Dynamic chemical characteristics of soil solution after pig manure application: a column study

When manures from intensive livestock operations are applied to agricultural or vegetable fields at a high rate, large amounts of salts and metals will be introduced into soils. Using a column leaching experiment, this study assessed the leaching potential of the downward movement of Cu and Zn as well as some salt ions after an intensive farm pig manure at rates of 0%, 5% and 10% (w/w) were applied to the top 20 cm of two different textured soils (G soil -sandy loam soil; H soil-silty clay loam soil), and investigated the growth of amaranth and Cu and Zn transfer from soil to amaranth (Amaranthus tricolor). Soil solutions were obtained at 20, 40 and 60 cm depth of the packed column and analyzed for pH, electrical conductivity (EC), dissolved organic matter (DOC) and Cu and Zn concentrations. The results indicated that application of pig manure containing Cu and Zn to sandy loam soil might cause higher leaching and uptake risk than silty clay loam soil, especially at high application rates. And manure amendment at 5% and 10% significantly decreased the biomass of amaranth, in which the salt impact rather than Cu and Zn toxicity from manures played more important role in amaranth growth. Thus the farmer should avoid application the high rate of pig manure containing metal and salt to soil at a time, especially in sandy soil.     

生物沥浸法去除猪粪中重金属的研究

探讨以猪粪为培养介质,驯化和加富培养获得硫细菌混合菌液,并研究其对猪粪中重金属的生物沥浸效果。结果表明：猪粪可以在18 d内完成驯化,经3轮富集培养的猪粪粪液可作为硫细菌接种菌液。采用此菌液对猪粪粪液接种并投加硫粉,经过9 d的生物沥浸,Cu、Zn和Cd的沥出率分别达到93.0%、90.1%和67.8%。     

化学沥浸与硫化钠钝化联合处理猪粪中重金属

利用柠檬酸浸提猪粪中重金属,减少总量,再利用硫化钠钝化经柠檬酸浸提后的猪粪残渣,降低猪粪中剩余重金属的生物可利用性。柠檬酸浸提实验表明：0.2 moL·L-1柠檬酸与猪粪按固液比1:5混合,反应24 h,对猪粪中Cu、Zn、Mn的浸出率为18.10%、66.16%、43.85%;硫化钠投加量5%,钝化7 d,猪粪中离子交换态Cu、Zn、Mn的浓度由酸浸后的14.08、116、81.75 mg·kg-1降为8.77、12.04、21.02 mg·kg-1,硫化钠对酸浸后猪粪中Cu、Zn的钝化率为52.00%、63.72%,猪粪残渣中离子交换态Mn所占全量的比例由对照组的30.22%降到7.77%;柠檬酸酸浸和硫化钠钝化对猪粪中Cu、Zn、Mn总处理效率为73.00%、61.44%、29.90%。重金属分离技术和钝化技术联合处理猪粪中重金属,可以有效减少猪粪中Cu、Zn、Mn的总量并降低其生物可利用性。     

超声和无机酸浸提猪粪中的重金属

对比研究了无机酸及超声对猪粪中重金属Cu、Zn和Mn的去除效果,并对处理前后猪粪中重金属形态变化进行分析。结果表明:无机酸浸提优化条件下Cu、Zn和Mn的浸出率分别为43.24%、76.28%和78.91%;超声协同无机酸浸提优化条件下Cu、Zn和Mn的浸出率分别为39.6%、76.3%和79.9%;2种浸提方式均能显著降低猪粪中重金属有机结合态含量。     

猪粪堆肥中铜锌与腐殖质组分的结合竞争

为研究猪粪堆肥中铜锌与腐殖质组分的结合竞争,以猪粪和秸秆为堆腐原料,进行了为期36 d的好氧堆肥实验,研究猪粪堆肥过程中腐殖质组分(胡敏酸和富里酸)、胡敏酸结合态铜锌、富里酸结合态铜锌含量的变化。结果表明,堆肥结束后,腐殖化程度提高,胡敏酸碳含量增加394.4%,富里酸碳含量降低64.9%,腐殖化指数从0.24增加到3.33;随着堆肥的进行,胡敏酸结合态铜锌含量分别增加394.3%和56%,而富里酸结合态铜锌含量分别下降17.5%和28.4%;相关分析表明,胡敏酸结合态铜、富里酸结合态锌与胡敏酸、富里酸碳含量及腐殖化指数均成显著相关(P<0.01);堆肥过程中,胡敏酸结合态铜与富里酸结合态铜之比大于1,而胡敏酸结合态锌与富里酸结合态锌小于1,另外,胡敏酸中的Cu/Zn大于1,而富里酸中的Cu/Zn小于1,表明在腐殖质中铜主要与胡敏酸结合,而锌主要与富里酸结合。研究揭示了猪粪堆肥中重金属铜锌与不同腐殖质组分的结合竞争关系,为畜禽粪便堆肥土地利用的风险评估和风险控制提供科学依据。     

