优势菌种浸取电解锰渣中锰的影响因素研究

采用电解锰废渣中分离出的一种锰抗性强的微生物Fusarium sp.浸取电解锰渣中的锰。研究了不同矿浆浓度、微生物生长活动、锰渣和培养基等对锰浸取效率的影响。结果表明,接种体积比为2%（v/v）时,矿浆浓度（m/v）对锰浸取效率影响显著,矿浆浓度过低（〈2%）或者过高（〉10%）对锰浸取效率都有不利影响。矿浆浓度为10%时锰浸取效率最高,达80%以上;微生物的生长活动对浸取过程有显著的影响;而锰渣的存在则能在一定程度上影响溶液的pH,进而影响锰浸取效率;培养基对锰浸取效率的贡献达50%左右。     

Origins of Manganese in Air Participates in California

The proportions of manganese to other metals in samples of airborne fine particles taken at some sites in California have increased greatly since the beginning of 1985. Here, data are presented which indicate that the addition of manganese to leaded gasoline is largely responsible for this increase. Concentrations of manganese, silicon, titanium, iron, lead and other elements in airborne particles were measured using energy-dispersive X-ray fluorescence analysis. Coefficients of correlation among levels of manganese, iron and lead measured at twenty sites in California were calculated. Levels of manganese and iron are generally highly correlated because of the presence of large amounts of these elements in the earth’s crust. Levels of airborne manganese and lead at sites In Southern California are often highly correlated, suggesting a vehicular source of manganese. Observed manganese concentrations are apportioned into two major sources: the earth’s crust and motor vehicles. The apportionment indicates that vehicular emissions of manganese may account for a significant part of the total at urban sites in Southern California. At most other sites, the contribution from vehicles is found to be far smaller than that from the earth’s crust.     

改性锰砂对废水中锰的吸附特性研究

通过正交实验,研究pH值、反应时间、锰砂投加量和锰砂改性时间等因素对Mn2+吸附效果的影响。结果表明,在25℃,吸附反应体系pH=9,锰砂投加量为15 g/L,吸附时间为30 min,锰砂的高锰酸钾改性时间为36 h时,改性锰砂对锰的吸附去除率最高,达到了99.99%。四因素的影响顺序为:pH>反应时间>锰砂投加量>锰砂改性时间。在单因素实验中,当pH=7,吸附剂投加量为25 g/L时,经60 min可达吸附平衡,锰的去除率为60.04%,其等温吸附符合Freundlich和Langmuir模型,并且与Langmuir模型的拟合程度更高。本研究还对改性锰砂吸附除锰的机理做了初步探讨。     

改性沸石处理高铁锰地下水

采用不同方法对天然沸石改性,并用改性后沸石进行了静态和动态除铁锰实验。结果表明,采用NaCl、HCl、微波方法对沸石改性,以NaCl改性效果最好。经浓度为25%的NaCl改性后的沸石铁去除率提高了13.81%,锰去除率提高了26.4%。沸石改性可以同步提高其除铁、除锰效果,且除锰效果提高更多。铁或锰的存在都能使对方单一被沸石吸附效果下降。用沸石滤柱处理高铁锰地下水,在停留时间1.0 h时,铁最高去除率为62.3%,锰最高去除率为58.3%。     

烟气脱硫过程锰催化氧化亚硫酸钙的研究

利用直径280 mm、高320 mm的间歇式搅拌槽,在MnSO4加入浓度为0～0.05 mol/L的情况下,对亚硫酸钙悬浮液进行了催化氧化实验研究.实验结果表明,锰离子的加入会改变亚硫酸钙的氧化机理及氧化过程,表现为终点氧化率和氧化速率的变化.当Mn2 浓度为0.05 mol/L时,亚硫酸钙的终点氧化率比未加入Mn2 时高30%;此外,与非催化反应过程相比,Mn2 的加入能使亚硫酸钙在一个更宽的浓度范围内(0.02～0.073 mol/L)和一个更宽的时间范围内(20～100 min)均保持较高的氧化速率水平.     

