垃圾焚烧电厂烟气降温模拟分析

采用fluent软件对江苏某垃圾焚烧厂的烟气2级喷水减温流程分别进行了模拟,并根据模拟结果分析了反应塔和冷却塔内烟气的温度、流速、湿度等在塔内的径向分布情况.结果表明,冷却塔和反应塔在不同进口烟气温度下将烟气温度降低到各自相应同一值时所需喷水量的模拟值和实际值均具有较好的一致性,模拟结果具有一定的可靠性;冷却塔内烟气温...     

燃煤电站湿法烟气脱硫的颗粒物脱除效果

伴随着我国燃煤电站污染物严峻形势,湿法烟气脱硫协同捕集颗粒物越来越受到工程应用部门的重视。从基本理论出发,引入捕集体与颗粒碰撞、拦截与扩散的基本方程,推导并建立多液滴对多颗粒的捕集模型。研究结果表明：直径245 μm的液滴,沉降速度小于气流速度,会被携带出脱硫塔;液滴对PM0.1、PM1、PM2.5、PM5、PM10颗粒物的去除效率为U型曲线,910 μm液滴对颗粒物的去除效率比4 666 μm液滴高近百倍;同等质量浓度,不同粒度分布,脱硫塔除尘性能仍然差异较大。     

煤矸石热电厂烟气治理技术及应用

介绍了一种新型喷淋泡沫塔在煤矸石热电厂烟气治理中的应用。根据离心、喷雾、泡沫相结合的多级净化原理 ,经旋风喷雾、二级喷淋泡沫板洗涤 ,脱硫效率高达 92 4 %。     

燃煤电厂重金属排放与周边土壤重金属污染评价

为研究燃煤电厂重金属排放对周边土壤重金属污染的影响,测定了某燃煤电厂烟囱入口烟气中Cd、Cr、Hg、Ni、Pb、As含量,同时根据当地气象及地形条件,在燃煤电厂周边采集19个土壤样品,分析了土壤中重金属含量及分布情况,并对其污染程度进行评价.结果表明,燃煤电厂烟气中6种重金属元素的质量浓度为0.02～2.00μg/m3...     

常温常压下采空区遗煤对电厂烟气的吸附

采用自制的煤大样量吸附实验装置,对常温常压条件下将电厂烟气注入采空区封存的可行性进行了探讨,对常压条件下煤对双组分N2/CO2气体的竞争吸附性进行了研究,并通过理论计算得出煤的结构单元-苯环与N2、CO2分子的相互作用能。常温常压下,单组分气体吸附实验得出煤对CO2的吸附量为0.5~1.1 cm3/g,对N2的吸附量为0.03~0.25 cm3/g,即煤对CO2的吸附量远大于N2的吸附量。煤对CO2/N2双组份气体竞争吸附实验得出,混合气体的存在促进了煤对2种气体的吸附,使吸附量均有所增加,即煤吸附电厂烟气的量远大于煤对N2与CO2的吸附量。通过理论计算,得出苯环与N2分子的相互作用能为-2.93 kJ/mol,与CO2分子的相互作用能为-26.50 kJ/mol,由此可以得出煤吸附CO2的能力强于吸附N2的能力。这与常压下煤吸附CO2及N2实验数据相吻合。     

Mercury distribution in seawater discharged from a coal-fired power plant equipped with a seawater flue gas desulfurization system

Background and purpose  

More and more coal-fired power plants equipped with seawater flue gas desulfurization systems have been built in coastal areas. They release large amount of mercury (Hg)-containing waste seawater into the adjacent seas. However, very limited impact studies have been carried out. Our research targeted the distribution of Hg in the seawater, sediment, biota, and atmosphere, and its environmental transportation.     