稳定剂协同水泥固化/稳定化重金属污染土壤的工程特性

采用稳定剂（SR）协同水泥（PC）固化/稳定化重金属污染土壤,以Pb、Zn浸出毒性和药剂吨处理成本为综合指标确定PC和SR的最优配比,并对固化土体进行无侧限抗压强度、不固结不排水三轴压缩实验和柔性壁渗透实验,探讨固化土体强度以及渗透特性。结果表明,最优配比为SR掺量 2.5%,PC掺量8%;最优配比下固化土体中重金属铅锌的浸出浓度分别降低97.5%和74.5%,均低于固体危险废物浸出标准值。其养护28 d无侧限抗压强度达到1 080 kPa,比未固化土体对应值高9.6倍;随着PC掺量增加,固化体的有效黏聚力及有效内摩擦角均不断增大,其中最优配比固化土体有效黏聚力达到216.9 kPa,有效内摩擦角为34.8°。加入稳定剂SR使固化体渗透系数增大,但随着PC掺量增加,渗透系数急剧降低。其中最优配比固化土体渗透系数相对未固化复合污染土体降低一个数量级至10-6cm·s-1,可有效增强土体的防渗阻隔能力,提高稳定化土壤的安全利用率。     

土霉素残留对猪粪堆肥过程中理化性质的影响

为探讨土霉素残留对猪粪堆肥过程的影响,以猪粪和锯末为原料,设置土霉素初始残留质量浓度分别为0、10、50、100、150 mg/kg的5个处理,进行为期30 d的好氧堆肥,研究土霉素对堆肥过程中温度、含水率、水溶性NH4+-N、水溶性NO3- -N、水溶性有机碳(DOC)的变化影响.结果表明:(1)土霉素残留加速了温度的下降,不利于温度的上升.(2)土霉素初始残留质量浓度为100、150 mg/kg不利于堆肥过程中水分的散失,并且会造成堆肥结束后堆体的高含水率.(3)土霉素抑制了堆肥过程中微生物对有机氮的分解及硝化细菌的硝化作用,其中150mg/kg处理的土霉素抑制作用最显著.(4)堆肥结束后,0、10、50、100、150 mg/kg处理的DOC分别为3 815.65、3 461.88、3 429.28、3 231.18、2 782.09mg/kg.0 mg/kg处理的DOC高于其他4个处理,且与150 mg/kg处理之间差异显著,表明土霉素抑制了堆肥过程中微生物对有机碳的利用,其中150 mg/kg处理的土霉素抑制作用最显著.     

Land application of tylosin and chlortetracycline swine manure: Impacts to soil nutrients and soil microbial community structure

The land application of aged chortetracycle (CTC) and tylosin-containing swine manure was investigated to determine associated impacts to soil microbial respiration, nutrient (phosphorus, ammonium, nitrate) cycling, and soil microbial community structure under laboratory conditions. Two silty clay loam soils common to southeastern South Dakota were used. Aerobic soil respiration results using batch reactors containing a soil-manure mixture showed that interactions between soil, native soil microbial populations, and antimicrobials influenced CO₂ generation. The aged tylosin treatment resulted in the greatest degree of CO₂ inhibition, while the aged CTC treatment was similar to the no-antimicrobial treatment. For soil columns in which manure was applied at a one-time agronomic loading rate, there was no significant difference in soil-P behavior between either aged CTC or tylosin and the no-antimicrobial treatment. For soil-nitrogen (ammonium and nitrate), the aged CTC treatment resulted in rapid ammonium accumulation at the deeper 40cm soil column depth, while nitrate production was minimal. The aged CTC treatment microbial community structure was different than the no-antimicrobial treatment, where amines/amide and carbohydrate chemical guilds utilization profile were low. The aged tylosin treatment also resulted in ammonium accumulation at 40 cm column depth, however nitrate accumulation also occurred concurrently at 10 cm. The microbial community structure for the aged tylosin was also significantly different than the no-antimicrobial treatment, with a higher degree of amines/amides and carbohydrate chemical guild utilization compared to the no-antimicrobial treatment. Study results suggest that land application of CTC and tylosin-containing manure appears to fundamentally change microbial-mediated nitrogen behavior within soil A horizons.     

