循环流化床灰制备聚合双酸铝铁絮凝剂

为了提高循环流化床灰(CFB灰)的资源综合利用率对CFB灰制备聚合双酸铝铁(PAFCS)的可行性及工艺参数进行了研究,提出了以酸浸、水解、聚合和熟化等工艺过程,制备PAFCS混凝剂产品。重点对制备PAFCS絮凝剂的工艺参数进行研究,并利用红外光谱分析技术对PAFCS进行了结构表征及实验了PAFCS絮凝性能。结果表明,在相同条件下PAFCS的絮凝效果明显好于聚合氯化铝(PAC),用CFB灰制备PAFCS絮凝剂产品是可行的。     

基于废弃桑枝的新型絮凝剂的制备及应用研究

针对栽桑养蚕过程中废弃桑枝的综合利用,以废弃桑枝和十六烷基三甲基溴化铵为原料,经微波辐射加热制备高分子絮凝剂。通过单因素实验确定了制备絮凝剂的最佳工艺条件,并采用该絮凝剂处理造纸废水。结果表明,制备絮凝剂的最佳工艺条件为:NaOH溶液浓度为8%,碱化温度为室温,碱化时间为30 m in,Fe2+/H2O2的加入量为14 mmol/L,桑枝粉与十六烷基三甲基溴化铵的质量比为1∶1,微波功率为500 W,反应温度为90℃,反应时间为60 m in。制备的絮凝剂对造纸废水具有高效絮凝性能,在造纸废水pH值为10,絮凝剂投加量为100 mg/L的条件下,COD和浊度去除率分别达48.2%和81.4%。该絮凝剂对造纸废水的絮凝效果明显优于氯化铝,与聚合氯化铝相当,但其用量明显低于氯化铝和聚合氯化铝。     

《环境污染与防治》网络版论文摘要

高效絮凝剂聚合氯化铝的制备及脱色实验的研究鲁秀国焦玲任焕弟贺志强(河北大学化学与环境科学学院,河北保定071002)以铝灰为原料,制备出高效絮凝剂聚合氯化铝(PAC),采用正交实验寻求制备的最佳配方和工艺条件。并将产品应用于模拟染料废水中,得到PAC的最佳投加量为0.5mL/L,PAC     

聚合氯化铝铁去除微污染水体中藻类的研究

以聚合氯化铝铁(PAFC)为絮凝剂,H2O2为预氧化剂,用正交实验研究了PAFC处理微污染水体中藻类和降低浊度,得出正交实验中各因素的主次关系及对除藻和除浊度的影响,研究表明,ρPAFC是影响除藻和除浊度的重要因素.在最佳处理条件,即ρPAFC为20 mg/L,ρH2O2为6 mg/L,pH为7,搅拌时间为4 min,能使水体中藻细胞街度从9.4×107 cells/L降至3.16×106 cells/L,除藻率为96.6%,浊度降至0.70 NTU,除浊度率达93.0%.     

用褐铁矿制备聚硅氯化硫酸铁的研究

通过正交实验研究了用盐酸、硫酸、褐铁矿和硅酸钠制备聚硅氯化硫酸铁（PSFCS）絮凝剂的工艺条件。实验结果表明,浸取时间为2.5～3 h,浸取温度为110℃,硫酸浓度为6 mol/L,盐酸浓度为3 mol/L,质量液固比为4∶1,铁的浸出率可达95.7%～96.3%。溶液中加入少量聚乙烯醇作稳定剂,亚硝酸钠作氧化催化剂。PSFCS的合成条件：Fe/Si摩尔比为2,硅酸活化pH值为2,硅酸活化时间是30～40 min,陈化时间是2～2.5 h。与聚合硫酸铁（PFS）和聚合氯化铝（PAC）比较了处理印染废水的效果,表明PSFCS具有良好的絮凝性能,COD和浊度的去除率分别可达81.4%和96.1%。     

