发酵类抗生素废水处理工艺及运行效果

介绍了内蒙古某抗生素废水处理厂的处理工艺流程、处理单元类型及其详细设计参数,通过对该污水处理厂半年内运行效果的调研,分析评价该污水处理系统的处理效果及出水指标;该水厂工艺流程对COD、TOC、氨氮、总氮、总磷、BOD和急性毒性的平均去除率分别为96.52%、95.83%、50.24%、55.20%、62.05%、98.52%和99.14%,COD、氨氮、总氮、总磷出水水质分别为477、438、556.7和7.69 mg/L,达到排放到城区下水道要求,园区内所有废水汇集到园区污水处理厂进行集中深度处理达标后排放水体。通过对该水厂工艺的介绍和水质分析,为我国抗生素生产企业面临的废水处理工艺类型选择及工程改造升级提供一定参考。     

Determination of Schulze equation for chemical oxygen demand reduction using stabilized landfill refuse media

Three columns each with 770 cm2 of surface area and 60-105 cm effective depth were set up for this study. These columns were filled with compacted, stabilized refuse. High-strength brewery wastewaters were uniformly trickled down the medium. Overall, 16 runs with various organic loadings were tested and the results demonstrated that the stabilized refuse had excellent capability in removing chemical oxygen demand (COD). The COD removal efficiency reached 95% at a depth of 60 cm at Q = 8 L/day for the initial COD of approximately 6000 mg/L and the efficiency increased to >99% at a depth of 90 cm (organic loading of 0.69 kg/m3/day). As would be expected, the filter performance is a function of flow rate, influent COD concentration, and bed depth. The Schulze equation is able to predict the COD removal performance well. The variations of pH, oxidation reduction potential, and volatile fatty acids indicated that the acidogenesis reaction occurred in the upper layers.     

Integrated physicochemical and biological treatment process for fluoride and phosphorus removal from fertilizer plant wastewater

The phosphate fertilizer industry produces highly hazardous and acidic wastewaters. This study was undertaken to develop an integrated approach for the treatment of wastewaters from the phosphate industry. Effluent samples were collected from a local phosphate fertilizer producer and were characterized by their high fluoride and phosphate content. First, the samples were pretreated by precipitation of phosphate and fluoride ions using hydrated lime. The resulting low- fluoride and phosphorus effluent was then treated with the enhanced biological phosphorus removal (EBPR) process to monitor the simultaneous removal of carbon, nitrogen, and phosphorus. Phosphorus removal included a two-stage anaerobic/aerobic system operating under continuous flow. Pretreated wastewater was added to the activated sludge and operated for 160 days in the reactor. The operating strategy included increasing the organic loading rate (OLR) from 0.3 to 1.2 g chemical oxygen demand (COD)/L.d. The stable and high removal rates of COD, NH4(+)-N, and PO4(3-)-P were then recorded. The mean concentrations of the influent were approximately 3600 mg COD/L, 60 mg N/L, and 14 mg P/L, which corresponded to removal efficiencies of approximately 98%, 86%, and 92%, respectively.     

内循环(IC)厌氧反应器处理糖蜜酒精废水的研究

糖蜜酒精废水由于含有高浓度的COD和硫酸盐,一般厌氧反应器无法有效处理.研究了IC反应器处理糖蜜酒精废水的效果.考察其COD及硫酸盐的去除率、沼气的产量和组分等.结果表明,反应器对于COD为5000～10 000 mg/L的中、高浓度废水去除效果良好,当COD在20 000～30 000 mg/L时,在适应了1～2个停留时间后,去除效果达到稳定,去除率在90%左右.实验中最高容积负荷提升至40 kg COD/m3·d左右.本研究中所用的糖蜜酒精废水的COD/SO24-的平均值为61.9,未对反应器的处理效果及产气量产生影响.     

