Use of fungi for the bioconversion of rice straw into cellulase enzyme

Cellulase production was carried out by solid state bioconversion (SSB) method using rice straw, a lignocellulosic material and agricultural waste, as the substrate of three Trichoderma spp. and Phanerochaete chrysosporium in lab-scale experiments. The results were compared to select the best fungi among them for the production of cellulase. Phanerochaete chrysosporium was found to be the best among these species of fungi, which produced the highest cellulase enzyme of 1.43 IU/mL of filter paper activity (FPase) and 2.40 IU/mL of carboxymethylcellulose activity (CMCase). The "glucosamine" and "reducing sugar" parameters were observed to evaluate the growth and substrate utilization in the experiments. In the case of Phanerochaete Chrysosporium, the highest glucosamine concentration was 1.60 g/L and a high concentration of the release of reducing sugar was measured as 2.58 g/L obtained on the 4th day of fermentation. The pH values were also recorded. The range of the pH was about 5.15 to 5.56 in the case of Phanerochaete Chrysosporium.     

Phanerochaete chrysosporium吸附载体的选择及染料降解研究

研究了游离细胞与载体吸附培养、不同载体材料对Phanerochaete chrysosporium进行连续染料脱色及产酶能力的影响。结果表明,P. chrysosporium可在载体上良好生长,甚至生长到载体内部。木屑、玉米芯、花生壳3种载体材料中,以木屑载体吸附培养物的持续脱色和产酶效果最佳,该培养物经三轮连续脱色后对染料RB5仍能达到最高95%的脱色率,并产生596 U/L锰依赖过氧化物酶（MnP）和1 326 U/L木质素过氧化物酶（LiP）,对染料的持续脱色和产酶能力明显优于游离细胞培养物。     

Decolouration of azo dyes by <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis> immobilised into alginate beads

Background, aim and scope  

Because of high discharged volumes and effluent composition, wastewater from the textile industry can be considered as the most polluting amongst all industrial sectors, thus greatly requiring appropriate treatment technologies. Although some abiotic methods for the reduction of several dyes exist, these require highly expensive catalysts and reagents. Biotechnological approaches were proven to be potentially effective in the treatment of this pollution source in an eco-efficient manner. The white-rot fungi are, so far, the most efficient microorganisms in degrading synthetic dyes. This white-rot fungi’s property is due to the production of extracellular lignin-modifying enzymes, which are able to degrade a wide range of xenobiotic compounds because of their low substrate specificity. In this paper, we studied the ability of the white-rot fungus Phanerochaete chrysosporium immobilised into Ca-alginate beads to decolourise different recalcitrant azo dyes such as Direct Violet 51 (DV), Reactive Black 5 (RB), Ponceau Xylidine (PX) and Bismark Brown R (BB) in successive batch cultures. To the best of our knowledge, this is the first study on the immobilisation of P. chrysosporium into Ca-alginate beads for its application in dye decolouration.     

Biodegradation of superabsorbent polymers in soil

Biodegradation of two superabsorbent polymers, a crosslinked, insoluble polyacrylate and an insoluble polyacrylate/ polyacrylamide copolymer, in soil by the white-rot fungus, Phanerochaete chrysosporium was investigated. The polymers were both solubilized and mineralized by the fungus but solubilization and mineralization of the copolymer was much more rapid than of the polyacrylate. Soil microbes poorly solublized the polymers and were unable to mineralize either intact polymer. However, soil microbes cooperated with the fungus during polymer degradation in soil, with the fungus solubilizing the polymers and the soil microbes stimulating mineralization. Further, soil microbes were able to significantly mineralize both polymers after solubilization by P. chrysosporium grown under conditions that produced fungal peroxidases or cellobiose dehydrogenase, or after solubilization by photochemically generated Fenton reagent. The results suggest that biodegradation of these polymers in soil is best under conditions that maximize solubilization.     

