糠醛渣纤维素酶解研究

以糠醛渣为原料进行纤维素酶解研究,考察了预处理方式、酶用量、底物浓度和酶解时间对糠醛渣酶解的影响,并将其与稀酸预处理的玉米芯进行对比.结果表明,未经处理的糠醛渣由于酸性较强并含有糠醛等抑制性的物质,不能直接用于酶解,水洗和Ca(OH)₂脱毒法都可以显著提高糠醛渣的酶解效果;水洗糠醛渣的酶解最佳条件为：1∶9（g∶mL）的底物浓度、20 FPU/g（酶活/底物）,酶解时间为48 h,在此条件下,还原糖浓度为35 g/L,糠醛渣的转化率为30%,糠醛渣中纤维素的转化率为61%.     

玉米芯水解生产糠醛清洁工艺

针对我国糠醛行业资源利用率低的问题,利用平流泵连续向高压釜中通水模拟糠醛工业生产工艺中玉米芯硫酸催化水解过程,进行了糠醛生产清洁工艺的研究. 分析了蒸出流量,反应时间,w(硫酸)和反应温度等条件对糠醛收率的影响. 结果表明:提高蒸出流量,控制反应时间(t)稍大于木糖反应完毕时间(t_x),调节w(硫酸),适当提高反应温度,以便反应釜停留时间(τ)≤最佳反应时间(t_opt),可使糠醛收率显著提高. 在蒸出流量为10 mL/min,反应4 h,w(硫酸)为0.25%和180 ℃时,糠醛收率达到80.84%,比国内现有工业生产过程中的糠醛收率提高了15%～20%.      

糠醛生产企业废水处理措施

使用糠醛塔下污水循环利用装置，糠醛生产污水得到全部综合利用，不产生二次污染，节省了能源消耗，减轻了环境污染，实现了“节能减排”的目标。     

糠醛渣为主要原料的引火饼的研究

<正> 本文论述了以糠醛渣为主要原料制上点火蜂窝煤引火饼的研究。糠醛渣是以玉米芯为原料,采用硫酸催化法生产糠醛的副产品,其中含有大量的腐植酸等有机质。以糠醛渣为主要原料制上点火蜂窝煤引火饼,即可制成助燃剂型的,也可制成无助燃剂型的。经试烧表明,点燃效果良好,取得较好的经济效益和环境效益。一、试验(一)糠醛渣特性生产糠醛的原料——玉米芯,其主要成份是纤维素、半纤维素和木质素。在水解过程中,半纤维素转为糠醛,剩下的残渣叫做水解纤维木素,即糠醛渣,经分析表明,用硫酸法产生的糠醛渣含有机质(干基)95％以上,其中腐植酸含量达25～35％,呈强酸性,pH 值约为2。对糠醛渣其成份、工业元素进行了分析,其数据如表1、2、3。     

糠醛废渣制备活性炭对糠醛废水的脱色研究

以水蒸气为活化剂,用热解糠醛废渣制备活性炭,着重研究了所制备的活性炭对糠醛废水的脱色性能. 结果表明:糠醛废渣制备的活性炭对糠醛废水脱色的最佳温度为50 ℃,并且在很短的时间内即可完成,该活性炭与糠醛废水混合搅拌15 min后,脱色率几乎不再变化. 由于采用糠醛废渣制备活性炭的成本较低,可以适当增加活性炭的投加量以提高糠醛废水的脱色率. 当活性炭投加量为10 g/L时,50 ℃条件下搅拌10 min,糠醛废水脱色率可达到86.65%. 经活性炭脱色后的糠醛废水无色、透明,以去离子水为参比溶液测定其吸光度,与自来水相当.      

浅谈糠醛精制装置的运行安全特点

介绍了润滑油基础油加工过程中糠醛精制装置的工艺流程,阐述了包括反应危险特点、爆燃危险特点和操作危险特点在内的装置运行安全特点。针对糠醛泄漏、加热炉炉管腐蚀着火异常情况,分析了可能的发生原因,提出了应急处置措施和注意事项;对装置开工初期满塔和腐蚀泄漏停工两个典型事故案例进行了分析,介绍了当时的处置措施,给出了防范措施和建议。     

当前房地产开发项目环境评估工作要点分析

结合房地产开发项目的自身特点,笔者就房地产开发项目环境评估工作要点进行较为详细的介绍,以期为住宅类房地产项目环境影响评价起到一定参考作用。     

环境工程评估工作方法及措施研究

在新时期,环境保护的重要性越来越突出,环境工程评估作为环境保护的重要措施,对于维护当地的生态环境具有重要的意义。环境工程评估通过对相关项目进行环境影响评估以及相关的技术咨询等,帮助、政府企业按照国家的法律法规依法展开项目建设工作,实现对环境的保护。环境工程评估工作需要遵循一定工作流程,在新时期下环境过程评估应当与时俱进,采取新的工作措施,提高评估效率。     

糠醛渣对苯酚吸附性能研究

文章研究了糠醛渣对苯酚的吸附性能。采用低温N2吸附-脱附和傅里叶红外光谱对糠醛渣进行了表征,测得糠醛渣的平均孔径为14.5 nm,孔容为0.016 cm3/g,BET比表面积为5.3 cm2/g,并且官能团丰富。室温下,考察了吸附时间、溶液pH值、苯酚的初始浓度、糠醛渣的粒度对吸附苯酚的影响。结果表明,当糠醛渣粒度为20目、加入量为2.0 g,吸附时间25 min,pH值为3,苯酚的初始浓度为0.1 g/L时,对溶液中苯酚的吸附率为95.2%。糠醛渣丰富的孔结构和较大的比表面积使其作为吸附剂,实现了以废治废的目的。     

糠醛废水处理工程试验研究

本主要介绍了糠醛废水的产生、规模危害及主要治理方法，着重阐述应用UASB加生物接触氧化法处理糠醛废水的成功经验。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Sorption of 1-naphthol by plant cuticular fractions

The contribution of aliphatic-rich plant biopolymer to sorption of hydrophobic organic compounds is significantly important because of their preservation and accumulation in the soil environment,but sorption mechanism is still not fully understood.In this study, sorption of 1-naphthol by plant cuticular fractions was examined to better understand the contributions of respective fraction.Toward this end,cuticular materials were isolated from the fruits of tomato by chemical method.The tomato cuticle sheet consisted of waxes (6.5 wt%),cuticular monomer (69.5 wt%),and polysaccharide (24.0 wt%).Isotherms of l-naphthol to the cuticular fractions were nonlinear (N value (0.82-0.90)) at the whole tested concentration ranges.The KodKow ratios for bulk cuticle (TC1),dewaxed cuticle (TC2),cutin (TC4),and desugared cuticle (TC5) were larger than unity,suggested that tomato bulk cuticle and cutin are much powerful solption medium.Sorption capability of cutin (TC4) was 2.4 times higher than the nonsaponifiable fraction (TC3).The 1-naphthol interactions with tomato cuticular materials were governed by both hydrophobic-type interactions and polar (H-bonding) interactions. Removal of the wax and polysaccharide materials from the bulk tomato cuticle caused a significant increase in the sorption ability of the cuticular material.There was a linear negative trend between K_(oc) values and the amount of polysaccharides or fraction's polarities ((N O)/C);while a linear positive relationship between K_(oc) values and the content of cutin monomer (linear R~2=0.993) was observed for present in the cuticular fractions.Predominant sorbent of the hydrophobic organic compounds (HOCs) in the plant cuticular fraction was the cutin monomer,contributing to 91.7% of the total sorption of tomato bulk cuticle.