催化氧化吸收法去除燃煤电厂烟气中Hg~0的研究

针对燃煤电厂汞污染问题,利用现有污染物设备实现汞的同步脱除是具有经济效益、环境效益与工程实用前景的一种方法。在广泛使用的湿法烟气脱硫(WFGD)系统中,研究过渡金属离子(Mn2+、Co2+、Ni 2+、Cu2+)与H2O2构成的类芬顿体系(简称M2+/H2O2体系)对烟气中Hg0的氧化脱除效果,以及不同H2O2浓度、反应温度、初始pH、SO2浓度对M2+/H2O2体系Hg0脱除效果的影响。结果表明,类芬顿试剂能有效促进烟气中Hg0的脱除,脱汞率随着H2O2浓度和过渡金属阳离子浓度增加而提高,且各过渡金属离子的催化氧化作用为Co2+Mn2+Ni 2+Cu2+。初始pH能促进M2+/H2O2体系Hg0的脱除,SO2的存在会起到一定抑制作用,反应温度会影响该系统对Hg0的脱除效果,脱汞最佳反应温度为55℃,符合工程运行条件。可见,采用直接向脱硫浆液中加入添加剂的方法能有效控制燃煤电厂汞污染,且该方法操作简单,具有很好的工业应用前景。     

Suppressing SO3 formation in copper smelting flue gas by ejecting pyrite into flue

Environmental Science and Pollution Research - SO3 in the copper smelting flue gas not only causes serious corrosion in heat exchange and dust collection equipment but also increases the amount of...     

Assessing sorbents for mercury control in coal-combustion flue gas

Sorbent injection for Hg control is one of the most promising technologies for reducing Hg emissions from power-generation facilities, particularly units that do not require wet scrubbers for SO2 control. Since 1992, EPRI has been assessing the performance of Hg sorbents in pilot-scale systems installed at full-scale facilities. The initial tests were conducted on a 5,000-acfm (142-m3/min) pilot baghouse. Screening potential sorbents at this scale required substantial resources for installation and operation and did not provide an opportunity to characterize sorbents over a wide temperature range. Data collected in the laboratory and in field tests indicate that sorbents are affected by flue gas composition and temperature. Tests carried out in actual flue gas at a number of power plants also have shown that sorbent performance can be site-specific. In addition, data collected at a field site often are different from data collected     

Heavy metal accumulation in wheat plant grown in soil amended with industrial sludge

The concentrations of different forms of Zn, Cu, Mn, Ni, Cd, Cr, Pb and Fe metals were determined for the roadside sludge collected from pickling-rolling and electroplating industrial area. In sludge the relative abundance of total heavy metals were Fe>Mn>Cr>Ni>Cu>Pb>Zn>Cd and DTPA-extractable metals were in the order--Fe>Ni>Mn>Cr>Cu>Zn>Pb>Cd. Pot-culture experiment was conducted in soils amended with sludge (0%, 10%, 20%, 30%), pretreated with lime (0%, 0.5% and 1%). The soils were alkaline in nature (pH>8.3) with organic carbon contents were 0.34% and 0.72%. The most abundant total and bio-available metal was Fe. Two wheat seedlings were grown in each pot containing 3kg sludge-amended or control soil and the experiment was conducted till harvesting. Application of sludge increased both total and bio-available forms of metals in the soils, while lime application decreased the bioavailability of heavy metals in sludge-amended soils. The content of organic carbon showed positive correlation with all metals except Zn, Cr and Pb. CEC also showed a strong positive correlation (R2>0.7) with Fe, Mn, Cu, Ni and Cd. Though wheat plants are not accumulators, the translocation efficiency was appreciably high. The translocation factor from shoot to grain was found smaller than that of root to shoot of wheat plants. This makes an implication that the heavy metal accumulation was proportionally lesser in grain than in shoot. In, 10% sludge with 0.5% lime-amended soils; each of these toxic heavy metals was found to be within permissible range (USEPA). Hence, on the basis of present study, the best possible treatment may be recommended.     

An analysis of extinction coefficients of particles and water moisture in the stack after flue gas desulfurization at a coal-fired power plant