二鼠李糖脂对白腐菌降解稻草中木质纤维素的影响

通过固态发酵方式采用白腐菌对稻草中木质纤维素进行降解,并研究了生物表面活性剂二鼠李糖脂对该降解过程的影响。结果表明,不同浓度的二鼠李糖脂能在不同程度上提高降解过程水溶性有机碳的含量,添加0.007%和0.021%二鼠李糖脂的实验组最高TOC(total organic carbon)浓度较对照组分别提高了83.6%和54.5%,这有利于黄孢原毛平革菌的生长,且延缓了菌体的衰退。添加临界胶束浓度0.007%和0.021%浓度的二鼠李糖脂可使LiP(lignin peroxidase)酶活分别提高85.7%和41.2%,二鼠李糖脂对MnP(manganese peroxidase)酶活没有显著影响。生物表面活性剂的介入促进了白腐菌对稻草中木质素的降解,添加0.007%二鼠李糖脂可使木质素降解率提高54%。     

Effects of tertiary treatment by fungi on organic compounds in a kraft pulp mill effluent

Background, aim and scope  

Pulp and paper mills generate a plethora of pollutants depending upon the type of pulping process. Efforts to mitigate the environmental impact of such effluents have been made by developing more effective biological treatment systems in terms of biochemical oxygen demand, chemical oxygen demand, colour and lignin content. This study is the first that reports an evaluation of the effects of a tertiary treatment by fungi (Pleurotus sajor caju, Trametes versicolor and Phanerochaete chrysosporium and Rhizopus oryzae) on individual organic compounds of a Eucalyptus globulus bleached kraft pulp and paper mill final effluent after secondary treatment (final effluent).     

Cellobiose dehydrogenase-dependent biodegradation of polyacrylate polymers by Phanerochaete chrysosporium

When Phanerochaete chrysosporium was cultured using conditions which promote the expression of cellobiose dehydrogenase (CDH), but not the ligninolytic peroxidases, the fungus effectively solubilized and mineralized an insoluble, crosslinked polyacrylate and an insoluble polyacrylate/polyacrylamide copolymer. Addition of iron to the cultures increased CDH activity in the cultures and the rate and extent of solubilization and mineralization of both polymers. Solubilization of both polymers was observed when incubated with purified CDH, ferric iron and hydrogen peroxide.     

纤维素高效降解菌NU-H的诱变选育及降解特性

以草酸青霉(Penicillium oxalicum)D1为出发菌株,经过紫外线、亚硝酸以及紫外与亚硝酸复合诱变处理,选育出1株高产纤维素酶突变株NU-H,与出发菌株相比,CMCase酶活提高69.8%,滤纸酶活提高75.28%,另外木聚糖酶活,还原糖得率也有显著地提高。通过单因子及正交实验,研究了突变株纤维素酶对稻草粉水解的最适宜条件。结果表明,该菌株酶解糖化的最佳条件为:温度50℃,时间28 h,纤维素酶浓度为60%,底物浓度3%,pH 4.8,还原糖得率为23.25%。     

Cellular and molecular damage of Phanerochaete chrysosporium by the oxidation hair dyes

Introduction

The toxic effect of the oxidation hair dyes on Phanerochaete chrysosporium was investigated by exposure of this fungus in a nitrogen-limited culture medium to various concentrations of the oxidation hair dyes.

Results

The results showed that both the size and the dry weight of the mycelial pellets of P. chrysosporium could be reduced when the concentration of the oxidation hair dyes was higher than 300?mg/L. By using the AFLP analysis and the UPGMA dendrogram, the DNA damage of P. chrysosporium by the oxidation hair dyes was also detected. Comparing with that in the control, the percent polymorphism under different concentrations of the oxidation hair dyes increased. In the meantime, the DNA similarity was decreased, which meant that the DNA damage was aggravated with an increase in the concentrations of the oxidation hair dyes.

Conclusion

Thus, as an environmental pollutant, the oxidation hair dyes have a toxic effect on P. chrysosporium at both cellular and molecular levels.     