盐酸浸出提取赤泥中铝和铁的工艺条件优化

系统研究盐酸浸出赤泥中铝和铁的过程,考察酸浸温度、盐酸浓度、酸浸时间、液固比以及赤泥粒度对铝、铁浸出率的影响。单因素实验和正交实验结果得出,在影响浸出率的酸浸温度、盐酸浓度、酸浸时间和液固比对铁、铝的浸出率的影响几个因素中,酸浸温度和盐酸浓度的影响最大,液固比和浸出时间其次。盐酸酸浸的最佳工艺条件为:赤泥粒度150μm、酸浸温度80℃、盐酸浓度10 mol·L~(-1)、液固比8∶1(V/m)、浸出时间150 min,此时铝的浸出率为96.7%,铁的浸出率为95.1%,铁铝总浸出率96.0%。     

水性漆洗涤废水的混凝条件优化

为了处理水性漆洗涤废水,对絮凝沉淀处理水性漆洗涤废水进行了研究。分别以硫酸铝(AS)、聚合氯化铝(PAC)、聚合氯化铝(PAFC)和聚合硫酸铁(PFS)4种无机絮凝剂为絮凝剂,考察了不同絮凝剂投加量、搅拌策略和时间以及沉降时间等因素对水性漆洗漆废水COD的去除率和剩余浊度的影响。为了研究几种絮凝剂对水性漆洗涤废水的絮凝机理,对废水和絮凝剂进行了Zeta电位分析。结合废水处理的成本和处理效率,确定了优化处理方案:最终选定PAFC作为絮凝剂,投加量为138 g·t~(-1),快速搅拌1 min,慢速搅拌1.5 min和沉淀60 min。     

新型絮凝剂聚磷氯化铝铁的制备及性能研究

以FeCl3.6H2O、AlCl3.6H2O和Na2HPO4.12H2O为主要原料,采用复合共聚生产工艺,首次制备了聚磷氯化铝铁(PPAFC)絮凝剂,并采用红外光谱及扫描电镜对其结构进行表征,可以推断磷酸根为接聚在PAFC上。考察了投加量、pH值、沉降时间和Al/Fe比等因素对PPAFC混凝性能的影响。与聚合氯化铝(PAC)和聚合氯化铝铁(PAFC)相比,PPAFC具有絮体大、沉降快、除浊效果好的特点,具有广阔的应用前景。     

丙烯酰胺改性壳聚糖絮凝剂处理焦化废水

合成了丙烯酰胺改性壳聚糖絮凝剂;用该絮凝剂处理了A/O工艺处理后的焦化废水.考察了pH值、絮凝剂用量及搅拌时间对去除污染物的影响.实验结果表明,当絮凝剂用量为50.0 mg·L-1,絮凝pH值为6.5,絮凝搅拌时间为12 min,COD、F-和色度的去除率分别达到64.7%、93.2%和75%;丙烯酰胺改性壳聚糖絮凝剂对焦化废水的深度处理效果优于聚合硫酸铁和聚合氯化铝絮凝剂.     

盐酸分级浸出赤泥中有价金属元素

采用盐酸2段分级浸出工艺回收氧化铝赤泥中的有价金属元素。通过考察液固比、反应温度、反应时间及盐酸使用量对浸出率的影响,确定了2段浸出的实验工艺。结果表明:在盐酸用量为理论用量的40%、90℃液固比为7∶1、反应时间1 h的条件下,Ca的浸出率为96.2%,Na的浸出率为82.47%,Al的浸出率为42.87%,其他元素几乎不浸出,这是第1段浸出;在盐酸用量为理论量的130%、90℃、盐酸浓度8.8 mol·L~(-1)的条件下,浸出1段酸浸渣,Fe的浸出率99.65%,Sc的浸出率88.76%,V的浸出率93.58%,其他稀土元素的浸出率均达到了70%左右,这是第2段浸出。     

