建筑垃圾作水泥混合材的试验研究

建筑垃圾排放量巨大 ,既污染环境 ,又浪费资源 ,其综合利用已得到重视。作者进行了用建筑垃圾中无机渣作为水泥混合材的试验研究。结果表明 ,粉磨后的无机渣掺入到细磨的P·Ⅰ型硅酸盐水泥中 ,水泥比表面积为 4 32 2m2 /kg时 ,掺入 2 0 %无机渣的水泥胶砂抗压强度可达 5 4 1MPa ,且凝结时间、安定性等指标均达国家标准。     

高铝粉煤灰提取氧化铝后硅钙渣用作水泥混合材

为了使高铝粉煤灰提取氧化铝后所产生的硅钙渣被大量的用作水泥混合材,通过水泥强度、水化放热和干缩性实验研究了原状硅钙渣和脱碱硅钙渣对水泥强度和稳定性的影响。结果表明,当硅钙渣掺量达30%时,硅钙渣水泥强度仍可满足P·C 32.5水泥要求。且随硅钙渣掺入量的增加,水泥早期水化放热速率增加的同时水泥累计水化放热量和干缩率还会显著降低。与原状硅钙渣相比,在同等掺量的情况下,脱碱硅钙渣更有利于保持水泥强度,降低其水化热和改善干缩性。     

硫酸铝渣作为水泥生产生料组分和混合材的试验研究

在对硫酸铝渣的物理化学特性研究的基础上，通过实验室试验和工业应用试验，成功地用硫酸铝渣代替粘土作为水泥生料组分，同时用作水泥混合材生产微集料水泥，从而彻底消除了硫酸铝渣对环境的污染，取得了巨大的经济效益和社会效益。     

碱激发电解锰渣制备水泥掺合料

电解锰渣是湿法冶炼金属锰的残渣,为降低其对环境的浸出毒性影响并提高其在水泥产品中的掺入量,利用碱激发技术处理电解锰渣制备水泥掺合料是一种可行的方法。主要研究了碱激发剂种类、掺量对电解锰渣的激发效果,并将碱激发电解锰渣用作水泥掺合料与水泥按不同比例混合研究对水泥抗压强度和浸出毒性的影响。结果表明:碱激发电解锰渣活性显著提高,NaOH中Na_2O当量为10%时试件M-SH10的3、7、28 d抗压强度最高,分别为7.15、9.46、10.03 MPa;将此条件下激发的电解锰渣按质量比取15%与85%的水泥混合制得的掺合料其抗压强度较净水泥试件有一定程度的提高;浸出毒性结果显示Cd、Cr、Pb、Ni、Mn和Zn浓度均下降,且低于GB 8978-1996限值。     

电石渣生产水泥

四川宜宾天源集团开发出电石渣生产的水泥，这种绿色环保特种水泥，采用燃煤废渣和电石渣作原料，采用国内最成熟的干法回转窑生产装置，年产量达34万t，比石灰石生产水泥节能30％，降低生产成本50％，电石渣水泥质量比普通水泥提高1～2个等级，实现了废物的资源化。     

铬渣的固化/稳定化研究

探讨了用水泥粘结剂对铬渣进行稳定化的方法。结果表明，把高炉矿渣和粉煤灰加入水泥基材中对铬渣进行固化，固化体抗压强度达到30MPa以上，浸出毒性大大降低，浸了同液中六价铬浓度在容许范围内，建议可以综合利用。     

硫铁矿烧渣制备无机复合混凝剂聚合铁盐

对用硫铁矿烧渣制备无机复合混凝剂聚合铁盐进行了试验研究,考察了影响烧渣酸溶和铁聚合的因素。结果表明,硫酸浓度、反应时间和体系温度等是影响硫铁矿烧渣中铁溶出率的主要因素,在烧渣液溶过程中添加适当的助溶剂,不仅能够加快酸浸速度,而且还可以提高产品的混凝性能。     

