用法律、用技术征服二氧化硫的污染（续四）

湿法烟气脱硫是指采用液体的吸收剂（溶液或浆液）来洗涤烟气以吸收烟气中的二氧化硫的方法。湿法烟气脱硫方法有多种，在工业上用得比较早，也比较普遍；主要工艺有；石灰／石灰石浆液洗涤法、双碱法、亚硫酸钠法、镁法、千代田法等。而尤以前两者应用最多，雄居占了世界各国烟气脱硫装置的一大半，在今后一个时期内也将仍占重要地位；下面主要介绍这两种方法。     

双碱法烟气脱硫工艺的研究

以旋流板塔为脱硫塔，实验研究了Na2CO3-Ca(OH)2双碱法脱硫工艺，试验了不同液气比L／G、Na^2 浓度、吸收液pH值和进气SO2浓度等主要参数对脱硫率的影响，并考察了Na^ 的损失与操作条件的关系，分析了双碱法脱硫过程的传质反应过程机理以及不同pH值对脱硫率的影响，此外，还讨论了本工艺适宜操作和工业应用前景。     

空塔钠碱法烟气脱硫实验研究

在内径200mm,高度1100mm的喷淋塔内,采用Na2CO3作为吸收剂进行SO2吸收实验,重点研究了液气比(L/G)、空塔气速、进口SO2质量浓度、吸收液pH及初始浓度对脱硫效率的影响。通过实验得到该系统适宜操作条件:吸收液pH值在6.5～7.5之间,液气比在1～1.5之间,吸收液初始浓度5%,空塔气速1.6m/s,在此条件下,进口SO2质量浓度在3000mg/m3以内,脱硫效率可以达到80%以上。     

微生物处理含SO2气体的试验研究

介绍一种氧化亚铁硫杆菌脱除SO2的新工艺。并研究铁离子浓度、液气比和气体SO2浓度等对脱硫效率的影响。对比实验表明细菌菌液比稀硫酸吸收法的脱硫效率更高。在细菌菌液的脱硫作用中，不仅铁离子，而且细菌本身也起到了关键作用。实验结果表明利用微生物脱除气体中的SO2是一个可行的技术方案。     

影响钠碱法烟气脱硫效率的因素分析与工艺优化

通过对钠碱法烟气脱硫工艺过程的分析和运行实践,分析总结了吸收液pH值、液气比（L/G）、烟气温度、烟气中烟尘浓度以及氧化空气量等参数的变化对烟气脱硫效率的影响规律,并从工艺过程控制、设备运行方式等方面提出了优化方案,为钠碱法脱硫工艺实现低成本、高效率的吸收提供有益的参考。     

喷雾吸收法处理烟气中SO2的试验

在内径３００ｍｍ的塔内，采用旋涡式压力喷嘴作雾化器，以石灰作为吸收剂进行烟气脱硫模拟试验研究，试验考究他吸收液ＰＨ值，吸收浆液浓度、循环浆液停留时间、液气比、空塔气速及进ＳＯ２浓度等对脱硫率的影响。结果表明：单级喷雾可获得３９％以上的脱硫率，整个试验过程中，喷嘴引起的塔压降很小。此外， 观察了脱硫过程中吸附塔内的结垢情况，通过烟气脱硫模拟试验，为进一步利用喷雾法对国内现有中小型锅炉麻石水膜除尘器的     

氨法烟气脱硫工艺实验研究

利用亚硫酸铵作为吸收剂进行氨法烟气脱硫模拟实验,主要考察了吸收液进塔pH值、液气比、吸收液浓度、进口SO2浓度、进口烟气温度等主要影响因素对脱硫效率的影响,并从理论上分析了它们之间的内在关系,得出了适宜的操作条件范围。     

氨法脱硫试验研究分析

为研究氨法脱硫中气液比、吸收液pH值、吸收液浓度以及进口烟温对脱硫效果的影响,设计了一套实验台,以亚硫酸铵为吸收剂进行了实验研究和分析.结果表明,气液比越小,脱硫效率越高;吸收液pH值越大,脱硫效果越好;脱硫效率随吸收液浓度的增大先增加后减小,中间存在最大值;而温度对脱硫效果的影响不大.同时可根据此结果,气液比选择在0.2～0.25L/m3范围,pH值选择为6～7.5范围,吸收液浓度为5.5％左右时,可使脱硫效果达到最好.     