猪粪在管道抽吸过程中的非牛顿流体流动阻力特性

为解决高浓度猪粪收集转运等过程涉及的基础性技术问题,以不同浓度猪粪为研究对象,探讨了含固率、真空度、管径及自然放置时间等参数对管道抽吸流量和非牛顿流体流动阻力特性的影响。结果表明：猪粪含固率由2%增加到20%,其流变指数由0.952 3降至0.300 4,抽吸流量随猪粪含固率增加而减少;抽吸流量与管径呈幂指增长关系,当猪粪的非牛顿流体特性增强时,管径是影响管道黏性阻力的重要因素;抽吸流量的平均降低率随自然放置时间不断增加,15 d后降低率为8.3%,25 d后达到26.2%;对于管道抽吸猪粪而言,高含固率(>16%)条件下实验范宁摩擦因子快速变大,说明此时不再适合抽吸;管道流动特征表现为高范宁摩擦因子(0.006 6~3.020 0)和低雷诺数(10~2 435)的层流特征。以上研究结果可为畜禽粪污环保处理等相关领域提供参考。     

镍渣的重金属浸出特性

在分析镍渣的矿物相组成和重金属元素含量的基础上,鉴定了镍渣样品的浸出毒性,并考察了pH、液固比和浸出时间等条件对镍渣样中铬、铅、铜和锌等重金属浸出特性的影响。结果表明,镍渣中的重金属总量约为渣样的0.9%,且铬、铜和锌的含量较高,需进行安全管理。实验所用镍渣样品为第Ⅰ类一般工业固体废物。在强酸条件下镍渣中重金属浸出浓度较大,pH3后浸出浓度显著降低;液固比40 L/kg时,镍渣中重金属不断溶出,液固比40 L/kg后,浸出达到饱和,浸出浓度趋于平衡;随着浸出时间的增加,重金属离子的浸出浓度先增加后减少,但由于各重金属性质不同,各重金属达到最大浸出浓度的时间不同。     

堆肥污泥重金属在黄土中的淋滤特征

堆肥污泥中所含重金属是污泥堆肥土地利用最大的障碍,实验选用北方贫瘠的黄土作为供试样品,通过室内土柱淋滤实验,对堆肥污泥重金属在黄土中的淋滤特征进行了研究。结果显示,在0～40 cm的浅层淋滤层,各种重金属在黄土中的纵向迁移能力为:Pb>Zn>Ni>Cu,而在50～55 cm的深层淋滤层,Cd在黄土中的迁移能力相对其他4种重金属是比较强的;各种重金属在50～60 cm深层淋滤层中会出现二次富集,出现明显富集层。研究揭示了堆肥污泥重金属在黄土中的迁移特征,为有效控制和消除堆肥污泥土地利用中重金属的污染研究提供了理论依据。     

热解吸工艺放置顺序对土壤重金属稳定化效果的影响

为了研究热解吸工艺放置顺序对土壤重金属稳定化效果的影响,通过小试模拟的方式,对不同种类的土壤样品进行实验,对比分析了土壤的关键指标在加热前后的变化。结果表明,当热解吸工艺放置在添加稳定化药剂前时,会提高土壤的pH,也会使土壤的重金属有效态质量分数和酸浸出质量浓度增加,但仅有较低的可能性使2者超标。并且,根据不同的土壤酸碱性质,热解吸工艺对重金属形态转化产生的影响不同。当热解吸工艺放置在添加稳定化药剂后,不影响土壤重金属有效态含量和浸出浓度,并对重金属的形态转化没有影响。2种技术联用时的顺序对重金属稳定化效果的影响较小。本研究可为工程项目实施时的工艺设计提供参考。     

