不同深度处理工艺去除污水处理厂出水中氮磷的比较研究

城市污水厂出水直接进入天然水体、或经过深度处理后回用于灌溉、补充景观水体和回灌地下水,均需要进行安全性评价.针对北京市北小河污水处理厂出水经过深度处理后回用于奥运公园的安全性,比较了不同深度处理工艺对营养盐(氮、磷)总量和不同形态的去除效果.研究表明,二级处理本身对氮磷的去除效果十分有限,回用水需经过深度处理.在所研究的生物活性炭吸附、微滤、超滤、反渗透以及上述技术的组合工艺中,使用超滤和反渗透联用的工艺路线对脱氮除磷的效果较为理想,其他工艺对去除氮磷的效果十分有限.     

不同深度处理工艺去除污水处理厂出水中氮磷的比较研究

城市污水厂出水直接进入天然水体、或经过深度处理后回用于灌溉、补充景观水体和回灌地下水,均需要进行安全性评价.针对北京市北小河污水处理厂出水经过深度处理后回用于奥运公园的安全性,比较了不同深度处理工艺对营养盐（氮、磷）总量和不同形态的去除效果.研究表明,二级处理本身对氮磷的去除效果十分有限,回用水需经过深度处理.在所研究的生物活性炭吸附、微滤、超滤、反渗透以及上述技术的组合工艺中,使用超滤和反渗透联用的工艺路线对脱氮除磷的效果较为理想,其他工艺对去除氮磷的效果十分有限.     

反渗透处理稀土氨氮废水试验研究

根据稀土冶炼厂排放的碳铵沉淀洗涤废水的水质情况,采用NH4Cl和 NaCl模拟废水进行了反渗透可行性对比实验。模拟实验发现,在相同条件下反渗透对NaCl 较NH₄Cl 有着更高的去除率,而NH₄Cl 相对NaCl则有着更高的产水速率。实际废水试验结果表明,在恒定操作压力范围内回收率为65%的条件下,NH₄Cl浓度为2.85 g/L的碳铵沉淀洗涤废水经反渗透处理其NH₄Cl去除率为77.3%,可作为氨氮废水的预处理。对该废水处理成本进行了分析,得出其约为2.7元/m³,比相近浓度氨氮废水的氨吹脱处理成本节省约26%。     

污泥干化芦苇床中的渗滤液水质变化特征

对3个中试规模的高有机质剩余污泥干化床中污泥渗滤液水质变化特征进行了为期2年的实验研究。Ⅰ单元作为对照床,未种植植物;Ⅱ单元和Ⅲ单元种植芦苇。Ⅰ单元和Ⅱ单元底部充填炉渣,通过穿孔PVC通风管与大气相连通,目的是通过床体填料空隙提供氧气。3个干化床按照如下周期运行:进泥大约半小时,闲置1周,污泥负荷平均为41.3kg TSS/(m2·a)。实验结果表明,污泥干化芦苇床去除污泥渗滤液中的有机物较传统干化床更有效,通风结构有利于有机物的降解;3个床体的污泥渗滤液总磷浓度均高于进泥,但两个芦苇床渗滤液总磷浓度较低,可能的原因是较传统干化床多了植物吸收作用。根据实验数据分析,3个床体中都发生了氨化、硝化和反硝化作用,单元Ⅲ获得了最高的总氮去除率30.38%,Ⅱ单元和Ⅰ单元获得的总氮去除率分别为25.47%和20.59%。高有机质剩余污泥渗滤液仍含有较高的污染物浓度,需回流至污水处理单元进行进一步处理。     

Differential pressure in membrane channel caused by foulant capture onto spacers.

Feed spacers in spiral-wound reverse osmosis membrane modules are highly susceptible to deposition or attachment of suspended particulates and organic matters in the feed stream. This type of fouling can cause a significant pressure drop along the membrane channel (differential pressure) without much effect on the average permeate flux. In practical applications, membrane cleaning is often triggered when the differential pressure in a membrane channel exceeds a threshold value. A mathematical model was developed to simulate the development of differential pressure in the feed channel resulting from foulant capture by the feed spacers. Simulations were carried out to investigate and demonstrate the effect of various parameters on differential pressures in the membrane channel. Differential pressures observed in a two-stage reverse osmosis water reclamation plant were simulated with the model, and the results showed that the model could adequately describe the increase of differential pressure with operating time in the reverse osmosis plant.     

饮用水中硝酸盐的脱除

饮用水中硝酸盐氮的污染问题日趋严重,对人类的健康有多方面的危害.离子交换、反渗透、电渗、生物反硝化、化学和化学催化反硝化都可从水中脱除硝酸盐,但目前投入实用的只有离子交换、生物反硝化、反渗透三种工艺.这些脱硝方法各有优缺点.本文综述了饮用水脱硝的应用与研究的现状,并对其发展的趋势进行了简单的论述.     