微生物处理含SO2气体的试验研究

介绍一种氧化亚铁硫杆菌脱除SO2的新工艺.并研究铁离子浓度、液气比和气体SO2浓度等对脱硫效率的影响.对比实验表明细菌菌液比稀硫酸吸收法的脱硫效率更高.在细菌菌液的脱硫作用中,不仅铁离子,而且细菌本身也起到关键作用.实验结果表明利用微生物脱除气体中的SO2是一个可行的技术方案.     

废大理石粉湿法烟气脱硫工艺实验

实验研究了废大理石粉作为脱硫剂的湿法烟气脱硫工艺,分析了其吸收SO₂的传质反应机理.试验了不同液气比(L/G)、吸收浆液pH值和进气SO₂浓度等主要参数对脱硫率的影响,并对实验结果进行了分析.结果表明,选择以下操作条件较为适宜:pH₀=5.5～6.5,L/G=3L/m³,a=2%;以上工艺条件下,在进气SO₂浓度为1000ml/m³时,脱硫率达60%以上.本文还讨论了废大理石粉作为脱硫剂的工业应用前景.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Alterations of organ histopathology and metallolhionein mRNA expression in silver barb, Puntius gonionotus during subchronic cadmium exposure

Common silver barb,Puntius gonionotus,exposed to the nominal concentration of 0.06 mg/L Cd for 60 d,were assessed for histopathological alterations(gills,liver and kidney),metal accumulation,and metallothionein(MT)mRNA expression.Fish exhibited pathological symptoms such as hypertrophy and hyperplasia of primary and secondary gill lamellae,vacuolization in hepatocytes,and prominent tubular and glomerular damage in the kidney.In addition,kidney accumulated the highest content of cadmium,more than gills and liver.Expression of MT mRNA was increased in both liver and kidney of treated fish.Hepatic MT levels remained high after fish were removed to Cd-free water.In contrast,MT expression in kidney was peaked after 28 d of treatment and drastically dropped when fish were removed to Cd-free water.The high concentrations of Cd in hepatic tissues indicated an accumulation site or permanent damage on this tissue.     

Sorption of 1-naphthol by plant cuticular fractions

The contribution of aliphatic-rich plant biopolymer to sorption of hydrophobic organic compounds is significantly important because of their preservation and accumulation in the soil environment,but sorption mechanism is still not fully understood.In this study, sorption of 1-naphthol by plant cuticular fractions was examined to better understand the contributions of respective fraction.Toward this end,cuticular materials were isolated from the fruits of tomato by chemical method.The tomato cuticle sheet consisted of waxes (6.5 wt%),cuticular monomer (69.5 wt%),and polysaccharide (24.0 wt%).Isotherms of l-naphthol to the cuticular fractions were nonlinear (N value (0.82-0.90)) at the whole tested concentration ranges.The KodKow ratios for bulk cuticle (TC1),dewaxed cuticle (TC2),cutin (TC4),and desugared cuticle (TC5) were larger than unity,suggested that tomato bulk cuticle and cutin are much powerful solption medium.Sorption capability of cutin (TC4) was 2.4 times higher than the nonsaponifiable fraction (TC3).The 1-naphthol interactions with tomato cuticular materials were governed by both hydrophobic-type interactions and polar (H-bonding) interactions. Removal of the wax and polysaccharide materials from the bulk tomato cuticle caused a significant increase in the sorption ability of the cuticular material.There was a linear negative trend between K_(oc) values and the amount of polysaccharides or fraction's polarities ((N O)/C);while a linear positive relationship between K_(oc) values and the content of cutin monomer (linear R~2=0.993) was observed for present in the cuticular fractions.Predominant sorbent of the hydrophobic organic compounds (HOCs) in the plant cuticular fraction was the cutin monomer,contributing to 91.7% of the total sorption of tomato bulk cuticle.     

Seed selections for crystallization of calcium phosphate for phosphorus recovery

Seed induces and promotes the crystallization of calcium phosphate, and acts as carrier of the recovered phosphorus （P）. In order to select suitable seed for P recovery from wastewater, three seeds including Apatite （AP）, Juraperle （JP） and phosphate-modified Juraperle （M-JP） were tested and compared. Batch and fixed-bed column experiments of seeded crystallization of calcium phosphate were undertaken by using synthetic wastewater with 10 mg/L P phosphate. It shows that AP has bad enduring property in the crystallization process, while JP has better performance for multiple uses, and M-JP is a hopeful seed for P recovery by crystallization of calcium phosphate.