废石粉渣制备混凝剂及其除浊净水效果研究

利用废石粉渣制备无机混凝剂,并研究所得初产品对硅藻土悬浮液和受污湖水样品进行处理的适宜操作条件以及除浊净水效果,结果表明,利用某些废石粉渣制备的混凝剂有较好效果,但制备工艺有待改善。     

烧结脱硫灰制备蒸压加气混凝土砌块的研究

研究了烧结烟气半干法脱硫灰复掺粉煤灰、水渣/水泥,辅之外加剂,制备蒸压加气混凝土砌块的可行性.实验结果显示,当脱硫灰掺入量25%,粉煤灰掺入量45%,水渣和水泥掺入量均15%,铝粉掺入量0.04%,水料比0.6,稳泡剂掺入量0.0012%,烧碱掺入量1%,无需额外添加石膏,采用蒸压养护12.5 h(其中抽真空时间为0....     

固硫型煤渣烧制水泥熟料的研究初探

发展固硫型煤工业是治理煤烟型大气污染及减少二氧化硫对大气污染的有效途径。燃烧固硫型煤将产生大量固硫煤渣,对环境构成新的威胁。本文从实验探索的角度,研究开发利用固硫渣的途径。实验中对固硫渣做了化学全分析,用Ｘ－射线粉末衍射法（ＸＲＰＤ）对固硫渣及其加入一定量的添加剂后的煅烧产物进行物相鉴定,证实在一定的条件下固硫渣可以烧制成硫铝酸盐水泥熟料     

Element immobilization in refuse incinerator ashes by solidification in glass, ceramic or cement

Incineration of municipal refuse results in the production of massive quantities of fly ash and bottom ash. Toxic elements in the original refuse may be concentrated up to 40-fold in the resultant ash. There is concern that burial of such ash in landfills could result in leaching of these elements downward into groundwater. In this study, refuse ashes were incorporated into glass, ceramic and cement composites to immobilize such toxic elements. The EP Toxicity Test (1986) was used to show that extraction of such elements by simulated acid rain is effectively blocked in these new solid materials.     

老港生活垃圾填埋场垃圾组成和资源化价值研究

在上海老港生活垃圾填埋场,对1991～2004年间填埋垃圾进行了小规模开采和手工分选,考察了填埋垃圾组成随填埋年份的变化规律.分选结果表明:在缺氧和避光的封场环境中,填埋垃圾中塑料、橡胶和化纤织物组分在未发生明显老化,经简单预处理后即可再生利用;以塑料为主的有机组分随填埋年份呈对数上升趋势,2010年将占填埋垃圾的50%以上.因此,焚烧和气化热处理工艺将是填埋垃圾资源化的理想选择之一.     

The Collection and Analysis of Inorganic Dust Downwind of Source Effluents

Two directionally oriented high-volume samplers are used to pinpoint the collection of specific inorganic dusts from an industrial emission. One of the samplers is placed upwind of the source, and the other downwind. Both samplers are activated by winds blowing from the direction of the source to the downwind sampler. Both are de-activated when the wind shifts from the 30° sampling arc. Thus, the upwind sampler “sees” background dust, and the downwind sampler “sees” material originating from the source. Microsorban filters are used to collect the dust materials. The filter is then dissolved in benzene and the residue washed with benzene to remove the filter material and organic substances collected. The residue consists of dry, inorganic dust, which is then subjected to X-ray diffraction and optical microscopy, for analysis. This technique was successfully used to collect and analyze cement dust and mica dust from two separate industrial sources. The technique has promise for the analysis of a wide variety of inorganic materials which can be identified by X-ray diffraction, optical microscopy or other techniques.     

利用水泥处理垃圾渗滤液生物处理出水的研究

利用水泥的表面吸附和水化反应性质处理垃圾渗滤液生物处理出水可以取得很好的效果,COD的去除率可达69.5%.处理效果与水灰比、反应时间密切相关,低水灰比和较长反应时间对COD的去除更为有利.对处理前后水样的COD和TOC分析表明,水泥对非TOC贡献的COD有很强的去除效果.     