改性锰砂滤料处理高铁锰煤矿矿井水

采用KMnO4溶液浸渍法制备了新型改性锰砂滤料,研究了滤料表面性能和过滤处理高铁锰矿井水的效果。结果表明,锰砂滤料除铁锰性能优于石英砂、陶粒以及瓷砂,采用KMnO4溶液浸渍能够提高锰砂滤料的过滤性能,最优的浸渍浓度为5%。5%KMnO4改性锰砂滤料过滤处理高铁锰矿井水的最佳工艺参数为：过滤周期24 h,反冲洗强度3.2 L/（s.m2）,反冲洗时间5 min;通过比表面积测试分析和SEM表征分析发现,KMnO4溶液浸渍能够提高锰砂滤料比表面积,并在锰砂滤料表面形成了氧化膜,从而提高除铁除锰效果,而且浸渍液浓度越高,这种作用越明显。     

电解锰渣无害化处理技术简

电解锰渣是湿法电解金属锰工艺产生的废渣,环境危害性大、治理难度大。为消除锰渣的污染性,实验研究了锰渣浸出液中污染物种类,并分别采用生石灰和氢氧化钠作处理剂,从成本、处理效果方面进行比较,确定处理剂以及最佳运行条件。得出结论：锰渣中主要污染物为锰和氨氮（分别超过相关标准453倍和26倍）,选取生石灰做处理剂,处理后的锰渣,浸出液中锰离子和氨氮的减排量分别达到99%和97%以上,水溶性锰离子浓度低于5 mg/L、氨氮浓度低于25 mg/L,均达到《污水综合排放标准》（GB8978-1996）中的排放标准;反应时间30 h以上、避免雨淋、不通风、无日照为最佳反应条件。     

废电池中氧化锰还原冶炼锰钢的实验研究

为促进我国锌锰废电池集中资源化处理,开发了一种高温回收废电池中锰的新工艺.废电池分选后,破碎和筛分,其中二氧化锰与还原剂碳制成球团,烧结后在感应炉中还原锰,制成锰钢.实验表明,球团中不加表面活性剂的二氧化锰还原率为34%,球团中加入硫化物表面活性剂促进二氧化锰在钢中的还原率,达到80%,钢液中锰含量可达3.97%,本实验条件下,还原最佳时间为20 min.在铸钢生产中可以直接应用该工艺处理废电池.     

二氧化氯-接触催化氧化联合去除水中铁和锰

为了解决水体中铁锰季节性超标的问题,提出一种既能够减少化学试剂的使用又能有效去除铁锰的经济有效的方法。研究了单一方法(二氧化氯氧化法、接触催化氧化法)及两者联合对铁锰的去除效果,提出用二氧化氯氧化-锰砂过滤联合方法解决。研究表明,用ClO2氧化去除水中Fe2+的反应先发生、速率较快且效果较好,而与Mn2+反应则较慢并且不能完全转化为沉淀。单纯接触催化氧化法需要较长时间,过滤层才能达到稳定且较好的处理效果,培养过程中其除锰效果并不理想。两者联合时,利用过滤层的吸附作用去除部分铁锰,减少了氧化剂的使用。初期3个柱的除Mn2+效果都比较好,去除率均大于80%;然而采用石英砂或纤维束滤料的滤柱去除Mn2+的效果随时间变差,但采用锰砂的除锰效果在实验期间始终维持在较高水平。     

SDS和PVP强化生物淋溶锰渣的性能

在生物淋溶锰渣的过程中,设置一系列浓度梯度(0～100 mg/L)的离子型表面活性剂SDS(十二烷基硫酸钠)和非离子型表面活性剂PVP(聚乙烯吡咯烷酮),研究两种活性剂对硫杆菌生长和对锰渣中锰的浸出率的影响.结果表明,两种表面活性剂均能有效强化硫杆菌对锰渣的淋溶性能,SDS和PVP的最佳浓度分别为35 mg/L和15 mg/L,在最佳浓度条件下,两者均能显著降低培养液的pH值,提高锰的浸出率,其浸出率分别达到88％和83％,均高于对照组的72％.进一步分析表明,SDS比PVP更能有效提高浸出体系的ORP电位,促进锰的浸出.电镜结果表明,在最佳浓度条件下,SDS比PVP更能有效促进硫杆菌对锰渣表面的侵蚀,降低锰渣的表面粒度,提高锰渣中锰的浸出率.     

