Effect of chemical and microbial amendment on phosphorus runoff from composted poultry litter

Environmental impacts of composting poultry litter with chemical amendments at the field scale have not been well quantified. The objectives of this study were to measure (i) P runoff and (ii) forage yield and N uptake from small plots fertilized with composted and fresh poultry litter. Two composting studies, aerated using mechanical turning, were conducted in consecutive years. Composted litter was collected at the completion of each study for use in runoff studies. Treatments in runoff studies included an unfertilized control, fresh (uncomposted) poultry litter, and litter composted with no amendment, H3PO4, alum, or a microbial mixture. An additional treatment, litter composted with alum plus the microbial mixture, was evaluated during the first year. Fertilizer treatments were applied at rates equivalent to 8.96 Mg ha(-1) and rainfall simulators were used to produce a 5 cm h(-1) storm event. Composted poultry litter, regardless of treatment, had higher total P concentrations than fresh poultry litter. Composting poultry litter resulted in reductions of N/P ratios by as much as 51%. Soluble reactive P concentrations were lowest in alum-treated compost, which reduced soluble P concentrations in runoff water by as much as 84%. Forage yields and N uptake were greatest from plots fertilized with fresh poultry litter. Composting poultry litter without the addition of C sources can increase P concentrations in the end product and surface runoff. This study also indicated that increased rates of composted poultry litter would be required to meet equivalent N rates supplied by fresh poultry litter.     

Relationship between compost stability and extractable organic carbon

Establishing a simple yet reliable compost stability test is essential for a better compost quality control and utilization efficiency. The objective of this study was to examine the relationship between extractable organic carbon (OC) and compost stability based on 18 compost samples from five composting facilities. The compost samples were extracted sequentially with water for 2 h [water(2h)] and 0.1 M NaOH for 2 and 24 h [NaOH(2h) and NaOH(24h), respectively]. The extractable OC was further separated into fulvic acid (FA) and humic acid (HA) fractions by adjusting the pH to <2. The mass specific absorbance (MSA) of OC in the six fractions was measured. Compost stability was estimated with a CO2 evolution method. The extractable OC concentration was influenced by the total volatile solids and decreased with curing time for compost with a high level of extractable OC. The OC levels in each fraction were significantly correlated (p < 0.05) to each other except for the water(2h)-extractable HA. In addition, all the FA and HA fractions except for water(2h)-extractable HA were highly (P < 0.01) and linearly correlated to CO2 evolution, but multiple regression showed that NaOH(24h)-extractable OC was insignificant for CO2 evolution. The relatively high slope of NaOH(2h)-extractable FA versus CO2 evolution suggests that this fraction may contribute the most to compost CO2 evolution. The water(2h)- and/or NaOH(2h)-extractable FA tests are recommended for measuring compost stability because of their high correlation with CO2 evolution. This estimation can be obtained through a simple photometric method covering a wide range of carbon concentrations up to 4,000 mg L(-1).     

浅谈污水厂污泥堆肥化技术

堆肥化技术是使污水厂污泥达到稳定化和无害化的一种经济而有效的手段。目前常用的污泥堆肥化系统可以划分为:条垛系统,强制通风静态垛系统和发酵槽系统。为了加快微生物对污泥中有机物的降解转化,提高处理能力,可对以下因素进行控制:C/N比,含水率,空隙率,温度和通风。在判定污泥堆肥腐熟上,建议采用与氮有关的参数如氨氮、亚硝酸和硝酸盐氮等作为污泥堆肥一般性熟化判定指标。     