活性焦吸附对反渗透浓水膜蒸馏减排工艺的影响

本研究采用膜蒸馏(MD)技术,对煤化工废水2套处理工艺——(1)"混凝-超滤(UF)-反渗透(RO)工艺"和(2)"混凝-活性焦(AC)吸附-超滤-反渗透工艺"的RO浓水进行浓缩。通过对比分析MD的膜通量、产水水质以及膜污染等指标,重点考察AC吸附预处理对后续MD工艺的影响。结果表明,AC吸附作为前置膜处理工艺,可有效降低污染物在膜表面的沉积,减少膜润湿现象,并提高膜通量。GC-MS分析表明,AC能有效吸附废水中的酮类、醇类、酯类以及杂环类等挥发性有机物,降低MD过程中挥发至产水侧的有机物浓度,从而提高MD产水水质。     

Membrane filtration of olive mill wastewater and exploitation of its fractions.

Olive mill wastewater (OMW) produced from small units scattered in rural areas of Southern Europe is a major source of pollution of surface and subsurface water. In the present work, a treatment scheme based on physical separation methods is presented. The investigation was carried out using a pilot-plant unit equipped with ultrafiltration, nanofiltration, and reverse osmosis membranes. Approximately 80% of the total volume of wastewater treated by the membrane units was sufficiently cleaned to meet the standards for irrigation water. The concentrated fractions collected in the treatment concentrates were characterized by high organic load and high content of phenolic compounds. The concentrates were tested in hydroponic systems to examine their toxicity towards undesired herbs. The calculations of the cost of the overall process showed that fixed and operational costs could be recovered from the exploitation of OMW byproducts as water for irrigation and/or as bioherbicides.     

A modified UCT method for biological nutrient removal: configuration and performance

A pilot-scale prototype activated sludge system is presented, which combines both, the idea of University of Cape Town (UCT) concept and the step denitrification cascade for removal of carbon, nitrogen and phosphorus. The experimental set-up consists of an anaerobic selector and stepwise feeding in subsequent three identical pairs of anoxic and oxic tanks. Raw wastewater with influent flow rates ranging between 48 and 168 l d(-1) was fed to the unit at hydraulic residence times (HRTs) of 5-18 h and was distributed at percentages of 60/25/15%, 40/30/30% and 25/40/35% to the anaerobic selector, 2nd and 3rd anoxic tanks, respectively (influent flow distribution before the anaerobic selector). The results for the entire experimental period showed high removal efficiencies of organic matter of 89% as total chemical oxygen demand removal and 95% removal for biochemical oxygen demand, 90% removal of total Kjeldahl nitrogen and total nitrogen removal through denitrification of 73%, mean phosphorus removal of 67%, as well as excellent settleability. The highest removal efficiency and the optimum performance were recorded at an HRT of about 9h and influent flow rate of 96 l d(-1), in which 60% is distributed to the anaerobic selector, 25% to the second anoxic tank and 15% to the last anoxic tank. Consequently, the plant configuration enhanced removal efficiency, optimized performance, saved energy, formed good settling sludge and provided operational assurance.     

UASB反应器处理生活污水的试验研究

采用UASB中试(100 m3/d)对生活污水处理进行了研究。试验结果表明,采用此系统处理生活污水,出水水质良好。COD的去除率在52%~83%,出水的COD值<100 mg/L以下,SS的去除率在95%左右,UASB处理生活污水的最佳停留时间为6 h。产气率在0.1 m3/d。不管停留时间在10 h、5 h,出水的氨氮、乙酸值比进水的高;钙、镁、总氮、总磷、硫酸根和硝酸根离子出水值比进水值低。     

厌氧产氢ASBR对氮的脱除

在厌氧序批式人工有机污水生物产氢反应器(ASBR)中发现氮"丢失"现象,并对此产氢系统发生脱氮作用的机理和主要影响因素进行了研究。结果表明,在以葡萄糖为发酵底物的厌氧产氢系统中,微生物分别以铵和硫酸盐为电子供体和电子受体发生了硫酸盐型厌氧氨氧化;进水有机物负荷和pH主要通过影响不同种微生物的活性而影响脱氮性能,氨氮和硫酸盐的浓度直接与氮素去除率有关。在最大产氢能力为16 m3/(m3·d)、氢气体积百分比为65%的生物制氢系统中,最大脱氮效率约为64%。产氢效率与氮脱除率呈现负相关关系。研究表明,在控制条件下,可以实现高有机物废水厌氧脱除氨态氮,为生活污水直接厌氧脱氮开辟一条新途径。     

添加氮损失抑制剂对蓝藻泥堆肥质量的影响

对脱水蓝藻进行大型生产性堆肥实验。研究堆肥过程中,氮损失抑制剂过磷酸钙的添加对堆肥物料各类理化性质的影响。研究结果表明,过磷酸钙加入的处理组与未加过磷酸钙的对照组堆制37 d后堆肥物料均可腐熟,且堆肥肥效均符合NY525-2002的相关要求。添加过磷酸钙处理组有机质含量为490 g/kg,全N、全P和全K含量分别为20.75、10.02和11.32 g/kg,总养分含量达到9.77%,堆肥品质明显优于对照处理。同时,在微生物的作用下,对照组中微囊藻毒素MC-RR与微囊藻毒素MC-LR去除率分别达到89.8%与78.3%。值得一提的是,添加过磷酸钙后,MC-RR和MC-LR的去除率得到进一步提高,分别达到了92.96%和100%,较好地保证了蓝藻堆肥农用的安全性,为脱水蓝藻好氧堆肥化提供了可行性依据。     