Emission and burnt smell characteristics from combustion experiments with defined materials

Typical burnt smell often results from fire accidents or in general from incomplete combustion. Recently, eleven compounds were identified, which are basically responsible for this odour. When analyzing residual materials from different fire accidents, the pattern that means the relative ratios of these compounds among each other varies strongly, although always causing a burnt smelling. Consequently, lab-scale combustion experiments were performed in order to investigate the influence of defined materials from domestic environment on the burnt-smell fingerprints. Furthermore, the occurrence of other polar and higher molecular combustion products was studied. It was found that under good combustion conditions, the burnt smell patterns resulting from the single materials were astonishingly consistent, mostly dominated by methylphenols or naphthalene. No correlation could be found between these ‘fingerprints’ and combustion product groups identified by GC/MS-screenings. LC/MS/MS-measurements especially pointed at the existence of higher molecular weight phenolic and acidic functionalized compounds in the combustion residues.     

絮凝剂的开发进展

分别对无机高分子絮凝剂、有机高分子絮凝剂、微生物絮凝剂和废物回收制备絮凝剂的物性、应用状况进行了简要介绍，并列出了近年来大量研究人员对这儿类絮凝剂的研究成果和开发进展。     

The leachability and chemical speciation of selected trace elements in fly ash from coal combustion and refuse incineration

A laboratory leaching test has been used to predict the potential mobility of As, Se, Pb and Cd in landfilled fly ash produced by coal combustion and refuse incineration. These waste residues also formed the basis of a speciation study in which the valency states of As and Se and the chemical forms of Pb and Cd have been determined. Selenium displayed the greatest leachability in each ash type, despite being present at relatively low concentrations in both materials. Substantial amounts of other trace elements were also leached, particularly Pb and Cd from refuse ash and As from coal ash. Chemical associations of Pb and Cd were examined by a sequential extraction procedure. In coal fly ash, both elements were mostly present in the residual fraction, while in refuse ash these elements were mainly associated with the exchangeable fraction. Water-soluble extracts of coal fly ash contained As exclusively as As(V); high background interference prevented the detection of water-soluble As in refuse ash. Selenium was present largely as Se(IV) in aqueous extracts of both ash types. The value of speciation techniques and leaching tests as predictors of environmental behaviour is discussed in conjunction with results of routine trace element determinations and plant uptake studies.     

垃圾分选设备及垃圾处理技术展望

我国是人口大国 ,随着人民生活水平的不断提高 ,现有的垃圾处理技术已逐渐不能适应产量日益增长与成分不断复杂化的垃圾处理的需要 ,垃圾处理急需一场革命性的变化 ,必须摆脱现有城市垃圾处理三大方法面临的技术上难以避免的弊端和“阴影”。也就是说 ,垃圾处理应该从垃圾分选设备技术整体创新入手 ,引入一整套的垃圾机械处理联合装置及各种新型的联合处理方法 ,使垃圾处理成本大大降低 ,从而产生一次历史转折性的突破 ,带动和实现垃圾处理的产业化。为了达到这一目标 ,对垃圾处理需要重点解决的技术难关进行了探讨与展望     

固体废弃物对新拌水泥浆体密实度与强度的影响

研究固体废弃物(石灰石粉、粉煤灰、赤泥和矿渣)作掺合料颗粒体系与新拌浆体填充密实性能的关系;分析了在水胶比为0.3时,以上4种固体废弃物以不同比例等质量取代水泥的净浆强度。实验结果表明,石灰石粉、粉煤灰、赤泥作为掺合料,能够改善胶凝材料的颗粒级配,填充新拌水泥浆体中的孔隙,使浆体更为密实,并且对其净浆的强度有利。