–pretreated cephalosporin bacterial residues could be one of the options for efficient methane production and waste treatment.     

Performances of mesophilic anaerobic digestion systems treating poultry mortalities

Abstract

A closed‐loop anaerobic digestion system consisting of a leachbed (LB) and an upflow anaerobic sludge blanket (UASB) was tested as an alternative for the disposal of poultry mortalities. This paper compares the performances of three LB‐UASB treatment systems with different initial moisture contents in the LBs. Each LB was loaded with one chicken and 5, 10 or 18 liters of water. The LBs initially carried out the hydrolysis/acidification phase while the UASBs the methanogenesis phase. Due to repeated inoculation by the UASBs, the LBs with 10 and 18 liters of water started producing methane on day 5, while the one with 5 liters of water on day 19. However, methane production rates were low before day 40 for the LB with 10 liters of water and day 60 for the other LBs. Methane production gradually improved as the LBs continued to receive ungranulated sludge from the UASBs. The LBs eventually became balanced methane reactors. Continued balanced fermentation in the LBs resulted in leachates with very low substrate concentrations that could no longer support high‐rate methanogenesis in the UASBs. Consequently, methane production rates from the UASBs decreased quickly while that from the LBs reached peak levels. Cumulative methane production from each LB eventually exceeded that from its connecting UASB. After 118 days of digestion, 414, 437 and 470 liters of methane were produced from the three systems, respectively. Cumulative methane production from the LBs with 5 and 18 liters of water accounted for 63% of the total methane produced from their respective systems. The LB with 10 liters of water produced 75% of the total methane from that system. Methane yields ranged from 0.485 to 0.554 m³ (Kg TS) ¹. About 86% of the initial dry weight was biodegraded. All three systems performed very well with little operational problems. Overall, the system that started with 10 liters of water in the LB performed the best. Strategy for enhancing system performances and implementing farm applications are discussed.     

Optimal Loading Rates and Economic Analyses for Anaerobic Digestion of Poultry Waste

ABSTRACT

Four combinations of litter and carcasses from broiler chickens were examined utilizing a thermophilic, stirred-tank digester of demonstration size of approximately 10,000 gal. Under computed optimal loading rates, litter with paper bedding had the highest daily production of methane over an 8-day retention period. The greatest methane production per lb of volatile solids was achieved over 10 days with litter and paper bedding combined with carcasses. This research found that sufficient poultry litter is generated within 20 mi (32 km) of Moorefield, WV, to support a commercial-sized digester operation. However, anaerobic digestion of poultry waste cannot be financially supported by methane production alone. To be financially viable, anaerobic digestion requires a disposal fee for poultry waste and/or the sale of the digested solid effluent as an organic fertilizer to retail markets.