NH3-SCR performance and the resistance to SO2 for Nb doped vanadium based catalyst at low temperatures

Niobium oxide as the promoter was doped in the V/WTi catalyst for the selective catalytic reduction(SCR)of NO.The results showed that the addition of Nb_2O_5could improve the SCR activity at low temperatures and the 6 wt.%additive was an appropriate dosage.The enhanced reaction activity of adsorbed ammonia species and the improved dispersion of vanadium oxide might be the reasons for the elevation of SCR activity at low temperatures.The resistances to SO_2of 3V6Nb/WTi catalyst at different temperatures were investigated.FTIR spectrum and TG-FTIR result indicated that the deposition of ammonium sulfate species was the main deactivation reason at low temperatures,which still exhibited the reactivity with NO above 200°C on the catalyst surface.There was a synergistic effect among NH_3,H_2O and SO_2that NH_3and H_2O both accelerated the catalyst deactivation in the presence of SO_2at 175°C.The thermal treatment at 400°C could regenerate the deactivated catalyst and get SCR activity recovered.The particle and monolith catalysts both kept stable NO_xconversion at 225°C with high concentration of H_2O and SO_2during the long time tests.     

Al2O3为载体的催化剂净化贫燃汽车尾气研究

在富氧条件下,考察了C₃H₆和C₂H₅OH在Ag/Al₂O₃、In/Al₂O₃、Sn/Al₂O₃、Co/Al₂O₃、Pt/Al₂O₃和Ag/Al₂O₃+Pt/Al₂O₃组合催化剂上选择性还原NO的性能.结果表明,Ag/Al₂O₃具有最高的NO还原活性.在负载型过渡金属氧化物催化剂上,会生成显著量的CO,其HC和CO氧化转化温度也远远高于Pt/Al₂O₃催化剂.串联组合Ag/Al₂O₃+Pt/Al₂O₃催化剂可显著拓宽活性温度范围,促进HC和CO氧化,降低N₂O和CH₃CHO生成量.     

气相组分对非热等离子体氧化气相元素汞的影响

采用线串齿轮-管式正极性流光放电反应器产生非热等离子体,考察了放电等离子体参与下烟气中各组分对元素汞氧化的影响.结果表明, CO2的加入和高浓度的NO导致作用于汞的活性粒子减少,从而阻碍元素汞的氧化.在等离子体作用下,部分CO2会与活性粒子作用而转化为CO.加入NO浓度为670mg/m3,电压升高到9.5kV时,仅有37%的元素汞被氧化. SO2的加入能促进元素汞的氧化,而且伴随SO2的氧化和白色HgSO4和Hg2SO4的生成,电压升高到10kV时,反应器出口基本检测不到元素汞. H2O和HCI也具有促进元素汞氧化的作用,这可能是因为氧化性· OH形成得到促进和反应气氛中存在C1-离子.部分元素汞和氧化态汞在荷电后会被等离子体反应器捕集,因此等离子体作用后,气相总汞浓度显著降低.     

Iron-doped Mn-Ce/TiO2 catalyst for low temperature selective catalytic reduction of NO with NH3

The catalysts of iron-doped Mn-Ce/TiO 2(Fe-Mn-Ce/TiO 2) prepared by sol-gel method were investigated for low temperature selective catalytic reduction(SCR) of NO with NH 3.It was found that the NO conversion over Fe-Mn-Ce/TiO 2 was obviously improved after iron doping compared with that over Mn-Ce/TiO 2.Fe-Mn-Ce/TiO 2 with the molar ratio of Fe/Ti = 0.1 exhibited the highest activity.The results showed that 96.8% NO conversion was obtained over Fe(0.1)-Mn-Ce/TiO 2 at 180°C at a space velocity of 50,000 hr 1.Fe-Mn-Ce/TiO 2 exhibited much higher resistance to H 2 O and SO 2 than that of Mn-Ce/TiO 2.The properties of the catalysts were characterized using X-ray diffraction(XRD),N 2 adsorption,temperature programmed desorption(NH 3-TPD and NOx-TPD),and Xray photoelectron spectroscopy(XPS) techniques.BET,NH3-TPD and NOx-TPD results showed that the specific surface area and NH3 and NOx adsorption capacity of the catalysts increased with iron doping.It was known from XPS analysis that iron valence state on the surface of the catalysts were in Fe3+ state.The doping of iron enhanced the dispersion and oxidation state of Mn and Ce on the surface of the catalysts.The oxygen concentrations on the surface of the catalysts were found to increase after iron doping.Fe-Mn-Ce/TiO2 represented a promising catalyst for low temperature SCR of NO with NH3 in the presence of H2 O and SO2.     