重金属污染土壤的草酸和EDTA混合淋洗研究

采用不同浓度的草酸(oxalic acid,OX)和乙二胺四乙酸(EDTA)混合的淋洗方法研究重金属污染土壤的最佳混合淋洗方式,探讨了液固比、淋洗时间及pH对淋洗效果的影响,并分析了0.2 mol/L OX+0.2 mol/L EDTA处理前后土壤中重金属形态的变化。结果表明,采用0.2 mol/L OX+0.2 mol/L EDTA混合的淋洗法可同时去除多种重金属,且对Cu、Zn、Ni和Cr的去除率明显高于单用OX和EDTA,去除率分别为Cu 41.29%、Zn 84.73%、Ni 54.2%和Cr 66.01%。0.2mol/L OX+0.2 mol/L EDTA在液固比为5∶1、淋洗时间为4 h、pH为6时可分别达到最佳淋洗效果,且分别为Cu 62.59%、Zn 93.48%、Ni 55.95%和Cr 71.57%;Cu 50.47%、Zn 86.67%、Ni 61.53%和Cr 72.68%;Cu 44.40%、Zn 81.82%、Ni68.76%和Cr 74.93%。形态分析结果表明,0.2 mol/L OX+0.2 mol/L EDTA能较好地改变土壤中重金属形态的分布。     

非混合接种对猪粪厌氧干发酵产气特性的影响

为达到缓解猪粪厌氧干发酵时有机酸的积累并能够同时提高产气性能的目的,采用小试批式实验,在中温(37 ℃)、总固体(TS)为20%的条件下研究了猪粪接种物全混合发酵、猪粪非混合接种发酵、猪粪玉米秸秆与接种物全混合发酵及猪粪玉米秸秆混合原料非混合接种发酵这4种方式对发酵体系的有机酸积累及产甲烷特性的影响。结果表明,猪粪接种物全混合发酵和猪粪玉米秸秆与接种物全混合发酵的总有机酸(TVFAs)质量浓度在发酵结束时分别为15.2和3.6 mg·g⁻¹,较对应底物的非混合接种发酵分别提高了6.3倍和5.0倍。在2种非混合接种发酵体系中,TVFAs质量浓度在21 d后迅速降低。其中,猪粪玉米秸秆混合原料非混合接种的TVFAs下降幅度更大,其第30天的TVFAs质量浓度低于1.5 mg·g⁻¹。猪粪玉米秸秆混合原料非混合接种厌氧发酵产气效果最佳,累积VS产甲烷量达到148.2 mL·g⁻¹。猪粪非混合接种发酵沼气中甲烷含量最高,达到75.1%。修正的Gompertz模型拟合结果显示,猪粪玉米秸秆混合原料非混合接种发酵和猪粪非混合接种发酵的迟滞期分别为10.6和12.4 d,较对应底物的混合接种发酵分别缩短了5.9和6.1 d;最大VS产甲烷速率分别提高了1.7倍和4.9倍,达到6.2和4.8 mL·(g·d)⁻¹。非混合接种能够缓解猪粪厌氧干发酵的酸抑制并同时提高其甲烷产率。     

玻璃抛光废渣理化特性研究

为处置和利用一种玻璃抛光废渣,用XRF、ICP、XRD、SEM、灰熔点炉、粒度分析和浸出毒性等实验手段对其化学成分、浸出毒性、颗粒径和比表面积等理化性质进行了系统研究。结果表明,玻璃抛光废渣虽然主体是Si、Al、Fe、K、Na、Ca和Mg的硅酸盐,但含一定量的Pb、Ba、Cr、Mn、Zn、V、Cu和As等重金属元素,80%的粒径小于15μm,平均粒径为6.31μm,比表面积为480 m2/g,是一种细粉状浸出毒性较高的有害固废;烧结能有效地固封和固溶其中的重金属,可作为控制其污染和处置利用的有效措施。     

