平板玻璃行业环境影响评价中工程分析要点浅析

在对平板玻璃行业环境影响评价中的工程组成、一般特征和环境影响特征进行全面分析的基础上,详细分析了建设项目的工艺过程、物料平衡、水平衡及硫平衡等,计算污染物的产生量,制订相应的防治措施,并从行业准入条件及清洁生产角度分析了项目建设的可行性,为环境影响预测和评价提供所需基础数据,为项目的环境管理提供建议指标和科学数据。     

炼铁工序减污降碳协同增效技术评估方法研究

为推广减污降碳协同控制技术,以炼铁工序为研究对象,从协同度、成本收益和环境影响3个维度评价炼铁工序源头、过程节能技术、末端治理技术和低碳技术的协同控制效益。从污染物和碳排放协同度分析来看,源头、过程节能技术能有效推动炼铁工序污染物和碳排放的协同减排,而末端控制技术对污染物和温室气体的减排不具有协同性。绿氢冶炼技术和熔剂性球团制备技术污碳减排协同度较高,此外高炉喷吹焦炉煤气技术、高炉煤气回收技术和高炉热风炉双预热能协同减少VOCs和碳排放。在当前我国碳交易价格条件下,从成本收益分析来看节能技术和污染物末端治理技术具有可推广性。随着碳交易价格的上涨,绿氢冶炼和碳捕集（CCS）技术减排成本呈下降趋势。绿氢冶炼技术、污染物末端治理技术最能有效地减少环境影响,其他节能技术也能相应减少环境影响,而现有条件下CCS技术的实施会增加对环境的影响。综合污染物和温室气体协同减排的协同度、经济效益和环境效益评估,炼铁工序中源头防治和节能技术可作为我国现阶段减污降碳协同增效技术进行推广,随着未来碳交易价格的增长和能源的转型,绿氢冶炼技术和CCS技术具有较大应用前景。     

电解锰行业重金属废水削减平台的开发与应用

电解锰企业的重金属工艺废水产生量高达3~4 m3/t锰,传统的末端处理工艺存在成本高、有二次污染、锰铬离子难以回收利用等缺点。电解车间是重金属废水产生量最大且污染最为严重的地方,废水主要源于电解车间技术和设备的不清洁,导致了电解车间工人的身体健康受到严重的重金属污染危害,而末端治理设施无论如何改善也无法解决电解车间工人身体健康受到重金属污染的问题。针对这些问题,该文开发了电解锰行业重金属废水过程减排成套工艺平台,从源头上解决了锰电解过程中重金属废水污染问题:将出槽及钝化过程的极板挟带液分别减量77.84%、75.90%,清洗废水减量85.44%,减量后的废水可以完全回用于电解锰主体工艺而不会发生水膨胀,从根本上解决了该行业废水末端处理设施现存弊病,彻底避免了车间工人环境暴露对人体健康造成的危害。     

我国电解锰行业氨氮污染分析与控制

我国"十二五"期间将氨氮纳入总量控制指标,电解锰行业氨氮污染控制变得非常紧迫。介绍了电解锰氨氮污染的现状,分析了电解锰氨氮污染的产生途径以及电解锰生产中的氨氮平衡,依据"源头消减、过程控制、末端循环"的清洁生产理念,提出了电解锰氨氮污染的控制措施。     

中国电解锰行业清洁生产技术发展现状和方向

无锰不成钢.尤其是200系列不锈钢技术的问世,推动电解锰迅速发展为一个很大的行业.21世纪以来,我国成为世界上最大的电解锰产品生产国和消费国.介绍了我国电解锰行业的产能和技术发展现状,分析了我国电解锰行业发展的主要限制因素,介绍了该行业清洁生产技术的最新研发动态和主要清洁生产技术,提出了未来电解锰行业清洁生产技术的研发...     

铅蓄电池工业清洁生产与污染治理技术研究

装备和技术落后是中国铅蓄电池企业清洁生产水平不高的主要原因.在该行业推动强制性清洁生产审核,针对生产过程中污染物产生的关键工艺环节,采用先进成熟技术实施清洁生产改造,从源头削减污染物的产生量,同时优化末端治理实现达标排放,事关铅蓄电池企业的生存发展.本文在分析铅蓄电池生产工艺过程和产污环节的基础上,介绍了各工序清洁生产关键装备和技术,对常用的废气、废水治理方法作了比较分析,为铅蓄电池工业环境影响评价及清洁生产审核提供参考.     