Ag/Al2O3催化剂用于碳氢化合物选择性还原NO

比较了富氧条件下CH4、C3H8、C3H6和C2H5OH分别用作还原剂时,NO在Ag/Al2O3催化剂上的还原活性.结果表明, CH4和C3H8还原NO的活性很低,而C3H6和C2H5OH能有效地还原NO.在此基础上,研究了H2O和SO2对C3H6和C2H5OH在Ag/Al2O3催化剂上还原NO活性的影响.结果表明,H2O的存在会降低低温区的NO还原活性,而且这种影响是可逆的.将H2O 和SO2同时加入反应混合气,引起NO还原活性较大幅度降低,结合程序升温脱附实验结果,认为可能是由于存在SO2时,Ag/Al2O3催化剂吸附NO的能力降低.     

Fe-MnOx-CeO2/ZrO2低温催化还原NO性能研究

以纳米ZrO2为载体,用浸渍法制备出Fe-MnOx-CeO2/ZrO2催化剂,考察了活性组分配比和助剂负载量对催化剂低温NH3选择性催化还原NO活性的影响,并对催化剂进行了XRD、SEM、EDS和BET表征;探讨了温度、H2O和SO2对Fe-MnOx-CeO2/ZrO2催化剂低温下NH3选择性催化还原NO的影响,结果表明,无SO2和H2O条件下,8%Fe-10%MnOx-CeO2/ZrO2催化剂具有良好的催化活性和稳定性.120℃时,催化剂的脱硝效率为85.23%,当温度升至180℃时,脱硝效率可达到92.0%.SO2和H2O共存条件下,催化剂易失活,采用傅立叶变换红外光谱对各反应阶段的催化剂进行了表征,对其失活机制进行深入研究,结果表明,催化剂失活的主要原因是催化剂表面硫酸铵盐的沉积和催化剂本身活性成分的硫酸盐化.     

V2O5/TiO2催化剂用于烟气同时脱硫脱硝的研究

研究了用V2O5/TiO2催化剂同时脱除烟气中的SO2和NO,考察了H2还原温度及其它反应条件对SO2和NO脱除率的影响。结果表明,经H2还原后所制得的V2O5/TiO2催化剂可以提高脱硫脱硝活性,最佳还原温度为700℃;在450～500℃的烟气温度范围内,该催化剂有较佳的脱硫脱硝活性;在相同反应温度下,空速越大,SO2和NO的脱除率越低;烟气中的氧气可大大提高V2O5/TiO2的脱硫脱硝活性,且氧气体积含量在5%～10%范围内变化时,对SO2和NO脱除率的影响较小。     

A novel four-way combining catalysts for simultaneous removal of exhaust pollutants from diesel engine

A novel four-way combining catalysts containing double layers was applied to simultaneously remove four kinds of exhaust pollutants(NOx,CO,HC and PM) emitted from diesel engine.The four-way catalysts were characterized using scanning electron microscope(SEM) and Ultraviolet visible diffuse reflectance spectroscopy(UV-Vis DRS).Their catalytic performances were evaluated by temperature-programmed reaction technology.The double layer catalysts could effectively remove the four main pollutants.The highest catalytic activity was given by the two-layered catalysts of La0.6K0.4CoO3/Al2O3 and W/HZSM-5.Under the simulated exhaust gases conditions,the peak temperature of the soot combustion was 421°C,the maximal conversion of NO to N2 was 74%,the temperature of the HC total conversion was 357°C,and the maximum conversion ratio of CO was 99%.     

CeO2-La2O3/γ-Al2O3稀土氧化物混合物催化还原SO2的实验研究

在La₂O₃ 中加入变价稀土氧化物CeO₂,组成一种稀土氧化物的混合物,以这种混合物作为CO还原SO₂的催化剂.采用连续流动固定床反应器,在反应气体SO₂和CO按SO₂∶CO = 1∶3,载流气体为N₂,气体流量为1000 mL/min的条件下,实验研究了该催化剂的活化过程以及温度和反应物浓度配比对活化反应的影响,用XRD和XPS对反应前后催化剂进行了表征,分析了相结构的变化.结果表明:CeO₂和La₂O₃ 2种稀土氧化物的混合物,在CO还原SO₂的催化反应中,活化温度比单个的CeO₂或La₂O₃氧化物下降了50℃～100℃,而且具有更高的活性.这可能是CeO₂和La₂O₃氧化物之间存在着某种协同作用所致.     