Odor and gas release from anaerobic treatment lagoons for swine manure

Odor and gas release from anaerobic lagoons for treating swine waste affect air quality in neighboring communities but rates of release are not well documented. A buoyant convective flux chamber (BCFC) was used to determine the effect of lagoon loading rate on measured odor and gas releases from two primary lagoons at a simulated wind speed of 1.0 m s(-1). Concentrations of ammonia (NH3), hydrogen sulfide (H2S), carbon dioxide (CO2), sulfur dioxide (SO2), and nitric oxide (NO) in 50-L air samples were measured. A panel of human subjects, whose sensitivity was verified with a certified reference odorant, evaluated odor concentration, intensity, and hedonic tone. Geometric mean odor concentrations of BCFC inlet and outlet samples and of downwind berm samples were 168 +/- 44 (mean +/- 95% confidence interval), 262 +/- 60, and 114 +/- 38 OU(E) m(-3) (OU(E), European odor unit, equivalent to 123 microg n-butanol), respectively. The overall geometric mean odor release was 2.3 +/- 1.5 OU(E) s(-1) m(-2) (1.5 +/- 0.9 OU s(-1) m(-2)). The live mass specific geometric mean odor release was 13.5 OU(E) s(-1) AU(-1) (animal unit = 500 kg live body mass). Overall mean NH3, H2S, CO2 and SO2 releases were 101 +/- 24, 5.7 +/- 2.0, 852 +/- 307, and 0.5 +/- 0.4 microg s(-1) m(-2), respectively. Nitric oxide was not detected. Odor concentrations were directly proportional to H2S and CO2 concentrations and odor intensity, and inversely proportional to hedonic tone and SO2 concentration (P < 0.05). Releases of NH3, H2S, and CO2 were directly proportional (P < 0.05) to volatile solids loading rate (VSLR).     

堆肥过程的生物学途径及主要影响因素的控制

从生物学的角度分析了固体有机废弃物堆肥过程中微生物群落的变化,强化堆肥及减少恶臭的生物学途径,简单概述了堆肥过程中提高堆肥质量和效率的主要影响因素（温度、C／N等）,最后提出了今后该领域的发展方向。     

Effect of poultry diet on phosphorus in runoff from soils amended with poultry manure and compost

Phosphorus in runoff from fields where poultry litter is surface-applied is an environmental concern. We investigated the effect of adding phytase and reducing supplemental P in poultry diets and composting poultry manures, with and without Fe and Al amendments, on P in manures, composts, and runoff. We used four diets: normal (no phytase) with 0.4% supplemental P, normal + phytase, phytase + 0.3% P, and phytase + 0.2% P. Adding phytase and decreasing supplemental P in diets reduced total P but increased water-extractable P in manure. Compared with manures, composting reduced both total P, due to dilution of manure with woodchips and straw, and water-extractable P, but beyond a dilution effect so that the ratio of water-extractable P to total P was less in compost than manure. Adding Fe and Al during composting did not consistently change total P or water-extractable P. Manures and composts were surface-applied to soil boxes at a rate of 50 kg total P ha(-1) and subjected to simulated rainfall, with runoff collected for 30 min. For manures, phytase and decreased P in diets had no significant effect on total P or molybdate-reactive P loads (kg ha(-1)) in runoff. Composting reduced total P and molybdate-reactive P loads in runoff, and adding Fe and Al to compost reduced total P but not molybdate-reactive P loads in runoff. Molybdate-reactive P in runoff (mg box(-1)) was well correlated to water-extractable P applied to boxes (mg box(-1)) in manures and composts. Therefore, the final environmental impact of dietary phytase will depend on the management of poultry diets, manure, and farm-scale P balances.     

不同腐熟度猪粪、奶牛粪在小白菜和香瓜上施用的农学效应研究

进行猪粪和奶牛粪自然高温堆肥发酵,分别在15、25、35、50 d取样,获得了不同腐熟程度堆肥产物,分别进行了小白菜和香瓜种子发芽与田间应用试验,以期获得不同腐熟堆肥在蔬菜上施用的农学效应,旨在从堆肥农田施用的农学效应角度,为制订堆肥腐熟度标准提供科学依据。结果表明：牛粪堆肥过程中的最高温度高于猪粪,且高温期也长于猪粪;两种处理在35d有机碳含量均显著降低,全氮含量为先降低后升高趋势;两种堆肥在35d后,均达到无害化标准。不同腐熟程度堆肥对小白菜株高和主根长及香瓜苗重和主根长均没有明显抑制作用,对小白菜和香瓜出苗率、根系活力及小白菜单株鲜重和生物产量影响较大,尤其是猪粪腐熟25d,奶牛粪腐熟15d的堆肥表现出显著抑制作用。将堆肥理化参数与小白菜、香瓜生长指标进行相关分析表明：pH值、全氮含量和C/N这3种指标均与小白菜和香瓜各项生物性状无显著相关性;有机碳和DOC与各项生物性状指标均表现出显著或极显著相关性;铵/硝与小白菜和香瓜的GI和根系活力均表现极显著或显著的相关性,其结果与现行的堆肥腐熟度指标并不一致。因此,在制订堆肥腐熟度标准时,应关注堆肥产物农田施用后不同作物所表现出的不同农学效应。     