Microwave enhanced advanced oxidation process for treating dairy manure at low pH

This study investigated the treatment of dairy manure using the microwave enhanced advanced oxidation process (MW-AOP) at pH 2. An experimental design was developed based on a statistical program using response surface methodology to explore the effects of temperature, hydrogen peroxide dosage and heating time on sugar production, nutrient release and solids destruction. Temperature, hydrogen peroxide dosage and acid concentration were key factors affecting reducing sugar production. The highest reducing sugar yield of 7.4% was obtained at 160°C, 0 mL, 15 min heating time, and no H₂O₂ addition. Temperature was a dominant factor for an increase of soluble chemical oxygen demand (SCOD) in the treated dairy manure. The important factors for volatile fatty acids (VFA) production were microwave temperature and hydrogen peroxide dosage. Temperature was the most important parameter, and heating time, to a lesser extent affecting orthophosphate release. Heating time, hydrogen peroxide dosage and temperature were significant factors for ammonia release. There was a maximum of 96% and 196% increase in orthophosphate and ammonia concentration, respectively at 160°C, 0.5 mL H₂O₂ and 15 min heating time. The MW-AOP is an effective method in dairy manure treatment for sugar production, nutrient solubilisation, and solids disintegration.     

林可霉素菌（Streptomyces lincolnensis）利用吡唑酮废水的研究

采用被吡唑酮废液驯化、分离、筛选后的林可霉素菌,并对其在摇瓶上利用吡唑酮废液中的硫酸铵发酵（7 d）生产林可霉素进行了研究。实验结果表明,废液加入培养基体积比都为1∶10,实验1中菌丝代谢和对照比正常,其中还原糖利用最快,在发酵后期为0.24 mg/L,林可霉素起步效价最低为2 100 IU/mL,与对照相比最后发酵效价降低了70 IU/mL;实验2发酵过程pH值偏低,全程为5.86～6.50,氨基氮代谢缓慢为40 mg/100 mL,最后林可霉素效价最低为4 480 IU/mL;实验3中废液在发酵进入48 h中后期的时候补入能促进菌丝体分泌,最后林可霉素为5 180 IU/mL,比对照发酵水平高出8.82%。可见实验3的实验设计有利于林可霉素菌利用吡唑酮废液生产林可霉素,为废物循环利用、变废为宝的可行性作了有意义尝试。     

林可霉素菌(Streptomyces lincolnensis)利用吡唑酮废水的研究

采用被吡唑酮废液驯化、分离、筛选后的林可霉素菌,并对其在摇瓶上利用吡唑酮废液中的硫酸铵发酵(7 d)生产林可霉素进行了研究。实验结果表明,废液加入培养基体积比都为1∶10,实验1中菌丝代谢和对照比正常,其中还原糖利用最快,在发酵后期为0.24 mg/L,林可霉素起步效价最低为2 100 IU/mL,与对照相比最后发酵效价降低了70 IU/mL;实验2发酵过程pH值偏低,全程为5.86～6.50,氨基氮代谢缓慢为40 mg/100 mL,最后林可霉素效价最低为4 480 IU/mL;实验3中废液在发酵进入48 h中后期的时候补入能促进菌丝体分泌,最后林可霉素为5 180 IU/mL,比对照发酵水平高出8.82%。可见实验3的实验设计有利于林可霉素菌利用吡唑酮废液生产林可霉素,为废物循环利用、变废为宝的可行性作了有意义尝试。     

烟草下脚料发酵制取乙醇

通过单因素实验考察了硫酸浓度、固液比和水解时间对硫酸水解的影响。结果显示最优条件为:硫酸浓度为50%(w/w),固液比为10%(w/v),时间为100 min。烟草下脚料在最佳硫酸水解条件下,经5倍稀释,中和pH值至5～6。取经过滤后的水解液(FH)用酿酒酵母(Sacchharomyces cerevisiae)发酵产生乙醇,最大的乙醇浓度和乙醇产量分别为1.09g/L和54.5 g/kg。未过滤水解液(UFH,包括水解残渣)加入纤维素酶(70 U/100 mL)和酿酒酵母(Sacchharomyces cerevisiae)进行发酵,最大的乙醇浓度和乙醇产量分别为1.23 g/L和61.5 g/kg。     

初始pH值对提油后藻渣发酵制氢的影响

提油后藻渣的利用和处理对于微藻生物柴油产业的发展具有重要意义.采用批次实验研究了初始pH值(pH值范围为5～9)对提油后藻渣发酵产氢的影响.研究结果表明,提高初始pH值引起累积产氢量和氢气产量逐渐下降.初始pH值从5增加到6.5引起氢气产生速率逐渐增加,而初始pH值从6.5增加到9时,氢气产生速率则逐渐下降.在pH 5...     