含锌铅废物碱法浸出工艺

各种工业过程中产生的大量含锌铅废物中含有大量的有毒重金属.必须在危险废物处置场所进行处置,这导致处置成本增加.采用强碱浸出的方法回收含锌铅废物中的Zn和Pb,考察了浸出温度、NaOH浓度、液固比(浸提液体积/原料质量)和搅拌速率等工艺参数对Zn、Pb和杂质金属浸出率的影响,得出其最佳工艺条件.在温度为70℃、液固比为13:1、搅拌速率为800r/min条件下.用5 mol/L的NaOH浸出含锌铅废物,浸出液中Zn和Pb的质量浓度分别达33.47、11.21 g/L,浸出率分别达到94.24%和93.47%.     

Assessment of metolachlor and diuron leaching in a tropical soil using undisturbed soil columns under laboratory conditions

In the present study, diuron [3-(3,4-dichlorophenyl)-1,1-dimethylurea] and metolachlor [2-chloro-N-(2-ethyl-6-methylphenyl)-N-(2-metoxi-1-methylethyl)acetamide] leaching was studied in undisturbed soil columns collected in a cotton crop area in Mato Grosso State, Brazil. The pesticides were applied to the soil surface in dosages similar to those used in a cotton plantation. To assess the leaching process, soil columns were submitted to simulated rain under laboratory conditions at 25 ± 3°C, in the absence of wind and direct solar radiation. During the rain simulations, leachate solutions were collected and herbicide concentrations were determined. At the end of the experiment, the soil columns were cut into 10 cm sections to determine the remaining herbicide concentrations through the soil profile. Metolachlor was detected in all soil sections, and approximately 4% of the applied mass was leached. Diuron was detected only in the upper two soil sections and was not detected in the leachate. A linear correlation (r > 0.94) between the metolachlor soil concentrations and the organic contents of the soil sections was observed. Mass balance suggests that around 56% of diuron and 40% of metolachlor were degraded during the experiments. Measurements of the water table depth in the area where the samples were collected showed that it varied from 2 to 6 m and is therefore vulnerable to contamination by the studied herbicides, particularly metolachlor, which demonstrated a higher leaching potential.     

Use of amendments to reduce leaching loss of phosphorus and other nutrients from a sandy soil in Florida

Goal, Scope and Background Transport of P from agricultural land contributes to the eutrophication of surface waters. Soil amendment is considered one of the best management practices (BMPs) to reduce P loss from sandy soils. Laboratory column leaching experiments were conducted to evaluate the effectiveness of different soil amendments in reducing P leaching from a typical sandy soil in Florida. Methods The tested amendments were CaCl₂, CaCO₃, Al(OH)₃, cellulose, and mill mud, and applied at the rate of 15 g/kg for a single amendment and each 7.5 g/kg if two amendments were combined. Leaching was conducted every four days for 32 days, 250 mL of deionized water being leached for each column per leaching event. Leachates were collected from each leaching event and analyzed for reactive P, PO₄-P, and macro and micro-elements. Results and Discussion Except for the soils amended with CaCl₂, or CaCl₂+CaCO₃, reactive P and PO₄-P leaching losses mainly occurred in the first three leaching events. Phosphorus leaching from the soils amended with CaCl₂ or CaCl₂+CaCO₃ was less but more persistent than that of other amendments. Reactive Pleaching loss was reduced by 36.0% and 40.4% for the amendments of CaCl₂, and CaCl₂+CaCO₃, respectively, as compared with chemical fertilizer alone, and the corresponding values for PO₄-P were 70.8% and 71.9%. The concentrations of K, Mg, Cu, and Fe in leachate were also decreased by CaCl₂ or CaCl₂+CaCO₃ amendment. Among the seven amendments, CaCl₂, CaCO₃, or their combination were most effective in reducing P leaching from the sandy soil, followed by cellulose and Al(OH)₃, the effects of mill mud and mill mud + Al(OH)₃ were marginal. Conclusions These results indicate that the use of CaCl₂, CaCO₃, or their combination can significantly reduce P leaching from sandy soil, and should be considered in the development of BMPs for the sandy soil regions. Recommendations and Outlook Most agricultural soils in south Florida are very sandy with minimal holding capacities for moisture and nutrients. Repeated application of fertilizer is necessary to sustain desired yield of crops on these soils. However, eutrophication of fresh water systems in this area has been increasingly concerned by the public. Losses of P from agricultural fields by means of leaching and surface runoff are suspected as one of the important non-point contamination sources. The benefits and effectiveness of soil amendment in reducing P losses from cropping production systems while sustaining desired crop yield need to be demonstrated. Calcium chloride, CaCO₃, or their combination significantly reduce Pleaching from sandy soil, and should be considered in the development of BMPs for the sandy soil regions.     

