膜生物反应器组合工艺处理PTA废水的研究

采用膜生物反应器为核心的组合工艺对PTA废水进行处理,考察了组合工艺的处理效果。结果表明,该工艺对PTA废水有较好的处理效果,系统抗负荷冲击性强,出水水质好。在有机负荷为3.55kgCOD/m3d时,系统出水CODcr稳定在120mg/L以下,COD去除率高达95%以上。同时构建了MBR系统有机底物降解动力学模型,并对其进行了分析。     

固定化甲烷八叠球菌及处理高浓度有机废水研究

为了克服PVA包埋固定化甲烷八叠球菌存在的缺点 ,采用吸附和包埋结合法对甲烷八叠球菌进行了固定化 ,并用UASB反应器以高浓度人工废水和豆制品废水为底物对固定化甲烷八叠球菌特性进行研究 .用人工废水运转的结果表明 ,最高容积负荷为 14 7kg(COD) (m3·d) ,最高COD去除率为 94 3 % ,最低水力停留时间 (HRT)为 16 4h ,甲烷含量为 65 %～73 % .用豆制品废水运转的结果表明 ,最高COD负荷 17 6kg (m3·d) ,平均容积负荷 8 2kg(COD) (m3·d) ,最低为 13 7h ,最高产气率 7L (d·L) ,平均产气率固定化为非固定化的 15 2倍 ,最高COD去除率达到了 87% .     

年产10万t啤酒项目废水处理工艺设计及运行分析

在详细调查啤酒企业生产工艺和废水排放情况的基础上,确定了以IC厌氧反应器和一体化氧化沟联合工艺处理10万t·a-1啤酒企业废水的工艺路线及主要设计参数,讨论了采用该工艺处理啤酒废水时的运行情况和处理效果.结果表明:IC厌氧反应器CODCr有机负荷为6 kg·(m3·d)-1时,CODCr去除率为85%以上,一体化氧化沟CODCr有机负荷为0.5 kg·(m3·d)-1时,CODCr去除率为90%以上,出水ρ(COD)小于80 mg·L-1,完全可满足废水处理要求,且具有良好的环境效益和经济收益.     

UASB处理生物柴油废水的效果研究

采用升流式厌氧污泥床(UASB)工艺处理地沟油回收制备生物柴油废水,通过试验研究了UASB反应器各个阶段对该类废水的处理效果,并考察了甲基磺酸、对甲基苯磺酸两种预酯化催化剂对该类废水处理效果的影响。结果表明:当进水COD为15g/L、容积负荷为15kg/(m3·d)时,UASB反应器COD的去除率稳定在87%左右,出水VFA为4~6mmol/L,沼气产量为16.8L/d;当容积负荷稳定在5kg/(m3·d),进水甲基磺酸浓度为5500mg/L时,UASB反应器COD的去除率达83%以上,进水对甲基苯磺酸浓度为1 000mg/L时,UASB反应器COD的去除率为58.3%,从废水处理的难易程度角度考虑,建议采用甲基磺酸为预酯化催化剂。     

冷冻浓缩处理废水COD、TOC及能耗分析

从冷冻时间、初始温度、冷冻温度及废水浓度4个方面通过实验和理论计算分析,研究了冷冻浓缩处理高浓度有机废水的能耗情况及COD和TOC的去除率。通过冷冻实验和理论计算,确定了对COD浓度范围为10 000~30 000 mg/L的高浓度有机废水去除率较高、能耗较低各个因素的取值范围。其中冷冻时间在12~24 h、初始温度在5~15℃范围内,COD和TOC去除率达到60%以上,冷冻温度在-16~-12℃时COD和TOC去除率达到70%以上。相应的冷冻废水处理能耗范围为0.044~0.067 kW·h/kg。     

厌氧处理核糖核酸废水的研究

根据核糖核酸废水水质的特性,采用高负荷UASB厌氧处理工艺,证明了核糖核酸废水采用厌氧处理的可能性。实验过程分析了UASB有机负荷对CODcr去除率的影响及进出水pH的变化情况,研究表明,在中温（35℃～38℃）的条件下,UASB有机负荷3.0 kg/（m^3·d）时,CODcr去除率可达到85%左右,出水平均pH值在7.0左右。因此该工艺有推广应用的可能性。     

高效除油菌应用于TMBR工艺处理采油废水

介绍了外置式超滤膜生物反应器处理采油废水的工艺特点、调试过程及处理效果,该工艺将活性污泥池和膜组件高度集成于一集装箱(11.8 m×2.33 m×2.72 m)内,通过生化反应及膜过滤处理采油废水。设计COD负荷1.35 kg/(d·m3),产水量2.56 m3/h,接种高效除油菌群并稳定运行后该设备COD负荷为1.83~2.68 kg/(d·m3),产水量达3.8 m3/h,日净化水量高达60~91 m3,COD平均去除率为94%,油含量平均去除率为95%,细菌及悬浮物去除率达99.9%,出水指标达SY/T 5329—94《碎屑岩油藏注水水质推荐指标》中A1级标准。     

微压流化式复合生物反应器处理含酚废水效能的研究

通过连续动态试验,对新型微压流化式复合生物反应器(MP-FHBR)处理模拟苯酚废水的效能进行研究.结果表明,MP-FHBR的COD容积负荷可达4.86kg/(m3·d)、苯酚容积负荷可达1.96kg/(m3·d),出水COD低于200mg/L、出水苯酚浓度低于1mg/L,COD和苯酚去除率分别达到90%和99%以上.当苯酚容积负荷达到2.04kg/(m3·d),苯酚在反应器中逐渐累积,反应器内微生物的TTC-比脱氢酶活性下降.当MP-FHBR进水苯酚浓度为800mg/L时,最佳水力停留时间为9～10h.水力负荷对反应器沉淀池的泥水分离效果影响较大,限制了反应器的进水量,所以MP-FHBR主要适用于处理较高浓度的含酚废水.     