Festuca arundinacea,glutathione S-transferase and herbicide safeners: A preliminary case study to reduce herbicidal pollution

The expression of glutathione S-transferase (GST) activity in Festuca arundinacea was investigated in response to the following herbicide safeners: benoxacor, cloquintocet-mexyl, fenchlorazol-ethyl, fenclorim, fluxofenim and oxabetrinil. All the above compounds enhanced the GST activity tested towards the “model” substrate 1-chloro-2,4-dinitrobenzene (CDNB). Assays of GST activity towards the herbicides terbuthylazine (N ²-tert-butyl-6-chloro-N ⁴-ethyl-1,3,5-triazine-2,4-diamine) and butachlor (N-butoxymethyl-2-chloro-2′,6′-diethylacetanilide) as substrates also showed the ability of the safeners to enhance the enzyme activity towards both these herbicides, with the exception of cloquintocet-mexyl for the enzyme activity towards butachlor. As a consequence of the above effects at a macro-scale level, decreased herbicide accumulation and persistence were ascertained in response to the addition of the safener benoxacor to both terbuthylazine and butachlor treatments. These results are discussed in terms of capacity of benoxacor to induce herbicide detoxification in Festuca arundinacea with a view to utilizing them in reducing herbicide pollution.     

Enhanced reduction of phenol content and toxicity in olive mill wastewaters by a newly isolated strain of Coriolopsis gallica

The search for novel microorganisms able to degrade olive mill wastewaters (OMW) and withstand the toxic effects of the initially high phenolic concentrations is of great scientific and industrial interest. In this work, the possibility of reducing the phenolic content of OMW using new isolates of fungal strains (Coriolopsis gallica, Bjerkandera adusta, Trametes versicolor, Trichoderma citrinoviride, Phanerochaete chrysosporium, Gloeophyllum trabeum, Trametes trogii, and Fusarium solani) was investigated. In vitro, all fungal isolates tested caused an outstanding decolorization of OMW. However, C. gallica gave the highest decolorization and dephenolization rates at 30 % v/v OMW dilution in water. Fungal growth in OMW medium was affected by several parameters including phenolic compound concentration, nitrogen source, and inoculum size. The optimal OMW medium for the removal of phenolics and color was with the OMW concentration (in percent)/[(NH₄)₂SO₄]/inoculum ratio of 30:6:3. Under these conditions, 90 and 85 % of the initial phenolic compounds and color were removed, respectively. High-pressure liquid chromatography analysis of extracts from treated and untreated OMW showed a clear and substantial reduction in phenolic compound concentrations. Phytotoxicity, assessed using radish (Raphanus sativus) seeds, indicated an increase in germination index of 23–92 % when a 30 % OMW concentration was treated with C. gallica in different dilutions (1/2, 1/4, and 1/8).

Biologically active antimicrobial and antioxidant substances in the Helianthus annuus L. bee pollen

The objective of this study was to measure the content of flavonoids, polyphenols, and carotenoids in the Helianthus annuus L. bee pollen. It was also to evaluate the ability of the dried, frozen, and freeze-dried extracts of sunflower (H. annuus) pollen, its scavenged free radicals and reducing action. Another aim of this study was to investigate the antimicrobial in vitro action of the H. annuus pollen extracts against the Gram-positive and Gram-negative bacteria and fungi. All pollen extracts showed medium antiradical activity and reductive ability. The most effective was the freeze-dried extract in both evaluation systems. The evaluation of the protective effects of DNA using a biosensor showed an opposite trending—frozen ? dried ? freeze-dried pollen. For the evaluation of antiradical activity, the DPPH method was used, and reductive ability was assessed by means of phosphomolybdic complex formation. The comparison of the polyphenols content shows higher values in freeze-dried bee pollen than in the dried and frozen pollen. The highest content of flavonoids was found in the frozen samples and the most carotenoids were present in the dried samples. In our study, the best antibacterial effects of the dried sunflower bee pollen extracts were found against Paenibacillus larvae, Pseudomonas aeruginosa, and Enterococcus raffinosus. The best inhibitory properties of the frozen sunflower bee pollen extracts were found against Escherichia coli, Pseudomonas aeruginosa, and Paenibacillus larvae. Very good inhibitory effects of freeze-dried sunflower bee pollen were found against Paenibacillus larvae, Brochotrix thermosphacta, and Enterococcus raffinosus. The best antifungal activity of the sunflower bee pollen was found in the frozen bee pollen extracts against Aspergillus ochraceus and freeze-dried bee pollen extracts against Aspergillus niger.     