施用垃圾堆肥土壤重金属在不同温度和酸雨条件下的淋溶特征

采用淋洗法,研究了垃圾堆肥中重金属在不同温度与模拟酸雨条件下的淋溶特征。结果表明,随着淋洗次数的增加,淋洗液中Cd、Cr、Cu、Ni和Pb的含量都有很大程度的减少。Cd、Cr、Cu和Ni 4种金属在模拟酸雨的情况下淋出量明显高于蒸馏水的情况,增幅都在116%和351%之间,差异显著(P<0.05)或极显著(P<0.01),而酸雨对Pb的淋出影响较小。在酸雨淋洗下,重金属的淋出率在30℃时达到最大,其中Ni随着温度的变化相对较小。而在蒸馏水淋洗下,重金属的淋出率随着温度的变化相对平稳。此外,5种重金属的淋出率明显不同,其中Cr和Ni的淋出率相对较大,Pb最小。     

镍渣的重金属浸出特性

在分析镍渣的矿物相组成和重金属元素含量的基础上,鉴定了镍渣样品的浸出毒性,并考察了pH、液固比和浸出时间等条件对镍渣样中铬、铅、铜和锌等重金属浸出特性的影响。结果表明,镍渣中的重金属总量约为渣样的0.9%,且铬、铜和锌的含量较高,需进行安全管理。实验所用镍渣样品为第Ⅰ类一般工业固体废物。在强酸条件下镍渣中重金属浸出浓度较大,pH3后浸出浓度显著降低;液固比40 L/kg时,镍渣中重金属不断溶出,液固比40 L/kg后,浸出达到饱和,浸出浓度趋于平衡;随着浸出时间的增加,重金属离子的浸出浓度先增加后减少,但由于各重金属性质不同,各重金属达到最大浸出浓度的时间不同。     

Incorporating uncertainty in a chemical leaching assessment

Pesticide leaching models are being used to assist in the regulation and management of pesticides by indicating their potential for leaching to groundwater. Uncertainty in model input data is not, regrettably, included in most pesticide leaching assessments. In the work described here, we use logarithmic transformations of the attenuation factor (AF), a simple process-based index model, to represent uncertainty in a pesticide leaching assessment. Characterization of a wide range of pesticides as `leachers' or `non-leachers' for a specific Hawaii hydrogeological setting is facilitated by comparing the log-transformed AF, designated AFR, for each chemical with two reference chemicals for which leaching behavior in Hawaii is known. Defining a mean and uncertainty interval for the AFR index of each chemical being ranked provides a practical method of incorporating data uncertainty into a regulatory protocol.     

电解锰渣中锰的浸出条件及特征

采用水洗-酸解法回收电解锰渣中锰,探讨了清水量、酸量以及温度在不同阶段对锰浸(洗)出条件的影响,分析了回收锰的主要因素及浸出特征。实验结果表明,50 g电解锰渣经m渣∶m水=1∶10的清水水洗后,采用10%的硫酸在70℃的水浴温度下酸解2 h,Mn2+浸出量为1.673 g,回收率达到97.3%,而温度和酸度对锰离子的浸出影响明显,酸度调控可有效分离酸浸锰液中金属成分,为减少电解锰渣环境污染的同时,实现电解锰渣资源化利用。     