微氧膜生物反应器同时去除有机物和氮的研究

采用微氧颗粒污泥膜生物反应器处理生活污水,进行同时去除有机物和氮的研究。结果表明,膜出水COD不受水力停留时间变化的影响一直稳定在较低值,为15~35mg/L,去除率在94%以上。氮通过发生同时硝化反硝化反应而去除。在水力停留时间为16h以上时, 系统总氮去除率为65% ~92%,平均去除率为77%。     

复合生物反应器处理焦化废水试验研究

采用在悬浮相污泥中投入纤维球填料形成单一复合生物反应器来处理焦化废水,研究了各个运行参数对复合生物反应器处理效果的影响,确定出最佳的运行参数,并研究了在最佳运行条件下复合生物反应器对焦化废水中的COD和NH3-N的去除情况。试验结果表明,采用单一复合生物反应器是一种很好的焦化废水处理方法,它能有效地降解焦化废水中的COD和NH3-N等难降解物质,当进水COD和NH3-N分别小于670、260mg／L时,COD和NH3-N的去除率分别可高达94．8％和91．4％。     

Chemical composition associated with different particle size fractions in municipal, industrial, and agricultural wastewaters

A more detailed characterization of particulate organic matter in wastewater streams is needed to improve solid-liquid separation and biological processes for wastewater treatment. The objective of this paper was to evaluate particle size distributions and the associated chemical composition for municipal, industrial, and agricultural waste streams. Most of the organic matter in these wastewaters was larger than a molecular weight of 10(3) amu and therefore would require extracellular hydrolysis before any bacterial metabolism. Particle size distributions were significantly different for the studied waste streams. In municipal wastewater, the organic matter was evenly distributed in all eight size fractions ranging from 10(3) amu up to 63 microm. The industrial and agricultural wastewaters, however, contained mainly soluble organic matter (<10(3) amu) and larger particles (>1.2 microm for the industrial and >10 microm for the agricultural waste) leaving a gap in the size range of large macromolecules and colloids. The relative protein and carbohydrate concentrations varied for the different size fractions compared to the measured chemical oxygen demand (COD) in the corresponding size fraction. Thus, the design of the solid-liquid separation at a treatment plant could be used to purposefully modify the overall chemical composition of the organic matter before further biological treatment. Particle size distributions will influence design and operation of biological nutrient removal processes such as denitrification or biological phosphorus removal that may be carbon limited if a large fraction of the organic matter is composed of large particles with slow hydrolysis rates. Measured particle size distributions for the different waste streams in this study (municipal, industrial, agricultural) were significantly different requiring specific approaches for treatment plant design.     

水解酸化-改良UASB工艺处理玉米酒精废水

采用一种新的工艺技术方法即水解酸化-改良UASB工艺处理玉米酒精废水。结果表明,在改良UASB运行60 d顺利启动完成后,进水COD在5 470～7 910 mg/L之间,TN在70～107 mg/L之间,TP在115～187 mg/L之间,SS在864～1 490 mg/L之间的条件下,水解酸化对COD和SS的去除率分别达50%和51%,NH3-N经过水解酸化后升高。改良UASB对COD的去除率达80%,对NH3-N、TN和TP也有一定去除,去除率分别为12%、17%和20%,经过水解酸化及改良UASB处理利于后续好氧处理。     

絮凝-Fenton试剂氧化处理印染废水

采用Fenton试剂对某染袜厂2种印染废水(印染红和印染蓝)进行处理。考察了硫酸亚铁投加量、双氧水投加量、反应时间及pH值对印染废水的色度及COD去除率的影响,通过正交实验确定了Fenton试剂处理该废水的最佳操作条件为:反应时间30 min、双氧水(30%)投加量4 mL/L、硫酸亚铁投加量300 mg/L、pH值为4左右。在最佳条件下,印染蓝废水经氧化处理后COD去除率大于80%,色度去除率95%以上;印染红废水需经絮凝预处理后再用Fenton试剂氧化处理,其脱色率达到了99.6%,COD去除率为91.2%,出水COD浓度为96 mg/L,可达标排放。     

青霉菌对印染废水吸附脱色及深度处理的研究

利用青霉菌P 1(Penicilliumsp )对 2种染浴废水中的染料进行吸附去除 ,研究结果表明 ,吸附处理 3h ,黑色和红色染浴废水色度基本被去除 ,去除率分别达 98 0 %和 74 5 % ,但去色处理后废水的CODCr值仍偏高。对去除色度的废水进一步用活性污泥进行深度处理 ,黑色和红色废水的CODCr去除率分别为 75 9%和 89 7%。青霉菌菌丝通过吸附作用从废水中抽提出的染料分子在有染料降解细菌L 1和L 2的降解池中脱色降解 ,菌丝吸附脱色能力得到再生。     