化学混凝-两级BAF工艺处理低温城市污水中试研究

以大庆东城污水处理厂进水为实验原水,采用化学混凝-两级曝气生物滤池(BAF)组合工艺进行现场中试研究(12 m3/d),重点考察了在化学混凝的强化作用下,曝气生物滤池工艺对低温城市污水中有机物、氮和磷等污染物的净化效能。实验结果表明,单独采用两级曝气生物滤池工艺,当原水COD、NH3-N、TN和TP的平均浓度分别为45...     

Electrochemical wastewater treatment: influence of the type of carbon and of nitrogen on the organic load removal

Boron-doped diamond (BDD) and Ti/Pt/PbO₂ anodes were utilized to perform the electrodegradation of synthetic samples containing humic acid in the presence of different organic and inorganic carbon-containing and nitrogen-containing compounds. The influence of the chloride ion in the degradation process of the different synthetic samples was also assessed. The results showed that the anodic oxidation process can efficiently degrade recalcitrant compounds such as humic acid. The presence of carbonate in solution enhances the nitrogen removal, whereas it hinders the oxidation of the organic compounds. When organic nitrogen is present, it is converted to NH₄ ⁺, which in turn is oxidized to nitrate and to volatile nitrogen compounds. Hydroxyl radicals are more prone to oxidize the organic nitrogen than the ammonium nitrogen. The presence of chloride enhances the organic matter and nitrogen removal rates, BDD being the anode material that yields the highest removals.     

制革废水中丙烯酸类鞣剂的膜分离特征

针对3种丙烯酸类鞣剂超滤(UF)、反渗透(RO)分离参数进行了实验研究,探索其在废水深度处理中膜去除的可行性,研究结果表明,3种鞣剂在分离参数:浓度为200 mg/L,超滤的操作压力(P UF)为0.11 MPa,反渗透的操作压力(P RO)为0.4 MPa的条件下UF-RO分离,效果最好。其次,丙烯酸类鞣剂对膜通量影响较大,导致产生的清液较少,所以用UF、RO处理含有这类物质的制革废水时,应尽可能对废水进行预处理。最后,丙烯酸类鞣剂分子中含有极性较强的基团时,粒径分离效果不同。     

电厂循环冷却排污水的回用研究

针对电厂循环冷却排污水的处理技术进行了中试研究。采用超滤、反渗透的工艺处理电厂循环冷却排污水，处理后的水能够满足低压锅炉补充水的要求。该工艺为循环冷却排污水的再利用开辟了一条新途径，既节约了水资源，又减少了环境污染。     

电厂循环冷却排污水的回用研究

针对电厂循环冷却排污水的处理技术进行了中试研究.采用超滤、反渗透的工艺处理电厂循环冷却排污水,处理后的水能够满足低压锅炉补充水的要求.该工艺为循环冷却排污水的再利用开辟了一条新途径,既节约了水资源,又减少了环境污染.     

安全饮用水保障处理中试平台的开发和建设

安全饮用水保障处理中试平台，除具有常规处理工艺外，还引入臭氧接触氧化／催化臭氧氧化、纳滤和反渗透过滤技术、动态膜树脂吸附、光催化氧化、管网生物膜控制等新技术。作者介绍了中试平台建设的设计思路、处理流程及控制系统，并对平台建设的作用进行了阐述。     

炼焦废水生化处理技术研究进展

综述了近几年来炼焦废水及炼焦废水中主要成分(酚类、氨类物质、氰化物)的生化处理方法.其中废水中酚类物质的去除方法有投加有效菌、超滤法等;去除氨类物质的方法有A2/O法、纳滤法和反渗透法等;去除氰化物的方法有生物法和化学法等.综合处理炼焦废水的方法有双层生物膜法、生物脱氮法和含铁活性污泥处理技术等.     

厌氧产氢ASBR对氮的脱除

在厌氧序批式人工有机污水生物产氢反应器（ASBR）中发现氮“丢失”现象,并对此产氢系统发生脱氮作用的机理和主要影响因素进行了研究。结果表明,在以葡萄糖为发酵底物的厌氧产氢系统中,微生物分别以铵和硫酸盐为电子供体和电子受体发生了硫酸盐型厌氧氨氧化;进水有机物负荷和pH主要通过影响不同种微生物的活性而影响脱氮性能,氨氮和硫酸盐的浓度直接与氮素去除率有关。在最大产氢能力为16m3／（m3·d）、氢气体积百分比为65％的生物制氢系统中,最大脱氮效率约为64％。产氢效率与氮脱除率呈现负相关关系。研究表明,在控制条件下,可以实现高有机物废水厌氧脱除氨态氮,为生活污水直接厌氧脱氮开辟一条新途径。