软锰矿电化学协同作用对活性嫩黄模拟废水脱色率的研究

以活性嫩黄K 4G模拟废水为处理对象 ,采用软锰矿与电化学协同法 ,分别在不同软锰矿加入量、电流密度、pH值、电解时间、染料初始浓度条件下进行电解实验 ,考察了各种因素对脱色率的影响。结果表明 ,增加软锰矿的用量、增大电流密度、降低pH值、延长电解时间都能提高脱色率 ,染料初始浓度对脱色率影响不显著。溶液中溶解态锰的浓度的变化表明 ,Mn(II)在处理过程中表现出催化作用 ,外加电压可强化软锰矿的氧化作用     

Development of Lymantria dispar affected by manganese in food

We studied the response of gypsy moth (Lymantria dispar (Linnaeus) (Lepidoptera: Lymantriidae)) to the content of manganese in food in the laboratory breeding of caterpillars. The food of the caterpillars {Betula pendula Roth (Fagales: Betulaceae) leaves} was contaminated by dipping in the solution of MnCl₂·4H₂O with manganese concentrations of 0, 0.5, 5 and 10 mg ml^?1, by which differentiated manganese contents (307; 632; 4,087 and 8,124 mg kg^?1) were reached. Parameters recorded during the rearing were as follows: effect of manganese on food consumption, mortality and length of the development of caterpillars, pupation and hatching of imagoes. At the same time, manganese concentrations were determined in the offered and unconsumed food, excrements, and exuviae of the caterpillars, pupal cases and imagoes by using the AAS method. As compared with the control, high manganese contents in the food of gypsy moth caterpillars affected the process of development particularly by increased mortality of the first instar caterpillars (8 % mortality for caterpillars with no Mn contamination (T0) and 62 % mortality for subjects with the highest contamination by manganese (T3)), by prolonged development of the first–third instar (18.7 days (T0) and 27.8 days (T3)) and by increased food consumption of the first–third instar {0.185 g of leaf dry matter (T0) and 0.483 g of leaf dry matter (T3)}. The main defence strategy of the caterpillars to prevent contamination by the increased manganese content in food is the translocation of manganese into frass and exuviae castoff in the process of ecdysis. In the process of development, the content of manganese was reduced by excretion in imagoes to 0.5 % of the intake level even at its maximum inputs in food.     

以河砂为填料的接触氧化法处理高铁锰地下水研究

分别选用河砂、锰砂、改性页岩3种滤料作为滤柱填料,采用接触氧化法去除地下水中的铁锰,通过对比实验选取最佳填料,并对最佳填料去除铁锰的影响因素进行了研究.实验结果表明,3种滤料成熟期基本相同且对铁锰均有较好的去除效果,由于河砂具有广泛易得、成本低廉等优点,因此更适用于小城镇地区使用.对以河砂为填料的接触氧化法除铁除锰的深...     

Natural manganese ore catalyst for low-temperature selective catalytic reduction of NO with NH3 in coke-oven flue gas

Environmental Science and Pollution Research - Different types of manganese ore raw materials were prepared for use as catalysts, and the effects of different manganese ore raw materials and...     

高锰酸钾生产废渣中的高价锰回收方法研究

高锰酸钾生产过程所产生的废渣中含有较多的高价态锰,导致锰资源的浪费和潜在的环境污染问题。采用葡萄糖-硫酸还原浸取法浸取高锰酸钾渣中的高价锰,实验探讨了葡萄糖用量、硫酸用量及浸取温度等因素对锰浸取率的影响,并研究了化学氧化法回收二价锰的工艺条件。结果表明,在葡萄糖与高锰酸钾渣质量比为0.3、硫酸物质的量与高锰酸钾渣质量之...     