Behavior of atrazine in soils of tropical zone

Abstract

Movement and degradation of ¹⁴C‐atrazine (2‐chloro 4‐(ethylamino)‐6‐(isopropylamino)‐s‐triazine, was studied in undisturbed soil columns (0.50m length × 0.10m diameter) of Gley Humic and Deep Red Latosol from a maize crop region of Sao Paulo state, Brazil. Atrazine residues were largely confined to the 0–20cm layers over a 12 month period Atrazine degraded to the dealkylated metabolites deisopropylatrazine and deethylatrazine, but the major metabolite was hydroxyatrazine, mainly in the Gley Humic soil. Activity detected in the leachate was equivalent to an atrazine concentration of 0.08 to 0.11μg/1.

The persistence of ¹⁴C‐atrazine in a maize‐bean crop rotation was evaluated in lysimeters, using Gley Humic and Deep Red Latosol soils. Uptake of the radiocarbon by maize plants after 14‐days growth was equivalent to a herbicide concentration of 3.9μg/g fresh tissue and was similar in both soils. High atrazine degradation to hydroxyatrazine was detected by tic of maize extracts. After maize harvest, when beans were sown the Gley Humic soil contained an atrazine concentration of 0.29 μg/g soil and the Deep Red Latosol, 0.13 μg/g soil in the 0–30 cm layer. Activity detected in bean plants corresponded to a herbicide concentration of 0.26 (Gley Humic soil) and 0.32μg/g fresh tissue (Deep Red Latossol) after 14 days growth and 0.43 (Gley Humic soil) and 0.50 μg/g fresh tissue (Deep Red Latossol) after 97 days growth. Traces of activity equivalent to 0.06 and 0.02μg/g fresh tissue were detected in bean seeds at harvest. Non‐extractable (bound) residues in the soils at 235 days accounted for 66.6 to 75% (Gley Humic soil and Deep Red Latossol) of the total residual activity.     

生物法和化学法回收制革污泥中铬的对比研究

研究了嗜酸性硫杆菌(Thiobacillus)生物沥滤法和1:1硫酸化学沥滤法分离回收制革污泥中的铬.比较了嗜酸性硫杆菌生物沥滤法和化学沥滤法回收制革污泥铬过程中pH、氧化还原电位(ORP)、沉降比(SV)以及铬的沥滤率的变化.试验结果表明,pH是影响制革污泥中铬的沥滤率的关键因素.生物沥滤法在使污泥pH大幅度降低的同时,能很好地改善污泥的沉降性能,对铬的沥滤效果好于化学沥滤法.     

Effect of fly ash on metsulfuron-methyl sorption and leaching in soils

This investigation was undertaken to determine the effect of amendment of two fly ashes [Kota and Inderprastha (IP)] on sorption behavior of metsulfuron-methyl in three Indian soil types. Kota fly ash (5%) did not show any effect on herbicide sorption while IP fly ash significantly enhanced the sorption. Further studies on metsulfuron-methyl sorption-desorption behavior in 0.5, 1, 2, and 5% IP fly ash-amended soils suggested that effect of fly ash varied with soil type and better effect was observed in low organic carbon content soils. The sorption-desorption isotherms fitted very well to the Freundlich sorption equation and, in general, slope (1/n) values less than unity were observed. Metsulfuron-methyl sorption in the IP fly ash-amended soils showed strong correlation with the fly ash content and compared to the Freundlich sorption constant (K _f), K _FA values (sorption normalized to fly ash content) showed less variation. Metsulfuron-methyl leaching studies suggested greater retention of herbicide in the application zone in IP fly ash-amended soils, but effect varied with soil type and no herbicide leaching was observed in 5% fly ash-amended soils. The study suggested that all coal fly ashes are not effective in enhancing the sorption of metsulfuron-methyl in soils. However, one which enhanced herbicide sorption, could play an important role in reducing its leaching losses.