施用垃圾堆肥土壤重金属在不同温度和酸雨条件下的淋溶特征

采用淋洗法,研究了垃圾堆肥中重金属在不同温度与模拟酸雨条件下的淋溶特征。结果表明,随着淋洗次数的增加,淋洗液中Cd、Cr、Cu、Ni和Pb的含量都有很大程度的减少。Cd、Cr、Cu和Ni 4种金属在模拟酸雨的情况下淋出量明显高于蒸馏水的情况,增幅都在116%和351%之间,差异显著(P<0.05)或极显著(P<0.01),而酸雨对Pb的淋出影响较小。在酸雨淋洗下,重金属的淋出率在30℃时达到最大,其中Ni随着温度的变化相对较小。而在蒸馏水淋洗下,重金属的淋出率随着温度的变化相对平稳。此外,5种重金属的淋出率明显不同,其中Cr和Ni的淋出率相对较大,Pb最小。     

3种环保型淋洗剂对重金属污染土壤的淋洗效果

采用振荡淋洗法研究衣康酸(IA)、丙烯酸-2-丙烯酰胺-2-甲基丙磺酸共聚物(AA/AMPS)和衣康酸-丙烯酸共聚物(IA-AA)在不同因素影响下对污染土壤Cd、Pb和Zn的淋洗效率。结果表明：3种淋洗剂对土壤Cd、Pb和Zn的去除率随其浓度增加而快速上升,随pH增加呈迅速下降和先升高后降低2种趋势,随淋洗时间总体呈上升趋势;3种淋洗剂在浓度为0.15 mol·L-1且pH为3时,对Cd和Zn去除率最高（39.34%~65.65%）;在相同浓度和pH为5条件下对Pb的去除率最高（22.05%~50.62%）。其中IA-AA对Cd、Pb和Zn的去除率分别可达65.65%、50.62%和44.92%。它们去除的主要重金属组分为酸溶态、可还原态和部分可氧化态,且经IA和IA-AA淋洗的土壤养分损失相对较小。因此,IA-AA是修复Cd、Pb和Zn复合污染土壤有工程应用前景的淋洗剂。     

A column test for leaching of organochlorines from soil by amphiphilic nonionic nanopolymers

Amphiphilic nonionic cross-linked nanopolymers (NPs) were synthesized to examine removal of five organochlorines (OCs), namely lindane, heptachlor, aldrin, dieldrin, endrin, and DDT, from a range of Thai agricultural soils. The synthesized NP particles had polarity characteristics similar to those of nonionic surfactant micelles and were largely in the size range of 55–155 nm. This work aimed to determine the optimal conditions for leaching of OC contaminated soil with NPs and also to investigate the role and influence of soil properties on this leaching. An investigation of the concentrations of aqueous dispersions of these particles found that a concentration of 10 g L^?1. was found most effective in leaching the OCs from a column of spiked soil. The optimal contact time that allowed a NP dispersion and spiked soil to reach equilibrium was 48 h. The results indicated influencing factors for OC removal and soil remediation were properties both of the soil and the compounds themselves. Soil organic carbon (SOC) content and soil texture played an important role on the sorption as well as compound hydrophobicity expressed as log K_OW values. The removal efficiency was found to be in the range of 85.2–92.8 % for all soil samples and in the order of DDT < aldrin < heptachlor < dieldrin < endrin < lindane regardless of soil type. This order is inversely related to the log K_OC values of these compounds. For OC compounds with a similar molecular structure, removal efficiency was related to molecular weight (MW).     

Recycling of EDTA solution after soil washing of Pb, Zn, Cd and As contaminated soil

Soil washing with EDTA is known to be an effective means of removing toxic metals from contaminated soil. A practical way of recycling of used soil washing solution remains, however, an unsolved technical problem. We demonstrate here, in a laboratory scale experiment, the feasibility of using acid precipitation to recover up to 50% of EDTA from used soil washing solution obtained after extraction of Pb (5330 mg kg⁻¹), Zn (3400 mg kg⁻¹), Cd (35 mg kg⁻¹) and As (279 mg kg⁻¹) contaminated soil. Up to 100% of EDTA residual in the washing solution and 100%, 97%, 98% and 100% of initial Pb, Zn, Cd and As concentration in the solution, respectively, were removed in an electrolytic cell using a graphite anode. We employed the recovered EDTA and treated washing solution to prepare recycled soil washing solution with the same potential for extracting toxic metals from soil as the original. The efficiency of soil washing depends on the EDTA concentration. Using twice recycled 30 mmol EDTA kg⁻¹ soil, we removed 44%, 20%, 53% and 61% of Pb, Zn, Cd and As, respectively, from contaminated soil.