SO2对CoH-ZSM-5催化CH4还原NO催化性能的影响

研究了富氧条件下SO₂对CoH-ZSM-5上CH₄选择还原NO(CH₄-SCR)的影响,应用SO₂-TPSR,NO+(O₂)-TPD等方法研究了产生中毒的原因并定量研究了被毒化的活性位.反应在773 K进行时,加入体积分数78×10^-6SO₂,NO的转化率由72%逐渐降低并稳定在58%,提高反应温度至823 K,NO稳定转化率上升至62%.同时加入2.5     

城市混合垃圾组分及其燃烧产物特性分析

对混合垃圾自然组分、物性及燃烧产物特性进行了实验研究。结果表明 :城市混合垃圾中无机物、水分、灰分含量较高 ,热值较低 ;燃烧产物中烟气的主要成分是 N2 、CO2 、H2 O、O2 ,以及少量 CO、HCl、NOx、SOx、H2 S等 ;灰渣的主要成分是 Si O2 、Al2 O3、Ca O、Ca SO4等。随着过量空气系数的增大 ,呈现 CO、HCl、SOx、H2 S减少 ,NOx 增加的趋势 ;随着温度的升高 ,CO、H2 S逐渐减少 ,HCl、SOx、NOx 增加 ;适宜的城市混合垃圾燃烧温度应在 80 0～ 1 0 0 0℃     

汽车尾气净化催化剂Ag/SAPO-34选择性催化还原NO

评价了Ag/SAPO-34分子筛催化剂选择性还原NO的活性,并运用漫反射红外光谱原位研究NO在Ag/SAPO-34催化剂上的选择性催化还原机理.结果表明Ag/SAPO-34有良好的低温活性,在氧气浓度为3.6%和温度为573K～673K时NO还原成N2的转化率达70%;催化剂活性随C3H6浓度的增加而升高,随空速的增加而稍有下降.基于漫反射红外光谱,认为反应机理为:NO、丙烯和氧反应,在Ag/SAPO-34催化剂上生成吸附的有机-氮氧化物,再由这些吸附物种分解成N₂,催化还原的关键是形成有机-氮氧化物中间体.氧的作用是充分促进丙烯活化以及增加NO_x吸附态含量,并且氧的存在是有效产生一系列中间物不可缺少的条件.     

Performance and mechanism study for low-temperature SCR of NO with propylene in excess oxygen over Pt/TiO2 catalyst

A 0.5 wt.% Pt/TiO2 catalyst was prepared and used for the low-temperature selective catalytic reduction(SCR) of NO with C3 H6 in the presence of excess oxygen.The effects of Pt loading and O2 concentration on Pt/TiO2 catalytic performance for low-temperature SCR were investigated.It was found that optimal Pt loading was 0.5 wt.% and excess O2 favored low-temperature SCR of NOx.The mechanism of low-temperature SCR of NO with C3 H6 was investigated with respect to the behavior of adsorbed species over Pt/TiO2 at 150°C using in situ DRIFTS.The results indicated that surface nitrosyl species(Pt δ+-NO and Ti 3+-NO) and Pt 2+-CO are main reaction intermediates during the interactions of NO,C3 H6 and O2.A simplified NO decomposition mechanism for the low-temperature SCR of NO with C3 H6 was proposed.     

Effect of SO2 on the performance of Ag-Pd/Al2O3 for the selective catalytic reduction of NOx with C2H5OH

The influence of SO2 on the performance of Ag-Pd/Al2O3 for the selective catalytic reduction （SCR） of NOx with C2H5OH was investigated experimentally. The activity test results suggest that Ag-Pd/Al2O3 shows a small activity loss in the presence of SO2 when using C2H5OH as a reductant. In situ DRIFTS spectra show that the activity loss originates from the formation of surface sulphate species on the Ag-Pd/Al2O3. The surface sulphate species formation inhibits the formation of nitrate, whereas hardly changes the partial oxidation of C2H5OH. Compared with the NOx reduction by C3H6, an obvious suppression of the surface sulphate species formation was observed by DRIFTS experiment when using C2H5OH as a reductant. This phenomenon reveals the better catalytic performance and strong SO2 tolerance of Ag-Pd/Al2O3-C2H50H system.     