UASB-SBR处理生物柴油制环氧脂肪酸甲酯废水

采用上流式厌氧污泥床(UASB)-序批式活性污泥法反应器(SBR)组合工艺处理生物柴油制环氧脂肪酸甲酯废水,考察了反应器各个阶段废水的处理效果。试验结果表明:当调整废水的氧化还原电位(ORP)降至-50~+50mV,UASB稳定运行阶段进水COD约为6 000mg/L时,出水COD在1 300mg/L以下,COD去除率约为80%,VFA浓度为180mg/L(以乙酸计)左右,最佳容积负荷为6.0kg/(m3·d);采用SBR处理UASB出水,当容积负荷为1.27kg/(m3·d)时,出水COD在250mg/L以下,COD去除率在80%以上,氨氮浓度在25mg/L以下,TP浓度在4mg/L以下,且处理后废水的COD、氨氮浓度、TP浓度均达到《污水排入城市下水道水质标准》(CJ343—2010)的A级要求。     

中温两相UBF反应器处理养鸡场离心废水的试验分析

在中温 35℃采用两相 UBF反应器处理养鸡场离心废水 ,结果表明 :进水 CODcr为 190 0 0 mg/ L,系统容积负荷 2 1.5 4kg CODcr/ m3· d,水力停留时间 2 1.17hr,CODcr去除率为 81.98% ,BOD5 去除率为 90 .45 % ,产气率为 0 .44 6 m3/kg CODcr     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Sorption of 1-naphthol by plant cuticular fractions

The contribution of aliphatic-rich plant biopolymer to sorption of hydrophobic organic compounds is significantly important because of their preservation and accumulation in the soil environment,but sorption mechanism is still not fully understood.In this study, sorption of 1-naphthol by plant cuticular fractions was examined to better understand the contributions of respective fraction.Toward this end,cuticular materials were isolated from the fruits of tomato by chemical method.The tomato cuticle sheet consisted of waxes (6.5 wt%),cuticular monomer (69.5 wt%),and polysaccharide (24.0 wt%).Isotherms of l-naphthol to the cuticular fractions were nonlinear (N value (0.82-0.90)) at the whole tested concentration ranges.The KodKow ratios for bulk cuticle (TC1),dewaxed cuticle (TC2),cutin (TC4),and desugared cuticle (TC5) were larger than unity,suggested that tomato bulk cuticle and cutin are much powerful solption medium.Sorption capability of cutin (TC4) was 2.4 times higher than the nonsaponifiable fraction (TC3).The 1-naphthol interactions with tomato cuticular materials were governed by both hydrophobic-type interactions and polar (H-bonding) interactions. Removal of the wax and polysaccharide materials from the bulk tomato cuticle caused a significant increase in the sorption ability of the cuticular material.There was a linear negative trend between K_(oc) values and the amount of polysaccharides or fraction's polarities ((N O)/C);while a linear positive relationship between K_(oc) values and the content of cutin monomer (linear R~2=0.993) was observed for present in the cuticular fractions.Predominant sorbent of the hydrophobic organic compounds (HOCs) in the plant cuticular fraction was the cutin monomer,contributing to 91.7% of the total sorption of tomato bulk cuticle.     

Alterations of organ histopathology and metallolhionein mRNA expression in silver barb, Puntius gonionotus during subchronic cadmium exposure

Common silver barb,Puntius gonionotus,exposed to the nominal concentration of 0.06 mg/L Cd for 60 d,were assessed for histopathological alterations(gills,liver and kidney),metal accumulation,and metallothionein(MT)mRNA expression.Fish exhibited pathological symptoms such as hypertrophy and hyperplasia of primary and secondary gill lamellae,vacuolization in hepatocytes,and prominent tubular and glomerular damage in the kidney.In addition,kidney accumulated the highest content of cadmium,more than gills and liver.Expression of MT mRNA was increased in both liver and kidney of treated fish.Hepatic MT levels remained high after fish were removed to Cd-free water.In contrast,MT expression in kidney was peaked after 28 d of treatment and drastically dropped when fish were removed to Cd-free water.The high concentrations of Cd in hepatic tissues indicated an accumulation site or permanent damage on this tissue.     

Seed selections for crystallization of calcium phosphate for phosphorus recovery

Seed induces and promotes the crystallization of calcium phosphate, and acts as carrier of the recovered phosphorus （P）. In order to select suitable seed for P recovery from wastewater, three seeds including Apatite （AP）, Juraperle （JP） and phosphate-modified Juraperle （M-JP） were tested and compared. Batch and fixed-bed column experiments of seeded crystallization of calcium phosphate were undertaken by using synthetic wastewater with 10 mg/L P phosphate. It shows that AP has bad enduring property in the crystallization process, while JP has better performance for multiple uses, and M-JP is a hopeful seed for P recovery by crystallization of calcium phosphate.