游离氨对热水解联合中温厌氧消化处理剩余污泥的影响

热水解预处理强化了污泥厌氧消化过程,但同时增加了微生物受游离氨抑制的风险.对比传统工艺,在有机容积负荷率1.74~4.27gVS/(L·d)条件下,研究了游离氨(FA)对热水解联合中温厌氧消化工艺性能的影响.结果表明,组合工艺甲烷产量较传统反应器提高89%~121%,有机去除率提高1.21~1.46倍.但同时导致系统中游离氨浓度达89~382mgN/L,显著高于传统工艺中37~84mgN/L的范围.游离氨毒性测试显示,传统工艺中FA浓度从43mgN/L升至84mgN/L,没有抑制解乙酸产甲烷途径,而组合工艺中FA升至264mgN/L时,表现出抑制作用,尽管厌氧菌对高浓度FA表现更强的驯化趋势.结合氮负荷试验, FA浓度与基质利用能力,解乙酸产甲烷途径抑制程度和挥发性有机酸积累的关系表明,高有机负荷条件下组合工艺效率可通过控制氮负荷优化.     

C/N比调控污泥厌氧发酵产酸的数学模型研究

采用改进粒子群算法对ADM1模型中的关键参数进行了估计,经敏感性分析,确定了Monod最大比吸收速率、半饱和值、产物对底物的产率等3种参数对产酸速率具有较大影响.应用修正后的动力学参数对ADM1模型在不同C/N比调控下污泥厌氧发酵产酸结果进行了模拟.结果表明,模拟产酸数据和实测数据误差较小,说明修正后的ADM1模型能够很好地描述污泥厌氧发酵中C/N比条件对产酸的影响.     

投碱种类和氨吹脱对污泥碱性发酵产酸的影响

采用完全混合式厌氧反应器,比较了NaOH和Ca(OH)2 2种碱试剂对污泥厌氧发酵产酸的作用效果,结合氨吹脱作用考察了NH4+浓度的降低对各有机物水解酸化程度的影响.结果表明在pH值为10的条件下,以NaOH调节的体系中各种有机物尤其是挥发性脂肪酸(VFAs)的量明显高于以Ca(OH)2调节的体系.Ca(OH)2调节的体系中释放出的蛋白质有部分沉淀,磷酸盐含量也较低,小于40mg/L;氨吹脱的体系发酵液中氨氮含量减少了43%,增大了VFAs的积累量;在NaOH和氨吹脱的组合条件下,污泥水解酸化程度最好,SCOD为6732mg/L,蛋白质为2029mg/L,碳水化合物374mg/L,VFAs总量2545mg/L,且氨氮含量低于200mg/L;分析认为氨吹脱作用增大VFAs积累量的原因主要是NH4+浓度的减小,促进了产酸菌对于碳水化合物的发酵.     

Identical full-scale biogas-lift reactors (BLRs) with anaerobic granular sludge and residual activated sludge for brewery wastewater treatment and kinetic modeling

Two identical full-scale biogas-lift reactors treating brewery wastewater were inoculated with different types of sludge to compare their operational conditions, sludge characteristics, and kinetic models at a mesophilic temperature. One reactor （R1） started up with anaerobic granular sludge in 12 weeks and obtained a continuously average organic loading rate （OLR） of 7.4 kg chemical oxygen demand （COD）/（m3.day）, COD removal efficiency of 80%, and effluent COD of 450 mg/L. The other reactor （R2） started up with residual activated sludge in 30 weeks and granulation accomplished when the reactor reached an average OLR of 8.3 kg COD/（m^3·day）, COD removal efficiency of 90%, and effluent COD of 240 mg/L. Differences in sludge characteristics,biogas compositions, and biogas- lift processes may be accounted for the superior efficiency of the treatment performance of R2 over R1. Grau second-order and modified StoverKincannon models based on influent and effluent concentrations as well as hydraulic retention time were successfully used to develop kinetic parameters of the experimental data with high correlation coefficients （R2 〉 0.95）, which further showed that R2 had higher treatment performance than R1. These results demonstrated that residual activated sludge could be used effectively instead of anaerobic granular sludge despite the need for a longer time.     

Achieving nitritation at low temperatures using free ammonia inhibition on Nitrobacter and real-time control in an SBR treating landfill leachate

Free ammonia(FA) inhibition on nitrite-oxidized bacteria(NOB) and real-time control are used to achieve nitrogen removal from landfill leachate via nitrite pathway at low temperatures in sequencing batch reactor. The inhibition of FA on NOB activity during the aerobic period was prolonged using real-time control. The degree of nitrite accumulation was monitored along with variations of the ammonia-oxidizing bacteria and NOB population using fluorescence in situ hybridization techniques. It is demonstrated that the end-point of ammonia oxidization is detected from the on-line measured dissolved oxygen,oxidization–reduction potential, and p H signals, which could avoid the loss the FA inhibition on NOB caused by excess aeration. At low temperature(13.0–17.6°C), the level of nitrite pathway rapidly increased from 19.8% to 90%, suggesting that nitritation was successfully started up at low temperature by applying syntrophic association of the FA inhibition and real-time control, and then this high level of nitrite pathway was stably maintained for as long as 233 days. Mechanism analysis shows that the establishment of nitritation was primarily the result of predominant ammonia-oxidizing bacteria developed in the nitrifying bacteria population compared to NOB. This was mainly due to a gradual reduction of nitrite amount that is available to provide energy for the growth of NOB,eventually leading to the elimination of NOB from the bacterial clusters in sequencing batch reactor sludge system.     