Humic acid formation in artificial soils amended with compost at different stages of organic matter evolution

A composting process was conducted under optimal conditions for 150 d, obtaining three biomasses at different levels of maturity: raw material (RM), fresh compost obtained after 11 d of composting (FC), and evolved compost (EC) obtained after 150 d of composting. During the composting process, HAs were extracted and fully characterized by mass balance, DRIFT, and 1H and 13C-nuclear magnetic resonance spectroscopy. Each compost sample was incubated for 180 d in an artificial soil, after which HA extraction was repeated and characterized. To compare composts containing different amounts of labile organic matter (OM), an equal amount of unhydrolyzable OM was added to the soils. Our results indicated that compost HAs consist of a biologically and chemically stable fraction (i.e., the unhydrolyzable HA [U-HA]) and a labile fraction, whose relative contents depended on the composting duration. Humic acid from more EC contained a higher amount of recalcitrant fraction (aromatic carbon) and a lesser amount of labile fraction (aliphatic carbon) than HA from RM and FC. These results suggest that the humification process during composting preserves the more recalcitrant fraction of the compost-alkali soluble/acid insoluble fraction (HA-fraction). Incubation of composts in soil showed that due to the higher labile fraction content, HAs from raw material were more degraded than those from EC. The abundance of labile carbon of soil amended with less-evolved compost (RM and FC) allowed the more recalcitrant fractions of U-HA to be more preserved than in EC. These results suggest that less-evolved compost could contribute more than well evolved compost to the stable soil OM.     

Bias of Tedlar bags in the measurement of agricultural odorants

Odor regulations typically specify the use of dynamic dilution olfactometery (DDO) as a method to quantify odor emissions, and Tedlar bags are the preferred holding container for grab samples. This study was conducted to determine if Tedlar bags affect the integrity of sampled air from animal operations. Air samples were collected simultaneously in both Tedlar bags and Tenax thermal desorption tubes. Sample sources originated from either a hydrocarbon-free air tank, dynamic headspace chamber (DHC), or swine-production facility, and were analyzed by gas chromatography-mass spectrometry-olfactometry (GC-MS-O). Several background contaminants were identified from Tedlar bags, which included the odorous compounds N,N-dimethyl acetamide (DMAC), acetic acid, and phenol. Samples from the DHC demonstrated that recovery of malodor compounds was dependent on residence time in the Tedlar bag with longer residence time leading to lower recovery. After 24 h of storage, recovery of C3-C6 volatile fatty acids (VFA) averaged 64%, 4-methylphenol and 4-ethylphenol averaged 10%, and indole and 3-methylindole were below the detection limits of GC-MS-O. The odor activity value (OAV) of grab samples collected in Tedlar bags were 33 to 65% lower following 24 h of storage. These results indicate that significant odorant bias occurs when using Tedlar bags for the sampling of odors from animal production facilities.     

Repeated compost application effects on phosphorus runoff in the Virginia Piedmont