Two important factors that affect in-stack opacity--light extinction by emitted particles and that by water moisture after a flue gas desulfurization (FGD) unit--are investigated. The mass light extinction coefficients for particles and water moisture, k(p) and k(w), respectively, were determined using the Lambert-Beer law of opacity with a nonlinear least-squares regression method. The estimated k(p) and k(w) values vary from 0.199 to 0.316 m2/g and 0.000345 to 0.000426 m2/g, respectively, and the overall mean estimated values are 0.229 and 0.000397 m2/g, respectively. Although k(w) is 3 orders of magnitude smaller than k(p), experimental results show that the effect on light extinction by water moisture was comparable to that by particles because of the existence of a considerable mass of water moisture after a FGD unit. The mass light extinction coefficient was also estimated using Mie theory with measured particle size distributions and a complex refractive index of 1.5-ni for fly ash particles. The k(p) obtained using Mie theory ranges from 0.282 to 0.286 m2/g and is slightly greater than the averaged estimated k(p) of 0.229 m2/g from measured opacity. The discrepancy may be partly due to a difference in the microstructure of the fly ash from the assumption of solid spheres because the fly ash may have been formed as spheres attached with smaller particles or as hollow spheres that contained solid spheres. Previously reported values of measured k(p) obtained without considering the effects of water moisture are greater than that obtained in this study, which is reasonable because it reflects the effect of extinction by water moisture in the flue gas. Additionally, the moisture absorbed by particulate matter, corresponding to the effect of water moisture on the particulates, was clarified and found to be negligible.     

燃煤电厂海水脱硫工艺的排水对海域环境的影响

进行了某4×300 MW燃煤锅炉的海水烟气脱硫(海水FGD)系统投运前后的海域监测.研究结果显示,海水曝气工艺可以较好地使脱硫后的海水水质得到恢复,除Hg必须引起严重关注外,排海海水的其他水质指标变化很小,附近海域所受影响甚微.     

用于臭氧氧化烟气脱硝与烟气余热回收的一体化实验台

锅炉烟气中的NOx是大气污染的重要原因之一。针对燃气锅炉NOx超低排放的要求、以及烟气中大量余热被浪费的现状,提出了烟气脱硝与余热回收一体化的新方法,搭建了一体化实验台,在逆流式烟气喷淋塔中,进行了采用臭氧氧化烟气脱硝、并同时回收烟气余热的实验研究。研究了O3/NO摩尔比、液气比、碱液吸收对脱硝效果的影响,并对脱硝与余热回收的耦合关系进行了分析。在实验室实验的基础上,进一步进行了实际工程的中试研究。结果表明,烟气脱硝与余热回收一体化是可行的,实验台实验中,当烟气温度为83.0 ℃、喷淋水温度为46.4 ℃、液气比为14.8 m3·L-1、O3/NO摩尔比为1.6时,脱硝率为30%,同时回收烟气余热量18.5 kW。     

Effect of NOx control processes on mercury speciation in utility flue gas

The speciation of Hg in coal-fired flue gas can be important in determining the ultimate Hg emissions as well as potential control options for the utility. The effects of NOx control processes, such as selective catalytic reduction (SCR) and selective non-catalytic reduction (SNCR), on Hg speciation are not well understood but may impact emissions of Hg. EPRI has investigated the reactions of Hg in flue gas at conditions expected for some NOx control processes. This paper describes the methodology used to investigate these reactions in actual flue gas at several power plants. Results have indicated that some commercial SCR catalysts are capable of oxidizing elemental Hg in flue gas obtained from the inlets of SCR or air heater units. Results are affected by various flue gas and operating parameters. The effect of flue gas composition, including the presence of NH3, has been evaluated. The influence of NH3 on fly ash Hg reactions also is being investigated.     

Organic compounds in the flue gas from a power station with circulating fluid bed combustion of coal

Numerous organic compounds have been analyzed by coupled gas chromatography-mass spectroscopy (GC-MS) in flue gas after fluid bed combustion of four coal species from South Africa, Poland, Spitsbergen and Ruhr area (Germany). Polynuclear aromatic hydrocarbons, aliphatic hydrocarbons, chlorinated, heterocyclic and nitro compounds as well as phthalate esters are detected.     

铜陵某富硫尾矿库周边土壤重金属污染特征及风险评价

铜陵某尾矿库堆积大量富硫尾矿,为研究其氧化状况及对周边土壤的污染情况,在尾矿库和周边采集尾矿及土壤样品,测试分析尾矿及土壤样品典型重金属(Hg、As、Cr、Cd、Pb、Zn)含量和赋存形态,并基于单因子污染指数法和内梅罗综合污染指数法对土壤污染状况进行了评价。结果表明:(1)尾矿中Fe_2O_3平均占比达到38.08%(质量分数,下同),S平均占比达到5.34%;(2)尾矿库周边土壤中Cd、As、Zn、Hg严重超标,分别为《土壤环境质量农用地土壤污染风险管控标准(试行)》(GB 15618—2018)风险筛选值的6.3、3.7、1.8、1.5倍;(3)土壤中重金属主要以残渣态形式存在,但Cd、Hg、Zn的非残渣态平均占比均达到25%以上,生物有效性较高,对周边环境存在潜在危害;(4)两种污染指数法评价结果表明,尾矿库周边土壤以Cd、As、Zn污染为主,该富硫尾矿库已对周边环境造成重度污染。     