EGSB反应器处理城市生活垃圾沥滤液

采用膨胀颗粒污泥床(EGSB)反应器对城市生活垃圾焚烧厂产生的垃圾沥滤液进行处理。实验结果表明:中温条件下,当COD浓度为55 000 mg/L左右,有机容积负荷(OLR)为22.8 kg COD/(m3.d)时,EGSB对垃圾沥滤液具有较好的的处理效果,COD去除率可达94.2%。当进水COD为72 000 mg/L左右时,为保证反应器的稳定运行,OLR应降低至18.2 kg COD/(m3.d),此时COD去除率可以达到88%左右,出水COD平均为9 103 mg/L。垃圾沥滤液和EGSB处理出水均以小分子量有机物为主,其中<4 kDa的有机物分别占76.5%和74.4%。EGSB对整个分子量区间的溶解性有机物都有较好的处理效果,其中对大分子有机物的处理效率相对更高。     

UASB performance for bleached and unbleached kraft pulp synthetic wastewater treatment

This paper presents the performance of two bench scale Upflow Anaerobic Sludge Blanket reactors (UASB) used for the treatment of synthetic substrates that simulate bleached and unbleached cellulose pulp plant wastewaters. The control reactor was fed with diluted black liquor and the treatment reactor with the same substrate plus a mixture of chlorinated organics. The total concentration of the chlorinated compounds was gradually increased from 2.5 mg l-1 to 15.0 mg l-1. The average COD removal efficiency during the last phase of the experiment was 81% in the control reactor and 76% in the treatment reactor. These results indicate the capability of UASB reactors to treat this kind of wastewater and the low impact of the chlorinated organics on COD removal efficiency. The minimum overall chlorinated organics removal efficiency was 71% and the maximum was 99.7%. The experiment indicates that under the conditions used in this research the presence of chlorinated organics does not negatively impact the treatment process.     

Treatability studies on wastewater from textile dyeing factories in Bursa, Turkey

The textile industry is one of the most rapidly developing industries in Turkey. It generates a large amount of wastewater, with corresponding concerns about pollution. The main sources of pollution in wastewater are the dyeing and finishing processes. The dyestuffs and polyvinyl alcohol (PVA) are the main refractory organics of concern in terms of meeting more stringent effluent standards of chemical oxygen demand (COD) and colour. In this study, wastewaters from textile dyeing factories in Bursa were characterised, and physical, chemical and biological treatability studies were carried out. In the physical and chemical studies, 60.80% COD, 80% suspended solids (SS) and 10.92% turbidity removal efficiencies were obtained. In the biological studies, 90% COD and 40% SS removal were obtained. The initial soluble inert COD of wastewater was determined by using comparison methods. The initial inert COD of wastewater and the microbial product concentration were determined as 37 mg/l and 13 mg/l, respectively.     

利用糖蜜废水生产微生物絮凝剂及条件优化和效果实验研究

用糖蜜废水取代葡萄糖作为发酵培养基中的碳源和能源培养微生物絮凝剂产生菌Pseudomonas alcaligenesPS-25。通过单因素试验和正交试验得到该菌株产絮凝剂的最佳培养条件:糖蜜废水COD浓度5 000 mg/L、培养基初始pH值6.5、接种量5%(体积比)、温度30℃、培养时间为72 h、摇床转速160 r/min,在此条件下,PS-25所产絮凝剂对高岭土悬浊液絮凝率达96.75%,并且对多种废水都有较好的净化效果,对废水中浊度和色度的去除率分别在90%和80%以上,COD去除率在73.60%～91.10%。研究表明,用糖蜜废水培养PS-25生产微生物絮凝剂处理废水是完全可行的,从而实现废物的资源化利用。     