Increasing amounts of animal and municipal wastes are being composted before land application to improve handling and spreading characteristics, and to reduce odor and disease incidence. Repeated applications of composted biosolids and manure to cropland may increase the risk for P enrichment of agricultural runoff. We conducted field research in 2003 and 2004 on a Fauquier silty clay loam (Ultic Hapludalfs) to compare the effects of annual (since 1999) applications of composted and uncomposted organic residuals on P runoff characteristics. Biosolids compost (BSC), poultry litter-yard waste compost (PLC), and uncomposted poultry litter (PL) were applied based on estimated plant-available N. A commercial fertilizer treatment (CF) and an unamended control treatment (CTL) were also included. Corn (Zea mays L.) and a cereal rye (Secale cereal L.) cover crop were planted each year. We applied simulated rainfall in fall 2004 and analyzed runoff for dissolved reactive P (DRP), total dissolved P (TDP), total P (TP), total organic C (TOC), and total suspended solids (TSS). End of season soil samples were analyzed for Mehlich-3 P (M3P), EPA 3050 P (3050P), water soluble P (WSP), degree of P saturation (DPS), soil C, and bulk density. Compost treatments significantly increased soil C, decreased bulk density, and increased M3P, 3050P, WSP, and DPS. The concentration of DRP, TDP, and TP in runoff was highest in compost treatments, but the mass of DRP and TDP was not different among treatments because infiltration was higher and runoff lower in compost-amended soil. Improved soil physical properties associated with poultry litter-yard waste compost application decreased loss of TP and TSS.     

Carbon monoxide from composting due to thermal oxidation of biomass

Emissions of carbon monoxide (CO) were observed from decomposing organic wastes and litter under laboratory, pilot composting plant, and natural conditions. Field studies included air from inside a compost heap of about 200 m3, emissions from composting of livestock wastes at a biologically operating farm, and leaf litter pile air samples. The concentration of CO was up to 120 micromol mol(-1) in the compost piles of green waste, and up to 10 micromol mol(-1) in flux chambers above livestock waste windrow composts. The mean CO flux rates were approximately 20 mg CO m(-2) h(-1) for compost heaps of green waste, and varied from 30 to 100 mg CO m(-2) h(-1) for fresh dung windrows. Laboratory studies using a temperature and ventilation-controlled substrate container were performed to elucidate the origin of CO, and included hay samples of fixed moisture content at temperatures between 5 and 65 degrees C, including nonsterilized as well as sterilized samples. The concentration of CO was up to 160 micromol mol(-1) in these experiments, and Arrhenius-type plot analyses resulted in activation energies of 65 kJ mol(-1) for thermochemically produced CO from the nonsterilized compost substrate. Sterilized samples showed dramatically reduced CO2 but virtually unchanged CO emissions, albeit at a slightly lower activation energy, likely a result of the high-temperature sterilization. Though globally and regionally these CO emissions are only a minor source, thermochemically produced CO emissions might affect local air quality in and near composting facilities.     

The effect of phosphogypsum on greenhouse gas emissions during cattle manure composting

Phosphogypsum (PG), a by-product of the phosphate fertilizer industry, reduces N losses when added to composting livestock manure, but its impact on greenhouse gas emissions is unclear. The objective of this research was to assess the effects of PG addition on greenhouse gas emissions during cattle feedlot manure composting. Sand was used as a filler material for comparison. The seven treatments were PG10, PG20, PG30, S10, S20, and S30, representing the rate of PG or sand addition at 10, 20, or 30% of manure dry weight and a check treatment (no PG or sand) with three replications. The manure treatments were composted in open windrows and turned five times during a 134-d period. Addition of PG significantly increased electrical conductivity (EC) and decreased pH in the final compost. Total carbon (TC), total nitrogen (TN), and mineral nitrogen contents in the final composted product were not affected by the addition of PG or sand. From 40 to 54% of initial TC was lost during composting, mostly as CO(2), with CH(4) accounting for <14%. The addition of PG significantly reduced CH(4) emissions, which decreased exponentially with the compost total sulfur (TS) content. The emission of N(2)O accounted for <0.2% of initial TN in the manure, increasing as compost pH decreased from alkaline to near neutral. Based on the total greenhouse gas budget, PG addition reduced greenhouse gas emissions (CO(2)-C equivalent) during composting of livestock manure by at least 58%, primarily due to reduced CH(4) emission.     