小型焚烧设施烟气中二噁英类的排放和控制

对中国典型的小型焚烧设施现状和二噁英类排放进行了初步调查研究,未经处理的小型垃圾焚烧设施烟气中二噁英类毒性当量(TEQ)大于6 ng/m3,小型火化机烟气中二噁英类TEQ大于5 ng/m3.设计并检验了布袋除尘器和活性炭滤布的二噁英类去除效果.仅使用布袋除尘器二噁英类去除率不高,布袋除尘器和活性炭滤布联用可以有效去除飞灰和气相中的二噁英类,去除率达到90%左右,可达到《生活垃圾焚烧污染控制标准》(GB 18485-2001)二噁英类排放标准.     

Reduction of dioxin emission by a multi-layer reactor with bead-shaped activated carbon in simulated gas stream and real flue gas of a sinter plant

A laboratory-scale multi-layer system was developed for the adsorption of PCDD/Fs from gas streams at various operating conditions, including gas flow rate, operating temperature and water vapor content. Excellent PCDD/F removal efficiency (>99.99%) was achieved with the multi-layer design with bead-shaped activated carbons (BACs). The PCDD/F removal efficiency achieved with the first layer adsorption bed decreased as the gas flow rate was increased due to the decrease of the gas retention time. The PCDD/F concentrations measured at the outlet of the third layer adsorption bed were all lower than 0.1 ng I-TEQ Nm⁻³. The PCDD/Fs desorbed from BAC were mainly lowly chlorinated congeners and the PCDD/F outlet concentrations increased as the operating temperature was increased. In addition, the results of pilot-scale experiment (real flue gases of an iron ore sintering plant) indicated that as the gas flow rate was controlled at 15 slpm, the removal efficiencies of PCDD/F congeners achieved with the multi-layer reactor with BAC were better than that in higher gas flow rate condition (20 slpm). Overall, the lab-scale and pilot-scale experiments indicated that PCDD/F removal achieved by multi-layer reactor with BAC strongly depended on the flow rate of the gas stream to be treated.     

Heavy metal pollution in China: Origin,pattern and control

GOAL, SCOPE AND BACKGROUND: Heavy metal is among one of the pollutants, which cause severe threats to humans and the environment in China. The aim of the present review is to make information on the source of heavy metal pollution, distribution of heavy metals in the environment, and measures of pollution control accessible internationally, which are mostly published in Chinese. METHODS: Information from scientific journals, university journals and governmental releases are compiled focusing mainly on Cd, Cu, Pb and Zn. Partly Al, As, Cr, Fe, Hg, Mn and Ni a included also in part as well. RESULTS AND DISCUSSION: In soil, the average contents of Cd, Cu, Pb and Zn are 0.097, 22.6, 26.0 and 74.2 mg/kg, respectively. In the water of the Yangtze River Basin, the concentrations of Cd, Cu, Pb and Zn are 0.080, 7.91, 15.7 and 18.7 microg/L, respectively. In reference to human activities, the heavy metal pollution comes from three sources: industrial emission, wastewater and solid waste. The environment such as soil, water and air were polluted by heavy metals in some cases. The contents of Cd, Cu, Pb and Zn even reach 3.16, 99.3, 84.1 and 147 mg/kg, respectively, in the soils of a wastewater irrigation zone. These contaminants pollute drinking water and food, and threaten human health. Some diseases resulting from pollution of geological and environmental origin, were observed with long-term and non-reversible effects. CONCLUSIONS: In China, the geological background level of heavy metal is low, but with the activity of humans, soil, water, air, and plants are polluted by heavy metals in some cases and even affect human health through the food chain. RECOMMENDATIONS AND OUTLOOK: To remediate and improve environmental quality is a long strategy for the polluted area to keep humans and animals healthy. Phytoremediation would be an effective technique to remediate the heavy metal pollutions.