Influence of parasitism on the use of small terrestrial rodents in environmental pollution monitoring

Bioaccumulation of cadmium, chromium, copper, manganese, nickel, lead and zinc in small terrestrial rodents – voles and their cestode parasite Paranoplocephala dentata was studied. Contents of Pb, Mn, Ni and Zn in the parasite were found to be higher than in the kidney and liver of the parasitized animals. Lead level in the cestode was 37 fold higher than in the liver of the infected rodents. Bioaccumulation factors of zinc, nickel and manganese in the cestode are mostly in the range from 2 to 4.5. Considering the different contents of manganese and zinc in livers of non-parasitized and parasitized rodents, kidney tissue was found to be more reliable than liver as an indicator of environmental pollution by manganese and zinc; the kidneys of parasitized animals showed no significant change in the concentrations of those elements that are accumulated in the cestode.     

改性沸石去除地下水中铁锰实验研究

测定了2种改性沸石的基本特性,并选取0.6 m层高的交换柱,通过动态试验,研究其分别用于除铁和除锰的工艺性能。实验结果表明,2种沸石质量全交换容量分别为578.2 mmol/kg和722.2 mmol/kg;产水水质均能达到饮用水标准：含铁量≤0.3 mg/L,含锰量≤0.1 mg/L;减少进水中铁锰含量（≤2 mg/L）和降低运行流速（≤20 m/h）,都有利于提高工作交换容量,但流速对除铁沸石影响较小;再生剂为1 mol/L的NaCl,再生速率1 m/h条件下,每升除铁沸石再生剂用量为1.2 L,洗脱率（再生废液中目标离子含量与原水中过滤时的去除量之比）达0.95,比耗（再生剂用量与工作交换容量之比）为16,每升除锰沸石再生剂用量为1.6 L,洗脱率达0.8,比耗为16。     

Oxidative decomposition of formaldehyde by metal oxides at room temperature

Formaldehyde (HCHO) is still a major indoor air pollutant in Japanese air-tight houses and is the subject of numerous complaints regarding health disorders. Authors have developed a passive-type air-cleaning material and an air cleaner using manganese oxide (77% MnO₂) as an active component and successfully reduced indoor HCHO concentrations in newly built multi-family houses. In this study, the reactivity between manganese oxide and HCHO was discussed. We tested the removal efficiencies of several metal oxides for HCHO in a static reaction vessel and found manganese oxide could react with HCHO and release carbon dioxide even at room temperature. The reactivity and mechanisms were discussed for the proposed chemical reactions. A mass balance study proved that a major product through the heterogeneous reaction between manganese oxide and HCHO was carbon dioxide. Harmful by-products (HCOOH and CO) were not found.     

Oxidized multiwalled carbon nanotubes as adsorbent for the removal of manganese from aqueous solution

A batch adsorption process was applied to investigate the removal of manganese from aqueous solution by oxidized multiwalled carbon nanotubes (MWCNTs). In doing so, the thermodynamic, adsorption isotherm, and kinetic studies were also carried out. MWCNT with 5–10-nm outer diameter, surface area of 40–600 m²/g, and purity above 95 % was used as an adsorbent. A systematic study of the adsorption process was performed by varying pH, ionic strength, and temperature. Manganese-adsorbed MWCNT was characterized by Raman, FTIR, X-ray diffraction, XPS, SEM, and TEM. The adsorption efficiency could reach 96.82 %, suggesting that MWCNT is an excellent adsorbent for manganese removal from water. The results indicate that second-order kinetics model was well suitable to model the kinetic adsorption of manganese. Equilibrium data were well described by the typical Langmuir adsorption isotherm. Thermodynamic studies revealed that the adsorption reaction was spontaneous and endothermic process. The experimental results showed that MWCNT is an excellent manganese adsorbent. The MWCNTs removed the manganese present in the water and reduced it to a permissible level making it drinkable.     

大洋锰结核在环境污染治理方面的应用

大洋锰结核能够有效分解转化气体污染物(如CO、CH、VOC、NOx、SO2);能够吸附水体中的Cu、CO、Ni、Mn、Zn、Cr、Hg、Pb、As等重金属阳离子和PO4^3-、SeO3^2-等阴离子;可做生物固定化载体除去水体中的有机污染物。大洋锰结核具有良好的环境矿物学属性,是一种理想的环境矿物材料,为环境治理提供了新的方向。