微波辅助工艺处理天然气净化废水的应用研究

进行了微波辅助工艺处理天然气净化废水的应用研究,考察了废水色度、COD、SS、含油量和细菌的去除效果以及对废水腐蚀率的降低作用,并进行了同等条件下的常温对照实验。研究结果表明:微波絮凝工艺中絮凝剂PAC和PAM的用量较常温下减少了100 mg/L和5 mg/L,絮凝沉降时间仅为常温絮凝的1/4,最佳微波辐照时间下废水的COD去除率比常温条件下提高4.6%。微波工艺处理后,难降解天然气净化废水的含油量去除率达到了94%、废水中硫酸盐还原菌死亡率达97%以上,废水腐蚀率降为原来的1/7,废水可生化性得到了很大提高,可直接进行好氧生化处理。实验表明,微波辅助工艺对难降解天然气净化废水具有很好的处理应用效果。     

O3/H2O2处理嘧啶废水的研究

采用O3/H2O2法对嘧啶废水进行处理,考察了不同反应条件对嘧啶和COD去除率的影响,并对O3/H2O2降解嘧啶的反应机制和动力学进行了初步探讨。实验结果表明,在pH值为11,反应时间为70 min,O3流量为4 g/h,H2O2投加量为50 mmol/L的条件下,废水的嘧啶和COD的去除率分别达到86.46%和74.97%。嘧啶的去除率随自由基抑制剂叔丁醇增加而降低,说明O3/H2O2降解嘧啶主要为体系中.OH的贡献。同时动力学研究表明,O3/H2O2对嘧啶的降解符合一级反应动力学模型。     

UASB-SBR处理涤纶短纤维废水的实验研究

分别采用水解酸化与好氧（SBR）、厌氧（UASB）与好氧（SBR）工艺对涤纶短纤维废水的生物降解性能进行研究。水解酸化与好氧工艺在进水COD为1 900 mg/L的时候,去除率在80%左右。采用UASB-SBR工艺,进水COD为2700 mg/L时,COD去除率可以达到96%,出水COD〈100 mg/L。实验研究表明,涤纶短纤维废水更适合采用UASB-SBR工艺来处理,并且能够取得较好的效果。     

COD对生物除磷颗粒污泥稳定性影响研究

颗粒污泥稳定性是影响其应用的主要因素之一.以SBR中成熟的生物除磷颗粒污泥为研究对象,探讨进水COD浓度对系统稳定性的影响.结果表明,当进水COD浓度由300 mg/L逐渐升高到500 mg/L时,磷去除率由93%降低到88%;当进水COD浓度在400 mg/L以下时,污泥的最大比释磷速率和比吸磷速率分别为45.2 m...     

氯化铁混凝剂中亚铁含量对混凝效果的影响

以城市污水处理厂原水为实验水样,研究了液体FeCl3混凝剂中亚铁含量对其混凝效果的影响。结果表明,液体FeCl3混凝剂中亚铁的含量与其对污水中总磷和COD的去除效果呈非线性相关性,当FeCl3中亚铁含量为25%时,16.0 mg/L的投加量即可使上清液COD降至195 mg/L,去除率达56.7%,总磷降至1.7 mg/L,去除率达70.7%;当FeCl3中亚铁含量继续降低至0.4%时,COD、总磷的去除率仅提高1.1%和1.3%。因此从性价比来讲,FeCl3混凝剂用于污水厂原水混凝时,可适当放宽产品质量标准中亚铁含量限值的规定,有利于降低氯化铁混凝剂的生产成本。     

两级UASB与好氧组合工艺处理城市生活垃圾渗滤液的启动研究

采用两级UASB与好氧组合工艺处理早期城市生活垃圾渗滤液.系统出水按不同比例回流到一级UASB中进行反硝化,同时进行产甲烷反应,有机物在二级UASB中被进一步降解,好氧池完成剩余有机物的去除和氨氮的硝化.启动阶段通过对原渗滤液不同比例的稀释,分5次逐步提高进水浓度,启动结束时完成了对原渗滤液的高效处理.在进水COD浓度从3000 mg/L提高到15000 mg/L,氨氮浓度从250 mg/L提高到1400 mg/L时,最终COD去除率稳定在92%左右,氨氮去除率可达99%以上,一级UASB中反硝化率接近100%,回流比为300%时系统总氮去除率为70%～80%.