煤半焦负载钠催化还原NO的研究

在石英固定床反应器上研究了Na对NO 半焦反应在不同气氛下的催化作用。研究结果表明 ,Na对半焦还原NO的反应具有很强的催化作用 ;热处理温度升高 ,Na的催化作用减小 ;CO和O2 气氛有助于NO的催化还原 ,但随温度的升高CO和O2 的促进作用减弱 ;低温下 ,Na催化剂易于失活 ;Na对于NO 半焦反应的催化作用是通过氧化 /还原机理实现的。     

Simultaneous removing SO2 and NO by a new system containing cobalt complex

Absorption and catalytic oxidation of nitric oxide can be achieved by using cobalt（Ⅲ） ethylenediamine （Co（en）3^3＋. When simultaneous absorbing SO2 and NO, the precipitation of Co2（SO3）3 will be yielded and the NO removal will be decreased. A new catalyst system using Co（en）3^3＋ coupled with urea has been developed to simultaneous remove NO and SO2 in the flue gas. NO is absorbed and catalytically oxidized to nitrite and nitrate by Co（en）3^3＋. The dissolved oxygen in scrubbing solution from the feed stream acts as oxidant. Urea restrains the precipitation of Co2（SO3）3 by oxidizing SO3^2-to SO4^2- as COSO4 is more soluble in water. The experimental results proved that nearly all SO3^2- can be oxidized to SO4^2- and the high NO and SO2 removal could be obtained with the new system. The NO removal is influenced by gas flow rate, the concentration of Co（en）3^3＋ and urea in the absorption solution, the temperature of the scrubbing solution and the content of oxygen in the flue gas. The low gas flow rate is favorable to increase the NO removal. The experiments proved that the NO removal could be maintained at more than 95% by the system of 0.02 mol/L Co（en）3^3＋ and 1% urea at 50℃ with 10% O2 in the flue gas.     

Rh-Al-MCM-41上NO选择性催化还原的原位红外研究

利用气-固相固定床反应装置考察了Rh交换的Al-MCM-41在高气体空速条件下对贫燃NOx的选择性催化还原活性,考察了氧含量对其的影响。结果表明,在200000h~(-1)的气体空速、O_2/C_3H_6=20、603K时,NO转化率为74.3％。利用原位FTIR技术研究了该催化剂的表面吸附物种及表面程序升温反应行为,并结合实验观察探讨了贫燃条件下Rh-Al-MCM-41催化剂上NO的选择性催化还原机理。     

燃煤流化床钙基脱硫剂对NO转变率的影响及机理

在φ150mm×1000mm流化床试验台上,温度区间840℃～960℃,研究了钙基脱硫剂品种、粒径和Ca/S比对NO转变率的影响.阐述了钙基脱硫剂使NO转变率增加机理试验发现,同等质量钙基脱硫剂使NO增加的次序为氧化钙、石灰石、方解石;Ca/S比越大,NO转变率越高;粒径为1～2mm时NO转变率最大,2～3mm时次之,0.2～1mm时最小.加入脱硫剂降低了HCl、HF、SO₂的浓度,导致O、H、HO₂浓度升高,CO的氧化反应加速,在床料、燃料灰催化作用下CO与NO的反应减慢,最终导致NO浓度升高.     

O2+、O3同时脱硫脱硝实验

针对目前的烟气同时脱硫脱硝方法中存在的投资成本、运行费用、占地面积大等问题,研究强电离放电方法产生高浓度氧活性粒子(O2+、O3)注入烟气外排管道中,进行O2+、O3消除烟气中的NO, SO2转化成HNO3, H2SO4的等离子化学反应.描述强电离介质阻挡放电制取O2+、O3原理和烟道中O2+与H2O反应形成·OH及其氧化脱硫脱硝反应机制,分析回收酸液中的酸根离子种类及浓度.在O2+、O3与NO+SO2的物质的量比为5,烟气温度为65℃,H2O体积浓度为10%,停留时间为1s的实验条件下,脱硝脱硫率分别为97.4%,83.2%.     

疏水型H-ZSM-5分子筛上NO氧化反应的研究

针对NO低温氧化催化剂的抗水汽性差的问题,以疏水型高硅H-ZSM-5分子筛为NO氧化催化剂,在温度为10~90℃、NO进口浓度为0.05%~0.08%,及相对湿度为0~100%条件下,考察了NO的氧化反应.结果表明,H-ZSM-5分子筛的硅铝比由50提高至300时,湿气条件(水汽含量1.18%)下,NO氧化率由20%升高至56%;干气下,低温有利于NO氧化;湿气下(水汽含量1.18%),NO氧化率随着温度的升高先增加后减少,最佳反应温度为20℃,与NOx工业废气的排放温度相近.200h的稳定性试验结果显示,在30℃、NO进口浓度0.08%、空时0.5s、保持相对湿度为50%或100%时,NO氧化率可维持在60%和50%,催化剂具有良好的稳定性.