糠醛制造业塔下废水中COD与BOD产生量的实测分析

糠醛制造业在生产过程中会产生大量高浓度废水,属重污染行业。通过实测其塔下废水中化学需氧量(COD)和生化需氧量(BOD)的产生量,并结合糠醛制造业具体工作实际进行数据分析,作者认为:塔下废水属难生化性废水;COD和BOD产生量与企业设计生产能力无直接关系;设备陈旧、管理粗放是影响COD和BOD产生量的主要因素;而从源头减少污染物的产生,是提高中国糠醛制造业活力和竞争力的关键。     

基于情景分析的浙江沿海地区环境污染防治战略研究

运用情景分析方法研究了浙江沿海地区经济发展方式对环境产生的压力.首先以COD、氨氮、二氧化硫和氮氧化物这4种污染物的排放量为基准,筛选了某典型城市的18个重污染工业行业.其次以重污染工业行业为对象,设计了情景分析模型和辅助程序,以2008年为基准年,目标年2015年重污染工业行业4种污染物的排放量须在基准年基础上下降一定比例作为约束条件,分析在基准情景、产业结构调整情景、工业结构调整情景、清洁生产技术情景、综合情景、可持续发展6种情景下,目标年该市18个重污染行业4种主要污染物的排放量.目的是明确人均GDP已突破70 000元的沿海经济发达城市如何转变发展方式,使经济发展的同时,污染物排放量有所减少,以期为优化工业行业发展结构提供决策参考.基于情景分析结论,提出了进一步发展建议,包括经济适度增长(GDP增长7%左右),加大力度调整产业结构,控制重污染行业发展速度,加强重污染行业的结构调整,加强源头控制,加大力度推进清洁生产技术,大幅削减污染物产生量,同时加强治污设施运营监管,提高污染物去除效率.通过上述措施在目标年可控制重污染行业的COD、氨氮、二氧化硫和氮氧化物分别在基准年基础上下降10%、10%、5%和15%.     

染料行业节水减污措施探讨

染料行业发展迅速,但随着节能减排要求的提高,问题也愈暴露,甚至影响到染料工业的生存。针对染料行业水耗高、废水产生量大的严峻环境问题,提出节水减污的工作思路。通过推行清洁生产,找出水耗高、污染物产生量大的环节,结合企业实际生产情况,从染料生产的技术工艺、设备、水回收利用、加强管理、结合一定的末端治理5个方面,探讨节水减污的措施,争取做到源头节水,将污染物最大程度地消灭在生产过程中,做到废水的回收利用,使染料行业能够可持续发展下去。     

工业行业源头-过程-末端全过程减排潜力评估研究

为探究行业不同工艺的污染物减排潜力,将污染物减排聚焦至行业产排污工艺,基于自上而下与自下而上结合的测算方法建立了一套源头-过程-末端全过程协同减排潜力评估模型——SPECM,选择广东省佛山市顺德区为研究区域,以污染物VOCs为主要对象测算减排潜力. 结果表明:①VOCs产生量较大但产污强度较低的减排行业(Ⅰ)和VOCs产生量较大且产污强度较高的减排行业(Ⅲ)是顺德区VOCs减排中需重点管控的行业,其源头-过程-末端全过程协同减排潜力最高达顺德区VOCs排放总量的71.23%. ②通过穷举法测算减排目标下源头-过程-末端全过程协同减排潜力系数,获得1.8×104组可行解. ③根据顺德区生产现状对减排潜力系数进行优化,对于具有源头减排潜力的木质家具制造行业、泡沫塑料制造行业和家用厨房电器具制造行业,其源头减排潜力系数取8%~13%,过程和末端减排潜力系数分别取20%~50%和60%~100%,共265组可选方案;对于其他仅具有过程和末端减排潜力的行业,其过程和末端减排潜力系数分别选取40%~80%和70%~100%,共2 230组可选方案. 研究显示,SPECM模型能够将行业减排具体到生产工艺减排,并可以针对性地提出行业减排方案.      

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Alterations of organ histopathology and metallolhionein mRNA expression in silver barb, Puntius gonionotus during subchronic cadmium exposure

Common silver barb,Puntius gonionotus,exposed to the nominal concentration of 0.06 mg/L Cd for 60 d,were assessed for histopathological alterations(gills,liver and kidney),metal accumulation,and metallothionein(MT)mRNA expression.Fish exhibited pathological symptoms such as hypertrophy and hyperplasia of primary and secondary gill lamellae,vacuolization in hepatocytes,and prominent tubular and glomerular damage in the kidney.In addition,kidney accumulated the highest content of cadmium,more than gills and liver.Expression of MT mRNA was increased in both liver and kidney of treated fish.Hepatic MT levels remained high after fish were removed to Cd-free water.In contrast,MT expression in kidney was peaked after 28 d of treatment and drastically dropped when fish were removed to Cd-free water.The high concentrations of Cd in hepatic tissues indicated an accumulation site or permanent damage on this tissue.