污泥厌氧发酵产酸关键影响因素的函数模型研究

本研究以城市剩余污泥预处理液作为底物,调节底物不同C/N比,测定了厌氧发酵过程中几种关键酶的酶活及发酵产物乙酸、丙酸及丁酸的浓度.同时,利用Matlab软件通过回归分析和函数拟合构建了C/N比-关键酶活-酸产量之间的多项式函数模型,发现所建立的二元三次多项式模型的拟合优度R2均大于0.9,且残差平方和较小,因此,判定二元三次多项式更适合描述C/N比-关键酶活-酸产量的数学关系.最后,建立了关键酶活、C/N比和产酸量三因素间的曲面模型,发现该模型能够很好地描述污泥厌氧发酵中C/N比条件对关键酶和产酸类型的影响,并能进一步预测C/N比所对应的酶活和产酸发酵类型,可为今后的实验研究及工程放大提供理论参考.     

活性污泥作为气化用型煤粘结剂的研究 Ⅰ.污泥添加量和型煤成型条件的考察

以活性污泥为研究对象，以合成氨厂广泛使用的白泥型煤参照，进行了气化用型煤粘结剂的研究，结果表明，当污泥添加量为２％白泥添加量为０．３％时，所制得的型煤抗压强度、跌落强度、热稳定性与白泥型相当。     

生物酶对初沉污泥厌氧发酵产短链脂肪酸的调控研究

旨在通过生物酶调节(碱性蛋白酶、中性蛋白酶和α-淀粉酶)提高初沉污泥的厌氧发酵效率,并通过微生物群落结构解析,SCFAs (short-chain fatty acids,SCFAs)组分分析等揭示其调控机理.结果表明,3种生物酶均可增强初沉污泥水解和产酸作用,碱性蛋白酶调控系统对初沉污泥厌氧发酵的促进效果最为明显,发酵第4d SCFAs的产量和产率分别达到1508mg COD/L和0.174g COD/g VSS.对比控制组,SCFAs的产量和产率分别增加了1129mg COD/L和0.13g COD/g VSS.微生物群落结构分析表明,在碱性蛋白酶调控发酵系统中,Lentimicrobium、Proteiniphilum和Bacteroides等发酵相关菌群的相对丰度得到了改善,Methanosaeta、Methanospirillum等产甲烷古菌的活性受到了抑制.同时,生物酶调控对促进发酵过程乙酸占比也有促进作用.     

嗜热菌株AT07-1的分离鉴定及其在污泥溶解预处理厌氧发酵产氢中的应用

从湖南大学花园土壤中采集样品,用稀释涂布法分离和纯化适于污泥溶解的典型嗜热菌菌株,从中选出一株高效菌进行形态观察,并对其进行生理生化鉴定.结果表明,该菌株的革兰氏染色为阳性,呈细杆状,产芽孢,为好氧或兼性需氧细菌,最适生长温度为65℃,最适生长pH值为6.8~7.5.通过16SrDNA碱基测序和对比证实,该菌株是目前尚未报道过的一株嗜热菌,GenBank中注册命名为Bacillus thermophilic bacteria AT071(注册号:FJ231108).同时,将其纯种菌用于嗜热酶溶解（solubilization by thermophilic enzyme,S-TE）污泥稳定化处理,接种该嗜热菌可促进污泥中悬浮固体的溶解,2.5d时接种试验挥发性悬浮固体 (volatile suspended solid,VSS)溶解率达到59.41%,比不接种试验同期提高了25.58%,达到了EPA规定的污泥稳定化要求.进一步对经AT071预处理的污泥厌氧产氢效果进行研究,试验结果显示,接种处理后污泥发酵产氢效果良好,高出未接种处理（65℃热处理）污泥26.4%,发酵气体中只含有H2和CO2.     

部分反硝化耦合厌氧氨氧化IFAS系统脱氮性能

采用部分反硝化活性污泥耦合厌氧氨氧化生物膜处理低碳氮比废水(C/TN=1.63),考察生物膜-活性污泥复合系统(IFAS)进行部分反硝化耦合厌氧氨氧化(PD/A)处理低碳氮比废水的可行性及其耦合后两相中功能菌活性与菌群分布变化规律.结果显示,系统耦合运行期间,出水TN为(5.07±0.2)mg/L,去除率为(90.7±0.1)%,厌氧氨氧化途径对TN去除的贡献率高达(86.61±3.4)%;固着相对厌氧氨氧化活性的贡献率为100%,悬浮相上,μ(NO3--N)占比为99.32%,μ(NO2--N)占比为99.22%;与耦合前相比,悬浮相中硝酸盐还原酶(Nar)活性由(0.43±0.05)μmol/(mgprotein·min)增加至(0.49±0.09)μmol/(mgprotein·min),亚硝酸盐转化率明显升高[(70±2.2)%～(90.01±2.3)%];IlluminaMiSeq结果显示,固着相上的优势菌属为Candidatus＿Brocadia,且耦合前后丰度无明显变化(33.61%～33.43%),悬浮相上反硝化菌属Prosthecobacter,Ferruginiba...