Effect of chemical and microbial amendments on ammonia volatilization from composting poultry litter

Research has shown that aluminum sulfate (alum) and phosphoric acid greatly reduce ammonia (NH3) volatilization from poultry litter; however, no studies have yet reported the effects of these amendments on field-scale composting of poultry litter. The objectives of this study were to (i) evaluate NH3 volatilization from composting litter by measuring both NH3 volatilization and changes in total nitrogen (N) in the litter and (ii) evaluate potential methods of reducing NH3 losses from composting poultry litter. Poultry litter was composted for 68 d the first year and 92 d the second year. Eleven treatments were screened in Year 1, which included an unamended control, a microbial mixture, a microbial mixture with 5% alum incorporated into the litter, 5 and 10% alum rates either surface-applied or incorporated, and 1 and 2% phosphoric acid rates either surface-applied or incorporated. Treatments in Year 2 included an unamended control, a microbial mixture, alum (7% by fresh wt.), and phosphoric acid (1.5% by fresh wt.). Alum and phosphoric acid reduced NH3 volatilization from composting poultry litter by as much as 76 and 54%, respectively. The highest NH3 emission rates were from microbial treatments each year. Compost treated with chemical amendments retained more initial N than all other treatments. Due to the cost and N loss associated with composting poultry litter, composting is not economical from an agronomic perspective compared with the use of fresh poultry litter.     

Effects of organic amendments on the reduction and phytoavailability of chromate in mineral soil

In this study, seven organic amendments (biosolid compost, farm yard manure, fish manure, horse manure, spent mushroom, pig manure, and poultry manure) were investigated for their effects on the reduction of hexavalent chromium [chromate, Cr(VI)] in a mineral soil (Manawatu sandy soil) low in organic matter content. Addition of organic amendments enhanced the rate of reduction of Cr(VI) to Cr(III) in the soil. At the same level of total organic carbon addition, there was a significant difference in the extent of Cr(VI) reduction among the soils treated with organic amendments. There was, however, a significant positive linear relationship between the extent of Cr(VI) reduction and the amount of dissolved organic carbon in the soil. The effect of biosolid compost on the uptake of Cr(VI) from the soil, treated with various levels of Cr(VI) (0-1200 mg Cr kg(-1) soil), was examined with mustard (Brassica juncea L.) plants. Increasing addition of Cr(VI) increased Cr concentration in plants, resulting in decreased plant growth (i.e., phytotoxicity). Addition of the biosolid compost was effective in reducing the phytotoxicity of Cr(VI). The redistribution of Cr(VI) in various soil components was evaluated by a sequential fractionation scheme. In the unamended soil, the concentration of Cr was higher in the organic-bound, oxide-bound, and residual fractions than in the soluble and exchangeable fractions. Addition of organic amendments also decreased the concentration of the soluble and exchangeable fractions but especially increased the organic-bound fraction in soil.     

Composting and compost application in China

The current situation of municipal solid waste (MSW) and sewage sludge production (in terms of volume as well as composition) in China is introduced. Composting and compost application in China are reviewed. In China, the production of municipal solid waste and sewage sludge is changing rapidly along with economic development. Composting is mainly applied for treating MSW, about 20% of the total amount of MSW being disposed. MSW composting is mainly co-composted with night soil or sewage sludge. Compost is used in agriculture, forestry and horticulture. Compost application is the key factor influencing the composting development in China. To promote composting and compost application in China, a state-wide survey on the production, composition and physical and chemical properties of MSW and sewage sludge should be carried out. More effort should be made to develop low cost and high efficient composting technologies according to China's conditions. The environmental impact of compost application should also be given more attention.     

Factors Affecting Take-up of and Drop-out from Home Composting Schemes

This paper reports survey results from Scotland and north-west England into home composting attitudes and behaviours. The results concentrate on: the take-up of home composting through promotional campaigns; and the reasons for drop-out. Motivations for take-up were balanced between environmental and gardening reasons, although capital cost was an important issue for some. Drop-outs occurred mainly through participants moving house or because of lack of success in producing compost. Few of those experiencing problems sought help. Those that did favoured official or professional sources. Neighbourhood social pressures to compost were relatively weak. The results are discussed in terms of the sustainability of home composting behaviour and the manage ment interventions that might be required in sustaining that behaviour.     