固定化小球藻与活性污泥的共生系统处理含锌废水

研究固定化小球藻与活性污泥的共生系统对含锌废水中Zn2+的去除效果,分析菌藻状态、初始Zn2+浓度、pH、固定化菌藻小球投加量和菌藻体积比等5个因素对固定化菌藻共生系统去除Zn2+的影响。结果表明,固定化活性污泥、固定化小球藻和固定化菌藻对Zn2+的去除效果均优于悬浮小球藻,其中固定化菌藻对Zn2+的去除效果最好;废水中初始Zn2+浓度小于100 mg/L时,固定化菌藻系统对废水中Zn2+的去除率达到90.5%;固定化菌藻系统去除废水中Zn2+的最佳条件是:初始Zn2+浓度为80 mg/L,pH=7,固定化小球投加量为80 mL,菌藻体积比为1∶2。     

Slightly acidic electrolyzed water for reducing airborne microorganisms in a layer breeding house

Reducing airborne microorganisms may potentially improve the environment in layer breeding houses. The effectiveness of slightly acidic electrolyzed water (SAEW; pH 5.29–6.30) in reducing airborne microorganisms was investigated in a commercial layer house in northern China. The building had a tunnel-ventilation system, with an evaporative cooling. The experimental area was divided into five zones along the length of the house, with zone 1 nearest to an evaporative cooling pad and zone 5 nearest to the fans. The air temperature, relative humidity, dust concentration, and microbial population were measured at the sampling points in the five zones during the study period. The SAEW was sprayed by workers in the whole house. A six-stage air microbial sampler was used to measure airborne microbial population. Results showed that the population of airborne bacteria and fungi were sharply reduced by 0.71 × 10⁵ and 2.82 × 10³ colony-forming units (CFU) m^?3 after 30 min exposure to SAEW, respectively. Compared with the benzalkonium chloride (BC) solution and povidone-iodine (PVP-I) solution treatments, the population reductions of airborne fungi treated by SAEW were significantly (P < 0.05) more, even though the three disinfectants can decrease both the airborne bacteria and fungi significantly (P < 0.05) 30 min after spraying.

Implications: There are no effective methods for reducing airborne microbial levels in tunnel-ventilated layer breeding houses; additionally, there is limited information available on airborne microorganism distribution. This research investigated the spatial distribution of microbial population, and the effectiveness of spraying slightly acidic electrolyzed water in reducing microbial levels. The research revealed that slightly acidic electrolyzed water spray was a potential method for reducing microbial presence in layer houses. The knowledge gained in this research about the microbial population variations in the building may assist producers in managing the bird housing environment and engineers in designing poultry houses.     

Fenton氧化法深度处理抗生素废水二级出水

采用Fenton氧化法对青霉素和土霉素混合废水二级处理出水进行深度处理,通过正交和单因素实验研究了废水初始反应pH值、H2O2投加量、Fe2+/H2O2摩尔比及反应时间等因素对废水处理效果的影响。实验结果表明,Fenton氧化法处理的最佳反应条件为:初始pH值4、H2O2(30%)投加量50 mL/L、Fe2+/H2O2摩尔比1/20和反应时间60 min,处理后出水COD小于120 mg/L,COD去除率在75%以上,急性毒性(HgCl2毒性当量)小于0.07 mg/L,满足《发酵类制药工业水污染物排放标准》(GB21903-2008)表2标准要求。