Open windrow composting of polymers: an investigation into the rate of degradation of polyethylene

The compostability of degradable polymers under open windrow composting conditions is explored within this paper. Areas for consideration were the use of, and impacts of, degradable polyethylene (PE) sacks on the composting process and the quality of the finished compost product. These factors were investigated through polymer weight loss over the composting process, the amount of polymer residue and chemical contaminants in the finished compost product, the windrow temperature profiles and a bioassay to establish plant growth and germination levels using the final compost product. This trial also included a comparative study of the weight loss under composting conditions of two different types of ‘degradable’ polymer sacks currently on the European market: PE and a starch based product. Statistical analysis of the windrow temperature profiles has led to the development of a model, which can help to predict the expected trends in the temperature profiles of open compost windrows where the organic waste is kerbside collected using a degradable PE sack.     

Convenience improves composting and recycling rates in high-density residential buildings

Increasing volumes of solid waste, implicated in environmental pollution and health problems, are central to the current environmental crisis. In two randomized field experiments, we demonstrate that convenience dramatically boosts recycling and composting rates in multi-family dwellings and university residences. When compost bins were placed on each floor in a multi-family residence, instead of on the ground floor, composting rates increased by 70%, diverting 27 kilograms of compost from the landfill per unit per year. When recycling stations were placed just meters from suites in student residences, instead of in the basement, recycling increased by 147% (container), and 137% (paper), and composting increased by 139%, diverting 23, 22, and 14 kilograms of containers, paper, and compost, respectively, from the landfill per person per year. Simply making recycling and composting convenient can significantly increase waste diversion, and as such this single intervention has important implications for waste management and environmental policy.     

Factors Affecting Take-up of and Drop-out from Home Composting Schemes

This paper reports survey results from Scotland and north-west England into home composting attitudes and behaviours. The results concentrate on: the take-up of home composting through promotional campaigns; and the reasons for drop-out. Motivations for take-up were balanced between environmental and gardening reasons, although capital cost was an important issue for some. Drop-outs occurred mainly through participants moving house or because of lack of success in producing compost. Few of those experiencing problems sought help. Those that did favoured official or professional sources. Neighbourhood social pressures to compost were relatively weak. The results are discussed in terms of the sustainability of home composting behaviour and the manage ment interventions that might be required in sustaining that behaviour.     

Persistent organic pollutants in source-separated compost and its feedstock materials--a review of field studies

Composting and the application of compost to the soil follow the principle of recycling and sustainability. Compost can also have a positive effect on physical, chemical, and biological soil parameters. However, little is known about the origin, concentration, and transformation of persistent organic pollutants (POPs) in compost. We therefore compiled literature data on some priority POPs in compost and its main feedstock materials from more than 60 reports. Our data evaluation suggests the following findings. First, median concentrations of Sigma 16 polycyclic aromatic hydrocarbons (PAHs), Sigma 6 polychlorinated biphenyls (PCBs), and Sigma 17 polychlorinated dibenzo-p-dioxins and -furans (PCDD/Fs) were higher in green waste (1803, 15.6 microg/kg dry wt., and 2.5 ng international toxicity equivalent [I-TEQ]/kg dry wt.) than in organic household waste (635, 14.6 microg/kg dry wt., and 2.2 ng I-TEQ/kg dry wt.) and kitchen waste (not available [NA], 14.9 microg/kg dry wt., 0.4 ng I-TEQ/kg dry wt.). The POP concentrations in foliage were up to 12 times higher than in other feedstock materials. Second, in contrast, compost from organic household waste and green waste contained similar amounts of Sigma 16 PAHs, Sigma 6 PCBs, and Sigma 17 PCDD/Fs (1915, 39.8 microg/kg dry wt., and 9.5 ng I-TEQ/kg dry wt., and 1715, 30.6 microg/kg dry wt., and 8.5 ng I-TEQ/kg dry wt., respectively). Third, concentrations of three-ring PAHs were reduced during the composting process, whereas five- to six-ring PAHs and Sigma 6 PCBs increased by roughly a factor of two due to mass reduction during composting. Sigma 17 PCDD/Fs had accumulated by up to a factor of 14. Fourth, urban feedstock and compost had higher POP concentrations than rural material. Fifth, the highest concentrations of POPs were usually observed in summer samples. Finally, median compost concentrations of POPs were greater by up to one order of magnitude than in arable soils, as the primary recipients of compost, but were well within the range of many urban soils. In conclusion, this work provides a basis for the further improvement of composting and for future risk assessments of compost application.